Optimization and characterization of an extruded snack based on taro flour (Colocasia esculenta L.) enriched with mango pulp (Mangifera indica L.).

The aim of this study was to optimize and characterize an extruded snack made with taro flour and mango pulp. A central experimental design composed of the following three variables was used: mango pulp proportion (MPP = 0-10 g/100 g) in taro flour, feed moisture content (FMC = 16-30 g/100 g) and extrusion temperature (zone 4 of extruder) (T = 80-150 °C) using a single-screw extruder with a compression screw ratio of 3:1. Increasing FMC values decreased the torque, pressure, specific mechanical energy (SME), expansion index (EI), water solubility index and pH values and increased the residence time, bulk density (BD), hardness and total colour difference. Increasing T values led to a decrease in the torque, pressure, BD and hardness values, while increasing MPP values only caused a significant increase in the hardness values and ß-carotene content and a decrease in the pressure value. The optimal extrusion conditions were T = 135.81 °C, FMC = 18.84 g/100 g and MPP = 7.97 g/100 g, with a desirability value of 0.772, to obtain a snack with EI = 1.52, BD = 0.66 g/cm3, hardness = 24.48 N, ß-carotene content = 99.1 µg/g and SME = 428.54 J/g. The mango pulp is an available and economical source of ß-carotene for the enrichment of extruded expanded taro snacks.

Behavior and Inactivation of Enterotoxin-Positive Clostridium perfringens in Pork Picadillo and Tamales Filled with Pork Picadillo under Different Cooking, Storage, and Reheating Conditions.

This study analyzed the behavior of Clostridium perfringens in individual ingredients and tamales containing different pathogen concentrations upon exposure to different temperatures and methods of cooking, storage, and reheating. In ground pork, C. perfringens cells were inactivated when exposed to 95°C for 30 min. Three lots of picadillo inoculated with 0, 3, and 5 log CFU/g C. perfringens cells, respectively, were exposed to different storage temperatures. At 20°C, cell counts increased 1 log in all lots, whereas at 8°C, counts decreased by 2 log. Four lots of tamales prepared with picadillo inoculated with 0, 2, 3, and 7 log CFU/g prior to the final cooking step exhibited no surviving cells (91°C for 90, 45, or 35 min). Four lots of tamales were inoculated after cooking with concentrations of 0, 0.6, 4, and 6 log CFU/g of the pathogen and then stored at different temperatures. In these preparations, after 24 h at 20°C, the count increased by 1.4, 1.7, and 1.8 log in the tamales inoculated with 0.6, 4, and 6 log inoculum, respectively. When they were stored at 8°C for 24 h, enumerations decreased to <1, 2.5, and 1.9 log in the tamales inoculated with 0.6, 4, and 6 log of C. perfringens cells, respectively. However, when the lots were exposed to 20°C and then 8°C, 0.8, 1.8, and 2.4 log changes were observed for the tamales inoculated with 0.6, 4, and 6 log, respectively. Microwaving, steaming, and frying to reheat tamales inoculated with 6 log CFU/g C. perfringens cells showed that the pathogen was inactivated after 2 min of exposure in the microwave and after 5 min of exposure to steam. In contrast, no inactivation was observed after 5 min of frying. The tamales inoculated with spores (7 log most probable number [MPN]/g) showed a decrease of 2 log after steaming or frying, and no survival was observed after microwaving. Tamales inoculated with spores (7 log MPN/g) after cooking were susceptible to microwaves, but 2.4 and 255 MPN/g remained after frying and steaming, respectively.

Antibacterial effect of roselle extracts (Hibiscus sabadariffa), sodium hypochlorite and acetic acid against multidrug-resistant Salmonella strains isolated from tomatoes.

UNLABELLED: Antibiotic-resistant Salmonella strains were isolated from saladette and red round type tomatoes, and an analysis done of the antibacterial activity of roselle calyx extracts against any of the identified strains. One hundred saladette tomato samples and 100 red round tomato samples were collected from public markets. Each sample consisted of four whole tomatoes. Salmonella was isolated from the samples by conventional culture procedure. Susceptibility to 16 antibiotics was tested for the isolated Salmonella strains by standard test. The antibacterial effect of four roselle calyx extracts (water, methanol, acetone and ethyl acetate), sodium hypochlorite and acetic acid against antibiotic-resistant Salmonella isolates was evaluated on contaminated tomatoes. Twenty-four Salmonella strains were isolated from 12% of each tomato type. Identified Salmonella serotypes were Typhimurium and Typhi. All isolated strains exhibited resistance to at least three antibiotics and some to as many as 12. Over contaminated tomatoes, the roselle calyx extracts produced a greater reduction (2-2·6 log) in antibiotic-resistant Salmonella strain concentration than sodium hypochlorite and acetic acid. SIGNIFICANCE AND IMPACT OF THE STUDY: The presence of multidrug-resistant Salmonella in vegetables is a significant public health concern. Multidrug-resistant Salmonella strains were isolated from raw tomatoes purchased in public markets in Mexico and challenged with roselle Hibiscus sabdariffa calyx extracts, sodium hypochlorite and acetic acid. On tomatoes, the extracts caused a greater reduction in the concentration of antibiotic-resistant Salmonella strains than sodium hypochlorite and acetic acid. Roselle calyx extracts are a potentially useful addition to disinfection procedures of raw tomatoes in the field, processing plants, restaurants and homes.

Behaviour of four diarrheagenic Escherichia coli pathotypes on carrots and in unpasteurized carrot juice.

UNLABELLED: The behaviours of Shiga toxin-producing Escherichia coli (STEC), enteroinvasive E. coli (EIEC), enteropathogenic E. coli (EPEC) and enterotoxigenic E. coli (ETEC) strains on raw carrots at 3 ± 1 and 30 ± 1°C, and in unpasteurized carrot juice at 3 ± 1, 12 ± 1, 20 ± 1, 30 ± 1°C and 37 ± 1°C were determined. Raw carrots were purchased in a local market. Fresh juice was obtained from raw carrots in the laboratory. On whole carrots stored at 30 ± 1 or 3 ± 1°C, no growth was observed for any of the diarrheagenic E. coli pathotype (DEPs) strains studied. After 15 days at 30 ± 1°C, the tested DEPs had decreased from an initial inoculum level of approximately 6 log colony-forming units (CFU) to approximately 3·5 log CFU on whole carrots, while at 3 ± 1°C, they decreased from approximately 2·4 log to 1·6 log CFU. All these DEPs grew in fresh carrot juice at 12 ± 1, 20 ± 1, 30 ± 1 and 37 ± 1°C, reaching counts of approximately 4·2 log, 5·8 log, 6·7 log and 7·5 log CFU ml(-1) , respectively, after 24 h. At 3 ± 1°C, the DEP growth was inhibited at least during 7 days. Thus, storage of carrot juice at unrefrigerated temperatures can result in DEP growth to levels likely to represent a risk to consumers. SIGNIFICANCE AND IMPACT OF THE STUDY: The information presented shows the potential of Shiga toxin-producing Escherichia coli, enteroinvasive E. coli, enteropathogenic E. coli and enterotoxigenic E. coli strains for survival on carrots and growth in carrot juice at warmer temperatures. The information can help food processors in plants and restaurants understand the importance of the implementation of hazard analysis and critical control point (HACCP) strategies for preventing potential diarrheagenic E. coli pathotypes (DEPs) contamination and growth in carrot juice. This is the first report regarding the behaviour these DEPs on carrots and in carrot juice.

Microbiological safety of domestic refrigerators and the dishcloths used to clean them in Guadalajara, Jalisco, Mexico.

Household refrigerators are a potential pathogen contamination source for foods. An evaluation of the microbiological safety of 200 refrigerators in Guadalajara, Jalisco, Mexico, was made by visual inspection, ATP-bioluminescence levels, indicator microorganisms including Escherichia coli and Staphylococcus aureus, and the presence of Listeria monocytogenes and Salmonella. Additionally, interviews of the owners of the refrigerators were carried out to determine relationships between food storage practices, demographic aspects, and microbiological status. Dishcloths used to clean refrigerators were also analyzed. Operational conditions (cleanliness, fullness, organization, frequency of cleaning, and temperature) were evaluated by trained observers. Results showed deficient cleanliness in 55% of refrigerators, 22% were completely full, 43% very disorganized, 28% were usually cleaned only once in 3 to 6 months, and 53% had internal temperatures >7.1°C. ATP-bioluminescence levels were >300 relative light units on 67 and 74% of shelves and drawers, respectively, indicating that surfaces were dirty according to the luminometer manufacturer. Psychrotrophic aerobic bacteria counts on shelves, drawers, and dishcloths were 6.3, 5.2, and 6.3 log CFU/cm(2); for coliform bacteria, 5.2, 3.9, and 4.7 CFU/cm(2); for E. coli, 3.7, 3.5, and 4.8 CFU/cm(2); and for Staphylococcus aureus, 2.1, 2.5, and 2.3 CFU/cm(2), respectively. L. monocytogenes and Salmonella were isolated from 59.5, 20.5, and 17% and 32.5, 8.0 and 12.5% of shelves, drawers, and dishcloths, respectively. Four Salmonella serotypes and nine serogroups (partially serotyped isolates) were identified. The most prevalent were Salmonella Anatum (39.5%), Salmonella group E1 (19.7%), and Salmonella group E1 monophasic (12.5%). Operational conditions and microbiological status were clearly deficient in sampled refrigerators, highlighting the consequent risk of foodborne disease among users. Educational programs are needed to improve the domestic food safety in Mexico.

Frequency of indicator bacteria, Salmonella and diarrhoeagenic Escherichia coli pathotypes on ready-to-eat cooked vegetable salads from Mexican restaurants.

UNLABELLED: The presence of coliform bacteria, faecal coliforms, Escherichia coli, diarrhoeagenic E. coli pathotypes (DEP) and Salmonella were determined in ready-to-eat cooked vegetable salads (RECS) from restaurants in Pachuca city, Mexico. The RECS were purchased from three types of restaurants: national chain restaurants (A), local restaurants (B) and small restaurants (C). Two restaurants for each A and B, and three for C, were included. Forty RECS samples were purchased at each A and B restaurant and 20 at each C restaurant. Of the overall total of 220 analysed samples, 100, 98·2, 72·3, 4·1 and 4·1% had coliform bacteria, faecal coliforms, E. coli, DEP and Salmonella, respectively. Identified DEP included enteropathogenic E. coli (EPEC), enterotoxigenic E. coli (ETEC) and Shiga toxin-producing E. coli (STEC). The EPEC, ETEC and STEC were isolated each from 1·4% of samples. No E. coli O157:H7 were detected in any STEC-positive samples. The analysis of Kruskal-Wallis anova and median test of microbiological data showed that the microbiological quality of RECS did not differ between the different restaurants (P > 0·05). SIGNIFICANCE AND IMPACT OF THE STUDY: This is the first report regarding microbiological quality and Salmonella, enteropathogenic E. coli (EPEC), enterotoxigenic E. coli (ETEC) and Shiga toxin-producing E. coli (STEC) isolation from ready-to-eat cooked vegetable salads from Mexican restaurants. Ready-to-eat cooked vegetable salads could be an important factor contributing to the endemicity of EPEC, ETEC and STEC, and Salmonella caused gastroenteritis in Mexico.

Presence of indicator bacteria, diarrhoeagenic Escherichia coli pathotypes and Salmonella in fresh carrot juice from Mexican restaurants.

UNLABELLED: Coliform bacteria (CB), faecal coliforms (FC), Escherichia coli, diarrhoeagenic E. coli pathotypes (DEP) and Salmonella frequencies were determined for fresh carrot juice from restaurants in Pachuca city, Mexico. Two hundred and eighty carrot juice samples were purchased in three types of restaurants: (A), national chain restaurants; (B), local restaurants; and (C), very small restaurants. Two restaurants for each A and B, and three for C, were included. Forty juice samples were purchased at each restaurant. All tested juice samples had poor microbiological quality. Of these samples, 100, 96·8, 54·3, 8·9 and 8·6% had CB, FC, E. coli, DEP and Salmonella, respectively. CB were present in all juice samples regardless of source, with limits ranging from 3·6 × 10² to 8·5 × 107 CFU ml⁻¹, and the limits for FC and E. coli were <3 to 1100 MPN ml⁻¹ and <3 to 460 MPN, respectively. DEP and Salmonella were isolated from samples from all the restaurants at levels of 5% or above: DEP, 5% (A1, B2, 10% (A2, B1, C1, C2) and 12·5% (C3); Salmonella, 5% (A1, A2, B2), 7·5% (C2), 10% (C1, 12·5% (B1) and 15% (C3). SIGNIFICANCE AND IMPACT OF THE STUDY: This is the first report of microbiological quality and Salmonella, enteroinvasive E. coli (EIEC), enterotoxigenic E. coli (ETEC) and Shiga toxin-producing E. coli (STEC) isolation from fresh carrot juice in Mexico. Fresh carrot juice from restaurants could be an important factor contributing to the endemicity of EIEC-, ETEC- and STEC- and Salmonella-caused gastroenteritis in Mexico.

Incidence of Salmonella, Listeria monocytogenes, Escherichia coli O157:H7, and Staphylococcal enterotoxin in two types of Mexican fresh cheeses.

Handcrafted fresh cheeses are popular among consumers in Mexico. However, unsafe raw materials and inadequate food safety practices during cheese manufacture and preservation make them a potential public health risk. The incidence of Salmonella, Listeria, Escherichia coli O157:H7, and staphylococcal enterotoxin was analyzed in two types of fresh cheese (panela and adobera) commonly marketed in Mexico. A total of 200 samples, 100 panela and 100 adobera, were acquired from 100 wholesale milk product distributors who supply small retailers in the Guadalajara metropolitan area, Jalisco State, Mexico. Pathogens were identified using culture and immunoassay (miniVidas) methods. The presence of staphylococcal enterotoxin was determined by an immunoassay method. Of the 200 analyzed samples, 92 were positive for at least one of the pathogens. The incidence in the panela samples was 56%: 34% Salmonella, 16% E. coli O157:H7, and 6% L. monocytogenes. In the adobera samples, incidence was 36%: 20% Salmonella, 4% E. coli O157:H7, and 12% L. monocytogenes. Staphylococcal enterotoxin was not detected in any of the 200 samples. Choice of technique had no effect on detection of pathogen incidence, although the immunoassay method identified more Salmonella serotypes than the culture method. Handcrafted panela and adobera fresh cheeses in Mexico frequently contain pathogenic bacteria and therefore pose a public health risk.

[Chemical and nutritional changes during preparation of whole corn tortillas prepared with instant flour obtained by extrusion process]. / Cambios en algunos componentes químicos y nutricionales durante la preparación de tortillas de maíz elaboradas con harinas instantáneas obtenidas por extrusión continua.

Chemical changes of some nutritional components (protein, total dietary fiber, vitamins, lysine, tryptophan, ether extract and fatty acids) of tortillas made from instant whole corn flour prepared by extrusion process (CINVESTAV process) were evaluated. The tortillas prepared by extrusion process were compared with tortillas made by traditional process and raw corn. The protein content of tortillas from both processes were statistically similar to those of the raw corn, although the traditional tortillas showed the lowest actual values. Tortillas from traditional process contained the lowest amount of total dietary fiber and available lysine. The loss of protein, crude fiber, total dietary fiber, available lysine, tryptophan, and vitamin contents during traditional tortillas process, was attributable to the partial loss of pericarp, aleurone and germ tissue during the process. Tortillas prepared by both processes showed loss of vitamins. The thermal treatment in both processes (traditional and extrusion) decreased the ether extract and fatty acids contents. Tortillas prepared by extrusion process showed better nutritional characteristics than traditional tortillas prepared by nixtamalization process.