Structural Identification of a Non-Glycosylated Variant at Ser126 for O-Glycosylation Site from EPO BRP, Human Recombinant Erythropoietin by LC/MS Analysis.

A variant peak was detected in the analysis of RP-HPLC of rHu-EPO, which has about 7% relative content. Fractions of the main and the variant peaks were pooled separately and further analyzed to identify the molecular structure of the variant peak. Total mass analysis for each peak fraction using ESI-TOF MS shows differences in molecular mass. The fraction of the main peak tends to result in higher molecular masses than the fraction of the variant. The detected masses for the variant are about 600-1000 Da smaller than those for the main peak. Peptide mapping analysis for each peak fraction using Asp-N and Glu-C shows differences in O-glycopeptide profiles at Ser126. The O-glycopeptides were not detected in the fraction of the variant. It is concluded that the variant peak is non-O-glycosylated rHu-EPO and the main peak is fully O-glycosylated rHu-EPO at Ser126.

Characterization of a recombinant L-rhamnose isomerase from Dictyoglomus turgidum and its application for L-rhamnulose production.

A putative recombinant enzyme from Dictyoglomus turgidum was characterized and immobilized on Duolite A568 beads. The native enzyme was a 46 kDa tetramer. Its activity was highest for L-rhamnose, indicating that it is an L-rhamnose isomerase. The maximum activities of both the free and immobilized enzymes for L-rhamnose isomerization were at pH 8.0 and 75 °C in the presence of Mn(2+). Under these conditions, the half-lives of the free and immobilized enzymes were 28 and 112 h, respectively. In a packed-bed bioreactor, the immobilized enzyme produced an average of 130 g L-rhamnulose l(-1) from 300 g L-rhamnose l(-1) after 240 h at pH 8.0, 70 °C, and 0.6 h(-1), with a productivity of 78 g l(-1) h(-1) and a conversion yield of 43 %. To the best of our knowledge, this is the first report describing the enzymatic production of L-rhamnulose.

Molecular characterization of a thermostable L-fucose isomerase from Dictyoglomus turgidum that isomerizes L-fucose and D-arabinose.

A recombinant thermostable l-fucose isomerase from Dictyoglomus turgidum was purified with a specific activity of 93 U/mg by heat treatment and His-trap affinity chromatography. The native enzyme existed as a 410 kDa hexamer. The maximum activity for l-fucose isomerization was observed at pH 7.0 and 80 °C with a half-life of 5 h in the presence of 1 mM Mn(2+) that was present one molecular per monomer. The isomerization activity of the enzyme with aldose substrates was highest for l-fucose (with a k(cat) of 15,500 min(-1) and a K(m) of 72 mM), followed by d-arabinose, d-altrose, and l-galactose. The 15 putative active-site residues within 5 Å of the substrate l-fucose in the homology model were individually replaced with other amino acids. The analysis of metal-binding capacities of these alanine-substituted variants revealed that Glu349, Asp373, and His539 were metal-binding residues, and His539 was the most influential residue for metal binding. The activities of all variants at 349 and 373 positions except for a dramatically decreased k(cat) of D373A were completely abolished, suggesting that Glu349 and Asp373 were catalytic residues. Alanine substitutions at Val131, Met197, Ile199, Gln314, Ser405, Tyr451, and Asn538 resulted in substantial increases in K(m), suggesting that these amino acids are substrate-binding residues. Alanine substitutions at Arg30, Trp102, Asn404, Phe452, and Trp510 resulted in decreases in k(cat), but had little effect on K(m).

Production of L-ribose from L-ribulose by a triple-site variant of mannose-6-phosphate isomerase from Geobacillus thermodenitrificans.

A triple-site variant (W17Q N90A L129F) of mannose-6-phosphate isomerase from Geobacillus thermodenitrificans was obtained by combining variants with residue substitutions at different positions after random and site-directed mutagenesis. The specific activity and catalytic efficiency (k(cat)/K(m)) for L-ribulose isomerization of this variant were 3.1- and 7.1-fold higher, respectively, than those of the wild-type enzyme at pH 7.0 and 70°C in the presence of 1 mM Co(2+). The triple-site variant produced 213 g/liter l-ribose from 300 g/liter L-ribulose for 60 min, with a volumetric productivity of 213 g liter(-1) h(-1), which was 4.5-fold higher than that of the wild-type enzyme. The k(cat)/K(m) and productivity of the triple-site variant were approximately 2-fold higher than those of the Thermus thermophilus R142N variant of mannose-6-phosphate isomerase, which exhibited the highest values previously reported.

l-Arabinose production from sugar beet arabinan by immobilized endo- and exo-arabinanases from Caldicellulosiruptor saccharolyticus in a packed-bed reactor.

The immobilized endo- and exo-arabinanases from Caldicellulosiruptor saccharolyticus produced continuously an average of 16.5 gl(-1)l-arabinose from 20 gl(-1) sugar beet arabinan at pH 5.0 and 75°C for 216 h, with a productivity of 9.9 gl(-1)h(-1) and a conversion yield of 83%.

Molecular characterization of a novel thermostable mannose-6-phosphate isomerase from Thermus thermophilus.

Mannose-6-phosphate isomerase catalyzes the interconversion of mannose-6-phosphate and fructose-6-phosphate. The gene encoding a putative mannose-6-phosphate isomerase from Thermus thermophilus was cloned and expressed in Escherichia coli. The native enzyme was a 29 kDa monomer with activity maxima for mannose 6-phosphate at pH 7.0 and 80 °C in the presence of 0.5 mM Zn(2+) that was present at one molecule per monomer. The half-lives of the enzyme at 65, 70, 75, 80, and 85 °C were 13, 6.5, 3.7, 1.8, and 0.2 h, respectively. The 15 putative active-site residues within 4.5 Å of the substrate mannose 6-phosphate in the homology model were individually replaced with other amino acids. The sequence alignments, activities, and kinetic analyses of the wild-type and mutant enzymes with amino acid changes at His50, Glu67, His122, and Glu132 as well as homology modeling suggested that these four residues are metal-binding residues and may be indirectly involved in catalysis. In the model, Arg11, Lys37, Gln48, Lys65 and Arg142 were located within 3 Å of the bound mannose 6-phosphate. Alanine substitutions of Gln48 as well as Arg142 resulted in increase of K(m) and dramatic decrease of k(cat), and alanine substitutions of Arg11, Lys37, and Lys65 affected enzyme activity. These results suggest that these 5 residues are substrate-binding residues. Although Trp13 was located more than 3 Å from the substrate and may not interact directly with substrate or metal, the ring of Trp13 was essential for enzyme activity.

Microbial metabolism and biotechnological production of D-allose.

D-allose has attracted a great deal of attention in recent years due to its many pharmaceutical activities, which include anti-cancer, anti-tumor, anti-inflammatory, anti-oxidative, anti-hypertensive, cryoprotective, and immunosuppressant activities. D-allose has been produced from D-psicose using D-allose-producing enzymes, including L-rhamnose isomerase, ribose-5-phosphate isomerase, and galactose-6-phosphate isomerase. In this article, the properties, applications, and metabolism of D-allose are described, and the biochemical properties of D-allose-producing enzymes and their D-allose production are reviewed and compared. Moreover, several methods for effective D-allose production are suggested herein.

Synergistic production of L-arabinose from arabinan by the combined use of thermostable endo- and exo-arabinanases from Caldicellulosiruptor saccharolyticus.

The optimum conditions for the production of L-arabinose from debranched arabinan were determined to be pH 6.5, 75°C, 20 g l(-1) debranched arabinan, 42 Um l(-1) endo-1,5-α-L-arabinanase, and 14 U ml(-1) α-L-arabinofuranosidase from Caldicellulosiruptor saccharolyticus and the conditions for sugar beet arabinan were pH 6.0, 75°C, 20 g l(-1) sugar beet arabinan, 3 U ml(-1) endo-1,5-α-L-arabinanase, and 24 U ml(-1) α-L-arabinofuranosidase. Under the optimum conditions, 16 g l(-1)l-arabinose was obtained from 20 g l(-1) debranched arabinan or sugar beet arabinan after 120 min, with a hydrolysis yield of 80% and a productivity of 8 g l(-1)h(-1). This is the first reported trial for the production of L-arabinose from the hemicellulose arabinan by the combined use of endo- and exo-arabinanases.

Characterization of a recombinant thermostable L: -rhamnose isomerase from Thermotoga maritima ATCC 43589 and its application in the production of L-lyxose and L-mannose.

A putative L-rhamnose isomerase (RhaA) from Thermotoga maritima was purified with a specific activity of 55 U/mg by His-Trap affinity chromatography. The native enzyme was estimated as a 46 kDa tetramer by gel filtration chromatography. The half-lives of the enzyme at 75, 80, 85, 90 and 95°C were 773, 347, 187, 118, and 65 h, respectively, indicating that it is the most thermostable of all RhaAs. Under the optimum conditions of pH 8.0, 85°C, and 1 mM Mn(2+), RhaA with 100 U enzyme/ml converted 500 L-xylulose/l to 225 g/l L-lyxose after 3 h, and converted 500 L-fructose/l to 175 g/l L-mannose after 5 h.