Sprouts and Needles of Norway Spruce (Picea abies (L.) Karst.) as Nordic Specialty-Consumer Acceptance, Stability of Nutrients, and Bioactivities during Storage.

Developing shoots, i.e., sprouts, and older needles of Norway spruce (Picea abies (L.) Karst.) have traditionally been used for medicinal purposes due to the high content of vitamins and antioxidants. Currently, sprouts are available as, for example, superfood and supplements. However, end-product quality and nutritive value may decline in the value-chain from raw material sourcing to processing and storage. We studied (1) impacts of different drying and extraction methods on nutritional composition and antioxidative properties of sprouts and needles, (2) differences between sprouts and needles in nutritional composition and microbiological quality, and (3) production scale quality of the sprouts. Additionally, (4) sprout powder was applied in products (ice-cream and sorbet) and consumer acceptance was evaluated. According to our results, older needles have higher content of dry matter, energy, and calcium, but lower microbial quality than sprouts. Sprouts showed a higher concentration of vitamin C, magnesium, potassium, and phosphorus than older needles. Freeze-drying was the best drying method preserving the quality of both sprouts and needles, e.g., vitamin C content. The antioxidative activity of the sprout extracts were lower than that of needles. Ethanol-water extraction resulted in a higher content of active compounds in the extract than water extraction. Sensory evaluation of food products revealed that on average, 76% of consumers considered sprout-containing products very good or good, and a creamy product was preferred over a water-based sorbet.

Bilberry and Sea Buckthorn Leaves and Their Subcritical Water Extracts Prevent Lipid Oxidation in Meat Products.

The aim of this study was to find new sustainable, Nordic natural antioxidant sources, develop subcritical water extraction (SWE) process for recovering the antioxidant compounds from the most potential raw materials, and to test their antioxidative effects in meat products. The antioxidant capacities of water and 50% ethanol (aq) extracts of 13 berry, grain, and horticultural plant materials as well as hexane/ethanol extracted stilbene fractions from pine heartwood and spruce inner bark were measured in hydrophilic and lipophilic systems. Tree, bilberry leaf (BL), and sea buckthorn leaf (SBL) extracts showed the highest antioxidant capacities. BL and SBL were selected for the development of SWE. The optimal conditions for recovering maximal antioxidative capacities were 110 °C/1 min for SBL and 120 °C/1 min for BL. Dried BL and SBL and the respective optimized subcritical water extracts were applied in chicken slices and pork sausage, and their ability to prevent lipid oxidation was evaluated during 8 and 20 days storage, respectively, at 6 °C. All tested plant ingredients effectively prevented lipid oxidation in the products compared to the control samples. Sensory acceptance of the plant ingredients was good, especially in the chicken product. To our knowledge, this is the first study to assess the antioxidant effects of SW extracted berry leaves in meat products.

The plant-based by-product diets for the mass-rearing of Acheta domesticus and Gryllus bimaculatus.

Edible insect rearing could provide one alternative for protein production by having a smaller environmental impact than traditional livestock farming due to insects' ability to convert organic side streams. Currently, the insect rearing industry utilizes soybeans as a major source of protein in the feeds. Protein-rich by-products of food industry could be used to replace them in insect feeds, but it is not known if they also meet the insects' nutritional requirements. Our study evaluated the growth performance of two widely used edible cricket species, Acheta domesticus and Gryllus bimaculatus (Orthoptera: Gryllidae), on 18 experimental diets. The experimental diets included commercial chicken feeds and cricket diets, where soybean was partly and completely replaced with by-products from food industry: potato protein, barley mash, barley feed, compressed leftover of turnip rape and mix of broad bean and pea on three levels of protein. We found that the high- and medium-protein turnip rape and barley mash diets produced the highest yield and an increase in all performance variables. Overall, the high- and medium-protein diets produced the highest yield, growth and fastest development. Our results showed that by-products of food industry could be utilized as a part of the cricket feeds and thus advance the goals of circular economy.

Microbiological quality of fresh-cut carrots and process waters.

Fresh vegetables may be contaminated by pathogens in different ways after harvest. Pathogenic microorganisms associated with fresh vegetables can cause severe outbreaks of foodborne disease. We discuss here the results of microbiological analysis of carrot samples, as well as of washing, processing, and wastewater samples. Washed, unpeeled carrots generally contained the highest aerobic plate counts (mean, 5.5 log CFU/g). Escherichia coli was not detected in any carrot or water sample examined. The amounts of coliform bacteria and enterobacteria were higher in carrot samples taken from the first steps in the processing line than in samples taken in later phases of the process. Yersinia pseudotuberculosis was not detected in any of the samples by the cultivation method; however, nonpathogenic Yersinia enterocolitica was detected from most carrot samples and almost all washing water and wastewater samples but only from 2 of 10 process water samples. Using a more-sensitive real-time PCR method, pathogenic Y. enterocolitica was found from several carrot samples, and when these positive samples were cultivated, no pathogenic Y. enterocolitica strains were detected.