Human T-lymphotropic virus tax activates human cytomegalovirus major-immediate early promoter and improves production of recombinant proteins in HEK293 cells.

The human cytomegalovirus (CMV) major immediate-early (MIE) promoter is widely used in mammalian cells for production of recombinant proteins. It is of great interest to further enhance protein production driven by the CMV promoter. Here, we report that the Tax protein of human T-lymphotropic virus stimulates the transgene expression under the control of CMV MIE promoter in HEK293 cells. At least threefold increases in transient production of recombinant proteins, including luciferase and two biopharmaceutical proteins (erythropoietin and interferon-γ), were detected. Furthermore, cyclic adenosine monophosphate (AMP)-response element binding protein 2 (CREB2) was identified as a cellular cofactor, which might be responsible for Tax transactivation of the CMV MIE promoter. Our results not only demonstrate the potential use of this novel expression strategy for improvement of recombinant protein production in HEK293 cells but also provide the molecular mechanism for Tax-mediated activation of CMV MIE promoter.

High-density transient gene expression in suspension-adapted 293 EBNA1 cells.

Large-scale transient gene expression (TGE) in mammalian cells is an attractive method to rapidly produce recombinant proteins for pre-clinical studies, with some processes reported to reach 100 L. However, the yield remains low, hardly over 20 mg protein/L, mainly because the current TGEs have been performed at low cell density (approximately 5 x 10(5) cells/mL). In this study, the strategy to improve TGE focuses on facilitating transfection at high cell density. A high-density perfusion culture of 293 EBNA1 cells was established in 2-L bioreactor using Freestyle 293 expression medium (Invitrogen, Singapore) to grow the cells for transfection. Transfection was then carried out at 1 x 10(7) cells/mL using polyethylenimine (PEI) as DNA carrier, at the optimized conditions of 6 microg DNA/10(7) cells and 1:3 DNA to PEI mass ratio. During the post-transfection phase, 80.8 mg/L of the model protein, EPO was obtained at day 5.5 post-transfection (130 mg total EPO production) using a fed-batch culture mode. In comparison, perfusion cultures using an enriched SFM II medium resulted in a longer post-transfection production phase (8 days), and 227 mg of EPO was produced in 10.7 L medium, showing that high-density TGE enables the production of several hundreds of milligrams of protein in a 2 L bioreactor. In addition, a protocol for economical plasmid preparation based on anion exchange was also established to satisfy TGE's demand in terms of quality and quantity. To the best of our knowledge, this is the first report of transient transfections at a high cell density of up to 1 x 10(7) cells/mL.

Acid hydrolysis and quantitative determination of total hexosamines of an exopolysaccharide produced by Citrobacter sp.

During the hydrolysis of an exopolysaccharide (EPS) produced by Citrobacter sp., the maximum liberation of hexosamine was obtained with 6 M HCl at 115 degrees C in an autoclave for 1 h. The glycosidic bond energy and degree of acetylation of the hexosamine in EPS were approximately 77 kJ mol(-1) and 61%, respectively. Thermal destruction of the hexosamines and the effect of salt on the hexosamine determination could be minimized under the optimized hydrolytic conditions. Using a modified Elson-Morgan method, maximum total hexosamine concentration was determined to be 3.2 g l(-1) (29% of crude EPS) after 96 h of fed-batch culture.

Improved borate method for the rapid distinction of glucosamine and galactosamine in an exopolysaccharide produced by Citrobacter sp.

An improved borate method for the quantitative distinction of glucosamine (GlcN) and galactosamine (GalN) in a mixture is presented which is based on the Elson-Morgan method with addition of sodium borate to differentiate colour formation by the two hexosamines. The r2 value and maximum deviation of the method based on calculations derived in this study were 0.9979 and 5.1 %, respectively. Using this method, the GlcN/GalN ratio in an exopolysaccharide (EPS) produced by Citrobacter sp. was found to change with time during the production process, with a maximum value at 9.8:1.