A single immunogenicity assay for testing potency of combination DTaP vaccines: Simultaneous quantitation of anti-DT, anti-TT, anti-PTxd and anti-FHA antibodies in Guinea-pig serum with a Luminex®-xMAP® bead-based serological assay.

The diphtheria toxoid (DT), tetanus toxoid (TT), and acellular pertussis (aP) single immunogenicity assay (DTaP SIA) is a Luminex®-xMAP®-bead-based multiplex immunoassay for estimating the potency of DTaP pediatric combination vaccines in guinea pigs. This manuscript describes the validation of this assay for the simultaneous quantitation of anti-diphtheria toxoid (anti-DT), anti-tetanus toxoid (anti-TT), anti-pertussis toxoid (anti-PTxd), and anti-filamentous hemagglutinin (anti-FHA) antibodies in guinea pig serum following injection of a DTaP vaccine formulation. The results were expressed in arbitrary units/mL (AU/mL) using reference serum for comparison. Specificity was demonstrated by ≥ 75% homologous and ≤25% heterologous inhibition for all the antigens. The results were linear for anti-DT, anti-TT, anti-PTxd and anti-FHA antibodies. Accuracy was demonstrated with recovery of between 80% and 120% for all four antibodies. The relative standard deviation of repeatability was ≤20%. The results demonstrate that this SIA can be used for the linear, accurate, and precise simultaneous detection of all four antibodies, based on both the ICH Q2 and the EMA guidelines on bioanalytical method validation.

Potency test to discriminate between differentially over-inactivated rabies vaccines: Agreement between the NIH assay and a G-protein based ELISA.

The NIH assay is used to assess the potency of rabies vaccine and is currently a key measure required for vaccine release. As this test involves immunization of mice and subsequent viral challenge, efforts are being made to develop alternative analytical methods that do not rely on animal testing. Sanofi Pasteur has reported the development of a G-protein specific ELISA assay that has shown agreement with the NIH test. In this study we have generated several non-conform vaccine lots by an excessive inactivation with ß-propiolactone (BPL) and assessed the capacity of both tests to detect the corresponding consequences. Excessive BPL inactivation causes G-protein unfolding, altering in turn viral morphology and the continuity of the G-protein layer in the viral particle. Both the NIH and the ELISA tests were able to monitor the consequences of excessive inactivation in a similar manner. Of note, the experimental error of the ELISA test was well below that of the NIH test. These results increase the prospect that the ELISA test could be considered a suitable candidate for the replacement of the NIH test.

G-protein based ELISA as a potency test for rabies vaccines.

The NIH test is currently used to assess the potency of rabies vaccine, a key criterion for vaccine release. This test is based on mice immunization followed by intracerebral viral challenge. As part of global efforts to reduce animal experimentation and in the framework of the development of Sanofi Pasteur next generation, highly-purified vaccine, produced without any material of human or animal origin, we developed an ELISA as an alternative to the NIH test. This ELISA is based on monoclonal antibodies recognizing specifically the native form of the viral G-protein, the major antigen that induces neutralizing antibody response to rabies virus. We show here that our ELISA is able to distinguish between potent and different types of sub-potent vaccine lots. Satisfactory agreement was observed between the ELISA and the NIH test in the determination of the vaccine titer and their capacity to discern conform from non-conform batches. Our ELISA meets the criteria for a stability-indicating assay and has been successfully used to develop the new generation of rabies vaccine candidates. After an EPAA international pre-collaborative study, this ELISA was selected as the assay of choice for the EDQM collaborative study aimed at replacing the rabies vaccine NIH in vivo potency test.