RESUMEN
Table salt fortified with KIO3 is commonly used to prevent iodine deficiency disorders. However, there is a lack of reliable data about the stability of KIO3 during food processing. In this study several meat and fish products were prepared with iodized salt and the iodine stability was determined through the whole production process. Applied processes included heating, fermenting, freezing, hot smoking, ripening by enzymes and storing. In all products an increase in iodine content was observed after addition of iodized salt. The iodine content remained constant during most of the applied processes. The only iodine loss was observed in ham after heating and can be explained by loss of iodine containing brine. During subsequent storage no iodine loss was observed in any of the products. The use of KIO3 fortified salt in the investigated products might therefore be beneficial for the iodine supply.
Asunto(s)
Yodo , Cloruro de Sodio Dietético , Animales , Productos Pesqueros , Yoduros , CarneRESUMEN
In single particle inductively coupled plasma mass spectrometry (spICP-MS), the transport efficiency is fundamental for the correct determination of both particle number concentration and size. In the present study, transport efficiency was systematically determined on three different days with six carefully characterised gold nanoparticle (AuNP) suspensions and in seven European and US expert laboratories using different ICP-MS instruments and spICP-MS software. Both particle size-(TES)-and particle frequency-(TEF)-methods were applied. The resulting transport efficiencies did not deviate much under ideal conditions. The TEF method however systematically resulted in lower transport efficiencies. The extent of this difference (0-300% rel. difference) depended largely on the choice and storage conditions of the nanoparticle suspensions used for the determination. The TES method is recommended when the principal measurement objective is particle size. If the main aim of the measurement is the determination of the particle number concentration, the TEF approach could be preferred as it might better account for particle losses in the sample introduction system.
RESUMEN
Titanium dioxide is a white colourant authorised as food additive E 171 in the EU, where it is used in a range of alimentary products. As these materials may contain a fraction of particulates with sizes below 100 nm and current EU regulation requires specific labelling of food ingredient to indicate the presence of engineered nanomaterials there is now a need for standardised and validated methods to appropriately size and quantify (nano)particles in food matrices. A single-particle inductively coupled plasma mass spectrometry (spICP-MS) screening method for the determination of the size distribution and concentration of titanium dioxide particles in sugar-coated confectionery and pristine food-grade titanium dioxide was developed. Special emphasis was placed on the sample preparation procedure, crucial to reproducibly disperse the particles before analysis. The transferability of this method was tested in an interlaboratory comparison study among seven experienced European food control and food research laboratories equipped with various ICP-MS instruments and using different software packages. The assessed measurands included the particle mean diameter, the most frequent diameter, the percentage of particles (in number) with a diameter below 100 nm, the particles' number concentration and a number of cumulative particle size distribution parameters (D0, D10, D50, D99.5, D99.8 and D100). The evaluated method's performance characteristics were, the within-laboratory precision, expressed as the relative repeatability standard deviation (RSDr), and the between-laboratory precision, expressed as the relative reproducibility standard deviation (RSDR). Transmission electron microscopy (TEM) was used as a confirmatory technique and served as the basis for bias estimation. The optimisation of the sample preparation step showed that when this protocol was applied to the relatively simple sample food matrices used in this study, bath sonication turned out to be sufficient to reach the highest, achievable degree of dispersed constituent particles. For the pristine material, probe sonication was required. Repeatability and reproducibility were below 10% and 25% respectively for most measurands except for the lower (D0) and the upper (D100) bound of the particle size distribution and the particle number concentration. The broader distribution of the lower and the upper bounds could be attributed to instrument-specific settings/setups (e.g. the timing parameters, the transport efficiency, type of mass-spectrometer) and software-specific data treatment algorithms. Differences in the upper bound were identified as being due to the non-harmonised application of the upper counting limit. Reporting D99.5 or D99.8 instead of the effectively largest particle diameter (D100) excluded isolated large particles and considerably improved the reproducibility. The particle number-concentration was found to be influenced by small differences in the sample preparation procedure. The comparison of these results with those obtained using electron microscopy showed that the mean and median particle diameter was, in all cases, higher when using spICP-MS. The main reason for this was the higher size detection limit for spICP-MS plus the fact that some of the analysed particles remained agglomerated/aggregated after sonication. Single particle ICP-MS is a powerful screening technique, which in many cases provides sufficient evidence to confirm the need to label a food product as containing (engineered) titanium dioxide nanomaterial according to the current EU regulatory requirements. The overall positive outcome of the method performance evaluation and the current lack of alternative standardised procedures, would indicate this method as being a promising candidate for a full validation study.
RESUMEN
Grass pea (Lathyrus sativus L.) is commonly consumed in cooked, fermented, and roasted forms in Ethiopia. However, the impacts of household processing practices on its nutrients, antinutrients, and toxic compounds have not been adequately studied. Therefore, the effects of household processing and fermentation in the presence and absence of a phytase on the contents of ß-N-oxalyl-L-α,ß-diaminopropionic acid (ß-ODAP), myo-inositol phosphates, crude protein, minerals and the in vitro bioaccessibility were investigated. Fermentation exhibited a significant decline in ß-ODAP (13.0-62.0%) and phytate (7.3-90.5%) irrespective of the presence of phytase. Pressure and pan cooking after discarding the soaking water resulted in a 27.0 and 16.2% reduction in ß-ODAP. A 30% reduction in phytate was observed during germination followed by roasting. In addition, germination resulted in a significant (p < 0.05) increase in crude protein. Germination and germination followed by roasting resulted in the highest Fe bioaccessibilities (more than 25 fold higher compared to untreated samples) followed by pressure cooking and soaking. Processing also improved Zn bioaccessibilities by 50.0% (soaked seed without soaking water), 22.5% (soaked seed with soaking water), and 4.3% (germination). Thus, the processing technologies applied were capable of reducing the content of phytate (InsP6) and ß-ODAP with a concomitant increase in mineral bioaccessibilities. Processing of grass peas could therefore contribute to their more widespread utilization.
RESUMEN
The fermentation of vegetables is a traditional preservation method, that experiences a renaissance even in domestic households. Table salt is added to the fermentation batches to favor the growth of lactic acid bacteria usually. On an industrial scale, the fermentation brine is typically prepared with non-iodized table salt. In our study, we investigated the microbiota of cucumber fermentations using culture-dependent and -independent methods. We could show that the fermentation process of cucumbers and the involved microbiota is influenced by the concentration of table salt and not by the use of iodized table salt. Therefore, we conclude that the use of iodized table salt does not negatively affect the fermentation process. We could verify that iodine permeates the cucumbers by diffusion, leading to satisfactory iodine concentrations in the final food product. The industrial use of iodized table salt in food fermentations could contribute to maintain a constant iodine supply to the general public.
Asunto(s)
Cucumis sativus/microbiología , Alimentos Fermentados/microbiología , Yodo/farmacología , Microbiota/efectos de los fármacos , Cloruro de Sodio Dietético/farmacología , Cloruro de Sodio/farmacología , Cucumis sativus/química , Cucumis sativus/metabolismo , Fermentación , Alimentos Fermentados/análisis , Microbiología de Alimentos , Yodo/análisis , Sales (Química)/análisis , Sales (Química)/farmacología , Cloruro de Sodio/análisis , Cloruro de Sodio Dietético/análisisRESUMEN
To counteract iodine deficiency in the population in areas of environmental iodine deficiency table salt is often fortified with potassium iodide or iodate. However, most estimations of iodine contribution from the diet rely on calculations based on the added iodized salt and very limited experimental data about the stability of potassium iodate (KIO3) or iodine uptake during food processing is available. Therefore, the influence of cooking on the iodine content of potatoes, pasta, and rice having different size, varieties or composition was investigated. Commonly used cooking procedures were applied, using KIO3-enriched table salt in the cooking water. After iodine extraction with 0.5% NH3 iodine content was measured by ICP-MS. All products showed an increase in iodine content. Waxy potatoes, especially cut in small pieces, and egg pasta showed the highest iodine uptake. Based on the results, the use of KIO3-enriched salt for cooking is recommended to enhance iodine supply.
Asunto(s)
Culinaria , Yodo/análisis , Oryza/química , Cloruro de Sodio Dietético , Solanum tuberosum/química , Humanos , TriticumRESUMEN
The effect of iodine present in 1.0% table salt in combination with the use of starter cultures in sauerkraut fermentations were investigated in order to determine whether iodine interferes with lactic acid bacteria responsible for the fermentation. The effect of iodine was tested in fermentations performed using selected starter cultures or without starters (spontaneous fermentation). Lactobacillus plantarum and Leuconostoc mesenteroides used as starters at levels of ca. 1â¯×â¯107â¯cfuâ¯ml-1 led to a quick establishment of lactic acid bacteria (LAB) as predominant microorganisms, reaching 1â¯×â¯109â¯cfuâ¯ml-1 after 24â¯h decreasing the pH to below 4.0. In contrast, LAB counts in control fermentations without starters increased slower from 1â¯×â¯105â¯cfuâ¯ml-1 to 1â¯×â¯109â¯cfuâ¯ml-1 and a pH reduction below 4.0 was achieved only after 3 days fermentation. A metagenomic investigation showed a more diverse bacterial community in fermentations without starters, consisting of enterobacteria and pseudomonads in the first days of fermentation, and of LAB such as lactococci in the later stages. In fermentations with starters, lactobacilli predominated. Leuconostocs also occurred, but at much lower sequence abundance than lactobacilli, and thus were not able to predominate. Determination of iodine in the fermentation with starter bacteria and with iodized salt showed that the fermentation did not affect iodine concentration. The use of iodized salt did not statistically significantly influence microbial populations in the fermentation. Thus, there is no basis for the popular held belief that the use of iodized salt inhibits the growth of the bacteria important for the sauerkraut fermentation. A statistically near significant effect (pâ¯=â¯0.06), however, was noted for the effect of iodine on yeasts and mould populations in the fermentations performed without starter cultures. As sauerkraut is usually produced without starters, this should be further investigated.
Asunto(s)
Bacterias/aislamiento & purificación , Bacterias/metabolismo , Biodiversidad , Brassica/microbiología , Alimentos Fermentados/microbiología , Yodo/metabolismo , Cloruro de Sodio Dietético/metabolismo , Bacterias/clasificación , Bacterias/genética , Brassica/química , Fermentación , Alimentos Fermentados/análisis , Microbiología de Alimentos , Concentración de Iones de Hidrógeno , Lactobacillus plantarum/genética , Lactobacillus plantarum/aislamiento & purificación , Lactobacillus plantarum/metabolismo , Leuconostoc/genética , Leuconostoc/aislamiento & purificación , Leuconostoc/metabolismoRESUMEN
Micronutrient deficiencies are a major public health problem. Beans are an important plant-based source of iron, zinc and copper, but their absorption is reduced in the presence of anti-nutrients such as phytates, polyphenols and tannins. Soaking and discarding the soaking water before cooking is unanimously recommended, but this can result in mineral loss. Data on the consequences for mineral bioaccessibility is still limited. This study aimed to evaluate iron, zinc and copper bioaccessibility in black beans cooked (regular pan, pressure cooker) with and without the soaking water. For that, three batches of black beans were investigated in triplicate, each split in nine parts (raw grains and four different household processes in duplicate) and analyzed by applying the quarter technique, resulting in a grand total of 164 samples. Minerals were quantified by ICP-MS (inductively coupled plasma mass spectrometry), myo-inositol phosphates (InsP5, InsP6) by HPLC (high-performance liquid chromatography) ion-pair chromatography, total polyphenols using Folin-Denis reagent and condensed tannins using Vanillin assay. Mineral bioaccessibility was determined by in vitro digestion and dialysis. All treatments resulted in a statistically significant reduction of total polyphenols (30%) and condensed tannins (20%). Only when discarding the soaking water a loss of iron (6%) and copper (30%) was observed, and InsP6 was slightly decreased (7%) in one treatment. The bioaccessibility of iron and zinc were low (about 0.2% iron and 35% zinc), but copper presented high bioaccessibility (about 70%). Cooking beans under pressure without discarding the soaking water resulted in the highest bioaccessibility levels among all household procedures. Discarding the soaking water before cooking did not improve the nutritional quality of the beans.