Addressing astringency of grape seed extract by covalent conjugation with lupin protein.

Astringency of phenolic-rich foods is a key tactile perception responsible for acceptability/rejection of plant extracts as ingredients in formulations. Covalent conjugation of phenolic extracts with plant proteins might be a promising strategy to control astringency, but suffers from a lack of mechanistic understanding from the lubrication point of view. To shed light on this, this ex vivo study evaluated the effect of conjugation of a phenolic grape seed extract (GSE) with legume protein (lupin, LP) on tribological and surface adsorption performance of GSE in the absence and presence of human saliva (ex vivo). Tribological results confirmed GSE had an inferior lubrication capacity as compared to LP. The lubrication performance of LP-GSE dispersions was comparable to their corresponding LP dispersion (p > 0.05) when covalently conjugated with LP (LP-GSE) with increasing LP:GSE ratio up to 1:0.04 w/w and at a specific degree of conjugation (DC: 2%). Tribological and surface adsorption measurements confirmed the tendency of GSE to interact with human saliva (ex vivo, n = 17 subjects), impairing the lubricity of salivary films. The covalent bonding of LP to GSE hindered GSE's interaction with human saliva, implying the potential influence of covalent conjugation on attenuating astringency. LP appeared to compete with human saliva for surface adsorption and governed the lubrication behaviour in LP-GSE dispersions. Findings from this study provide valuable knowledge to guide the rational design of sustainable, functional foods using conjugation of phenolics with plant proteins to incorporate larger proportions of health-promoting phenolics while controlling astringency, which needs validation by sensory trials.

Unveiling the formation capacity of multicomponent oleogels: Performance of lecithin interacting with monostearate derivatives.

Oleogels have been explored as fat substitutes due to their healthier composition compared to trans and saturated fats, also presenting interesting technological perspectives. The aim of this study was to investigate the compositional perspective of multicomponent oleogels. Structuring ability of lecithin (LEC) (20 or 90 wt% of phosphatidylcholine - PC) combined with glycerol monostearate (GMS), sorbitan monostearate (SMS) or sucrose monostearate (SAC) in sunflower oil was evaluated from oleogels properties. The thermal and rheological properties, microstructure and stability of the oleogels were affected by the difference in the chemical composition of LEC and the ratio between LEC and different surfactants. Interestingly, low-phosphatidylcholine LEC (L20) performed better, although systems formed with reduced amounts of LEC tended to be softer (LEC-GMS) and present high oil holding capacity (LEC-SMS). The mixtures of LEC and monostearate-based surfactants showed different behaviors, depending on the surfactant polar head. In LEC-GMS systems, LEC hindered the self-assembly of GMS in sunflower oil, compromising mechanical properties and increasing oil release. When combined with SMS, LEC acted as a crystal habit modifier of SMS, forming a more homogeneous microstructure and producing stronger oleogels with greater oil binding capacity. However, above the threshold concentration, LEC prevented SMS self-assembly, resulting in a weaker gel. A positive interaction was found in LEC-SAC formulations in specific ratios, since SAC cannot act as a single oleogelator. Results show the impact of solubility balance played by LEC and fatty-acid derivatives surfactant when combined and used as oleogelators. This knowledge can contribute to a rational perspective in the preparation and modulation of the properties of edible oleogels.

Glyceryl monostearate-based oleogels as a new fat substitute in meat emulsion.

Bologna sausages were produced with 25, 50, 75 and 100% of their pork fat content replaced by monoglyceride based-oleogels prepared from conventional or high oleic sunflower oils. Physicochemical, technological, and sensory properties of Bologna sausages were evaluated. Emulsion stability was little affected by fat replacement. All treatments batters exhibited characteristic rheological properties of gels (G' > G″). Overall, the addition of oleogel as a fat substitute made the sausages lighter and a small increase in hardness was observed in the sausages with total fat replacement by oleogels. The sliceability was affected by the reformulation and a higher number of slices were obtained in samples with oleogels in relation to the control. These results were associated to the product structure that became more compact as the amount of pork fat was reduced. However, all samples showed good acceptance by the consumers and no significant difference was observed between treatments. The results showed that monostearate-based oleogel can be a potential fat replacer with higher amount of unsaturated fatty acids to be used in meat products, but retaining the desired characteristics of the traditional products.

Modulating properties of polysaccharides nanocomplexes from enzymatic hydrolysis of chitosan.

Synthesis of nanocomplexes is a simple and low-cost technique for the production of encapsulation systems aiming industrial applications, based on the interaction of at least two oppositely charged molecules. Gellan gum (anionic) is a water-soluble biopolymer resistant to stomach pH conditions, therefore an interesting alternative as an encapsulating matrix. Chitosan (cationic) is also widely used due to its biocompatibility and mucoadhesive properties, although its low water solubility is an important step to be overcome for the production of the complexes. To improve this property, many techniques have been employed, but most of them use unsustainable techniques and chemical agents. The enzymatic hydrolysis of chitosan using proteases emerges as an alternative to these drawbacks and, therefore, this study aimed to evaluate the electrostatic nanocomplexation of native (C) or hydrolyzed (HC) chitosan (by porcine pepsin protease) with gellan gum (G). Polysaccharides and nanocomplexes formed with different G:C or G:HC ratio were evaluated by zeta potential measurements, particle size distribution, X-ray diffraction (XRD), Fourier Transform Infrared Spectroscopy (FTIR), Scanning Transmission Electron Microscopy (STEM), intrinsic viscosity and turbidity analyses. Chitosan hydrolysis allowed the formation of a smaller (445.3 nm in pH 4.5) and more soluble structure (3 kDa), which positively influenced the formation of the complexes. The ratios G:HC of 7:3 and 8:2 formed complexes with lower values of zeta potential (13.9 mV and -5.0 mV, respectively), particle size (635.8 nm and 533.6 nm, respectively) and polydispersity (0.28 and 0.23) compared to complexes formed with native chitosan. Overall, our results show that enzymatic hydrolysis of chitosan favored the formation of electrostatic complexes with reduced size and low polydispersity, which can be used as efficient encapsulating matrices for improved targeted delivery and controlled release of bioactive compounds.