Survival persistence of the 3 common Salmonella enterica serotypes isolated from broilers' in different matrices.

Broiler meat is the predominant source of Salmonella as a foodborne pathogen. Several control strategies have focused on the reduction of Salmonella spp. levels at different production stages. However, the persistence of Salmonella between consecutive flocks is still of great concern. This study was designed to understand the cause of reinfection in broiler flocks due to survival of Salmonella in feeding lines of related matrices. Salmonella (S.) Enteritidis, S. Infantis, and S. Typhimurium isolated from broiler farms in North-West Germany were used. Four types of matrices (phosphate buffer saline (PBS), dietary plant fat, fat with feed mixture, and feed) were applied to evaluate Salmonella survival (with the initial dose about 8.0 log10 CFU/mL) during a simulation of 4 production cycles. To evaluate the growth and survival status of Salmonella ISO 6579-1:2017 were performed (quantitatively by plate count method (PCM) and most probable number method (MPN)) and qualitatively) at 5 defined time points (-7, 0, 4, 7, and 35 d). In all matrices and for the 3 serovars, the Salmonella count decreased at the end of the fourth cycle in comparison to the beginning of the experimental infection, and was still cultivated except for fat matrix. The PBS matrices showed the highest survival level of Salmonella and did not decline drastically by the end of the fourth cycle (5.93 ± 0.00, 5.87 ± 0.02, 5.73 ± 0.05 log10 CFU/mL, respectively). However, the fat matrices showed the lowest survival level for the 3 isolates at d 35 since the first cycle (0 log10 CFU/mL using PCM). Regarding the fat-feed mixture, and feed matrices, there was a fluctuation in the survival rate of Salmonella (all serovars) within each cycle. For the qualitative method, the 3 serovars persisted in all matrices until the end of the fourth cycle except for fat matrices. The present study highlights the ability of Salmonella to survive for a long time in different temperatures and matrices despite efficient cleaning and disinfection processes in the feeding lines, which may influence reinfection with Salmonella in poultry houses.

Effect of replacing whole wheat with broken rye as a sustainable grain in diets of fattening turkeys on growth performance, litter quality, and foot pad health.

Introduction: Rye is one of the most important cereal crops in Central Europe, thus attempts have been made to include it in the diets of birds to reduce production costs, since the cost of feed accounts for as much as 50 %-70 % thereof. Nevertheless, the use of rye has been limited to date, particularly in turkeys. This study aimed to test the effects of rye inclusion up to 10 % on growth, excreta, and/or litter dry matter, and foot pad health. Methods: Four trials were performed with a total of 4,322, 4,307, 4,256, and 4,280 female turkeys (BUT BIG 6, Aviagen) for trials 1, 2, 3, and 4, respectively. All birds were fed commercial starter diets for the dietary phases 1 and 2 (up to d 35 of life). Thereafter, at the start of the study, the control group received commercial supplementary feed with 5 % or 10 % wheat until the end of the fattening period. The experimental group was offered supplementary feed to which instead of wheat increasing levels of rye were added stepwise from 5 % to 10 %. Results: Using supplementary feed with rye showed no significant differences in the final body weight between the control and experimental groups (10.9 vs. 10.8 kg). The dry matter content of fresh excreta for turkeys during the experimental period did not show significant differences between both groups, except at weeks 10 and 14 of life. The feed type (either control diet or experimental diet) did not significantly affect litter dry matter content between the groups throughout the experimental period. No significant differences were noted in food pad dermatitis scoring between both groups throughout the experimental period, except at weeks 11 and 16 of life. Overall, this study showed that including proportions of rye up to 10% could replace conventional ingredients and may increase sustainability in poultry production regardless of the addition of supplementary feed.

Effect of Different Fiber Sources as Additives to Wet Food for Beagle Dogs on Diet Acceptance, Digestibility, and Fecal Quality.

In order to enhance the health and welfare of obese dogs and to facilitate the required loss of body weight, commercial diets are produced with fibrous ingredients. Cellulose is a common dietary fiber used mainly in powdered form. However, other processing forms and fibers are available as fibrous additives. This work aimed to test the effects of different fiber sources on apparent total tract digestibility and fecal quality in dogs. Four diets were fed to eight dogs (experimental design: 4 × 4 Latin square) for a 14-day period each. In addition to a basal diet (CO), three experimental diets varying in fiber sources were used: powdered cellulose (CE), granulated cellulose (GC), and lignocellulose (LC). Dogs fed the CO had lower crude fiber digestibility than those fed the other experimental diets (p < 0.0033). Dogs fed diets supplemented with fiber sources had lower gross energy digestibility (range: 76.2-77.3%) compared with those fed the CO (84.4%). In all groups, the fecal score (consistency and shape) ranged within the optimal values; solely wet fecal output was increased for the fiber groups compared with those on the CO. This study demonstrated that various sources of fiber such as GC and LC can be used as alternatives to CE without restrictions.

In vitro evaluation of sodium butyrate on the growth of three Salmonella serovars derived from pigs at a mild acidic pH value.

Foodborne zoonotic diseases can be transferred into the food chain at the stage of livestock farming. As an emerging public health challenge, practicable reduction measures in porcine health management for Salmonella are constantly being investigated. This in vitro study aimed to determine the influence of six different sodium butyrate (SB) concentrations (0, 5, 10, 20, 40, and 80 mM) on the growth of three different Salmonella enterica serovars at a constant pH value of 6.0, corresponding to conditions in the pig's hindgut. S. Derby and S. Typhimurium, isolated from a pig farm, and S. Typhimurium DSM 19587, which served as control, were used. Broth microdilution assay was applied to record Salmonella growth in the presence of different SB-concentrations over six different incubation periods (0, 1, 2, 4, 6, and 24 h). Results were quantified in the log colony-forming units (log10 CFU/mL). For 1 h incubation, the addition of SB showed no significant differences in the range of initial Salmonella dose of about 5.7 log10 between concentrations (0-80 mM, 5.26 ± 0.10-5.60 ± 0.07 log10, p > 0.05). After 6 h, for SB addition, the range of Salmonella counts was significantly lower compared to no addition of SB (5-80 mM, p < 0.05), 6.78 ± 0.84-7.90 ± 0.10 log10 for 5 mM, and 7.53 ± 0.04-8.71 ± 0.22 log10 for 0 mM. Moreover, for SB concentrations of 40 and 80 mM, no difference in the range of Salmonella counts over 6 h was obtained (5.23 ± 0.11-5.38 ± 0.05 log10, p > 0.05), and minor Salmonella growth was recorded at the earliest after 24 h incubation. Growth rates for varying SB concentrations and incubation times were confirmed in a similar manner for the three serovars. Obtained results suggest that increasing SB concentrations suppress Salmonella growth for concentrations of 5-20 mM over a 6 h incubation period and for 40 and 80 mM over a 24 h incubation period. When transferring these in vitro findings to the porcine organism, it may be assumed that Salmonella reduction can be achieved by increased butyrate content in the chyme of the large intestine.

Epidemiological Study on Salmonella Prevalence in Sow Herds Using Direct and Indirect Detection Methods.

In piglet production, the beginning of pork production, Salmonella prevalence requires greater attention as having an impact on the subsequent production steps. The aim of this study was to investigate Salmonella prevalence in three sow herds with attached piglet rearing units. Salmonella prevalence was investigated either directly by boot swabs and feces or indirectly by serum samples taken during gilt integration, the peripartal period, and piglet rearing. Boot swabs and feces were analyzed by real-time PCR and subsequent microbiology. Results indicated that high biosecurity measures in sow husbandry do not necessarily result in a low Salmonella prevalence. Furthermore, the sow herds' Salmonella prevalence should not be used to infer the situation in the associated piglet rearing. The proportion of positive boot swabs was 10.5, 3.6, and 21.3% for sows (gilts and peripartal) with an inverse situation in piglet rearing with 50.0, 63.3, and 5.8% positive swabs for farms A, B, and C, respectively. Boot swabs are suitable as a direct sampling method to gain an overview of Salmonella prevalence in both sows and piglets. Indirect serum antibody testing can be useful, although it should be evaluated considering age-dependent levels of antibody titres.

Influence of Using Perforated Plastic Flooring Beneath the Waterline on Growth Performance, Litter Quality, and Footpad Health of Broiler Chickens: A Field Study.

The aim of this study was to evaluate the effect of slatted flooring beneath waterlines in broiler barns on litter quality and, subsequently, footpad health. The hypothesis tested was that installing slatted flooring underneath waterlines helps to improve litter quality and thus reduces footpad diseases, enhancing animal welfare as a result. Five experimental runs with two groups were conducted. Each run was defined as one fattening period of 32 days and consisted of 15,000 broiler Ross 308 of both sexes. Every barn was divided into three areas (drinkers, feeders, and comfort area) for weekly sampling. No influence on growth performance was noted. The slatted flooring influenced the litter quality by preventing the litter in the experimental group (EG = 690 ± 167 g/kg DM) from becoming moisture until day 14 of the fattening period compared to the control group (CON = 636 ± 198 g/kg DM). The footpad health was also influenced by using slatted flooring, with lower camera-based footpad scores in the EG (8.80) compared to CON (22.0) at the slaughterhouse (p = 0.0258). Installing slatted flooring beneath the waterline reduced the moisture of the litter compared to the control barn in the first two weeks of age and showed a positive effect on the footpad health of the broilers at the end of fattening, which indicates an improvement in animal welfare.

Nutrient Composition and In Vitro Fermentation Characteristics of Sorghum Depending on Variety and Year of Cultivation in Northern Italy.

Sorghum is the fifth most produced cereal in the world and is a source of nutrients and bioactive compounds for the human diet. This study examined the nutrient composition and in vitro fermentation characteristics of sorghum varieties grown in 2020 and 2021 (n = 15 × 3 × 2) across three locations in the north of Italy (Bologna, Padova, and Rovigo). In 2020, the crude protein content of sorghum was significantly higher in the region of Padova than in the region of Bologna (124 vs. 95.5 g/kg dry matter). However, crude fat, sugar, and gross energy levels showed no significant differences among the different regions in 2020. In 2021, the levels of crude protein, crude fat, sugar, and gross energy had no significant differences among different sorghum varieties harvested from the three regions. Significant differences in some mineral contents were found among the samples particularly in manganese and zinc in both years. After 24 h of fermentation of two different sorghum hybrids (hybrids 1 and 2 of both years harvested in Bologna, n = 4 × 2 × 2), the pH value was significantly higher in hybrid 1 of year 2021 (3.98) than in the other fermented samples (range: 3.71-3.88). The sorghum harvested from the region of Bologna had a significantly higher viscosity value (1.22 mPa·s) compared to other regions (1.8-1.10 mPa·s) in 2021 only. The results show that the nutritional value and viscosity of different sorghum varieties could differ depending on the location and year of cultivation.

Effects of Early Nutrition of Hatched Chicks on Welfare and Growth Performance: A Pilot Study.

This study aimed to investigate the possibility of rearing newly hatched chicks with immediate access to feed and water in the same hatching unit one week prior to transferring them to the conventional broiler house with special regards to foot pad health and growth performance. Two trials were performed with a total of 6900/6850 (trials 1/2) broiler chickens (ROSS 308). A total of 3318/3391 chicks (trials 1/2) were transported from the hatchery (duration of about 3 h) and reared in a conventional broiler house (control group: delayed nutrition on-hatchery hatched). The control group did not receive any form of nutrition until they were taken to conventional broiler housing. Additionally, a total of 3582/3459 (trials 1/2) embryonated eggs (d 18) were obtained from the same parent flock of the same commercial hatchery and taken to the farm facility. After on-farm hatch, the chicks had immediate access to water and feed (experimental group: early nutrition on-farm hatched). After d 6/7 of life, the on-farm hatched chicks (trials 1/2) were transferred to the broiler house on the same facility. The delayed nutrition on-hatchery hatched groups displayed a significantly lower dry matter content in the litter compared to the early nutrition on-farm hatched groups (two-factorial analysis) at d 6/7 and d 14 of life. However, thereafter, no significant differences were noted. Based upon two-factorial analysis, the early nutrition on-farm hatched groups revealed lower foot pad lesions from d 14 of life onwards and showed a higher body weight (BW) throughout the rearing period compared to the delayed nutrition on-hatchery hatched groups (p < 0.05). Overall, early nutrition on-farm hatched chickens is of critical importance together with using new litter at d 7 to maintain healthy foot pads as well as to enhance nutrient utilization and optimize the growth performance.