Effect of external dead volume on performance while wearing a respirator.

Respirator dead volume accumulates exhaled carbon dioxide and returns it to the respiratory system during subsequent inhalations. Because inhaled carbon dioxide is known to be a powerful respiratory stimulant and psychoactive gas, respirator dead volume would be expected to influence performance times while respirators are worn during work. This experiment was performed at intense levels of treadmill walking (80-85% VO2max) to demonstrate maximum sensitivity to respiratory stress. Six dead volume conditions (representing a range of 280 to 1,160 mL) were imposed on the subjects. Results show linear decreases in performance times and breathing apparatus comfort with increasing dead volumes. For each 350 mL of external dead volume, a 19% decrease of performance time and an 18% decrease in breathing apparatus comfort can be expected.

Communication using a telephone while wearing a respirator.

Respirators have been found to degrade communication effectiveness when wearers speak face-to-face. However, little is known about communication effectiveness when using the telephone and wearing a respirator. Eleven pairs of subjects were asked to pronounce and identify words chosen from Modified Rhyme Test lists. Each word appeared on a computer screen in one room and the speaker said the word into the telephone. The listener in another room identified the word and typed it into a computer linked with the first. Subjects wore U.S. Army M40 full-facepiece air-purifying respirators with hoods. Three different speech diaphragm arrangements and two hood materials were tested. Results show that accuracy suffered by about 10% when respirators and hoods were worn compared with the control condition. Word identification speed was one-third to one-half of the control (no respirator or hood) condition depending on specific equipment worn.

Effect of respirator inspiratory resistance level on constant load treadmill work performance.

Respirator inspiratory resistance can affect performance times, especially when the experiment is optimized to elicit respiratory stress. Twelve subjects performed on a treadmill at constant speeds and grades chosen to result in performance times of 5-15 min. Six levels of inspiratory resistance were used, ranging from 0.78 to 7.64 cm H2O.sec/L. The results showed that performance times decrease linearly with resistance level, and no threshold resistance value is apparent. Inspiratory resistance also induces hypoventilation, with lower minute volumes and lower oxygen consumption values at higher resistances. These trends are also linear. From these results, there is no value for inspiratory resistance that can be given as a design goal. Other parameters such as weight and space may dictate filter resistance values, and these, in turn, will lead to determined performance degradations.

Respiratory resistance measured by an airflow perturbation device.

The airflow perturbation device (APD) is an instrument for the measurement of respiratory resistance. The APD is small, lightweight, fast and requires no special breathing manoeuvres. Airflow perturbation determines resistance by superimposing a periodic signal onto spontaneous breathing with a variable resistance device. Respiratory impedance is the ratio of magnitude of pressure perturbation to magnitude of flow perturbation, and respiratory resistance is the in-phase portion of respiratory impedance. The APD was tested to determine its responses to repeated resistance measurements and to changes in resistance. A mechanical model test showed that the APD could detect increased resistance levels, but overestimated resistance when resistance increased with flow. Tests with human subjects showed that the APD gave results consistent from day to day, was able to detect added resistances, and gave resistance values correlated with airway resistance values obtained by body plethysmography. Accelerometers placed on the chests of the subjects showed that perturbations extend to the chest surface. Thus, the APD must measure total respiratory resistance.