Development of a Nose-only Inhalation Toxicity Test Chamber That Provides Four Exposure Concentrations of Nano-sized Particles.

Using a numerical analysis based on computerized fluid dynamics, a nose-only inhalation toxicity chamber with four different exposure concentrations is designed and validated for flow field uniformity and cross-contamination among the exposure ports for each concentration. The designed flow field values are compared with the measured values from exposure ports located horizontally and vertically. For this purpose, nanoscale sodium chloride particles are generated as test particles and introduced to the inhalation chamber to evaluate the cross-contamination and concentration maintenance among the chambers, for each concentration group. The results indicate that the designed multiconcentration inhalation chamber can be used in animal inhalation toxicity testing without cross-contamination among concentration groups. Moreover, the designed multiconcentration inhalation toxicity chamber can also be converted to a single-concentration inhalation chamber. Further testing with gas, organic vapor, or non-nanoscale particles will ensure the use of the chamber in the inhalation testing of other test articles.

Lobar evenness of deposition/retention in rat lungs of inhaled silver nanoparticles: an approach for reducing animal use while maximizing endpoints.

BACKGROUND: Information on particle deposition, retention and clearance are important for the evaluation of the risk of inhaled nanomaterials to human health. Recent revised OECD inhalation toxicity test guidelines require to evaluate the lung burden of nanomaterials after rodent subacute and subchronic inhalation exposure (OECD 412, OECD 413). These revised test guidelines require additional post-exposure observation (PEO) periods that include lung burden measurements that can inform on lung clearance behavior and translocation. The latter being particularly relevant when the testing chemical is a solid poorly soluble nanomaterial. Therefore, in the spirit of 3 R's, we investigated whether measurement of retained lung burden of inhaled nanoparticles (NPs) in individual lung lobes is sufficient to determine retained lung burden in the total lung. If it is possible to use only one lobe, it will reduce animal use and maximize the number of endpoints evaluated. RESULTS: To achieve these goals, rats were exposed nose-only for 1 or 5 days (6 h/day) to an aerosol of 20 nm well-dispersed silver nanoparticles (AgNPs), which is the desired particle diameter resulting in maximum deposition in the pulmonary region when inhaled as singlets. After exposure, the five lung lobes were separated and silver concentration was measured using inductively coupled plasma-mass spectrophotometer (ICP-MS). The results showed that the retention of deposited silver nanoparticle in the different lung lobes did not show any statistically significant difference among lung lobes in terms of silver mass per gram lung lobe. This novel finding of evenness of retention/deposition of inhaled 20 nm NPs in rats for all five lobes in terms of mass per unit tissue weight contrasts with earlier studies reporting greater apical lobe deposition of inhaled micro-particles in rodents. The difference is most likely due to preferred and efficient deposition of inhaled NPs by diffusion vs. additional deposition by sedimentation and impaction for micron-sized particles. CONCLUSION: AgNPs following acute inhalation by rats are evenly retained in each lung lobe in terms of mass per unit lung tissue weight. Accordingly, we suggest sampling any of the rat lung lobes for lung burden analysis can be used to determine deposited or retained total lung burden after short-term inhalation of NPs and using the other lobes for collecting and analyzing bronchoalveolar lavage fluid (BALF) and for histopathological analysis. Therefore, by combining lung burden measurement, histopathological tissue preparation, and BALF assay in the same rat will reduce the number of animals used and maximize the number of endpoints measured.

Size-dependent clearance of gold nanoparticles from lungs of Sprague-Dawley rats after short-term inhalation exposure.

Gold nanoparticles are known to be distributed to many tissues following their oral, inhalation, or intravenous exposure. Information on the biodistribution and clearance of gold nanoparticles from these tissues is, therefore, important to understand their behavior in vivo. To study the effect of size on the biodistribution of gold nanoparticles, Sprague-Dawley rats were exposed by inhalation to small gold nanoparticles (13 nm in diameter on average) at an exposure concentration of 12.8 ± 2.42 µg/m(3), and to large gold nanoparticles (105 nm in diameter on average) at an exposure concentration of 13.7 ± 1.32 µg/m(3). The experimental animals were exposed to the gold nanoparticles and the control animals to fresh air for 5 days (6 h/day), followed by a recovery period of 1, 3, and 28 days in fresh air. None of the exposed animals exhibited any toxic response to the gold nanoparticles. Despite the difference in size, both small and large gold nanoparticles deposited mainly in rat lungs. Their biodistribution from the lungs to secondary target organs was significantly higher with the small compared to the large gold nanoparticles. While the large gold nanoparticles were only found in the blood, the small gold nanoparticles were detected in the liver, spleen, brain, testes, and blood. In addition, the elimination half-life of the small gold nanoparticles from the lungs was significantly shorter than that of the large gold nanoparticles. The present data may, therefore, suggest that the smaller gold nanoparticles are able to translocate from the lungs, the primary exposure organ to extrapulmonary organs at a faster rate than the larger gold nanoparticles and thus confirming previous observations reported in the literature.

Subchronic inhalation toxicity of gold nanoparticles.

BACKGROUND: Gold nanoparticles are widely used in consumer products, including cosmetics, food packaging, beverages, toothpaste, automobiles, and lubricants. With this increase in consumer products containing gold nanoparticles, the potential for worker exposure to gold nanoparticles will also increase. Only a few studies have produced data on the in vivo toxicology of gold nanoparticles, meaning that the absorption, distribution, metabolism, and excretion (ADME) of gold nanoparticles remain unclear. RESULTS: The toxicity of gold nanoparticles was studied in Sprague Dawley rats by inhalation. Seven-week-old rats, weighing approximately 200 g (males) and 145 g (females), were divided into 4 groups (10 rats in each group): fresh-air control, low-dose (2.36 × 104 particle/cm3, 0.04 µg/m3), middle-dose (2.36 × 105 particle/cm3, 0.38 µg/m3), and high-dose (1.85 × 106 particle/cm3, 20.02 µg/m3). The animals were exposed to gold nanoparticles (average diameter 4-5 nm) for 6 hours/day, 5 days/week, for 90-days in a whole-body inhalation chamber. In addition to mortality and clinical observations, body weight, food consumption, and lung function were recorded weekly. At the end of the study, the rats were subjected to a full necropsy, blood samples were collected for hematology and clinical chemistry tests, and organ weights were measured. Cellular differential counts and cytotoxicity measurements, such as albumin, lactate dehydrogenase (LDH), and total protein were also monitored in a cellular bronchoalveolar lavage (BAL) fluid. Among lung function test measurements, tidal volume and minute volume showed a tendency to decrease comparing control and dose groups during the 90-days of exposure. Although no statistically significant differences were found in cellular differential counts, histopathologic examination showed minimal alveoli, an inflammatory infiltrate with a mixed cell type, and increased macrophages in the high-dose rats. Tissue distribution of gold nanoparticles showed a dose-dependent accumulation of gold in only lungs and kidneys with a gender-related difference in gold nanoparticles content in kidneys. CONCLUSIONS: Lungs were the only organ in which there were dose-related changes in both male and female rats. Changes observed in lung histopathology and function in high-dose animals indicate that the highest concentration (20 µg/m3) is a LOAEL and the middle concentration (0.38 µg/m3) is a NOAEL for this study.

Exposure assessment of carbon nanotube manufacturing workplaces.

Seven CNT (carbon nanotube) handling workplaces were investigated for exposure assessment. Personal sampling, area sampling, and real-time monitoring using an SMPS (scanning mobility particle sizer), dust monitor, and aethalometer were performed to characterize the mass exposure, particle size distribution, and particle number exposure. No workplace was found to exceed the current ACGIH (American Conference of Governmental Industrial Hygienists) TLVs (threshold limit values) and OELs (occupational exposure levels) set by the Korean Ministry of Labor for carbon black (3.5 mg/m(3)), PNOS (particles not otherwise specified; 3 mg/m(3)), and asbestos (0.1 fiber/cc). Nanoparticles and fine particles were most frequently released after opening the CVD (chemical vapor deposition) cover, followed by catalyst preparation. Other work processes that prompted nanoparticle release included spraying, CNT preparation, ultrasonic dispersion, wafer heating, and opening the water bath cover. All these operation processes could be effectively controlled with the implementation of exposure mitigation, such as engineering control, except at one workplace where only natural ventilation was used.

Subchronic inhalation toxicity of silver nanoparticles.

The subchronic inhalation toxicity of silver nanoparticles was studied in Sprague-Dawley rats. Eight-week-old rats, weighing approximately 253.2 g (males) and 162.6 g (females), were divided into four groups (10 rats in each group): fresh-air control, low dose (0.6 x 10(6) particle/cm(3), 49 microg/m(3)), middle dose (1.4 x 10(6) particle/cm(3), 133 microg/m(3)), and high dose (3.0 x 10(6) particle/cm(3), 515 microg/m(3)). The animals were exposed to silver nanoparticles (average diameter 18-19 nm) for 6 h/day, 5 days/week, for 13 weeks in a whole-body inhalation chamber. In addition to mortality and clinical observations, body weight, food consumption, and pulmonary function tests were recorded weekly. At the end of the study, the rats were subjected to a full necropsy, blood samples were collected for hematology and clinical chemistry tests, and the organ weights were measured. Bile-duct hyperplasia in the liver increased dose dependently in both the male and female rats. Histopathological examinations indicated dose-dependent increases in lesions related to silver nanoparticle exposure, including mixed inflammatory cell infiltrate, chronic alveolar inflammation, and small granulomatous lesions. Target organs for silver nanoparticles were considered to be the lungs and liver in the male and female rats. No observable adverse effect level of 100 microg/m(3) is suggested from the experiments.