Effect of temperature and bleaching agent on bleaching of liquid Cheddar whey.

The use of whey protein as an ingredient in foods and beverages is increasing, and thus demand for colorless and mild-tasting whey protein is rising. Bleaching is commonly applied to fluid colored cheese whey to decrease color, and different temperatures and bleach concentrations are used. The objectives of this study were to compare the effects of hot and cold bleaching, the point of bleaching (before or after fat separation), and bleaching agent on bleaching efficacy and volatile components of liquid colored and uncolored Cheddar whey. First, Cheddar whey was manufactured, pasteurized, fat-separated, and subjected to one of a number of hot (68°C) or cold (4°C) bleaching applications [hydrogen peroxide (HP) 50 to 500 mg/kg; benzoyl peroxide (BP) 25 to 100 mg/kg] followed by measurement of residual norbixin and color by reflectance. Bleaching agent concentrations were then selected for the second trial. Liquid colored Cheddar whey was manufactured in triplicate and pasteurized. Part of the whey was collected (no separation, NSE) and the rest was subjected to fat separation (FSE). The NSE and FSE wheys were then subdivided and bleaching treatments (BP 50 or 100 mg/kg and HP 250 or 500 mg/kg) at 68°C for 30 min or 4°C for 16 h were applied. Control NSE and FSE with no added bleach were also subjected to each time-temperature combination. Volatile compounds from wheys were evaluated by gas chromatography-mass spectrometry, and norbixin (annatto) was extracted and quantified to compare bleaching efficacy. Proximate analysis, including total solids, protein, and fat contents, was also conducted. Liquid whey subjected to hot bleaching at both concentrations of HP or at 100mg/kg BP had greater lipid oxidation products (aldehydes) compared with unbleached wheys, 50mg/kg BP hot-bleached whey, or cold-bleached wheys. No effect was detected between NSE and FSE liquid Cheddar whey on the relative abundance of volatile lipid oxidation products. Wheys bleached with BP had lower norbixin content compared with wheys bleached with HP. Bleaching efficacy of HP was decreased at 4°C compared with 68°C, whereas that of BP was not affected by temperature. These results suggest that fat separation of liquid Cheddar whey has no effect on bleaching efficacy or lipid oxidation and that hot bleaching may result in increased lipid oxidation in fluid whey.

Influence of bleaching on flavor of 34% whey protein concentrate and residual benzoic acid concentration in dried whey proteins.

Previous studies have shown that bleaching negatively affects the flavor of 70% whey protein concentrate (WPC70), but bleaching effects on lower-protein products have not been established. Benzoyl peroxide (BP), a whey bleaching agent, degrades to benzoic acid (BA) and may elevate BA concentrations in dried whey products. No legal limit exists in the United States for BP use in whey, but international concerns exist. The objectives of this study were to determine the effect of hydrogen peroxide (HP) or BP bleaching on the flavor of 34% WPC (WPC34) and to evaluate residual BA in commercial and experimental WPC bleached with and without BP. Cheddar whey was manufactured in duplicate. Pasteurized fat-separated whey was subjected to hot bleaching with either HP at 500 mg/kg, BP at 50 or 100 mg/kg, or no bleach. Whey was ultrafiltered and spray dried into WPC34. Color [L*(lightness), a* (red-green), and b* (yellow-blue)] measurements and norbixin extractions were conducted to compare bleaching efficacy. Descriptive sensory and instrumental volatile analyses were used to evaluate bleaching effects on flavor. Benzoic acid was extracted from experimental and commercial WPC34 and 80% WPC (WPC80) and quantified by HPLC. The b* value and norbixin concentration of BP-bleached WPC34 were lower than HP-bleached and control WPC34. Hydrogen peroxide-bleached WPC34 displayed higher cardboard flavor and had higher volatile lipid oxidation products than BP-bleached or control WPC34. Benzoyl peroxide-bleached WPC34 had higher BA concentrations than unbleached and HP-bleached WPC34 and BA concentrations were also higher in BP-bleached WPC80 compared with unbleached and HP-bleached WPC80, with smaller differences than those observed in WPC34. Benzoic acid extraction from permeate showed that WPC80 permeate contained more BA than did WPC34 permeate. Benzoyl peroxide is more effective in color removal of whey and results in fewer flavor side effects compared with HP and residual BA is decreased by ultrafiltration and diafiltration.

Comparison of the flavor chemistry and flavor stability of mozzarella and cheddar wheys.

The flavor and flavor stability of fresh and stored liquid Cheddar and Mozzarella wheys were compared. Pasteurized, fat separated, and unseparated Cheddar and Mozzarella wheys were manufactured in triplicate and evaluated immediately or stored for 72 h at 3 °C. Flavor profiles were documented by descriptive sensory analysis, and volatile components were extracted and characterized by solvent extraction followed by gas chromatography-mass spectrometry and gas chromatography-olfactometry with aroma extract dilution analysis. Cheddar and Mozzarella wheys were distinct by sensory and volatile analysis (P < 0.05). Fresh Cheddar whey had higher intensities of buttery and sweet aromatic flavors and higher cardboard flavor intensities following storage compared to Mozzarella whey. High aroma impact compounds (FD(log3) > 8) in fresh Cheddar whey included diacetyl, 1-octen-3-one, 2-phenethanol, butyric acid, and (E)-2-nonenal, while those in Mozzarella whey included diacetyl, octanal, (E)-2-nonenal, and 2-phenethanol. Fresh Cheddar whey had higher concentrations of diacetyl, 2/3-methyl butanal, (E)-2-nonenal, 2-phenethanol, and 1-octen-3-one compared to fresh Mozzarella whey. Lipid oxidation products increased in both whey types during storage but increases were more pronounced in Cheddar whey than Mozzarella whey. Increases in lipid oxidation products were also more pronounced in wheys without fat separation compared to those with fat separation. Results suggest that similar compounds in different concentrations comprise the flavor of these 2 whey sources and that steps should be taken to minimize lipid oxidation during fluid whey processing. Practical Application: Cheddar and Mozzarella wheys are the primary sources of dried whey ingredients in the United States. An enhanced understanding of the flavor of these 2 raw product streams will enable manufacturers to identify methods to optimize quality.