RESUMEN
The occurrence of antimicrobial resistance in microorganisms isolated from eggshells, especially Enterococcus, might serve as a parameter to assess the selection of bacteria due to the use of drugs in the diet of laying hens. In order to evaluate the frequency and the antimicrobial resistance profile of Enterococcus spp. isolated from the eggshells, 225 Hy-line laying hens were submitted to a 25-d long trial. The treatments were the following: hens fed ration without antimicrobials (control) and groups that received oxytetracycline (10 mg kg-1), doxycycline (20 mg kg-1), lincomycin (50 mg kg-1), and enrofloxacin (10 mg kg-1) in the ration for 5 d. Six replications were analyzed per treatment, composed of a pool of 5 eggs each. They were collected before treatment and on days 3, 6, 15, and 25, totaling 150 samples. Eggshells were submitted to counts of Enterococcus spp., which were identified by proteomic analyses. Antimicrobial resistance was determined by the disk-diffusion test. It was observed that 97.3% (n = 146) of the samples were contaminated with Enterococcus spp. There were no differences (P > 0.05) in the bacterial counts between treatments on the same day of evaluation. E. faecalis and E. faecium were the most frequent on the eggshells of all treatments. Multiresistance to the four classes of antimicrobials was also verified in the isolated bacteria. A total of 83% of the Enterococcus isolates showed resistance to neomycin, which was not administered to the hens, demonstrating an environmental problem. Thus, feeding laying hens with diets added with antimicrobials induces drug resistance in Enterococcus spp., isolated form the eggshells.
Asunto(s)
Antiinfecciosos , Enterococcus , Animales , Antibacterianos/farmacología , Pollos , Farmacorresistencia Bacteriana , Cáscara de Huevo , Femenino , Óvulo , ProteómicaRESUMEN
In commercial hatcheries, it is common to store eggs before incubation. One practice to improve hatchability consists in egg turning during this storage. This work aims to highlight the effects of turning on the physicochemical aspects of eggs and, consequently, how this turning can influence the hatching of chicks. An experiment was conducted to evaluate the effects of storage duration and egg turning during storage on egg quality, hatchability, and residual analysis. A total of 7â¯500 hatching eggs were collected from a 55-week-old commercial Cobb500 breeder flock and storage according to the treatments. The experiment was completely randomized in a 3×2 factorial design with three storage periods (4, 8, and 12â¯days) and egg turning (180° turn of eggs once a day) or no turning during storage, totaling six treatments. Regardless of turning, eggs stored for 4â¯days weighed more than turned eggs stored for 8 and 12â¯days, which were similar (Pâ¯<â¯0.05). Non-turned eggs experienced an increase in relative shell weight with increased storage duration, and non-turned eggs stored for 4 and 8â¯days differed from non-turned eggs stored for 12â¯days (Pâ¯<â¯0.05). Albumen pH of turned eggs stored for 4 and 8â¯days was lower than that of non-turned eggs stored for the same durations (Pâ¯<â¯0.05). Albumen pH of turned eggs increased as storage duration increased (Pâ¯<â¯0.05). Egg turning increased hatching by 2.02% over that of non-turning (Pâ¯<â¯0.05). Eggs stored for 12â¯days, irrespective of turning, had higher late embryonic mortality (Pâ¯<â¯0.05) compared to the other treatments. It was concluded that turning eggs during pre-incubation storage was adequate to improve hatchability of fertile eggs. Storing fertile eggs for 12â¯days is harmful to egg quality and increases embryo mortality even if eggs were turned.
Asunto(s)
Pollos , Óvulo , Animales , Peso Corporal , Femenino , Fertilidad , Factores de TiempoRESUMEN
A sanitation method that could continually clean and disinfect the air and surfaces in a hatchery could provide a second layer of microbial reduction on top of routine cleaning and disinfection. A gaseous dry hydrogen peroxide (DHP) system has been used in other facilities for this purpose and could have potential for use in chicken hatcheries. Because the DHP is a true gas and can permeate through the entire hatchery space, contact with eggs during storage and incubation could potentially interfere with normal hatching processes. Therefore, the aim of this study was to evaluate the effects of the DHP system on hatching parameters and chick quality. A total of 3,960 hatching eggs were collected from an â¼40-week-old Ross 308 broiler breeder flock and distributed in 2 treatments: treated and nontreated. For the treated group, the egg cooler was cleaned, and 1 DHP generator was placed inside. Two other DHP generators were placed in the common area outside as well. Both areas were treated for 7 D before placement of eggs, and then eggs were collected and placed inside the cooler over a 4-day period. Eggs were then stored for an additional 3 D after the last collection. Dry hydrogen peroxide levels were recorded each day during storage. For the nontreated group, all DHP machines were removed from the cooler and external room, and the egg cooler was cleaned. Eggs were collected in the same way for the control group as the treated group. After storage, eggs were placed into a single stage Natureform incubator. The eggs exposed to DHP showed higher (P < 0.05) hatchability of fertile eggs and lower (P < 0.05) early embryonic dead than eggs from the nontreated group. No other parameters evaluated were different between groups. Based on this work, the DHP treatment of fertile eggs had no detrimental effect on any performance parameter, with potential positive effects seen on hatch of fertile eggs and early embryonic dead embryos.
Asunto(s)
Pollos , Desinfección , Peróxido de Hidrógeno , Cigoto , Animales , Desinfectantes/farmacología , Desinfección/normas , Peróxido de Hidrógeno/farmacología , Cigoto/efectos de los fármacos , Cigoto/crecimiento & desarrolloRESUMEN
The objective was to evaluate the digestive tract characteristics, metabolizability and nutrient retention of broilers fed diets supplemented with enzyme complex (EC). To evaluate the characteristics of the digestive tract 600 female Cobb 500 birds were used, distributed in a completely randomized design, with 5 inclusion levels of the EC (0; 100, 200, 300 and 400 g/ton) and 6 replicates of 20 birds each. To evaluate the metabolizability and the retention of nutrients 200 female Cobb 500 birds at 15 days of age were used, distributed in a completely randomized design with 5 levels of supplementation of the EC and 4 replicates of 10 birds each. No significant effects (P>0.05) were observed for the supplementation of the EC in the intestinal pH, digestive organ weight, intestinal length and metabolizable coefficients of dry matter and crude protein. The metabolizable coefficient of ethereal extract was influenced in a quadratic decreasing form (P<0.01). The metabolizable coefficients of calcium (Ca) and phosphorus (P) were influenced in a quadratic increase (P<0.01), resulting in increased Ca retention in 21.39% and P in 9.56%. Supplementation of the EC in broiler diets improves the metabolizability and retention of P and Ca, without affecting the other parameters evaluated.(AU)
Asunto(s)
Animales , Nutrientes/administración & dosificación , Pollos/metabolismo , Tracto Gastrointestinal/metabolismo , Enzimas/administración & dosificación , Péptido Hidrolasas , Suplementos Dietéticos/análisis , CelulasasRESUMEN
Objetivou-se verificar a viabilidade econômica da produção de frangos de corte sob mecanismos de governança híbrida e hierárquica. Estudos de caso foram escolhidos para avaliação da atividade em núcleos de empresas integradoras e de produtores rurais integrados. Realizou-se pesquisa de campo para coleta de dados em 36 unidades de produção em Minas Gerais. Informações provenientes de 216 lotes produzidos entre agosto de 2015 e agosto de 2016 foram utilizadas nas análises econômicas. O cálculo dos custos baseou-se na metodologia proposta pela Embrapa - CNPSA e IEA - SP. As análises econômicas se realizaram conforme proposto pelo DAE - Ufla e pela Conab. Constatou-se que o custo com mão de obra causou maior impacto sobre o desempenho econômico de núcleos com estruturas de governança distintas. No modelo de produção via governança hierárquica, mesmo se considerando receitas secundárias ao processo de produção de aves, verificou-se prejuízo financeiro na atividade. Concluiu-se que a estrutura de governança híbrida representou melhor alternativa econômica que a internalização do processo de criação de frangos pelas empresas integradoras. Assim, sugere-se que empresas integradoras esgotem as possibilidades de produção via contrato de integração antes de investirem recursos em instalações próprias de criação.(AU)
The objective was to verify the economic feasibility in the production of broilers under hybrid and hierarchical governance mechanisms. Case studies were used to evaluate the activity of the integrating company and the integrated rural producers. The primary data about costs, income, and zootechnical indicators were collected in 36 poultry production units belonging to an integrated company and five rural producers, in state of Minas Gerais. Data from 216 batches of broilers produced between August 2015 and August 2016 were used in the economic analysis. Costs calculation was based on the methodology proposed by EMBRAPA - CNPSA and IEA - SP. The economic analyzes were carried out as proposed by DAE UFLA and CONAB. It was verified that the cost of labor caused the greatest impact on the economic performance of cores with different governance structures. In all breeding sites via hierarchical governance, even considering secondary revenues, there was a financial loss in the activity. It was concluded that the hybrid governance represented a better economic alternative than the internalization of the broiler production by integrating companies. Thus, it is suggested that integrating companies deplete the production possibilities through an integration contract before investing resources in their own breeding facilities.(AU)
Asunto(s)
Aves de Corral , Pollos , Gobernanza/economía , Gobernanza/organización & administración , Gobernanza/estadística & datos numéricos , Crianza de Animales Domésticos/economía , Crianza de Animales Domésticos/organización & administración , Crianza de Animales Domésticos/estadística & datos numéricosRESUMEN
Different sanitization methods were evaluated as alternatives to formaldehyde fumigation for the reduction of eggshell and yolk sac microbiological counts, improvement of eggshell quality, incubation parameters, and day-old chick quality. A total of 10,080 hatching eggs were collected from a 70-wk-old commercial broiler breeder flock and distributed in a completely randomized block design with seven treatments: fumigation with paraformaldehyde (5.03 g/m3/30 min), fumigation with ozone (5-15 ppm/30 min), ultraviolet light-C irradiation (8.09 mW/cm2; 120 s; UV-C), hydrogen peroxide spraying (3%; 0.69 mL/egg), peracetic acid spraying (0.3%; 0.69 mL/egg; PAA), water spraying (0.69 mL/egg; water control), and without disinfection (dry control-DC). Spraying eggs with PAA and UV-C significantly reduced aerobic bacteria plate counts compared to the DC group. In addition, eggs disinfected with PAA had lower Enterobacteriaceae counts than the DC and water control groups. Eggshell quality, incubation parameters, and microbiological counts for yolk sac did not differ (P > 0.05) among treatments. This study demonstrated the potential for the application of PAA and UV-C for eggshell disinfection instead of formaldehyde; however, an electronic microscopic evaluation of the eggshell is necessary to determine if these methods cause any damage to the cuticle.
Asunto(s)
Crianza de Animales Domésticos/métodos , Pollos , Desinfección/métodos , Óvulo/efectos de los fármacos , Óvulo/microbiología , Animales , Cáscara de Huevo/microbiología , Formaldehído/uso terapéutico , Fumigación/métodos , Peróxido de Hidrógeno/uso terapéutico , Ozono/uso terapéutico , Ácido Peracético/uso terapéutico , Rayos Ultravioleta , Saco Vitelino/microbiologíaRESUMEN
This work aimed at evaluating the effects of 4 digestible Met+Cys levels on the diet of commercial layers and their influence on the productive performance, quality, and amino acid profile of eggs and economic viability of the activity. A total of 576 white Lohmann LSL-Lite layers was distributed into 6 replicates of 24 birds for each diet. The experimental design was completely randomized, with 4 treatments defined by levels evaluated in the feed (0.465, 0.540, 0.581, and 0.647%). The productive performance was measured for 30 weeks. The quality (34 and 50 wk old) and the amino acid profile of eggs (43 wk old) also were evaluated. A linear positive response was observed at higher Met+Cys levels for feed intake, number of eggs per housed bird, and digestible Met+Cys intake. Egg production, egg weight, egg mass, feed efficiency, and weight gain had their optimal values determined by the quadratic regression model at 0.638, 0.654, 0.647, 0.644, and 0.613% digestible Met+Cys, respectively. In the 34th wk, eggshell thickness decreased linearly at higher Met+Cys levels. In the 50th week, the optimal levels detected for eggshell thickness and percentage were 0.571 and 0.570% digestible Met+Cys, respectively. The percentages of proteins, branched-chain amino acids (leucine, isoleucine, and valine), histidine, and proline in eggs (albumen+yolk) showed a linear negative response in function of higher Met+Cys levels. Higher digestible Met+Cys levels (>0.630%) led to a good performance of layers, while lower Met+Cys levels improved the eggshell quality of layers in peak production. Optimal Met+Cys levels may change according to the price of the synthetic amino acid.
Asunto(s)
Aminoácidos/metabolismo , Pollos/fisiología , Cisteína/metabolismo , Dieta/veterinaria , Metionina/metabolismo , Óvulo/efectos de los fármacos , Alimentación Animal/análisis , Animales , Análisis Costo-Beneficio , Cisteína/administración & dosificación , Dieta/economía , Suplementos Dietéticos/análisis , Relación Dosis-Respuesta a Droga , Femenino , Metionina/administración & dosificación , Óvulo/fisiología , Distribución AleatoriaRESUMEN
Objetivou-se avaliar os efeitos de antioxidantes suplementados às dietas de galos de matrizes pesadas em idade avançada sobre as características reprodutivas. Foram utilizados galos da linhagem Cobb com 47 semanas de idade. Estes foram distribuídos em quatros tratamentos, de acordo com a adição de antioxidante à dieta, sendo: A = grupo controle (sem suplementação antioxidante); B = suplementação de 9ppm de citranaxantina; C = suplementação de 6ppm de cantaxantina e D = 150ppm de vitamina E. Foram avaliadas as características seminais, tais como volume, vigor, motilidade e concentração, a composição de ácidos graxos do sêmen (saturados, insaturados, monoinsaturados, poli-insaturados, ômega 3, ômega 6 e ômega 9) e a correlação entre o peso dos testículos e o peso dos galos. Não foram observados efeitos das substâncias antioxidantes testadas sobre os parâmetros reprodutivos avaliados. Os antioxidantes avaliados não influenciam as respostas reprodutivas de machos reprodutores de matrizes pesadas em idade avançada.(AU)
This study aimed to evaluate the effect of antioxidant supplementation in diets of aging broiler breeder roosters on reproductive characteristics. Cobb roosters were divided into four groups, according to antioxidant addition, where: A = control group (without antioxidant supplementation); B = 9ppm of citranaxanthin; C = 6ppm of canthaxanthin, and D = 150ppm of vitamin E. Seminal characteristics (volume, force, motility and concentration), semen fatty acid composition (saturated, unsaturated, monounsaturated, polyunsaturated, ω3, ω6 and ω9), and the correlation between testis weight with rooster weight were evaluated. No effects of the antioxidants tested were observed. The antioxidants do not influence the reproductive responses of aging male broiler breeder.(AU)
Asunto(s)
Animales , Masculino , Alimentación Animal/análisis , Antioxidantes/análisis , Pollos , Suplementos Dietéticos/estadística & datos numéricos , Análisis de Semen/veterinaria , Cantaxantina/uso terapéutico , Vitamina E/administración & dosificaciónRESUMEN
A high-performance liquid chromatography with ultraviolet detection (HPLC-UV) method was validated for the study of bioactive amines in chicken meat. A gradient elution system with an ultraviolet detector was used after extraction with trichloroacetic acid and pre-column derivatization with dansyl chloride. Putrescine, cadaverine, histamine, tyramine, spermidine, and spermine standards were used for the evaluation of the following performance parameters: selectivity, linearity, precision, recovery, limits of detection, limits of quantification and ruggedness. The results indicated excellent selectivity, separation of all amines, a coefficient of determination greater than 0.99 and recovery from 92.25 to 102.25% at the concentration of 47.2mg.kg-1, with a limit of detection at 0.3mg.kg-1 and a limit of quantification at 0.9mg.kg-1 for all amines, with the exception of histamine, which exhibited the limit of quantification, of 1mg.kg-1. In conclusion, the performance parameters demonstrated adequacy of the method for the detection and quantification of bioactive amines in chicken meat.(AU)
Um método de cromatografia líquida de alta eficiência (CLAE) para pesquisa de aminas bioativas em carne de frango foi validado. Foi utilizado um sistema de gradiente de eluição com detector ultravioleta, após extração com ácido tricloroacético e derivação pré-coluna com cloreto de dansila. Os padrões de putrescina, cadaverina, histamina, tiramina, espermidina e espermina foram utilizados para avaliação dos seguintes parâmetros de desempenho: seletividade, linearidade, precisão, recuperação, limites de detecção, limites de quantificação e robustez. Os resultados mostraram excelente seletividade e separação de todas as aminas, coeficiente de determinação superior a 0,99, recuperação entre 92,25 e 105,25% na concentração 47,2mg.kg-1, limites de detecção de 0,3mg.kg-1 e limite de quantificação de 0,9mg.kg-1 para todas as aminas, com exceção da histamina, que apresentou o limite de quantificação mais alto, de 1mg.kg-1. Foi concluído que os parâmetros de desempenho demonstraram adequação do método para detecção e quantificação de aminas bioativas em carne de frango.(AU)
Asunto(s)
Animales , Aminas/análisis , Microscopía Ultravioleta/veterinaria , Aves de Corral , Ácido Tricloroacético/análisis , Pollos , Cromatografía Líquida de Alta Presión/veterinaria , Histamina , Carne/análisis , Putrescina/análisisRESUMEN
Foram utilizados 936 pintos de corte machos e 1008 fêmeas da linhagem Cobb(r) criados no período de um a 45 dias. Os tratamentos foram compostos por duas formas físicas da ração (farelada e peletizada) e duas granulometrias do milho (3,8mm e 7,0mm). O delineamento experimental foi inteiramente ao acaso, em arranjo fatorial 2 x 2 (duas granulometrias x duas formas físicas), com seis repetições de 39 aves cada para os machos e seis repetições de 42 aves cada para as fêmeas. A ração peletizada produzida com moagem 3,8mm apresentou melhor PDI (P≤0,05). Aves fêmeas alimentadas com ração peletizada apresentaram maior consumo de ração, ganho de peso e melhor conversão alimentar que aquelas que receberam ração farelada. Não foi observada diferença significativa (P>0,05) entre os tratamentos para as variáveis ganho de peso, conversão alimentar e consumo de ração dos machos. Não houve influência da forma física e da granulometria sobre a viabilidade das aves em nenhuma fase de criação (P>0,05).
A total of 936 male chickens and 1008 female Cobb(r) were used from 1 to 45 days old. Treatments consisted of two physical forms (mash and pelleted diets) and two particle sizes ( corn ground through 3.8mm and 7.0mm sieves). The experimental design was completely randomized in a 2 x 2 factorial design (two particle sizes x two physical forms), with six replicates of 39 birds each for males and six replicates of 42 birds each for females. PDI from the pelleted physical form that was produced with 3.8mm grinding showed better results (P≤0.05). Female birds fed pelleted diets had greater feed intake, weight gain and better feed conversion than those fed mash diet. No significant difference (P>0.05) was observed between the treatments for male feed intake, weight gain and feed conversion from 1 to 45 days of age. There was no influence of the physical form and particle size on the feasibility of birds in any phase (P>0.05).
Asunto(s)
Animales , Fenómenos Fisiológicos Nutricionales de los Animales , Pollos/metabolismo , Alimentación Animal/análisis , Aves de Corral/crecimiento & desarrollo , Aumento de Peso , Zea maysRESUMEN
Com o objetivo de determinar valores de energia metabolizável aparente e de energia metabolizável aparente corrigida pelo balanço de nitrogênio de alimentos para frangos de corte, bem como avaliar os efeitos da correção da energia sobre seu desempenho, foram conduzidos dois experimentos: I) determinação da energia do milho, do farelo de soja, da farinha de carne e ossos, da farinha de vísceras e da farinha de penas, pelo método de coleta total de excretas, utilizando-se 450 pintos de corte com um dia de idade, distribuídos em delineamento inteiramente ao acaso, sendo seis tratamentos e cinco repetições; II) desempenho de 960 frangos de corte, distribuídos ao acaso, em cinco tratamentos e seis repetições. As aves que receberam os tratamentos A (matriz energética de acordo com Rostagno et al. (2011)) e E (energia sem correção com ajuste pela idade) apresentaram melhor desempenho, e as aves do tratamento E tiveram melhor conversão alimentar. Portanto, formulações com energia sem correção pelo balanço de nitrogênio e ajustadas pela idade são viáveis tanto sob o ponto de vista zootécnico, quanto econômico.
In order to determine apparent metabolizable energy and apparent metabolizable energy corrected by nitrogen balance of feed ingredients and to evaluate the effects of this correction on performance of broiler chickens, two experiments were conducted: I) energy determination of corn, soybean meal, meat and bone meal, poultry by-products meal and feather meal by total excreta collection method, using 450 chicks randomly distributed in 30 cages, with 6 treatments and 5 replications; II) performance of 960 broilers, distributed in a completely randomized design, with 5 treatments and 6 replications. Birds that received treatments A (energy matrix from literature) and E (energy without correction adjusted by age) showed better performance with the best feed cost, and treatment E had smaller feed conversion ratio. Therefore, the use of formulations based on metabolizable energy adjusted for age and without correction by nitrogen balance is feasible, both from a zootechnical and economic point of view.
Asunto(s)
Animales , Alimentación Animal , Fenómenos Fisiológicos Nutricionales de los Animales , Aves de Corral/crecimiento & desarrollo , Aves de Corral/metabolismo , Dieta/veterinaria , Aumento de PesoRESUMEN
Objetivou-se avaliar os efeitos da umidade relativa do ar nas incubadoras (URI) e da idade da matriz leve sobre a eclodibilidade, qualidade dos pintos recém-eclodidos e o desempenho da progênie. Foram incubados 10.840 ovos, sendo os tratamentos definidos pela idade das matrizes Lohmann LSL(r) (26, 41 e 56 semanas) e pelos níveis de URI (48, 56 e 64%). Após a incubação, 1.620 pintos fêmeas foram alojados em galpão experimental convencional, de acordo com os tratamentos, até as 12 semanas de idade. Para a avaliação de eclodibilidade sobre ovos férteis e fêmeas refugos, o delineamento experimental foi em blocos ao acaso no arranjo em parcelas subdivididas. A parcela foi a URI (três níveis) e a subparcela foi a idade da matriz (três idades). Os blocos foram constituídos pelos andares dos carrinhos de incubação, em que cada andar continha uma repetição de cada idade da matriz. Os nove tratamentos foram constituídos por 14 repetições cada. As repetições foram bandejas de incubação, constituindo 1.204 ovos por tratamento. Para a avaliação do desempenho das frangas, o delineamento experimental foi inteiramente ao acaso, constituído por um esquema fatorial 3x3 (três níveis de URI e três idades), com seis repetições de 30 aves em cada tratamento. A eclodibilidade sobre ovos férteis foi maior (P<0,05) com a utilização de 56% de umidade relativa do ar durante a incubação, independentemente da idade da matriz; e ovos de matrizes mais velhas (56 semanas) apresentaram eclodibilidade menor (P<0,05), independentemente do nível de umidade relativa do ar no interior das incubadoras. Não foram constatados efeitos da idade da matriz e URI sobre o percentual de pintos refugos. A URI ou a idade da matriz leve não afetam o desempenho da progênie.
The aim of this study was to evaluate the effects of relative humidity in incubators (RHI) and breeder hen age on hatchability, hatchling quality and performance of progeny. 10,840 eggs were incubated, and the treatments were defined by the Lohmann LSL(r) breeder age (26, 41 and 56 weeks) and the levels of RHI (48, 56 and 64%). After incubation, 1,620 female chicks were raised in a conventional experimental shed, according to the treatments, until 12 weeks of age. To assess the hatchability of fertile eggs and unviable female chicks, the experimental design was randomized blocks in split plots design. The plot factor was the RHI and the subplot was the age of the breeder hens. The blocks were made by the floors of the incubation carriages, where each floor contained a repetition of each breeder age. The nine treatments consisted of 14 repetitions each. The repetitions were trays of incubation, with 1,204 eggs per treatment. To evaluate the performance of the progeny, the experimental design was completely randomized, consisting of a 3x3 factorial scheme with six replicates of 30 birds in each treatment. Hatchability of fertile eggs was higher (P<0.05) with the use of 56% relative humidity during incubation, regardless of breeder age, and the eggs from the oldest breeder hens (56 weeks) had lower hatchability (P<0.05), regardless of the level of relative humidity inside the incubator. No effects of breeder age and RHI on the percentage of unviable chicks were observed. The RHI or the age of the breeder hen does not affect the performance of progeny.
Asunto(s)
Animales , Pollos/crecimiento & desarrollo , Humedad/prevención & control , Incubadoras/veterinariaRESUMEN
Avaliaram-se os efeitos da protease sobre o coeficiente de metabolizabilidade dos nutrientes em dietas contendo farinha de penas (2,0% na fase inicial e 3,0% na fase de crescimento) para frangos de corte machos, Cobb(r), de um a 32 dias de idade. Foram alojadas 336 aves em gaiolas metálicas equipadas com bandeja para coleta total de excretas. Foi utilizado delineamento inteiramente ao acaso, em arranjo fatorial 2x2 (com e sem adição da enzima protease 0,05% e duas valorizações da matriz nutricional da enzima), sendo sete repetições por tratamento, de 12 aves cada. Observou-se, na fase inicial, maior CMPB (P≤0,05) para as aves que, independentemente da adição de protease, consumiram ração com valorização da matriz nutricional da enzima. Não houve efeito dos tratamentos sobre o CMMS e o CMEE (P>0,05). Na fase de crescimento, houve interação entre os tratamentos para as variáveis CMPB e CMEE. Os frangos alimentados com dieta valorizada sem adição de enzima (controle negativo) apresentaram melhores resultados (P≤0,05) para CMPB e CMEE. Nos tratamentos com enzima, o melhor CMEE (P≤0,05) foi obtido com o tratamento sem valorização da matriz nutricional (over the top). Conclui-se que níveis reduzidos e enzima sem valorização melhoram os coeficientes de metabolizabilidade dos nutrientes na fase adulta de frangos de corte.(AU)
This experiment aimed to evaluate the effects of protease on metabolization coefficient of nutrients, performance and slaughter yield from male Cobb(r) broilers fed diets with feather meal. Two experiments were carried out in a completely randomized design in a 2x2 factorial arrangement - with (0.05%) or without enzyme addition x considering or not the improvement of the nutritional value by protease, with seven replicates per treatment group. In experiment 1 the metabolization coefficient of dry matter (MCDM), crude protein (MCCP) and ether extract (MCEE) in initial (9-12-d-old) and growth (29-32-d-old) phase was evaluated. In the initial phase it was observed that regardless of enzyme addition, broiler chickens fed a diet considering improvement in nutritional value had higher MCCP (P≤0.05). However, MCDM and MCEE were not affected (P>0.05). In the growth phase, there were interactions between treatments for the variables MCCP and MCEE. The birds fed diets considering the improvement in nutritional value without enzyme (negative control) showed better results (P≤0.05) for MCCP and MCEE. In the treatments with enzyme, the best MCEE (P≤0.05) was observed in the treatment not considering the improvement in the nutritional value (over the top). Therefore, considering the improvement in the nutritional value and enzyme without considering the improvement in the nutritional value improves the coefficients of metabolization of nutrients in broiler chickens.(AU)
Asunto(s)
Animales , Péptido Hidrolasas/administración & dosificación , Pollos/metabolismo , Enzimas/administración & dosificación , Tasa de Depuración MetabólicaRESUMEN
O experimento foi conduzido em delineamento inteiramente ao acaso para avaliar os efeitos de diferentes níveis de glicina+serina (gli+ser) total em dietas de baixa proteína bruta (PB) sobre o desempenho e características de carcaça de frangos de corte de um a 21 dias de idade. Foram utilizadas 750 aves, distribuídas em cinco tratamentos, cinco repetições e 30 aves por unidade experimental. As dietas utilizadas continham 190g/kg de PB e níveis de gli+ser de 16,7; 19,2; 21,7 e 24,2g/kg; a dieta controle continha 230g/kg de PB. Avaliaram-se os efeitos dos níveis de glicina+serina sobre o desempenho e composição de carcaça. Os dados foram submetidos à análise de variância e os resultados obtidos com as dietas de baixos níveis proteicos com diferentes níveis de gli+ser foram comparados à dieta controle pelo teste de Dunnett. Os níveis de gli+ser apresentaram efeito linear sobre a conversão alimentar, ganho de peso e peso aos 21 dias, sendo o nível de 24,2g/kg de gli+ser com resultado semelhante à dieta controle. A redução proteica aumentou o conteúdo de extrato etéreo na carcaça.(AU)
A completely randomized experimental design was carried out to evaluate the effects of total gly+ser levels in low crude protein diets on performance and body composition of male broiler chickens from 1 to 21 days of age. Seven hundred and fifty broiler chickens were used in each one of the production phases. The birds were randomly allotted to five treatments and five replicates. The diets contained 190g/kg crude protein (CP) and total gly+ser levels of 16.7; 19.2; 21.7 and 24.2g/kg; and a control diet with 230 g/kg CP. The effect of glycine+serine levels on performance and body composition was evaluated. Data were subjected to analysis of variance and the results obtained with the diets of low crude protein levels with different levels of Gly + Ser were compared to the control diet by Dunnett's test. The gly+ser levels improved the feed linearly: weight gain ratio; weight gain and final weight. The broilers fed 24.2g/kg gly+ser diet showed a performance similar to broilers fed control diets. The carcass fat increased with CP reduction.(AU)
Asunto(s)
Animales , Serina/administración & dosificación , Proteínas en la Dieta/administración & dosificación , Aumento de Peso , Pollos , Glicina/administración & dosificación , Alimentación AnimalRESUMEN
Objetivou-se a avaliação dos efeitos dos níveis de suplementação de vitamina E na ração para frangos de corte sobre o desempenho na fase inicial (um a 21 dias de idade) e de crescimento (21 a 39 dias de idade). Os tratamentos foram definidos pelos níveis de suplementação de vitamina E (DL-α tocoferol). As quantidades adicionadas às rações foram: 10; 30; 50; 75 e 100mg de vitamina E para cada kg de ração. Na fase inicial (experimento I), o menor nível de suplementação de vitamina E mostrou-se superior aos demais, apresentando efeito significativo (P≤0,05) sobre o peso médio aos 21 dias de idade e ganho de peso de um a 21 dias de idade. Na fase de crescimento (experimento II), não houve efeito significativo (P>0,05) dos níveis de suplementação de vitamina E sobre as variáveis estudadas. O nível mínimo de suplementação de vitamina E testado (10mg/kg) é suficiente para atender às exigências dos frangos de corte machos sobre o desempenho.(AU)
This study aimed to evaluate the effect of vitamin E supplementation on the performance of broiler chickens in the initial and growth phase, from one to 21 and 21 to 39 days of age, respectively. Five increasing levels of DL-α tocopherol supplementation (10, 30, 50, 75 and 100mg to each kg of diet) were added to the diet. In the initial phase (experiment I), the lowest vitamin E level was superior by presenting significant effect (P≤0.05) on body weight at 21 days of age and weight gain from one to 21 days old. In the growth phase (experiment II), there was no significant effect (P>0.05) of vitamin E supplementation on the variables studied. The minimum level of vitamin E supplementation tested is sufficient to attend the requirements of male broiler chickens.(AU)
Asunto(s)
Animales , Vitamina E/administración & dosificación , Aumento de Peso , Pollos/crecimiento & desarrollo , Suplementos Dietéticos , Tocoferoles , Alimentación Animal/análisisRESUMEN
The objective of this study was to evaluate the quality of pellets from the end of the pelletizer machine until the end of the line feed plate, using two methods of analysis: pellet durability index (PDI) and EMBRAPA pelletizing method (MEP). Furthermore, the effect of the discharging methods at the broiler farm on the physical quality of pellets using MEP as a method of analysis was evaluated. The first phase of the experiment was a randomized block with six treatments: A - pellets at the end of the pelletizer machine; B - pellets inside the truck; C - truck's discharging at the feed silo; D - place inside the warehouse after the feed silo; E - the middle of the feed plate line and F - the end of the feed plate line. The experiment was carried out in seven replicates (blocks). The second phase of the experiment was a randomized block with two treatments: A - smaller discharge opening (for pellets feed); B - bigger discharge opening (for mashed feed). The experiment was performed with twelve replicates (blocks). The discharge of the pellets feed at broilers farm is the point that worsens the pellets quality. The discharge of pellets feed by the truck should be done with the bigger discharge opening. Moreover, MEP showed to be a better method than PDI to evaluate the integrity of the pellets for broiler chickens.(AU)
Asunto(s)
Animales , Aumento de Peso , Partículas Orgánicas/métodos , Pollos/metabolismo , Buenas Prácticas de Fabricación , Alimentación AnimalRESUMEN
Foram analisados os níveis de pCO2, pO2, pH e HCO3 - de embriões e pintos de corte provenientes de matrizes novas e velhas, nos momentos anteriores à bicagem interna e externa da casca e ao nascimento, submetidos a diferentes períodos de transferência para as condições ambientais dos nascedouros. Os tratamentos foram definidos pela idade da matriz (33 e 63 semanas) e pela transferência para o nascedouro (aos 15, 17 e 19 dias). O delineamento experimental foi em parcelas subdivididas, sendo a parcela os três momentos de transferência e a subparcela as duas idades das matrizes. Foram utilizadas seis repetições para cada tratamento, e o embrião ou o pinto foi considerado uma repetição. Os dados normais e homogêneos foram submetidos às análises de variância, e as médias comparadas pelos testes F, de Tukey e SNK. Embriões cujos ovos foram transferidos aos 15 dias para o nascedouro apresentaram melhor equilíbrio ácido-básico durante as fases pré-natal e perinatal. Durante o último terço da incubação, independentemente das diferentes condições ambientais às quais os embriões são submetidos e da idade da matriz, há capacidade de resposta fisiológica que permite uma estabilidade no equilíbrio ácido-básico dos pintos após a eclosão...
We analyzed the levels of pCO2, pO2, pH and HCO3 - in embryos and chicks from young and older breeders, in the moments before internal pipping, external pipping and at hatch and submitted to different periods in the environmental conditions of hatchers. The treatments were defined by breeder age (33 and 63 weeks) and transfer to the hatcher (at 15, 17 and 19 days). The experimental design was split plots with three periods in the hatcher and the plots were the two breeder ages. We used six replicates per treatment and the embryo or chick was considered a repetition. The normal data forms were submitted to analysis of variance and means were compared by F, Tukey and SNK tests. Embryos transferred at 15 days to the hatcher had better acid-base balance during the pre-and perinatal phases. During the last third of incubation, regardless of the different environmental conditions which the embryos are subjected and breeder age, there is physiological responsiveness that allows for stability in acid-base balance of the chicks after hatching...
Asunto(s)
Animales , Embrión de Pollo , Bicarbonatos/análisis , Dióxido de Carbono/análisis , Pollos/metabolismo , Análisis de los Gases de la Sangre/veterinaria , Hidrógeno/análisis , Oxígeno/análisis , Equilibrio Hidroelectrolítico , Distribución por Edad , Análisis de VarianzaRESUMEN
O desenvolvimento embrionário nas aves tem início antes mesmo da postura. A variabilidade do estágio de desenvolvimento embrionário no momento da oviposição é conhecida e influencia a taxa de eclosão, uma vez que estágios muito avançados ou muito precoces são prejudiciais por tornarem os embriões mais sensíveis ao estresse do armazenamento. O aquecimento de ovos férteis no período entre a postura e o armazenamento vem sendo estudado como forma de reduzir os efeitos negativos do armazenamento sobre o rendimento de incubação por permitir que os embriões progridam até um estágio em que são mais aptos a suportar o estresse do armazenamento. Este experimento teve como objetivo avaliar os efeitos do aquecimento artificial de ovos de matrizes pesadas no período entre a coleta e o armazenamento sobre o rendimento de incubação e o peso do pinto ao nascimento. Foram utilizados 5.760 ovos de matrizes pesadas Cobb(r) com 57 semanas de idade. O delineamento experimental foi inteiramente ao acaso, constituído por quatro tratamentos definidos com base no tempo de aquecimento dos ovos (zero, três, seis e nove horas). O aquecimento foi feito em câmara de fumigação a 30°C, e os ovos foram armazenados por três dias. O aquecimento artificial no período entre a coleta e o armazenamento não influenciou a eclodibilidade, a mortalidade embrionária e o peso do pinto ao nascimento, tendo sido, nessas circunstâncias, uma prática injustificada...
In birds, embryonic development begins before laying. The embryonic development variability at the time of egg laying is known and influences hatching rate, since very early or advanced stages are detrimental for embryos because they become more sensitive to stress storage. The heating of fertile eggs in the period between posture and storage has been studied as a way to reduce the negative effects of storage on hatchability since it allows embryos to progress to a stage where they are more able to survive during storage. This experiment aimed to evaluate the effects of artificial heating of fertile broiler breeder eggs in the period between the collection and storage on hatchability and chick weight at birth. For this, 5760 eggs from Cobb(r) broiler breeders, 57 weeks old, were used. The experimental design was completely randomized. It consisted of four defined treatments based on the heating time of eggs (zero, three, six and nine hours). Heating was done in a fumigation chamber at 30°C, and eggs were stored for three days. The artificial heating in the period between collection and storage didn't affect hatchability, embryo mortality and chick weight at birth, being, in this case, an unjustified practice...
Asunto(s)
Animales , Aves de Corral/crecimiento & desarrollo , Aves de Corral/embriología , Desarrollo Embrionario , Peso al Nacer , Mortalidad , Índice de EmbarazoRESUMEN
The objective of this study was to evaluate the correlation between the levels of bioactive amines and the microbiological quality of liquid pasteurized egg stored under refrigeration. Pasteurized whole egg liquid was obtained from 2 types of different raw materials, fresh eggs, and commercial fertile eggs. They were stored under refrigeration over a period of 21 d. The treatments were arranged in a completely randomized split plot, with the plots being the 2 types of liquid pasteurized egg, and the subplots being the 4 storage periods (1, 7, 14, and 21 d). The storage period did not contribute to the increase (P > 0.05) of contamination by mesophilic aerobic microorganisms and total coliforms in commercial liquid pasteurized egg. However, for fertile eggs, the storage period led to an increase (P < 0.05) in the numbers of microorganisms. Levels of the amines putrescine, cadaverine, and tyramine were detected only in fertile liquid pasteurized egg, and the storage period contributed to the increase (P < 0.05) in the levels of these amines. There was a high correlation between total coliform most probable number and cadaverine levels, and a moderate correlation between the numbers of aerobic mesophilic microorganisms and tyramine levels. It was concluded that the most contaminated liquid pasteurized eggs were the fertile liquid pasteurized eggs and this caused the highest levels of bioactive amines in them compared with all the eggs that had been subjected to pasteurization and refrigerated storage.
Asunto(s)
Aminas/metabolismo , Huevos/análisis , Huevos/microbiología , Microbiología de Alimentos , Almacenamiento de Alimentos , Pasteurización , Animales , Pollos , Recuento de Colonia Microbiana , Refrigeración , Factores de TiempoRESUMEN
Foram avaliados os efeitos do momento de transferência dos ovos da incubadora para o nascedouro e da idade da matriz pesada sobre o rendimento de incubação. Os tratamentos foram definidos pela idade das matrizes Cobb®, sendo considerados ovos de matrizes novas (33 semanas) e ovos de matrizes velhas (63 semanas), e pelos momentos de transferência da câmara de incubação para os nascedouros (aos 15, 17 e 19 dias). O delineamento experimental foi inteiramente ao acaso em parcelas subdivididas, sendo o fator da parcela os três momentos das transferências e as subparcelas as duas idades das matrizes, com 18 repetições por tratamento. A bandeja com 96 ovos foi considerada a repetição, totalizando 1.728 ovos para cada tratamento. Ovos de matrizes velhas são mais pesados, perdem mais peso durante a incubação e têm percentual de fertilidade menor (P<0,05), qualquer que seja o momento de transferência dos ovos. Independentemente da idade das matrizes, a transferência dos ovos da incubadora para o nascedouro aos 15, 17 ou 19 dias de incubação não interfere na mortalidade embrionária, eclodibilidade e peso dos pintos ao nascimento. É possível adaptar o manejo de transferência à necessidade logística do incubatório ou reduzir o período dos ovos na máquina de incubação para aumentar o fluxo de produção, sem prejuízo ao rendimento de incubação.
We evaluated the effects of the moment of egg transfer to the hatcher and broiler breeder age on the incubation yield. The treatments were defined by Cobb ® broiler breeder age, separating young breeders (33 weeks old) from older breeders (63 weeks old) and the moment of transfer from incubation chamber to the hatcher (at 15, 17 and 19 days). The experimental design was completely randomized split plot. The plots factor was the three times of transfers and the subplots the two breeder ages, with 18 replicates per treatment. A tray of 96 eggs was considered replay, totaling 1728 eggs for each treatment. Eggs from older breeders are heavier, lose more weight during incubation and fertility rate is lower (p<0.05), regardless of the moments of eggs transfer. Regardless of the breeder age, the transfer of eggs from the incubator to the hatcher at 15, 17 or 19 days of incubation does not interfere in embryonic mortality, hatchability and chick weight at hatch. You can adapt the transfer management to the logistic needs of the hatchery or reduce the period of egg incubation in the machine to increase the flow of production with no losses in incubation yield.