Measurement of in vivo Gastrointestinal Release and Dissolution of Three Locally Acting Mesalamine Formulations in Regions of the Human Gastrointestinal Tract.

As an orally administered, locally acting gastrointestinal drug, mesalamine products are designed to achieve high local drug concentration in the gastrointestinal (GI) tract for the treatment of ulcerative colitis. The aim of this study was to directly measure and compare drug dissolution of three mesalamine formulations in human GI tract and to correlate their GI concentration with drug concentration in plasma. Healthy human subjects were orally administered Pentasa, Apriso, or Lialda. GI fluids were aspirated from stomach, duodenum, proximal jejunum, mid jejunum, and distal jejunum regions. Mesalamine (5-ASA) and its primary metabolite acetyl-5-mesalamine (Ac-5-ASA) were measured using LC-MS/MS. GI tract pH was measured from each GI fluid sample, which averaged 1.82, 4.97, 5.67, 6.17, and 6.62 in the stomach, duodenum, proximal jejunum, middle jejunum, and distal jejunum, respectively. For Pentasa, high levels of 5-ASA in solution were observed in the stomach, duodenum, proximal jejunum, mid jejunum, and distal jejunum from 1 to 7 h. Apriso had minimal 5-ASA levels in stomach, low to medium levels of 5-ASA in duodenum and proximal jejunum from 4 to 7 h, and high levels of 5-ASA in distal jejunum from 3 to 7 h. In contrast, Lialda had minimal 5-ASA levels from stomach and early small intestine. A composite appearance rate (CAR) was calculated from the deconvolution of individual plasma concentration to reflect drug release, dissolution, transit, and absorption in the GI tract. Individuals dosed with Pentasa had high levels of CAR from 1 to 10 h; individuals dosed with Apriso had low levels of CAR from 1 to 4 h and high levels of CAR from 5 to 10 h; Lialda showed minimal levels of CAR from 0 to 5 h, then increased to medium levels from 5 to 12 h, and then decreased to further lower levels after 12 h. In the colon region, Pentasa and Apriso showed similar levels of accumulated 5-ASA excreted in the feces, while Lialda showed slightly higher 5-ASA accumulation in feces. However, all three formulations showed similar levels of metabolite Ac-5-ASA in the feces. These results provide direct measurement of drug dissolution in the GI tract, which can serve as a basis for investigation of bioequivalence for locally acting drug products.

Solubility measurement of polymorphic compounds via the pH-metric titration technique.

In drug development, the thermodynamically most stable form of a compound is preferred because metastable forms are prone to transform to the stable form during processing, formulation, or storage [Guillory, J.K., 1999. Generation of polymorphs, hydrates, solvates, and amorphous solids. In: Brittain, H.G. (Ed.), Polymorphism in Pharmaceutical Solids. Marcel Dekker, New York, pp. 183-226]. It is therefore important to discover and characterize the stable form as early as possible. One of the most important properties to determine is thermodynamic solubility. However, due to compound and time constraints this solubility value is usually not determined until late in discovery. This report explores the ability of the pH-metric titration method to measure intrinsic solubility of the stable form of compounds that exist in one or more polymorphic forms. One metastable form and the stable form of eight compounds were examined. Intrinsic solubility was measured via pH-metric titration. The technique was performed on a larger scale in order to monitor polymorphic form changes by powder X-ray diffraction. Shake-flask solubility and corresponding X-ray diffraction data of each form was also determined. The results of this study indicate that, in general, when starting with a metastable polymorph, the pH-metric titration method is able to achieve the solubility of the stable form by the third titration, while the traditional shake-flask solubility method is unable to consistently determine the stable form solubility.