Effect of negative air ions on Escherichia coli ATCC 25922 inoculated onto mung bean seed and apple fruit.

The effect of negative air ions on the reduction of Escherichia coli ATCC 25922 inoculated onto mung bean sprout seed and whole or fresh-cut apple fruit was studied. Mung bean seeds, whole Gala apples, and Gala apple slices were inoculated with E. coli ATCC 25922 before being exposed to negative air ions for up to 18 h at room temperature (-23 degrees C). Results revealed a less than 0.5-log reduction of E. coli on mung bean seed even after 18 h of exposure. The reduction of E. coli on the surface of whole apples increased with increasing exposure time from 0.5 to 3 h, but the maximum reduction was less than 1 log CFU/g. Increasing exposure time from 3 to 18 h did not lead to increased treatment efficacy. No reduction of E. coli was observed on apple slices after 3 h of treatment. When the negative air ion system was applied with acetic acid vapor, no additive or synergistic effect of negative ions on the reduction of E. coli was found. These results suggest that negative air ions have a very limited effect on the population of E. coli on mung bean seed and apples.

Effects of cell surface charge and hydrophobicity on attachment of 16 Salmonella serovars to cantaloupe rind and decontamination with sanitizers.

Adherence of bacteria to cantaloupe rind is favored by surface irregularities such as roughness, crevices, and pits, thus reducing the ability of washing or sanitizer treatments to remove or inactivate attached cells. In this study, we compared the surface charge and hydrophobicity of two cantaloupe-related outbreak strains of Salmonella Poona (RM2350 and G-91-1595) to those of 14 additional Salmonella strains using electrostatic and hydrophobic interaction chromatography. The relative abilities of the 16 strains to attach to cantaloupe surfaces and resist removal by washing with water, chlorine (200 ppm), or hydrogen peroxide (2.5%) for 5 min after a storage period of up to 7 days at 5 to 20 degrees C also were determined. Whole cantaloupes were inoculated with each pathogen at 8.36 log CFU/ml, dried for 1 h inside a biosafety cabinet, stored, and then subjected to the washing treatments. Only the positive surface charge of the two cantaloupe-related strains of Salmonella Poona was significantly higher (P < 0.05) than that of the other strains. Initial bacterial attachment to cantaloupe surfaces ranged from 3.68 to 4.56 log CFU/cm2 (highest values for Salmonella Michigan, Newport, Oranienburg, and Mbandaka). The average percentage of the total bacterial population strongly attached to the cantaloupe surface for the Salmonella serovars studied ranged from 0.893 to 0.946 at 5 degrees C and from 0.987 to 0.999 at 25 degrees C. Washing inoculated melons with water did not produce a significant reduction in the concentration of the pathogens (P > 0.05). Chlorine and hydrogen peroxide treatments caused an average 3-log reduction when applied 20 to 40 min postinoculation. However, sanitizer treatments applied 60 min or more postinoculation were less effective (approximately 2.5-log reduction). No significant differences were noted in sanitizer efficacy against the individual strains (P > 0.05). The two cantaloupe-related outbreak Salmonella Poona strains did not significantly differ from the other Salmonella strains tested in negative cell surface charge or hydrophobicity, were not more effective in attaching to whole melon surfaces, and were not more resistant to the various washing treatments when present on rinds.

Inhibition of Salmonella enterica by plant-associated pseudomonads in vitro and on sprouting alfalfa seed.

Foodborne illness due to the consumption of contaminated raw or lightly cooked sprouts is a continuing food safety concern. In this study, we tested several plant-associated pseudomonads for their ability to inhibit the growth of Salmonella enterica both in vitro and in situ. An agar spot bioassay method was used with three different media. Only Pseudomonas fluorescens 2-79 produced clear zones of inhibition when tested against five serovars of S. enterica, and activity was dependent on media type and serovar. The antibiosis by derivative strains of P. fluorescens 2-79 defective in the production of phenazine-1-carboxylic acid and fluorescent siderophore was not reduced, indicating that these known antimicrobial metabolites were not responsible for the inhibition observed in our studies. However, mutants defective in the regulatory gene gacS (global antibiotic and cyanide control) were severely reduced in inhibitory activity. In tryptic soy broth, the control cultures of a cocktail of S. enterica strains reached approximately 10 log CFU/ml by 24 h but, when coinoculated with P. fluorescens 2-79, reached only approximately 5 log CFU/ml. The addition of P. fluorescens 2-79 to the seed soak water prior to the germination of alfalfa seed previously inoculated with a cocktail of S. enterica strains led to an average reduction of 5 log CFU/g at 6 days of sprouting without an adverse effect on sprout yield or appearance. Time course studies indicated that S. enterica outgrowth was controlled on days 1 through 6 of sprouting. Competitive exclusion as a potential food safety intervention for seed sprouts merits further study.

ATP bioluminescence assay for estimation of microbial populations of fresh-cut melon.

Estimation of microbial numbers in foods by conventional microbiological techniques takes days, so there is a need for faster methods that can give results in minutes. Research was undertaken to investigate the use of bioluminescent ATP determination and a firefly luciferase assay to estimate the initial population of aerobic mesophilic bacteria on fresh-cut melons immediately after preparation and during storage at 5 or 15 degrees C for up to 12 days. Populations of aerobic mesophilic bacteria on fresh-cut cantaloupe prepared immediately from unsanitized whole melons averaged 3.42 log CFU/g, corresponding to an ATP value of 5.40 log fg/g. Populations for fresh-cut honeydew prepared from unsanitized whole melon averaged 1.97 log CFU/g, corresponding an ATP value of 3.94 log fg/g. Fresh-cut pieces prepared from cantaloupe or honeydew melons sanitized with either chlorine (200 ppm free chlorine) or hydrogen peroxide (2.5%) had similar ATP values: 3.1 log fg/g (corresponding to bacterial counts 1.7 log CFU/g) for cantaloupes and 2.6 log fg/g (corresponding to bacterial counts of 0.48 CFU/g) for fresh-cut honeydew. Positive linear correlations for ATP concentrations and microbial populations were found for fresh-cut cantaloupe (R2 = 0.99) and honeydew R2 = 0.95) during storage at 5 degrees C for up to 12 days. ATP values in fresh-cut melons inoculated with either aerobic mesophilic bacteria or yeast and mold were significantly higher (P < 0.05) than control values and parallel total plate counts on plate count agar. Results of this study indicate that the bioluminescent ATP assay can be used to monitor total microbial populations on fresh-cut melon after preparation and during storage for quality control purposes to establish specific sell-by or consume-by dates.

Effect of nisin in combination with EDTA, sodium lactate, and potassium sorbate for reducing Salmonella on whole and fresh-cut cantaloupet.

Nisin (50 microg/ml), EDTA (0.02 M, disodium salt), sodium lactate (NaL, 2%), and potassium sorbate (KS, 0.02%) were tested individually and in various combinations as sanitizer treatments for reducing Salmonella on whole and fresh-cut cantaloupe. Whole cantaloupe and fresh-cut pieces were inoculated with a five-strain cocktail of Salmonella to give 4.76 +/- 0.23 log CFU/cm2 and 3.42 +/- 0.13 log CFU/g, respectively. Inoculated whole melons and fresh-cut pieces were stored at 5 degrees C for 7 days. Washing treatments were applied to inoculated whole melons at days 0, 3, and 7 of storage, and surviving bacterial populations were determined. The effect of the washing treatments on transfer of Salmonella to fresh-cut pieces prepared immediately after treatment was also determined. Directly inoculated fresh-cut pieces were treated at day 0, and surviving bacteria were enumerated at days 0, 3, and 7 of storage. The combination treatments of nisin-EDTA, nisin-NaL, nisin-KS, NaL-KS, and nisin-NaL-KS all resulted in reductions of approximately 3 log CFU/cm2 at day 0 for whole melons. When tested alone, all compounds, along with water washes, were ineffective. After 3 and 7 days of storage, the five combination washing treatments were less effective, resulting in reductions of approximately 2 log CFU/cm2. None of the combination treatments completely eliminated transfer of pathogen survivors to fresh-cut pieces. The combination treatments nisin-NaL, nisin-KS, NaL-KS, and nisin-NaL-KS, but not nisin-EDTA, gave significant (P < 0.05) reductions of Salmonella directly inoculated onto fresh-cut pieces. Washing with nisin-NaL-KS was significantly (P < 0.05) more effective than the other three combination treatments, resulting in a reduction of 1.4 CFU/g. Inhibition by the four effective treatments carried over from day 0 through day 7 of storage, with no increase in the population of Salmonella on the stored fresh-cut pieces. Sensory evaluations indicated that treatment of fresh-cut pieces with nisin-NaL and NaL-KS, but not nisin-KS or nisin-NaL-KS, were acceptable in terms of appearance, odor, and overall acceptability. After the required regulatory approval, treatment of whole cantaloupe with nisin in combination with EDTA, NaL, KS, or NaL and KS and of fresh-cut pieces with nisin-NaL or NaL-KS could help ensure the microbiological safety of fresh-cut cantaloupe.

Method of applying sanitizers and sample preparation affects recovery of native microflora and Salmonella on whole cantaloupe surfaces.

Standardized methods for applying sanitizer treatments to cantaloupes and for recovering surviving native microflora or Salmonella on inoculated cantaloupe after sanitizing are lacking. Accordingly, the objectives of this study were to compare four methods for applying sanitizers (dipping, dipping with rotation, dipping with agitation, and dipping with rubbing) using 200 ppm of chlorine or 5% H2O2, two recovery methods (homogenization of rind plugs in a stomacher or blender), and five selective recovery media for Salmonella. Whole cantaloupes were submerged in a cocktail of five strains of Salmonella (each at approximately 2 x 10(8) CFU/ml) for 10 min and allowed to dry for 1 h inside a biosafety cabinet and stored at 20 degrees C for approximately 23 h before sanitizing. The recovery of Salmonella from whole cantaloupe without sanitizing averaged 5.09 log CFU/cm2 by blending and 4.30 log CFU/cm2 by homogenization in a stomacher for the five selective agar media. Microbial populations (Salmonella or the indigenous aerobic mesophilic bacteria, gram-negative bacteria, lactic acid bacteria, Pseudomonas spp., and yeast and mold) were not significantly (P > 0.05) reduced by treating with water regardless of the treatment method used. Sanitizing with chlorine or H2O2 by dipping, with or without rotation for 2 min, also did not reduce microbial populations. However, populations of all classes of native microflora and Salmonella were significantly (P < 0.05) reduced by sanitizer treatments (2 min) applied with agitation or by rubbing. In general, sanitizer treatments applied by rubbing resulted in greater log reductions (by up to 1.7 log unit) than for treatments applied with agitation. Populations of native microflora and Salmonella recovered from cantaloupe were higher (by up to 1.8 log unit) by blending compared to homogenization in a stomacher. In most instances, selective media used did not differ significantly (P > 0.05) for recovery of Salmonella after washing treatments.

Reduction of Escherichia coli O157:H7 and Salmonella on laboratory-inoculated alfalfa seed with commercial citrus-related products.

Alfalfa sprouts contaminated with the bacterial pathogens Escherichia coli O157:H7 and Salmonella have been the source of numerous outbreaks of foodborne illness in the United States and in other countries. The seed used for sprouting appears to be the primary source of these pathogens. The aim of this study was to determine whether the efficacy of commercial citrus-related products for sanitizing sprouting seed is similar to that of high levels of chlorine. Five products (Citrex, Pangermex, Citricidal, Citrobio, and Environné) were tested at concentrations of up to 20,000 ppm in sterile tap water and compared with buffered chlorine (at 16,000 ppm). Alfalfa seeds were inoculated with four-strain cocktails of Salmonella and E. coli O157:H7 to give final initial concentrations of ca. 9.0 and 7.0 CFU/g, respectively. Treatments (10 min) with Citrex, Pangermex, and Citricidal at 20,000 ppm and chlorine at 16,000 ppm produced similar log reductions for alfalfa seed inoculated with four-strain cocktails of E. coli O157:H7 and Salmonella (3.42 to 3.46 log CFU/g and 3.56 to 3.74 log CFU/g, respectively), and all four treatments were significantly (P<0.05) more effective than the control treatment (a buffer wash). Citrobio at 20,000 ppm was as effective as the other three products and chlorine against Salmonella but not against E. coli O157:H7. Environné was not more effective (producing reductions of 2.2 to 2.9 log CFU/g) than the control treatment (which produced reductions of 2.1 to 2.3 log CFU/g) against either pathogen. None of the treatments reduced seed germination. In vitro assays, as well as transmission electron microscopy, confirmed the antibacterial nature of the products that were effective against the two pathogens and indicated that they were bactericidal. When used at 20,000 ppm, the effective citrus-related products may be viable alternatives to chlorine for the sanitization of sprouting seed pending regulatory approval.

Scanning electron microscopy of native biofilms on mung bean sprouts.

Native biofilms present on the adaxial surface of cotyledons of mung bean sprouts (Vigna radiata) were studied by use of scanning electron microscopy. Biofilms were abundant on the cotyledon surfaces and were comprised of rod-shaped bacteria, cocci-shaped bacteria, or yeasts, often with one type of microbe predominant. In contrast to our earlier study of biofilms on green sprouts (alfalfa, clover, broccoli, and sunflower), yeast and cocci were abundant on mung bean. Filamentous fungi were not observed. Sheet-like or fibrillar material (presumably composed of secreted microbial polysaccharides, proteins, lipids, and nucleic acids) fully or partially covered the biofilms. Biofilms up to 5 mm in length were observed, and some biofilms were comprised of more than just a monolayer of microbial cells. Native biofilms on sprout surfaces undoubtedly play an important role in the ecology of plant epiphytic microbes and may also afford protected sites for plant and human bacterial pathogens.

Isolation of Salmonella from alfalfa seed and demonstration of impaired growth of heat-injured cells in seed homogenates.

Three major foodborne outbreaks of salmonellosis in 1998 and 1999 were linked to the consumption of raw alfalfa sprouts. In this report, an improved method is described for isolation of Salmonella from alfalfa seed lots, which had been implicated in these outbreaks. From each seed lot, eight samples each containing 25 g of seed were tested for the presence of Salmonella by the US FDA Bacteriological Analytical Manual (BAM) procedure and by a modified method applying two successive pre-enrichment steps. Depending on the seed lot, one to four out of eight samples tested positive for Salmonella by the standard procedure and two to seven out of eight samples tested positive by the modified method. Thus, the use of two consecutive pre-enrichment steps led to a higher detection rate than a single pre-enrichment step. This result indirectly suggested that Salmonella cells on contaminated seeds might be injured and failed to fully resuscitate in pre-enrichment broth containing seed components during the first 24 h of incubation. Responses of heat-injured Salmonella cells grown in buffered peptone water (BPW) and in three alfalfa seed homogenates were investigated. For preparation of seed homogenates, 25 g of seeds were homogenized in 200 ml of BPW using a laboratory Stomacher and subsequently held at 37 degrees C for 24 h prior to centrifugation and filtration. While untreated cells grew at about the same rate in BPW and in seed homogenates, heat-injured cells (52 degrees C, 10 min) required approximately 0.5 to 4.0 h longer to resuscitate in seed homogenates than in BPW. This result suggests that the alfalfa seed components or fermented metabolites from native bacteria hinder the repair and growth of heat-injured cells. This study also shows that an additional pre-enrichment step increases the frequency of isolation of Salmonella from naturally contaminated seeds, possibly by alleviating the toxic effect of seed homogenates on repair or growth of injured cells.

Composition and physiological profiling of sprout-associated microbial communities.

The native microfloras of various types of sprouts (alfalfa, clover, sunflower, mung bean, and broccoli sprouts) were examined to assess the relative effects of sprout type and inoculum factors (i.e., sprout-growing facility, seed lot, and inoculation with sprout-derived inocula) on the microbial community structure of sprouts. Sprouts were sonicated for 7 min or hand shaken with glass beads for 2 min to recover native microfloras from the surface, and the resulting suspensions were diluted and plated. The culturable fraction was characterized by the density (log CFU/g), richness (e.g., number of types of bacteria), and diversity (e.g., microbial richness and evenness) of colonies on tryptic soy agar plates incubated for 48 h at 30 degrees C. The relative similarity between sprout-associated microbial communities was assessed with the use of community-level physiological profiles (CLPPs) based on patterns of utilization of 95 separate carbon sources. Aerobic plate counts of 7.96 +/- 0.91 log CFU/g of sprout tissue (fresh weight) were observed, with no statistically significant differences in microbial cell density, richness, or diversity due to sprout type, sprout-growing facility, or seed lot. CLPP analyses revealed that the microbial communities associated with alfalfa and clover sprouts are more similar than those associated with the other sprout types tested. Variability among sprout types was more extensive than any differences between microbial communities associated with alfalfa and clover sprouts from different sprout-growing facilities and seed lots. These results indicate that the subsequent testing of biocontrol agents should focus on similar organisms for alfalfa and clover, but alternative types may be most suitable for the other sprout types tested. The inoculation of alfalfa sprouts with communities derived from various sprout types had a significant, source-independent effect on microbial community structure, indicating that the process of inoculation alters the dynamics of community development regardless of the types of organisms involved.

Relationship of cell surface charge and hydrophobicity to strength of attachment of bacteria to cantaloupe rind.

The cantaloupe melon has been associated with outbreaks of Salmonella infections. It is suspected that bacterial surface charge and hydrophobicity may affect bacterial attachment and complicate bacterial detachment from cantaloupe surfaces. The surface charge and hydrophobicity of strains of Salmonella, Escherichia coli (O157:H7 and non-O157:H7), and Listeria monocytogenes were determined by electrostatic and hydrophobic interaction chromatography, respectively. Initial bacterial attachment to cantaloupe surfaces and the ability of bacteria to resist removal by washing with water were compared with surface charge and hydrophobicity. Whole cantaloupes were submerged in inocula containing individual strains or in cocktails containing Salmonella, E. coli, and L. monocytogenes, either as a mixture of strains containing all three genera or as a mixture of strains belonging to a single genus, for 10 min. Inoculated cantaloupes were dried for 1 h in a biosafety cabinet and then stored for up to 7 days at 4 degrees C. Inoculated melons were washed with water, and bacteria still attached to the melon surface, as well as those in the wash water, were enumerated. Initial bacterial attachment was highest for individual strains of E. coli and lowest for L. monocytogenes, but Salmonella exhibited the strongest attachment on days 0, 3, and 7. When mixed-genus cocktails were used, the relative degrees of attachment of the three genera ware altered. The attachment of Salmonella strains was the strongest. but the attachment of E. coli was more extensive than that of L. monocytogenes on days 0, 3, and 7. There was a linear correlation between bacterial cell surface hydrophobicity (r2 = 0.767), negative charge (r2 = 0.738), and positive charge (r2 = 0.724) and the strength of bacterial attachment to cantaloupe surfaces.

Reduction of Escherichia coli O157:H7 and Salmonella spp. on laboratory-inoculated mung bean seed by chlorine treatmentt.

Three U.S. outbreaks of foodborne illness due to consumption of contaminated raw mung bean sprouts occurred in the past 2 years and were caused by Salmonella Enteritidis. The original source of the pathogens is thought to have been the seed. The aim of this study was to determine whether treatment with aqueous chlorine would eliminate the pathogens from mung bean seed inoculated in the laboratory with four-strain cocktails of Escherichia coli O157:H7 and Salmonella spp. Treatments (for 5, 10, or 15 min) with buffered (500 mM potassium phosphate, pH 6.8) or unbuffered solutions containing 0.3 or 3.0% (wt/vol) Ca(OCl)2 were tested. In order to mimic common commercial practice, seed was rinsed before and after treatment with sterile tap water. Treatment for 15 min with buffer (500 mM potassium phosphate, pH 6.8) or sterile water in combination with the seed rinses resulted in maximum reductions of approximately 3 log10 CFU/g. The largest reductions (4 to 5 log10 CFU/g) for the chlorine treatments in combination with the rinses were obtained after treatment with buffered 3.0% (wt/vol) Ca(OCl)2 for 15 min. Treatment of mung bean seed for 15 min with unbuffered or buffered 3.0% (wt/vol) Ca(OCl)2 did not adversely affect germination. Even though treatments with 3% (wt/vol) Ca(OCl)2 in combination with the water rinses were effective in greatly reducing the populations of both bacterial pathogens, these treatments did not result in the elimination of the pathogens from laboratory-inoculated seed.

Inactivation of Escherichia coli O157:H7 on inoculated alfalfa seeds with ozonated water and heat treatment.

Alfalfa seeds inoculated with a five-strain mixture of Escherichia coli O157:H7 were immersed in water containing 4, 8, 10, and 21 ppm of ozone for 2, 4, 8, 16, 32, and 64 min at 4 degrees C. Direct ozone sparging of seeds in water was used as an alternative mode of ozone treatment. Ozone-sparged seeds were also subsequently exposed to heat treatment at 40, 50, and 60 degrees C for 3 h. Populations of E. coli O157:H7 on untreated and treated seeds were determined by spread plating diluted samples on tryptic soy agar supplemented with 50 microg/ml of nalidixic acid. Since E. coli O157:H7 was released from inoculated seeds during treatment with ozone, the rate of release of cells from inoculated seeds soaked in 0.1% peptone water for up to 64 min was also determined. The overall reduction of E. coli O157:H7 on seeds treated with ozonated water without continuous sparging ranged from 0.40 to 1.75 log10 CFU/g (59.6 to 98.2%), whereas reductions for control seeds were 0.32 to 1.03 log10 CFU/g (51.7 to 90.5%). Treatment with higher ozone concentrations enhanced inactivation, but contact time longer than 8 min did not result in significantly higher reductions (P > 0.05). For seeds treated by ozone sparging, a 1.12-log10 CFU/g (92.1%) reduction was achieved using a 2-min contact time, and a 2.21-log10 CFU/g (99.4%) reduction was achieved with a 64-min contact time. The corresponding reductions for control seeds were 0.71 log10 CFU/g (79.5%) and 2.21 log10 CFU/g (99.4%), respectively. Treatment of ozone-sparged seeds at 60 degrees C for 3 h reduced the population to an undetectable level by direct plating (4 to 4.8 log10 CFU/g), although survivors were detected by enrichment. Ozone did not have a detrimental effect on seed germination percentage.

Detection and elimination of Salmonella mbandaka from naturally contaminated alfalfa seed by treatment with heat or calcium hypochlorite.

In 1999, consumption of alfalfa sprouts contaminated with Salmonella Mbandaka led to a multistate outbreak of salmonellosis. In this study, the implicated alfalfa seed lot (no. 8,119) was confirmed to be contaminated with Salmonella Mbandaka at a detection frequency of approximately 72% per replicated 100 g of seed. The sensitivity of detection was improved by a combination of nonselective and selective enrichment of 5.0 ml of germination effluent, followed by immunomagnetic separation. Detection of low levels of viable cells with nonselective enrichment, employed to enhance the recovery of stressed or injured cells, was facilitated by the application of Salmonella-specific polymerase chain reaction (PCR). With PCR assays, Salmonella Mbandaka was detectable on seed stored at 5 degrees C for at least 11 months, but at an increasingly diminishing frequency. Using conventional techniques, viable populations were detected in the seed germination effluent from seeds stored for up to 8 months. Seed treatments with buffered (to pH 7) and unbuffered solutions of calcium hypochlorite, providing approximately 2,000 and 20,000 ppm of free chlorine, for 10 min were equally effective in eliminating viable populations of Salmonella Mbandaka. However, aqueous heat treatments at up to 85 degrees C for 1 min did not eliminate the naturally occurring contaminant from the seed. Reductions of > 15% in germination were observed following heat treatments of 65 degrees C for > or = 6 min or 70 degrees C for > or = 4 min. On the basis of these results, aqueous heat treatments alone do not appear to be a viable alternative to hyperchlorination as an effective method to eliminate Salmonella from alfalfa seed.

Reduction of the native microflora on alfalfa sprouts during propagation by addition of antimicrobial compounds to the irrigation water.

Alfalfa and other types of sprouts are known to harbor large populations of native microorganisms. As some of these microbes may be causes of reduced shelf life of the product (plant pathogens and other spoilage organisms) and sprouts may, on occasion, harbor bacteria pathogenic towards humans, the addition of antimicrobial compounds to the irrigation water may be warranted. In this study, we tested the efficacy of several antimicrobial compounds for reducing the native microbial populations on alfalfa sprouts during propagation. These compounds included H2O2, peroxyacetic acid+hydrogen peroxide (Tsunami 100), acidified NaClO2, NaClO2 (Aquatize), EDTA, Na3PO4 and NaOCl. When added to the irrigation water at vanous concentrations, none of the antimicrobial compounds reduced the levels of any class of native microflora by more than 1 log10 without evidence of phytotoxicity.