RESUMEN
Hydrogen is an alternative fuel for transportation vehicles because it is clean, sustainable, and highly flammable. However, the production of hydrogen from lignocellulosic biomass by microorganisms presents challenges. This microbial process involves multiple complex steps, including thermal, chemical, and mechanical treatment of biomass to remove hemicellulose and lignin, as well as enzymatic hydrolysis to solubilize the plant cell walls. These steps not only incur costs but also result in the production of toxic hydrolysates, which inhibit microbial growth. A hyper-thermophilic bacterium of Caldicellulosiruptor bescii can produce hydrogen by decomposing and fermenting plant biomass without the need for conventional pretreatment. It is considered as a consolidated bioprocessing (CBP) microorganism. This review summarizes the basic scientific knowledge and hydrogen-producing capacity of C. bescii. Its genetic system and metabolic engineering strategies to improve hydrogen production are also discussed. KEY POINTS: ⢠Hydrogen is an alternative and eco-friendly fuel. ⢠Caldicellulosiruptor bescii produces hydrogen with a high yield in nature. ⢠Metabolic engineering can make C. bescii to improve hydrogen production.
Asunto(s)
Clostridiales , Ingeniería Metabólica , Biomasa , HidrógenoRESUMEN
This work aimed to evaluate the feasibility of biohydrogen production from Barley Straw and Miscanthus. The primary obstacle in plant biomass decomposition is the recalcitrance of the biomass itself. Plant cell walls consist of cellulose, hemicellulose, and lignin, which make the plant robust to decomposition. However, the hyperthermophilic bacterium, Caldicellulosiruptor bescii, can efficiently utilize lignocellulosic feedstocks (Barley Straw and Miscanthus) for energy production, and C. bescii can now be metabolically engineered or isolated to produce more hydrogen and other biochemicals. In the present study, two strains, C. bescii JWCB001 (wild-type) and JWCB018 (ΔpyrFA Δldh ΔcbeI), were tested for their ability to increase hydrogen production from Barley Straw and Miscanthus. The JWCB018 resulted in a redirection of carbon and electron (carried by NADH) flow from lactate production to acetate and hydrogen production. JWCB018 produced ~54% and 63% more acetate and hydrogen from Barley Straw, respectively than its wild-type counterpart, JWCB001. Also, 25% more hydrogen from Miscanthus was obtained by the JWCB018 strain with 33% more acetate relative to JWCB001. It was supported that the engineered C. bescii, such as the JWCB018, can be a parental strain to get more hydrogen and other biochemicals from various biomass.
Asunto(s)
Hordeum , Celulosa , Lignina/química , Plantas , Hidrógeno , Acetatos , BiomasaRESUMEN
The development of a yeast strain capable of fermenting mixed sugars efficiently is crucial for producing biofuels and value-added materials from cellulosic biomass. Previously, a mutant Pichia stipitis YN14 strain capable of co-fermenting xylose and cellobiose was developed through evolutionary engineering of the wild-type P. stipitis CBS6054 strain, which was incapable of cofermenting xylose and cellobiose. In this study, through genomic and transcriptomic analyses, we sought to investigate the reasons for the improved sugar metabolic performance of the mutant YN14 strain in comparison with the parental CBS6054 strain. Unfortunately, comparative wholegenome sequencing (WGS) showed no mutation in any of the genes involved in the cellobiose metabolism between the two strains. However, comparative RNA sequencing (RNA-seq) revealed that the YN14 strain had 101.2 times and 5.9 times higher expression levels of HXT2.3 and BGL2 genes involved in cellobiose metabolism, and 6.9 times and 75.9 times lower expression levels of COX17 and SOD2.2 genes involved in respiration, respectively, compared with the CBS6054 strain. This may explain how the YN14 strain enhanced cellobiose metabolic performance and shifted the direction of cellobiose metabolic flux from respiration to fermentation in the presence of cellobiose compared with the CBS6054 strain.
Asunto(s)
Celobiosa , Xilosa , Xilosa/metabolismo , Celobiosa/metabolismo , Transcriptoma , Fermentación , Saccharomyces cerevisiae/metabolismo , Genómica , Pichia/metabolismoRESUMEN
The valorization of CO2 into valuable products is a sustainable strategy to help overcome the climate crisis. In particular, biological conversion is attractive as it can produce long-chain hydrocarbons such as terpenoids. This study reports the high yield of ß-farnesene production from CO2 by expressing heterologous ß-farnesene synthase (FS) into Rhodobacter sphaeroides. To increase the expression of FS, a strong active promoter and a ribosome binding site (RBS) were engineered. Moreover, ß-farnesene production was improved further through the supply of exogenous antioxidants and additional nutrients. Finally, ß-farnesene was produced from CO2 at a titer of 44.53 mg/L and yield of 234.08 mg/g, values that were correspondingly 23 times and 46 times higher than those from the initial production of ß-farnesene. Altogether, the results here suggest that the autotrophic production of ß-farnesene can provide a starting point for achieving a circular carbon economy.
Asunto(s)
Rhodobacter sphaeroides , Sesquiterpenos , Antioxidantes/metabolismo , Carbono/metabolismo , Dióxido de Carbono/metabolismo , Rhodobacter sphaeroides/metabolismo , Sesquiterpenos/metabolismoRESUMEN
This study is aimed to explore the impact of fermentation temperature on laver kombucha by profiling the accumulation and degradation of metabolites and elucidating their related pathways of metabolism. Laver kombucha was produced through ultrasound-assisted extraction and fermentation using a biofilm called SCOBY at 25 and 30 °C (hereafter named K-25 and K-30, respectively) for 14 days. Overall, organic acids, soluble sugars, amino acids, and phenolic compounds were found to participate in the biosynthesis pathway. The level of amino acids showed a decreasing trend, except taurine in the K-30. At day 14, phenolic compounds (pyrogallol, ρ-hydroxybenzoic acid, ρ-coumaric acid, salicylic acid, rutin, and naringin) were accumulated in both samples. Although it showed a similar trend, K-25 exhibited a higher metabolite accumulation tendency than K-30. This comprehensive characterization of the dynamic changes of metabolites and pathway prediction can pinpoint the influence of the fermentation conditions on the biosynthesis of secondary metabolites.
Asunto(s)
Porphyra , Antioxidantes , Fermentación , Fenoles , Porphyra/química , TemperaturaRESUMEN
Industrial demand for capture and utilization using microorganisms to reduce CO2, a major cause of global warming, is significantly increasing. Rhodobacter sphaeroides is a suitable strain for the process of converting CO2 into high-value materials because it can accept CO2 and has various metabolic pathways. However, it has been mainly studied for heterotrophic growth that uses sugars and organic acids as carbon sources, not autotrophic growth. Here, we report that the regulation of reactive oxygen species is critical for growth when using CO2 as a sole carbon source in R. sphaeroides. In general, the growth rate is much slower under autotrophic conditions compared to heterotrophic conditions. To improve this, we performed random mutagenesis using N-methyl-N'-nitro-N-nitrosoguanidine (NTG). As a result, we selected the YR-1 strain with a maximum specific growth rate (µ) 1.44 day-1 in the early growth phase, which has a 110% faster growth rate compared to the wild-type. Based on the transcriptome analysis, it was confirmed that the growth was more sensitive to reactive oxygen species under autotrophic conditions. In the YR-1 mutant, the endogenous contents of H2O2 levels and oxidative damage were reduced by 33.3 and 42.7% in the cells, respectively. Furthermore, we measured that concentrations of carotenoids, which are important antioxidants. The total carotenoid is produced 9.63 g/L in the YR-1 mutant, suggesting that the production is 1.7-fold higher than wild-type. Taken together, our observations indicate that controlling ROS promotes cell growth and carotenoid production under autotrophic conditions.
RESUMEN
Until recently, four types of cellobiose-fermenting Saccharomyces cerevisiae strains have been developed by introduction of a cellobiose metabolic pathway based on either intracellular ß-glucosidase (GH1-1) or cellobiose phosphorylase (CBP), along with either an energy-consuming active cellodextrin transporter (CDT-1) or a non-energy-consuming passive cellodextrin facilitator (CDT-2). In this study, the ethanol production performance of two cellobiose-fermenting S. cerevisiae strains expressing mutant CDT-2 (N306I) with GH1-1 or CBP were compared with two cellobiose-fermenting S. cerevisiae strains expressing mutant CDT-1 (F213L) with GH1-1 or CBP in the simultaneous saccharification and fermentation (SSF) of cellulose under various conditions. It was found that, regardless of the SSF conditions, the phosphorolytic cellobiose-fermenting S. cerevisiae expressing mutant CDT-2 with CBP showed the best ethanol production among the four strains. In addition, during SSF contaminated by lactic acid bacteria, the phosphorolytic cellobiose-fermenting S. cerevisiae expressing mutant CDT-2 with CBP showed the highest ethanol production and the lowest lactate formation compared with those of other strains, such as the hydrolytic cellobiose-fermenting S. cerevisiae expressing mutant CDT-1 with GH1-1, and the glucose-fermenting S. cerevisiae with extracellular ß-glucosidase. These results suggest that the cellobiose-fermenting yeast strain exhibiting low energy consumption can enhance the efficiency of the SSF of cellulosic biomass.
Asunto(s)
Celobiosa/biosíntesis , Celobiosa/genética , Fermentación , Ingeniería Metabólica/métodos , Saccharomyces cerevisiae/genética , Saccharomyces cerevisiae/metabolismo , Biomasa , Reactores Biológicos , Celulosa/análogos & derivados , Celulosa/metabolismo , Dextrinas , Etanol , Glucosiltransferasas/biosíntesis , Glucosiltransferasas/genética , Hidrólisis , beta-Glucosidasa/biosíntesis , beta-Glucosidasa/genéticaRESUMEN
Although engineered Saccharomyces cerevisiae fermenting cellobiose is useful for the production of biofuels from cellulosic biomass, cellodextrin accumulation is one of the main problems reducing ethanol yield and productivity in cellobiose fermentation with S. cerevisiae expressing cellodextrin transporter (CDT) and intracellular ß-glucosidase (GH1-1). In this study, we investigated the reason for the cellodextrin accumulation and how to alleviate its formation during cellobiose fermentation using engineered S. cerevisiae fermenting cellobiose. From the series of cellobiose fermentation using S. cerevisiae expressing only GH1-1 under several culture conditions, it was discovered that small amounts of GH1-1 were secreted and cellodextrin was generated through trans-glycosylation activity of the secreted GH1-1. As GH1-1 does not have a secretion signal peptide, non-conventional protein secretion might facilitate the secretion of GH1-1. In cellobiose fermentations with S. cerevisiae expressing only GH1-1, knockout of TLG2 gene involved in non-conventional protein secretion pathway significantly delayed cellodextrin formation by reducing the secretion of GH1-1 by more than 50%. However, in cellobiose fermentations with S. cerevisiae expressing both GH1-1 and CDT-1, TLG2 knockout did not show a significant effect on cellodextrin formation, although secretion of GH1-1 was reduced by more than 40%. These results suggest that the development of new intracellular ß-glucosidase, not influenced by non-conventional protein secretion, is required for better cellobiose fermentation performances of engineered S. cerevisiae fermenting cellobiose.
Asunto(s)
Celobiosa/metabolismo , Celulosa/análogos & derivados , Dextrinas/metabolismo , Saccharomyces cerevisiae/metabolismo , beta-Glucosidasa/metabolismo , Biocombustibles , Celulosa/metabolismo , Etanol/metabolismo , Fermentación , Glicosilación , Proteínas de Transporte de Membrana/genética , Proteínas de Transporte de Membrana/metabolismo , Ingeniería Metabólica , Proteínas Qa-SNARE/genética , Proteínas Qa-SNARE/metabolismo , Saccharomyces cerevisiae/genética , Proteínas de Saccharomyces cerevisiae/genética , Proteínas de Saccharomyces cerevisiae/metabolismo , Vías Secretoras/genética , beta-Glucosidasa/genéticaRESUMEN
In a previously engineered Saccharomyces cerevisiae recombinant, the cellobiose fermentation rate was significantly lower than the glucose fermentation rate. Thus, we implemented a genome-wide perturbation library to find gene targets for improving the cellobiose fermentation capability of the yeast strain. Unexpectedly, we discovered a transformant that contained an additional ß-glucosidase gene (gh1-1), possibly through homologous recombination between the plasmids. The additional ß-glucosidase led to the fastest cellobiose fermentation activity among all the transformants evaluated, and the strain demonstrated significantly higher ß-glucosidase activity than the control strain, especially during the initial exponential growth phase. The present work revealed the benefit of the extra gh1-1 copy for efficient cellobiose fermentation in the engineered S. cerevisiae strain.
RESUMEN
To efficiently ferment intermediate cellodextrins released during cellulose hydrolysis, Saccharomyces cerevisiae has been engineered by introduction of a heterologous cellodextrin utilizing pathway consisting of a cellodextrin transporter and either an intracellular ß-glucosidase or a cellobiose phosphorylase. Among two types of cellodextrin transporters, the passive facilitator CDT-2 has not enabled better cellobiose fermentation than the active transporter CDT-1, which suggests that the CDT-2 might be engineered to provide energetic benefits over the active transporter in cellobiose fermentation. We attempted to improve cellobiose transporting activity of CDT-2 through laboratory evolution. Nine rounds of a serial subculture of S. cerevisiae expressing CDT-2 and cellobiose phosphorylase on cellobiose led to the isolation of an evolved strain capable of fermenting cellobiose to ethanol 10-fold faster than the original strain. After sequence analysis of the isolated CDT-2, a single point mutation on CDT-2 (N306I) was revealed to be responsible for enhanced cellobiose fermentation. Also, the engineered strain expressing the mutant CDT-2 with cellobiose phosphorylase showed a higher ethanol yield than the engineered strain expressing CDT-1 and intracellular ß-glucosidase under anaerobic conditions, suggesting that CDT-2 coupled with cellobiose phosphorylase may be better choices for efficient production of cellulosic ethanol with the engineered yeast.
Asunto(s)
Celobiosa/química , Glucosiltransferasas/genética , Proteínas de Transporte de Membrana/genética , Saccharomyces cerevisiae/crecimiento & desarrollo , Celulosa/análogos & derivados , Celulosa/metabolismo , Dextrinas/metabolismo , Fermentación , Glucosiltransferasas/metabolismo , Proteínas de Transporte de Membrana/metabolismo , Ingeniería Metabólica , Proteínas Recombinantes , Saccharomyces cerevisiae/genética , Saccharomyces cerevisiae/metabolismoRESUMEN
In simultaneous saccharification and fermentation (SSF) for production of cellulosic biofuels, engineered Saccharomyces cerevisiae capable of fermenting cellobiose has provided several benefits, such as lower enzyme costs and faster fermentation rate compared with wild-type S. cerevisiae fermenting glucose. In this study, the effects of an alternative intracellular cellobiose utilization pathway-a phosphorolytic pathway based on a mutant cellodextrin transporter (CDT-1 (F213L)) and cellobiose phosphorylase (SdCBP)-was investigated by comparing with a hydrolytic pathway based on the same transporter and an intracellular ß-glucosidase (GH1-1) for their SSF performances under various conditions. Whereas the phosphorolytic and hydrolytic cellobiose-fermenting S. cerevisiae strains performed similarly under the anoxic SSF conditions, the hydrolytic S. cerevisiae performed slightly better than the phosphorolytic S. cerevisiae under the microaerobic SSF conditions. Nonetheless, the phosphorolytic S. cerevisiae expressing the mutant CDT-1 showed better ethanol production than the glucose-fermenting S. cerevisiae with an extracellular ß-glucosidase, regardless of SSF conditions. These results clearly prove that introduction of the intracellular cellobiose metabolic pathway into yeast can be effective on cellulosic ethanol production in SSF. They also demonstrate that enhancement of cellobiose transport activity in engineered yeast is the most important factor affecting the efficiency of SSF of cellulose.
Asunto(s)
Celobiosa/metabolismo , Etanol/metabolismo , Ingeniería Metabólica/métodos , Saccharomyces cerevisiae/metabolismo , Biocombustibles , Biomasa , Celulosa/metabolismo , Etanol/análisis , Fermentación , Glucosiltransferasas/metabolismo , Plásmidos , Saccharomyces cerevisiae/genéticaRESUMEN
Although simultaneous saccharification and fermentation (SSF) of cellulosic biomass can offer efficient hydrolysis of cellulose through alleviating feed-back inhibition of cellulases by glucose, supplementation of ß-glucosidase is necessary because most fermenting microorganisms cannot utilize cellobiose. Previously, we observed that SSF of cellulose by an engineered Saccharomyces cerevisiae expressing a cellobiose transporter (CDT-1) and an intracellular ß-glucosidase (GH1-1) without ß-glucosidase could not be performed as efficiently as the traditional SSF with extracellular ß-glucosidase. However, we improved the ethanol production from SSF of cellulose by employing a further engineered S. cerevisiae expressing a mutant cellobiose transporter [CDT-1 (F213L) exhibiting higher VMAX than CDT-1] and GH1-1 in this study. Furthermore, limitation of cellobiose formation by reducing the amounts of cellulases mixture in SSF could lead the further engineered strain to produce ethanol considerably better than the parental strain with ß-glucosidase. Probably, better production of ethanol by the further engineered strain seemed to be due to a higher affinity to cellobiose, which might be attributed to not only 2-times lower Monod constant (KS) for cellobiose than KS of the parental strain for glucose but also 5-times lower KS than Michaelis-Menten constant (KM) of the extracellular ß-glucosidase for glucose. Our results suggest that modification of the cellobiose transporter in the engineered yeast to transport lower level of cellobiose enables a more efficient SSF for producing ethanol from cellulose.
Asunto(s)
Etanol/metabolismo , Proteínas de Transporte de Membrana , Organismos Modificados Genéticamente , Proteínas de Saccharomyces cerevisiae , Saccharomyces cerevisiae , beta-Glucosidasa , Celobiosa/genética , Celobiosa/metabolismo , Proteínas de Transporte de Membrana/biosíntesis , Proteínas de Transporte de Membrana/genética , Organismos Modificados Genéticamente/genética , Organismos Modificados Genéticamente/metabolismo , Saccharomyces cerevisiae/genética , Saccharomyces cerevisiae/metabolismo , Proteínas de Saccharomyces cerevisiae/biosíntesis , Proteínas de Saccharomyces cerevisiae/genética , beta-Glucosidasa/biosíntesis , beta-Glucosidasa/genéticaRESUMEN
2'-Fucosyllactose (2-FL) is one of most abundant functional oligosaccharides in human milk, which is involved in many biological functions for human health. To date, most microbial systems for 2-FL production have been limited to use Escherichia coli JM strains since they cannot metabolize lactose. In this study, E. coli BL21star(DE3) was engineered through deletion of the whole endogenous lactose operon and introduction of the modified lactose operon containing lacZâ³M15 from E. coli K-12. Expression of genes for guanosine 5'-diphosphate (GDP)-l-fucose biosynthetic enzymes and heterologous α-1,2-fucosyltransferase (FucT2) from Helicobacter pylori allowed the engineered E. coli BL21star(DE3) to produce 2-FL with 3-times enhanced yield than the non-engineered E. coli BL21star(DE3). In addition, the titer and yield of 2-FL were further improved by adding the three aspartate molecules at the N-terminal of FucT2. Overall, 6.4 g/L 2-FL with the yield of 0.225 g 2-FL/g lactose was obtained in fed-batch fermentation of the engineered E. coli BL21star(DE3) expressing GDP-l-fucose biosynthetic enzymes and three aspartate tagged FucT2.
Asunto(s)
Escherichia coli/genética , Fucosiltransferasas/metabolismo , Operón Lac , Lactosa/metabolismo , Trisacáridos/biosíntesis , Técnicas de Cultivo Celular por Lotes , Escherichia coli/metabolismo , Proteínas de Escherichia coli/genética , Fermentación , Fucosiltransferasas/genética , Eliminación de Gen , Humanos , Microbiología Industrial/métodos , Proteínas Recombinantes/genética , Proteínas Recombinantes/metabolismo , beta-Galactosidasa/genéticaRESUMEN
Sepiapterin is a precursor for the synthesis of tetrahydrobiopterin (BH4), which is a wellknown cofactor for aromatic amino acid hydroxylation and nitric oxide synthesis in higher mammals. In this study, a recombinant Escherichia coli BL21(DE3) strain harboring cyanobacterial guanosine 5'-triphosphate cyclohydrolase 1 (GCH1) and human 6- pyruvoyltetrahydropterin synthase (PTPS) genes was constructed to produce sepiapterin. The optimum conditions for T7 promoter-driven expression of GCH1 and PTPS were 30°C and 0.1 mM isopropyl-ß-D-thioglucopyranoside (IPTG). The maximum sepiapterin concentration of 88.1 ± 2.4 mg/l was obtained in a batch cultivation of the recombinant E. coli, corresponding to an 18-fold increase in sepiapterin production compared with the control condition (37°C and 1 mM IPTG).
Asunto(s)
Biopterinas/análogos & derivados , Escherichia coli/genética , Escherichia coli/metabolismo , Ingeniería Metabólica/métodos , Redes y Vías Metabólicas , Pterinas/metabolismo , Biopterinas/biosíntesis , Cianobacterias/enzimología , Cianobacterias/genética , Expresión Génica , Humanos , Temperatura , Activación TranscripcionalRESUMEN
Baeyer-Villiger (BV) oxidation of cyclohexanone to epsilon-caprolactone in a microbial system expressing cyclohexanone monooxygenase (CHMO) can be influenced by not only the efficient regeneration of NADPH but also a sufficient supply of oxygen. In this study, the bacterial hemoglobin gene from Vitreoscilla stercoraria (vhb) was introduced into the recombinant Escherichia coli expressing CHMO to investigate the effects of an oxygen-carrying protein on microbial BV oxidation of cyclohexanone. Coexpression of Vhb allowed the recombinant E. coli strain to produce a maximum epsilon-caprolactone concentration of 15.7 g/l in a fed-batch BV oxidation of cyclohexanone, which corresponded to a 43% improvement compared with the control strain expressing CHMO only under the same conditions.
Asunto(s)
Proteínas Bacterianas/metabolismo , Caproatos/metabolismo , Ciclohexanonas/metabolismo , Escherichia coli/enzimología , Escherichia coli/metabolismo , Lactonas/metabolismo , Oxigenasas/metabolismo , Hemoglobinas Truncadas/metabolismo , Proteínas Bacterianas/genética , Escherichia coli/genética , Expresión Génica , Ingeniería Metabólica , Oxigenasas/genética , Proteínas Recombinantes/genética , Proteínas Recombinantes/metabolismo , Hemoglobinas Truncadas/genética , Vitreoscilla/genéticaRESUMEN
Saccharomyces cerevisiae can be engineered to ferment cellodextrins produced by cellulases as a product of cellulose hydrolysis. Direct fermentation of cellodextrins instead of glucose is advantageous because glucose inhibits cellulase activity and represses the fermentation of non-glucose sugars present in cellulosic hydrolyzates. To facilitate cellodextrin utilization by S. cerevisiae, a fungal cellodextrin-utilizing pathway from Neurospora crassa consisting of a cellodextrin transporter and a cellodextrin hydrolase has been introduced into S. cerevisiae. Two cellodextrin transporters (CDT-1 and CDT-2) were previously identified in N. crassa, but their kinetic properties and efficiency for cellobiose fermentation have not been studied in detail. In this study, CDT-1 and CDT-2, which are hypothesized to transport cellodextrin with distinct mechanisms, were introduced into S. cerevisiae along with an intracellular ß-glucosidase (GH1-1). Cellobiose transport assays with the resulting strains indicated that CDT-1 is a proton symporter while CDT-2 is a simple facilitator. A strain expressing CDT-1 and GH1-1 (DCDT-1G) showed faster cellobiose fermentation than the strain expressing CDT-2 and GH1-1 (DCDT-2G) under various culture conditions with different medium compositions and aeration levels. While CDT-2 is expected to have energetic benefits, the expression levels and kinetic properties of CDT-1 in S. cerevisiae appears to be optimum for cellobiose fermentation. These results suggest CDT-1 is a more effective cellobiose transporter than CDT-2 for engineering S. cerevisiae to ferment cellobiose.
Asunto(s)
Celobiosa/metabolismo , Celulosa/análogos & derivados , Dextrinas/metabolismo , Proteínas de Transporte de Membrana/metabolismo , Neurospora crassa/enzimología , Celulosa/metabolismo , Fermentación , Proteínas de Transporte de Membrana/genética , Neurospora crassa/genética , Proteínas Recombinantes/genética , Proteínas Recombinantes/metabolismo , Saccharomyces cerevisiae/genética , Saccharomyces cerevisiae/metabolismoRESUMEN
Simultaneous saccharification and fermentation (SSF) has been considered a promising and economical process for cellulosic ethanol production. Further cost savings could be gained by reducing enzyme loading and engineering host strain for ethanol production. In this study, we demonstrate efficient ethanol production by SSF without supplementation of ß-glucosidase using an engineered Saccharomyces cerevisiae strain expressing a cellodextrin transporter and an intracellular ß-glucosidase from Neurospora crassa. Ethanol production profiles by the engineered yeast without supplementation of ß-glucosidase and by a parental strain with supplementation of ß-glucosidase were examined under various fermentation conditions. When initial cell mass concentrations were low, the traditional SSF with supplementation of ß-glucosidase showed better ethanol production than SSF with the engineered strain without supplementing ß-glucosidase. However, the engineered strain without supplementation of ß-glucosidase showed almost the same or even better ethanol productivity than the parental strain with supplementation of ß-glucosidase when initial cell mass concentrations were elevated. Our results suggest that efficient ethanol production by SSF could be achieved by engineered yeast capable of fermenting cellobiose without addition of extracellular ß-glucosidase, leading to economic production of cellulosic ethanol.
Asunto(s)
Saccharomyces cerevisiae/genética , Saccharomyces cerevisiae/metabolismo , beta-Glucosidasa/metabolismo , Biotecnología , Celulosa/análogos & derivados , Celulosa/metabolismo , Etanol/metabolismo , Fermentación , Ingeniería Genética/métodos , Ácidos Fosfóricos/metabolismo , Saccharomyces cerevisiae/enzimologíaRESUMEN
Saccharomyces cerevisiae can be engineered for xylose fermentation through introduction of wild type or mutant genes (XYL1/XYL1 (R276H), XYL2, and XYL3) coding for xylose metabolic enzymes from Scheffersomyces stipitis. The resulting engineered strains, however, often yielded undesirable phenotypes such as slow xylose assimilation and xylitol accumulation. In this study, we performed the mating of two engineered strains that exhibit suboptimal xylose-fermenting phenotypes in order to develop an improved xylose-fermenting diploid strain. Specifically, we obtained two engineered haploid strains (YSX3 and SX3). The YSX3 strain consumed xylose rapidly and produced a lot of xylitol. On the contrary, the SX3 strain consumed xylose slowly with little xylitol production. After converting the mating type of SX3 from alpha to a, the resulting strain (SX3-2) was mated with YSX3 to construct a heterozygous diploid strain (KSM). The KSM strain assimilated xylose (0.25gxyloseh(-1)gcells(-1)) as fast as YSX3 and accumulated a small amount of xylitol (0.03ggxylose(-1)) as low as SX3, resulting in an improved ethanol yield (0.27ggxylose(-1)). We found that the improvement in xylose fermentation by the KSM strain was not because of heterozygosity or genome duplication but because of the complementation of the two xylose-metabolic pathways. This result suggested that mating of suboptimal haploid strains is a promising strategy to develop engineered yeast strains with improved xylose fermenting capability.
Asunto(s)
Fermentación/genética , Ingeniería Genética/métodos , Saccharomyces cerevisiae/genética , Saccharomyces cerevisiae/metabolismo , Xilosa/metabolismo , Biomasa , Biotecnología , Diploidia , Etanol/análisis , Etanol/metabolismo , Glucosa/análisis , Glucosa/metabolismo , Haploidia , Redes y Vías Metabólicas , Mutación , Fenotipo , Xilitol/análisis , Xilitol/metabolismo , Xilosa/análisisRESUMEN
Efficient regeneration of NADPH is one of the limiting factors that constrain the productivity of biotransformation processes. In order to increase the availability of NADPH for enhanced biotransformation by engineered Escherichia coli, modulation of the pentose phosphate pathway and amplification of the transhydrogenases system have been conventionally attempted as primary solutions. Recently, other approaches for stimulating NADPH regeneration during glycolysis, such as replacement of native glyceradehdye-3-phosphate dehydrogenase (GAPDH) with NADP-dependent GAPDH from Clostridium acetobutylicum and introduction of NADH kinase catalyzing direct phosphorylation of NADH to NADPH from Saccharomyces cerevisiae, were attempted and resulted in remarkable impacts on NADPH-dependent bioprocesses. This review summarizes several metabolic engineering approaches used for improving the NADPH regenerating capacity in engineered E. coli for whole-cell-based bioprocesses and discusses the key features and progress of those attempts.
Asunto(s)
Escherichia coli/genética , Escherichia coli/metabolismo , Ingeniería Metabólica , NADP/metabolismo , Biotransformación , Clostridium acetobutylicum/enzimología , Clostridium acetobutylicum/genética , Gliceraldehído-3-Fosfato Deshidrogenasa (Fosforilante)/genética , Gliceraldehído-3-Fosfato Deshidrogenasa (Fosforilante)/metabolismo , Proteínas Mitocondriales/genética , Proteínas Mitocondriales/metabolismo , NADP Transhidrogenasas/genética , NADP Transhidrogenasas/metabolismo , Vía de Pentosa Fosfato/genética , Fosfotransferasas (Aceptor de Grupo Alcohol)/genética , Fosfotransferasas (Aceptor de Grupo Alcohol)/metabolismo , Saccharomyces cerevisiae/enzimología , Saccharomyces cerevisiae/genética , Proteínas de Saccharomyces cerevisiae/genética , Proteínas de Saccharomyces cerevisiae/metabolismoRESUMEN
The focus of this work was to develop a combined acid and alkaline hydrothermal pretreatment of lignocellulose that ensures high recovery of both hexose and pentose. Dilute sulfuric acid and lime pretreatments were employed sequentially. Process performance was optimized in terms of catalyst concentration, retention time, and temperature using response surface methodology. Medium operational conditions in the acid stage and harsh conditions in the alkaline stage were desirable with optimal performance at 0.73 wt% H(2)SO(4), 150 °C, 6.1 min in the first stage, and 0.024 g lime/g biomass, 202 °C, 30 min in the second stage. In comparison to single-stage pretreatments with high recovery of either glucose or xylose, two-stage process showed great promises with >80 % glucose and >70 % xylose recovery. In addition, the method greatly improved ethanol fermentation with yields up to 0.145 g/g Miscanthus, due to significantly reduced formation of inhibitory by-products such as weak acids, furans, and phenols. Supplementing biomimetic acids would further increase glucose yield by up to 15 % and xylose yield by 25 %.