RESUMEN
This study aims to characterize a complete volatile organic compound profile of pork neck fat for boar taint prediction. The objectives are to identify specific compounds related to boar taint and to develop a classification model. In addition to the well-known androstenone, skatole and indole, 10 other features were found to be discriminant according to untargeted volatolomic analyses were conducted on 129 samples using HS-SPME-GC×GC-TOFMS. To select the odor-positive samples among the 129 analyzed, the selection was made by combining human nose evaluations with the skatole and androstenone concentrations determined using UHPLC-MS/MS. A comparison of the data of the two populations was performed and a statistical model analysis was built on 70 samples out of the total of 129 samples fully positive or fully negative through these two orthogonal methods for tainted prediction. Then, the model was applied to the 59 remaining samples. Finally, 7 samples were classified as tainted.
Asunto(s)
Carne de Cerdo , Carne Roja , Porcinos , Masculino , Animales , Humanos , Escatol/análisis , Espectrometría de Masas en Tándem , Carne de Cerdo/análisis , Carne Roja/análisis , Odorantes/análisis , Carne/análisisRESUMEN
Mass spectrometry has been widely accepted as a confirmatory tool for the sensitive detection of undeclared presence of allergenic ingredients. Multiple methods have been developed so far, achieving different levels of sensitivity and robustness, still lacking harmonization of the analytical validation and impairing comparability of results. In this investigation, a quantitative method has been validated in-house for the determination of six allergenic ingredients (cow's milk, hen's egg, peanut, soybean, hazelnut, and almond) in a chocolate-based matrix. The latter has been produced in a food pilot plant to provide a real and well-characterized matrix for proper assessment of method performance characteristics according to official guidelines. In particular, recent considerations issued by the European Committee for Standardization have been followed to guide a rigorous single-laboratory validation and to feature the main method performance, such as selectivity, linearity, and sensitivity. Synthetic surrogates of the peptide markers have been used both in native and labelled forms in matrix-matched calibration curves as external calibrants and internal standards, respectively. A two-order of magnitude range was investigated, focusing on the low concentration range for proper assessment of the detection and quantification limits (LOD and LOQ) by rigorous calibration approach. Conversion factors for all six allergenic ingredients have been determined for the first time to report the final quantitative information as fraction of total allergenic food protein (TAFP) per mass of food (µgTAFP/gfood), since such a reporting unit is exploitable in allergenic risk assessment plans. The method achieved good sensitivity with LOD values ranging between 0.08 and 0.2 µgTAFP/gfood, for all ingredients besides egg and soybean, whose quantitative markers reported a slightly higher limit (1.1 and 1.2 µgTAFP/gfood, respectively). Different samples of chocolate bar incurred at four defined concentration levels close to the currently available threshold doses have been analyzed to test the quantitative performance of the analytical method, with a proper estimate of the measurement uncertainty from different sources of variability. The sensitivity achieved resulted in compliance with the various threshold doses issued or recommended worldwide.
Asunto(s)
Cacao , Chocolate , Hipersensibilidad a los Alimentos , Bovinos , Animales , Femenino , Chocolate/análisis , Cromatografía Líquida con Espectrometría de Masas , Cromatografía Liquida/métodos , Pollos , Espectrometría de Masas en Tándem/métodos , Huevos/análisis , Alérgenos/análisis , Análisis de los Alimentos/métodosRESUMEN
BACKGROUND: Food allergen analysis is essential for the development of a risk-based approach for allergen management and labeling. MS has become a method of choice for allergen analysis, even if quantification remains challenging. Moreover, harmonization is still lacking between laboratories, while interlaboratory validation of analytical methods is necessary for such harmonization. OBJECTIVE: This interlaboratory study aimed to evaluate the potential of MS for food allergen detection and quantification using a standard addition quantification strategy and a stable isotope-labeled (SIL) concatemer as an internal standard. METHODS: In-house-produced test material (cookies), blank and incurred with four allergens (egg, milk, peanut, and hazelnut), allergen standards, an internal standard, and the complete methodology (including sample preparation and ultra-HPLC-MS/MS method) were provided to nine laboratories involved in the study. Method sensitivity and selectivity were evaluated with incurred test material and accuracy with spiked test material. Quantification was based on the standard addition strategy using certified reference materials as allergen protein standards and a SIL concatemer as an internal standard. RESULTS: All laboratories were able to detect milk, hazelnut, and peanut in the incurred cookies with sufficient sensitivity to reach the AOAC INTERNATIONAL Standard Method Performance Requirements (SMPR® 2016.002). Egg detection was more complicated due to food processing effects, yet five laboratories reached the sensitivity requirements. Recovery results were laboratory-dependent. Some milk and hazelnut peptides were quantified in agreement with SMPR 2016.002 by all participants. Furthermore, over 90% of the received quantification results agreed with SMPR 2016.002 for method precision. CONCLUSION: The encouraging results of this pioneering interlaboratory study represent an additional step towards harmonization among laboratories testing for allergens. HIGHLIGHTS: In this pioneering interlaboratory study, food allergens were analyzed by MS with characterized incurred and spiked test materials, calibrated with a certified reference material, and a single SIL concatemer used as an internal standard.
Asunto(s)
Hipersensibilidad a los Alimentos , Espectrometría de Masas en Tándem , Humanos , Espectrometría de Masas en Tándem/métodos , Alérgenos/análisis , Cromatografía Líquida de Alta Presión/métodos , Péptidos/análisis , Análisis de los Alimentos/métodosRESUMEN
The design and production of incurred test materials are critical for the development and validation of methods for food allergen analysis. This is because production and processing conditions, together with the food matrix, can modify allergens affecting their structure, extractability and detectability. For the ThRAll project, which aims to develop a mass spectrometry-based reference method for the simultaneous accurate quantification of six allergenic ingredients in two hard to analyse matrices. Two highly processed matrices, chocolate bars and broth powder, were selected to incur with six allergenic ingredients (egg, milk, peanut, soy, hazelnut and almond) at 2, 4, 10 and 40 mg total allergenic protein/kg food matrix using a pilot-scale food manufacturing plant. The allergenic activity of the ingredients incurred was verified using food-allergic patient serum/plasma IgE, the homogeneity of the incurred matrices verified and their stability at 4 °C assessed over at least 30-month storage using appropriate enzyme-linked immunosorbent assays (ELISA). Allergens were found at all levels from the chocolate bar and were homogenously distributed, apart from peanut and soy which could only be determined above 4 mg total allergenic ingredient protein/kg. The homogeneity assessment was restricted to analysis of soy, milk and peanut for the broth powder but nevertheless demonstrated that the allergens were homogeneously distributed. All the allergens tested were found to be stable in the incurred matrices for at least 30 months demonstrating they are suitable for method development.
Asunto(s)
Chocolate , Hipersensibilidad a los Alimentos , Alérgenos/análisis , Arachis/química , Chocolate/análisis , Ensayo de Inmunoadsorción Enzimática , Análisis de los Alimentos/métodos , Humanos , PolvosRESUMEN
Peptide marker identification is an important step in development of a mass spectrometry method for multiple allergen detection, since specificity, robustness and sensitivity of the overall analytical method will depend on the reliability of the proteotypic peptides. As part of the development of a multi-analyte reference method, discovery analysis of two incurred food matrices has been undertaken to select the most reliable peptide markers. Six allergenic ingredients (milk, egg, peanut, soybean, hazelnut, and almond) were incurred into either chocolate or broth powder matrix. Different conditions of protein extraction and purification were tested and the tryptic peptide pools were analysed by untargeted high resolution tandem mass spectrometry and the resulting fragmentation spectra were processed via a commercial software for sequence identification. The analysis performed on incurred foods provides both a prototype effective and straightforward sample preparation protocol and delivers reliable peptides to be included in a standardized selected reaction monitoring method.
Asunto(s)
Alérgenos/química , Chocolate/análisis , Análisis de los Alimentos/métodos , Espectrometría de Masas en Tándem , Animales , Polvos , Reproducibilidad de los ResultadosRESUMEN
Peptide marker identification is one of the most important steps in the development of a mass spectrometry (MS) based method for allergen detection, since the robustness and sensitivity of the overall analytical method will strictly depend on the reliability of the proteotypic peptides tracing for each allergen. The European legislation in place issues the mandatory labelling of fourteen allergenic ingredients whenever used in different food formulations. Among these, six allergenic ingredients, namely milk, egg, peanut, soybean, hazelnut and almond, can be prioritized in light of their higher occurrence in food recalls for undeclared presence with serious risk decision. In this work, we described the results of a comprehensive evaluation of the current literature on MS-based allergen detection aiming at collecting all available information about proteins and peptide markers validated in independent studies for the six allergenic ingredients of interest. The main features of the targeted proteins were commented reviewing all details available about known isoforms and sequence homology particularly in plant-derived allergens. Several critical aspects affecting peptide markers reliability were discussed and according to this evaluation a final short-list of candidate markers was compiled likely to be standardized and implemented in MS methods for allergen analysis.
Asunto(s)
Alérgenos/análisis , Alérgenos/inmunología , Análisis de los Alimentos/métodos , Hipersensibilidad a los Alimentos/inmunología , Espectrometría de Masas/métodos , Péptidos/análisis , Biomarcadores/análisis , Péptidos/inmunología , Reproducibilidad de los ResultadosRESUMEN
A sensitive competitive indirect enzyme-linked immunosorbent assay (ciELISA) was developed for the detection and quantification of citrinin (CIT) in grain-based food samples. The limit of quantification (IC20) of the established method was 0.10 ± 0.02 ng mL-1, with the limit of detection (IC10) being 0.04 ± 0.007 ng mL-1 in wheat and corn flour matrices with a coefficient of variation (CV) less than 20%. The assay was very specific to CIT and showed no cross-reactivity with other mycotoxins (OTA, T-2 toxin, HT-2 toxin, DON, patulin and zearalenone). In spiked wheat and corn flours, the recoveries ranged from 86.6% to 115.6% with CVs of less than 20%. The effectiveness of this method was verified by participating in a proficiency test (PT) from the Food Analysis Performance Assessment Scheme (FAPAS) 17181 corn flour. A successful z-score (-0.6) for this PT sample showed that the present method is comparable to the instrumental methods used by other laboratories in the PT testing scheme. A small survey of grain-based foods was conducted using this method and CIT was detected in 43% of the samples up to a concentration of 17.7 ng g-1. This method is suitable for sensitive and rapid quantitation of citrinin in wheat and corn matrices.
Asunto(s)
Anticuerpos/inmunología , Citrinina/análisis , Grano Comestible/química , Ensayo de Inmunoadsorción Enzimática , Análisis de los Alimentos , Contaminación de Alimentos/análisis , Especificidad de Anticuerpos , Reacciones Antígeno-Anticuerpo , Citrinina/inmunologíaRESUMEN
Risk-based approaches to managing allergens in foods are being developed by the food industry and regulatory authorities to support food-allergic consumers to avoid ingestion of their problem food, especially in relation to the traces of unintended allergens. The application of such approaches requires access to good quality data from clinical studies to support identification of levels of allergens in foods that are generally safe for most food-allergic consumers as well as analytical tools that are able to quantify allergenic food protein. The ThRAll project aims to support the application of risk-based approaches to food-allergen management in two ways. First, a harmonized quantitative MS-based prototype reference method will be developed for the detection of multiple food allergens in standardized incurred food matrices. This will be undertaken for cow's milk, hen's egg, peanut, soybean, hazelnut, and almond incurred into two highly processed food matrices, chocolate and broth powder. This activity is complemented by a second objective to support the development and curation of data on oral food challenges, which are used to define thresholds and minimum eliciting doses. This will be achieved through the development of common protocols for collection and curation of data that will be applied to allergenic foods for which there are currently data gaps.
Asunto(s)
Alérgenos/análisis , Contaminación de Alimentos/análisis , Hipersensibilidad a los Alimentos/inmunología , Alérgenos/inmunología , Animales , Chocolate/análisis , Relación Dosis-Respuesta Inmunológica , Comida Rápida/análisis , Humanos , Espectrometría de Masas , Leche/química , Leche/inmunología , Nueces/química , Nueces/inmunología , Plantas/química , Plantas/inmunologíaRESUMEN
Background: Celiac disease, a complex, long-term autoimmune disorder and gluten intolerance, is estimated to affect from 1 to 5% of the world's population. Objective: As a consequence, to protect gluten-sensitive consumers, the development of reliable analytical methods allowing the detection of gluten in various food products is needed. Methods: Currently, ELISA is probably the most widespread used methodology. The method based on the R5 antibody has received type I status in Codex Alimentarius. However, the ELISA method suffers from some limitations, especially concerning quantification of nonwheat gluten. As a consequence, the development of another complementary methodology such as LC-tandem MS (MS/MS) is considered to be essential. Furthermore, this method could also be used for the simultaneous detection of gluten with other allergens, which will constitute a great additional benefit for producers of "free-from" food products and/or having a management policy integrated for several allergies and/or intolerances. Results: A multi-allergen and grain-specific ultra-HPLC coupled to MS/MS method allowing the identification and the discrimination of gluten from seven cereals, simultaneously with the detection and identification of 10 allergens in only one analysis, is thus described here. Conclusions: This method can be used for the analysis of a broad range of foodstuff matrices containing wheat and/or its derivatives, including cereals, flours, heat-treated and foodstuffs, but also more complex samples having undergone fermentation processes (such as beers).
Asunto(s)
Alérgenos/análisis , Cromatografía Líquida de Alta Presión/métodos , Grano Comestible/química , Glútenes/análisis , Espectrometría de Masas en Tándem/métodos , Secuencia de Aminoácidos , Ensayo de Inmunoadsorción Enzimática/métodos , Límite de Detección , Péptidos/análisis , Poaceae/químicaRESUMEN
Sterigmatocystin (STC) is a toxic secondary metabolite produced by more than 50 fungal species, including Aspergillus flavus, A. parasiticus, A. nidulans, and A. versicolor. The Joint FAO/WHO Expert Committee on Food Additives concluded that sterigmatocystin is genotoxic and carcinogenic with the critical effect determined to be carcinogenicity. The present study describes a simple method to prepare hapten and immunogens in order to generate polyclonal antibodies against this metabolite. We developed a sensitive and specific polyclonal antibody-based competitive indirect enzyme-linked immunosorbent assay (ciELISA) for monitoring STC in wheat and corn flours without the need for derivatisation of STC or clean-up of samples by immunoaffinity chromatography for quantification. The half inhibitory concentration (IC50) of the established method was 4.52 ± 0.81 ng mL-1, with the limit of detection (IC10) being 0.19 ± 0.04 ng mL-1 in wheat and corn flour matrices with the coefficient of variation of less than 22%.The assay was very specific to STC and showed no cross-reactivity with its analogue structures. The ELISA allowed for up to 5% methanol without significant influence on the IC50 value. Validation of the assay was performed by spiking STC into a blank flour matrix and the recoveries were in the range of 75.3 % to 104.5 % with a coefficient of variation less than 15%. A small retail survey was conducted by purchasing wheat (n = 8) and corn flours (n = 2) from local grocery stores. All of these retail samples were negative for STC using the developed ELISA method and were confirmed by LC-MS/MS. We demonstrated a rapid, simple, and reliable method for screening STC in wheat and corn flours.
Asunto(s)
Anticuerpos/química , Ensayo de Inmunoadsorción Enzimática , Harina/análisis , Contaminación de Alimentos/análisis , Esterigmatocistina/análisis , Triticum/química , Zea mays/químicaRESUMEN
Paralytic shellfish toxins (PSTs) in bivalve molluscs represent a public health risk and are controlled via compliance with a regulatory limit of 0.8 mg saxitoxin (STX)â 2HCl equivalents per kilogram of shellfish meat (eq/kg). Shellfish industries would benefit from the use of rapid immunological screening tests for PSTs to be used for regulation, but to date none have been fully validated. An interlaboratory study involving 16 laboratories was performed to determine the suitability of the Neogen test to detect PSTs in mussels and oysters. Participants performed the standard protocol recommended by the manufacturer and a modified protocol with a conversion step to improve detection of gonyautoxin 1&4. The statistical analysis showed that the protocols had good homogeneity across all laboratories, with satisfactory repeatability, laboratory, and reproducibility variation near the regulatory level. The mean probability of detection (POD) at 0.8 mg STXâ 2HCl eq/kg using the standard protocol in mussels and oysters was 0.966 and 0.997, respectively, and 0.968 and 0.966 using the modified protocol. The estimated LOD in mussels was 0.316 mg STXâ 2HCl eq/kg with the standard and 0.682 mg STXâ 2HCl eq/kg with the modified protocol, and 0.710 and 0.734 mg STXâ 2HCl eq/kg for oysters, respectively. The Neogen test may be acceptable for regulatory purposes for oysters in accordance with European Commission directives in which the standard protocol provides, at the regulatory level, a probability of a negative response of 0.033 on 95% of occasions. Its use for mussels is less consistent at the regulatory level due to the wide prediction interval around the POD.
Asunto(s)
Toxinas Marinas/análisis , Saxitoxina/análogos & derivados , Animales , Crassostrea/química , Dinoflagelados , Inmunoensayo/métodos , Límite de Detección , Toxinas Marinas/inmunología , Toxinas Marinas/aislamiento & purificación , Mytilus/química , Juego de Reactivos para Diagnóstico , Saxitoxina/análisis , Saxitoxina/inmunología , Saxitoxina/aislamiento & purificaciónRESUMEN
Recombinant bovine somatotropin (rbST), a synthetic growth hormone, is used to stimulate growth and enhance milk production in dairy cows. Both its use and the sale of dairy products from treated animals are prohibited in the European Union, as well as in Australia, Canada, Japan, and New Zealand, but authorised in several countries (e.g. Brazil, USA). Screening methods involve detecting anti-rbST antibodies (biomarkers) in treated cows. Confirmatory methods are required to prove rbST abuse. The major challenges in determining rbST are its potentially low levels, its high similarity to native bST, and matrix interferences. To overcome these obstacles, we have developed a method involving immunomagnetic precipitation followed by UHPLC-MS/MS for rbST detection. Briefly, protein G magnetic beads pre-coated with an in-house produced monoclonal antibody were added to plasma. Incubation at room temperature allowed rbST present in the sample to bind to the magnetic beads. After that, magnetic beads were isolated by centrifugation and thoroughly washed (PBS, PBS + 0.2% Tween 20). Finally, rbST was released by alkalinisation and the samples were trypsin digested prior to UHPLC-MS/MS analysis in the MRM mode. Validation was done in accordance with European Commission Decision 2002/657/CE. Matrix-matched calibration with internal standards was used. The decision limit (CCα) reached with this approach was 0.11 µg l-1.
Asunto(s)
Hormona del Crecimiento/sangre , Separación Inmunomagnética , Animales , Bovinos , Cromatografía Líquida de Alta Presión , Proteínas Recombinantes/sangre , Espectrometría de Masas en TándemRESUMEN
The European Commission (EC) wants to reintroduce nonruminant processed animal proteins (PAPs) safely into the feed chain. This would involve replacing the current ban in feed with a species-to-species ban which, in the case of nonruminants, would only prohibit feeding them with proteins from the same species. To enforce such a provision, there is an urgent need for species-specific methods for detecting PAPs from several species in animal feed and in PAPs from other species. Currently, optical microscopy and the polymerase chain reaction are the officially accepted methods, but they have limitations, and alternative methods are needed. We have developed immunoassays using antibodies raised against targets which are not influenced by high temperature and pressure. These targets were identified in a previous study based on an experimental approach. One optimized competitive ELISA detects bovine PAPs at 2% in plant-derived feed. The detection capability demonstrated on blind samples shows a good correlation with mass spectrometry results.
Asunto(s)
Alimentación Animal/análisis , Proteínas en la Dieta/análisis , Ensayo de Inmunoadsorción Enzimática , Animales , Bovinos , Dieta/veterinaria , Proteínas en la Dieta/administración & dosificación , Contaminación de Alimentos/análisis , Inmunoensayo , Reacción en Cadena de la Polimerasa , Especificidad de la Especie , PorcinosRESUMEN
Despite ethical and technical concerns, the in vivo method, or more commonly referred to mouse bioassay (MBA), is employed globally as a reference method for phycotoxin analysis in shellfish. This is particularly the case for paralytic shellfish poisoning (PSP) and emerging toxin monitoring. A high-performance liquid chromatography method (HPLC-FLD) has been developed for PSP toxin analysis, but due to difficulties and limitations in the method, this procedure has not been fully implemented as a replacement. Detection of the diarrhetic shellfish poisoning (DSP) toxins has moved towards LC-mass spectrometry (MS) analysis, whereas the analysis of the amnesic shellfish poisoning (ASP) toxin domoic acid is performed by HPLC. Although alternative methods of detection to the MBA have been described, each procedure is specific for a particular toxin and its analogues, with each group of toxins requiring separate analysis utilising different extraction procedures and analytical equipment. In addition, consideration towards the detection of unregulated and emerging toxins on the replacement of the MBA must be given. The ideal scenario for the monitoring of phycotoxins in shellfish and seafood would be to evolve to multiple toxin detection on a single bioanalytical sensing platform, i.e. 'an artificial mouse'. Immunologically based techniques and in particular surface plasmon resonance technology have been shown as a highly promising bioanalytical tool offering rapid, real-time detection requiring minimal quantities of toxin standards. A Biacore Q and a prototype multiplex SPR biosensor have been evaluated for their ability to be fit for purpose for the simultaneous detection of key regulated phycotoxin groups and the emerging toxin palytoxin. Deemed more applicable due to the separate flow channels, the prototype performance for domoic acid, okadaic acid, saxitoxin, and palytoxin calibration curves in shellfish achieved detection limits (IC20) of 4,000, 36, 144 and 46 µg/kg of mussel, respectively. A one-step extraction procedure demonstrated recoveries greater than 80% for all toxins. For validation of the method at the 95% confidence limit, the decision limits (CCα) determined from an extracted matrix curve were calculated to be 450, 36 and 24 µg/kg, and the detection capability (CCß) as a screening method is ≤10 mg/kg, ≤160 µg/kg and ≤400 µg/kg for domoic acid, okadaic acid and saxitoxin, respectively.
Asunto(s)
Mariscos , Toxinas Biológicas/análisis , Animales , Técnicas Biosensibles , Cromatografía Líquida de Alta Presión , Límite de Detección , Reproducibilidad de los Resultados , Resonancia por Plasmón de SuperficieRESUMEN
Pyrrolizidine alkaloids (PAs) are a group of plant secondary metabolites with carcinogenic and hepatotoxic properties. When PA-producing plants contaminate crops, toxins can be transferred through the food chain and cause illness in humans and animals, most notably hepatic veno-occlusive disease. Honey has been identified as a direct risk of human exposure. The European Food Safety Authority has recently identified four groups of PAs that are of particular importance for food and feed: senecionine-type, lycopsamine-type, heliotrine-type and monocrotaline-type. Liquid or gas chromatography methods are currently used to detect PAs but there are no rapid screening assays available commercially. Therefore, the aim of this study was to develop a rapid multiplex ELISA test for the representatives of three groups of alkaloids (senecionine, lycopsamine and heliotrine types) that would be used as a risk-management tool for the screening of these toxic compounds in food and feed. The method was validated for honey and feed matrices and was demonstrated to have a detection capability less than 25 µg/kg for jacobine, lycopsamine, heliotrine and senecionine. The zinc reduction step introduced to the extraction procedure allows for the additional detection of the presence of N-oxides of PAs. This first multiplex immunoassay for PA detection with N-oxide reduction can be used for the simultaneous screening of 21 samples for >12 PA analytes. Honey samples (n = 146) from various origins were analysed for PA determination. Six samples were determined to contain measurable PAs >25 µg/kg by ELISA which correlated to >10 µg/kg by LC-MS/MS.
Asunto(s)
Ensayo de Inmunoadsorción Enzimática , Análisis de los Alimentos/métodos , Contaminación de Alimentos/análisis , Miel/análisis , Óxidos/análisis , Alcaloides de Pirrolicidina/análisis , Alimentación Animal/análisis , Límite de Detección , Óxidos/química , Factores de TiempoRESUMEN
Coccidiostats are authorized in the European Union (EU) to be used as poultry feed additives. Maximum (residue) levels (M(R)Ls) have been set within the EU for consumer and animal protection against unintended carry-over, and monitoring is compulsory. This paper describes the single-laboratory validation of a previously developed multiplex flow cytometric immunoassay (FCIA) as screening method for coccidiostats in eggs and feed and provides and compares different approaches for the calculation of the cut-off levels which are not described in detail within Commission Decision 2002/657/EC. Comparable results were obtained between the statistical (reference) approach and the rapid approaches. With the most rapid approach, the cut-off levels for narasin/salinomycin, lasalocid, diclazuril, nicarbazin (DNC) and monensin in egg, calculated as percentages of inhibition (%B/B0), were 60, 32, 76, 80 and 84, respectively. In feed, the cut-off levels for narasin/salinomycin, lasalocid, nicarbazin (DNC) and monensin were 70, 64, 72 and 78, respectively, and could not be determined for diclazuril. For all analytes, except for diclazuril in feed, the rate of false positives (false non-compliant) in blank samples was lower than 1 %, and the rate of false negatives (false compliant) at the M(R)Ls was below 5 %. Additionally, very good correlations (r ranging from 0.994 to 0.9994) were observed between two different analysers, a sophisticated flow cytometer (FlexMAP 3D(®)) and a more cost-efficient and transportable planar imaging detector (MAGPIX(®)), hence demonstrating adequate transferability.
Asunto(s)
Alimentación Animal/análisis , Coccidiostáticos/análisis , Residuos de Medicamentos/análisis , Huevos/análisis , Citometría de Flujo/métodos , Inmunoensayo/métodos , Animales , PollosRESUMEN
This article presents a review of the current trends in the analysis of coccidiostats in various matrices, focusing principally on screening and rapid methods. Coccidiosis is an infectious disease having a high negative impact on the animal industry. Drugs are therefore necessary to prevent and/or to combat this disease. However, it is also of crucial importance that these veterinary drugs do not enter the human food chain. European legislation has therefore established the boundaries for the use of coccidiosats and has also addressed the unavoidable problem of cross-contamination of the feed, mainly caused by the use of the same production lines. Consequently there is a need for analytical methods and/or analytical strategies for the monitoring and control of the residues of anticoccidials, both in feed and in the resulting matrices for human consumption. In the frame of the European collaborative project CONffIDENCE, such attempts to establish the required analytical tools were made, which required beforehand a review of the state of the art in this domain. Aiming at this objective, in this review we consider the most interesting publications since 2000. In essence, both a rapid approach with mainly immunoassays and chromatographic methods were developed. To date, the obstacle to routine use of the first approach has been its inability to detect more than two compounds simultaneously, but recent developments in flow cytometry have made it possible to detect six coccidiostats at once. On the other hand, an increasingly popular approach for detecting multiple coccidiostats simultaneously is liquid chromatography coupled with tandem mass spectrometry. There remains a need to adapt these analytical methods to legislative requirements.
Asunto(s)
Técnicas de Química Analítica/métodos , Coccidiostáticos/análisis , Cadena Alimentaria , Drogas Veterinarias/análisis , Animales , Cromatografía Liquida , Coccidiostáticos/química , Contaminantes Ambientales/análisis , Ensayos Analíticos de Alto Rendimiento/tendencias , Humanos , Espectrometría de Masas en Tándem , Drogas Veterinarias/químicaRESUMEN
Coccidiostats are the only veterinary drugs still permitted to be used as feed additives to treat poultry for coccidiosis. To protect consumers, maximum levels for their presence in food and feed have been set by the European Union (EU). To monitor these coccidiostats, a rapid and inexpensive screening method would be a useful tool. The development of such a screening method, using a flow cytometry-based immunoassay, is described. The assay uses five sets of colour-coded paramagnetic microspheres for the detection of six selected priority coccidiostats. Different coccidiostats, with and without carrier proteins, were covalently coupled onto different bead sets and tested in combination with polyclonal antisera and with a fluorescent-labelled secondary antibody. The five optimal combinations were selected for this multiplex and a simple-to-use sample extraction method was applied for screening blank and spiked eggs and feed samples. A very good correlation (r ranging from 0.995 to 0.999) was obtained with the responses obtained in two different flow cytometers (Luminex 100 and FLEXMAP 3D). The sensitivities obtained were in accordance with the levels set by the EU as the measured limits of detection for narasin/salinomycin, lasalocid, diclazuril, nicarbazin (4,4'-dinitrocarbanilide) and monensin in eggs were 0.01, 0.1, 0.5, 53 and 0.1 µg/kg and in feed 0.1, 0.2, 0.3, 9 and 1.5 µg/kg, respectively.
Asunto(s)
Alimentación Animal/análisis , Coccidiostáticos/análisis , Huevos/análisis , Citometría de Flujo/métodos , Animales , Anticuerpos/análisis , Anticuerpos/inmunología , Coccidiostáticos/inmunología , Citometría de Flujo/economía , Inmunoensayo/economía , Inmunoensayo/métodos , Aves de Corral , Sensibilidad y Especificidad , Factores de TiempoRESUMEN
A multiplex dipstick immunoassay based method for the simultaneous determination of major Fusarium toxins, namely zearalenone, T-2 and HT-2 toxins, deoxynivalenol and fumonisins in wheat, oats and maize has been developed. The dipstick format was based on an indirect competitive approach. Four test lines (mycotoxin-BSA conjugates) and one control line were located on the strip membrane. Labelled antibodies were freeze-dried within the microwell. Two matrix-related sample preparation protocols have been developed for wheat/oats (not containing fumonisins) and maize (containing fumonisins) respectively. The use of a methanol/water mixture for sample preparation allowed recoveries in the range 73-109% for all mycotoxins in all tested cereals, with relative standard deviation less than 10%. The optimized immunoassay was able to detect target mycotoxins at cut off levels equal to 80% of EU maximum permitted levels, i.e. 280, 400, 1400 and 3200 µg kg(-1), respectively, for zearalenone, T-2/HT-2 toxins, deoxynivalenol and fumonisins in maize, and 80, 400 and 1400 µg kg(-1), respectively, for zearalenone, T-2/HT-2 toxins and deoxynivalenol in wheat and oats. Analysis of naturally contaminated samples resulted in a good agreement between multiplex dipstick and validated confirmatory LC-MS/MS. The percentage of false positive results was less than or equal to 13%, whereas no false negative results were obtained. Data on the presence/absence of 6 mycotoxins at levels close to EU regulatory levels were obtained within 30 min. The proposed immunoassay protocol is rapid, inexpensive, easy-to-use and fit for purpose of rapid screening of mycotoxins in cereals.
Asunto(s)
Avena/microbiología , Grano Comestible/microbiología , Fusarium/aislamiento & purificación , Inmunoensayo/instrumentación , Micotoxinas/aislamiento & purificación , Triticum/microbiología , Zea mays/microbiología , Diseño de Equipo , Inmunoensayo/economía , Inmunoensayo/métodos , Sensibilidad y EspecificidadRESUMEN
Malachite green (MG), a member of the N-methylated triphenylmethane class of dyes, has long been used to control fungal and protozoan infections in fish. MG is easily absorbed by fish during waterborne exposure and is rapidly metabolized into leucomalachite green (LMG), which is known for its long residence time in edible fish tissue. This paper describes the development of an enzyme-linked immunosorbent assay (ELISA) for the detection and quantification of LMG in fish tissue. This development includes a simple and versatile method for the conversion of LMG to monodesmethyl-LMG, which is then conjugated to bovine serum albumin (BSA) to produce an immunogenic material. Rabbit polyclonal antibodies are generated against this immunogen, purified and used to develop a direct competitive enzyme-linked immunosorbent assay (ELISA) for the screening and quantification of LMG in fish tissue. The assay performed well, with a limit of detection (LOD) and limit of quantification (LOQ) of 0.1 and 0.3 ng g(-1) of fish tissue, respectively. The average extraction efficiency from a matrix of tilapia fillets was approximately 73% and the day-to-day reproducibility for these extractions in the assay was between 5 and 10%.