Using Sweet Bran instead of forage during grain adaptation in finishing feedlot cattle.

Two trials evaluated adapting cattle to a finishing diet using wet corn gluten feed compared with traditional methods using forage. A 33-d grain adaptation metabolism trial (Exp. 1) compared decreasing wet corn gluten feed (Sweet Bran; Corn Milling unit, Cargill Corn Milling, Blair, NE) while increasing corn inclusion (SB) and a traditional grain adaptation system decreasing alfalfa hay while increasing corn with no Sweet Bran inclusion (CON). Ruminal pH, intake characteristics, and 24-h in situ digestibility were evaluated using 8 ruminally fistulated steers (291 kg BW [SD 19]). Steers (4/treatment) were adapted to finishing diets across 4 periods consisting of 5, 7, 7, and 7 d and then fed a finishing diet for 7 d. No period × adaptation diet interactions were observed ( ≥ 0.12). Average ruminal pH decreased ( < 0.01) whereas time and area below a pH of 5.6 increased ( ≤ 0.02) for the SB adaptation system compared with the CON adaptation system. Cattle adapted using SB had greater DMI than cattle adapted using CON ( < 0.01). As steers were adapted to finishing diets, DMI increased ( = 0.01), average ruminal pH decreased ( = 0.05), and time and area below a pH of 5.6 increased ( ≤ 0.04) for both treatments. Ruminal pH for CON steers decreased from 6.59 to 6.12 across periods as corn replaced alfalfa hay whereas ruminal pH decreased from 6.00 to 5.79 for SB steers. Steers adapted using SB had greater ( ≤ 0.05) in situ digestion of adaptation diets than steers adapted using CON for adaptation periods 3, 4, and 5. The SB diets were more digestible than the CON diets when incubated in either CON- or SB-fed steers for adaptation periods 1 and 2 ( < 0.01). Experiment 2 used 240 finishing steers (273 kg BW [SD 14]) to determine performance impacts of using Sweet Bran instead of forage to adapt cattle to finishing diets. Steers were fed either decreasing Sweet Bran inclusion while increasing corn (SB) or decreasing alfalfa hay inclusion while increasing corn (CON). Treatments were applied only during grain adaptation (26 d) and all steers were finished on a common diet containing 35% Sweet Bran for an additional 147 d. Steers adapted using SB had greater ( ≤ 0.01) final BW, ADG, G:F, and HCW compared with steers adapted using CON, even though treatments differed only the first 26 d. Grain adaptation treatment had no effect ( ≥ 0.13) on carcass quality. These results indicate that Sweet Bran can be used to adapt cattle to finishing diets instead of forage and improves ADG and G:F while decreasing the forage needs of feedlots.

Effects of roughage source and inclusion in beef finishing diets containing corn wet distillers' grains plus solubles.

Two experiments were conducted to determine the effects of roughage source and inclusion in diets containing wet distillers' grains plus solubles (WDGS) on finishing cattle performance and ruminal metabolism. In Exp. 1, 385 crossbred steer calves (initial BW = 346 kg [SD 29]) were used in a finishing trial. A control diet with no roughage inclusion was compared with 6 diets containing either alfalfa hay (ALF), corn silage (CSIL), or corn stalks (CSTK) at 2 inclusions as a 3 × 2 factorial. Alfalfa hay was included at 4 (low) or 8% (standard) of diet DM. Diets containing CSIL or CSTK were formulated to provide total dietary NDF equal to the low and standard ALF inclusion diets. The final diets contained 6.13 and 12.26% CSIL or 3.04 and 6.08% CSTK (DM basis). All diets contained 30% WDGS and a 1:1 mixture of dry-rolled and high-moisture corn (DM basis). Cattle fed no roughage had reduced ( < 0.01) DMI and tended ( ≤ 0.10) to have the lowest final BW and ADG compared with cattle fed roughage. There were no differences ( ≥ 0.11) in DMI, ADG, or G:F due to roughage source. Cattle fed a standard inclusion of roughage had greater ( ≤ 0.04) DMI and ADG compared with cattle fed diets with low inclusion, regardless of roughage source. Feed efficiency tended to be different among treatments ( = 0.09), with cattle fed no roughage having greater G:F than all treatments ( ≤ 0.06) except cattle fed the low level of CSTK, which had a similar G:F ( = 0.48). Feed efficiency was not affected by source of roughage ( = 0.23) or inclusion of roughage ( = 0.49). In Exp. 2, 6 ruminally fistulated steers (347 kg BW [SD 25]) were used in a 6 × 6 Latin square design. Treatments were arranged as a 2 × 3 factorial with ALF or CSTK included at zero, low, or standard levels similar to Exp. 1. Apparent total tract digestibility (%) of DM, OM, and NDF decreased linearly ( ≤ 0.07) due to increasing roughage inclusion. Average, maximum, and minimum ruminal pH increased linearly ( ≤ 0.09) as roughage inclusion was increased. Based on the results of this study, low levels of CSTK improved cattle performance relative to low inclusions of ALF or CSIL. Diets with standard inclusions of ALF, CSIL, or CSTK had similar performance. Roughage sources can be exchanged to provide equal NDF in finishing diets containing 30% WDGS without negatively impacting finishing cattle. Based on ADG, eliminating roughages when 30% WDGS was included in finishing diets was not beneficial.

Effects of monensin and tylosin in finishing diets containing corn wet distillers grains with solubles with differing corn processing methods.

A total of 3,632 crossbred steers were used in 3 separate randomized complete-block designed finishing experiments. Data from Exp. 1 were analyzed separately whereas data were combined for Exp. 2 and 3, based on corn processing method used [Exp.1 = equal combination of dry-rolled and high-moisture (DRC:HMC); Exp. 2 and 3 = steam-flaked (SFC)]. Steers were fed 1 of 5 treatments to evaluate the effects of monensin and tylosin in feedlot diets containing 25% corn wet distillers grains with solubles (WDGS; DM basis). Treatments included: 1) corn-based diet (no WDGS) with 360 mg/d monensin and 90 mg/d tylosin (CORN+MT), 2) 25% wet distillers grains with solubles (WDGS-CON), 3) 25% WDGS with 360 mg/d monensin (WDGS+M), 4) WDGS with monensin and tylosin at same levels as treatment 1, and 5) WDGS with 480 mg/d monensin and 90 mg/d tylosin (WDGS+HIMT). In Exp. 1, WDGS+MT increased (P < 0.01) ADG (6.5%), G:F (6.9%), and HCW (3.0%) compared with CORN+MT. Alternatively, in Exp. 2 and 3, WDGS+MT had no effect on ADG (P = 0.18), decreased (P < 0.01) G:F by 3.2%, and did not affect HCW (P = 0.57) compared with CORN+MT. In Exp. 1, addition of monensin to a WDGS diet increased G:F by 3.1% (P = 0.03) and tended to increase G:F in Exp. 2 and 3 (P = 0.09) compared with WDGS-CON. For all experiments, addition of monensin and tylosin in a diet containing WDGS increased G:F (P < 0.01) and reduced total and severe liver abscesses (P < 0.01) compared with WDGS-CON. Additionally, HCW was increased in Exp. 2 and 3 (P < 0.01) and tended to increase in Exp. 1 (P = 0.09) when monensin and tylosin were fed in a WDGS diet compared with WDGS-CON. Feeding WDGS+MT reduced total liver abscesses by 79.3% (Exp. 1) and 57.6% (Exp. 2 and 3) compared with WDGS-CON. Compared with WDGS+MT, minimal differences were observed when monensin was fed at 480 mg/steer daily with tylosin in diets containing WDGS. Inclusion of WDGS in finishing steer diets did not alter effectiveness of monensin with tylosin in improving G:F and reducing prevalence of liver abscesses, regardless of corn processing method. Corn processing method appears to be an important factor in performance response to WDGS with feeding value of WDGS, measured as an increase in feed efficiency, being greater in a DRC:HMC-based diet compared with a SFC-based diet.

Effects of level of condensed distillers solubles in corn dried distillers grains on intake, daily body weight gain, and digestibility in growing steers fed forage diets1.

Three experiments were conducted examining the effects of feeding different levels of dried distillers grains (DDG) and different proportions of condensed distillers solubles (CDS) added to DDG on performance and digestibility in forage-fed steers. In Exp. 1, a total of 120 individually fed crossbred steers (276 +/- 31 kg) were used in a randomized complete block design with a 4 x 5 factorial arrangement of treatments. Factors included DDG supplementation level (0.25, 0.50, 0.75, or 1.0% of BW daily) and proportion of CDS in DDG (0.0, 5.4, 14.5, 19.1, and 22.1% of DDG DM). A basal diet of 58.8% alfalfa hay, 39.2% sorghum silage, and 2% vitamin and mineral supplement (DM basis) was fed for ad libitum intake. As the level of DDG increased, intake of forage decreased linearly (P < 0.01), intake of DDG increased linearly (P < 0.01), and total DMI increased quadratically (P = 0.06). A DDG level x CDS level interaction (P < 0.01) was observed for ADG and G:F. The 0.0, 5.4, 14.5, 19.1, and 22.1% CDS treatments had the greatest ADG when DDG was supplemented at 0.75, 1.0, 1.0, 0.75, and 0.50% of BW daily, respectively. In Exp. 2, four crossbred steers (295 +/- 19 kg) were used in a 3-period switchback design. A basal diet of 58.8% alfalfa hay, 39.2% brome hay, and 2% vitamin and mineral supplement (DM basis) was fed at 95% of ad libitum intake. Treatments were DDG containing 0.0 or 22.1% CDS supplemented at 1.0% of BW daily. Apparent total tract digestibility was measured by total fecal collection. No differences between treatments were observed for digestibility of DM, OM, or NDF (P >/= 0.14). Digestibility of ether extract was greater (P = 0.02) in steers supplemented with DDG containing 22.1% CDS. In Exp. 3, two ruminally and duodenally cannulated Holstein steers (663 +/- 24 kg) were used to estimate DM and CP digestion of the DDG fed in Exp. 1 using the mobile bag technique. Basal diets were the same as fed in Exp. 1 and steers were supplemented with DDG at 0.5% of BW daily. Ruminal DM digestibility increased linearly (P < 0.01), and postruminal and total tract DM digestibility increased quadratically (P = 0.02 and P = 0.03, respectively) as the level of CDS increased. Level of CDS may affect growing steer performance because depressions in ADG and G:F were observed as intake of ether extract increased. A clear explanation for the interaction between the DDG supplementation level and the CDS level on growing steer performance was not evident in the digestion experiments.

Effect of corn processing method and corn wet distillers grains plus solubles inclusion level in finishing steers.

Two experiments were conducted to determine the effect of corn processing method and corn wet distillers grains plus solubles (WDGS) level on steer performance and metabolism. In Exp. 1, 480 crossbred steer calves (314 +/- 18 kg of BW) were used in a finishing experiment with a randomized complete block design and a 3 x 4 treatment structure. Diets were based on dry-rolled (DRC), high-moisture (HMC), or steam-flaked corn (SFC) with increasing levels of WDGS (0, 15, 27.5, or 40%; DM basis). A corn processing x WDGS level interaction (P < 0.01) was observed for ADG and G:F. Average daily gain and G:F increased linearly (P < 0.01) in steers fed DRC; ADG increased quadratically (P = 0.04) and G:F increased linearly (P = 0.02) in steers fed HMC; and ADG decreased quadratically (P = 0.02) with no change in G:F (P = 0.52) in steers fed SFC as WDGS increased. In Exp. 2, 7 ruminally fistulated steers (440 +/- 41 kg of BW) were used in a 6-period crossover design with 3 x 2 factorial treatment structure. Diets were the same as those fed in Exp. 1, except they contained only 2 levels of WDGS (0 or 40% of diet DM). Total tract starch digestibility was greater (P < 0.01) for steers fed SFC than for steers fed DRC or HMC. Minimum ruminal pH was less (P < 0.01) for steers fed SFC than for steers fed HMC or DRC. Variance of ruminal pH was different among all 3 processing methods with DRC < HMC < SFC (P < 0.10). In situ 22-h DM digestibility of DRC and HMC and starch digestibility of DRC were greater (P < 0.10) in steers fed DRC compared with steers fed HMC or SFC. Steers fed 0% WDGS had less (P < or = 0.02) intake of DM, OM, NDF, and ether extract compared with steers fed 40% WDGS. Total tract digestibility of DM and OM was greater (P < or = 0.08) and digestibility of ether extract tended (P = 0.11) to be less for steers fed 0% WDGS compared with steers fed 40% WDGS. Maximum ruminal pH and pH variance were greater (P < or = 0.08) in steers fed 0% WDGS. A corn processing x WDGS level interaction (P = 0.09) was observed for ruminal acetate to propionate ratio (A:P). Within diets containing 0% WDGS, A:P in steers fed SFC was less (P < or = 0.08). In diets containing 40% WDGS, A:P was similar between processing methods and not different from the SFC with 0% WDGS. The corn processing x WDGS level interaction observed in the finishing experiment may be due to the decreased ruminal A:P in DRC and HMC diets with 40% WDGS.

Effect of essential oils, tylosin, and monensin on finishing steer performance, carcass characteristics, liver abscesses, ruminal fermentation, and digestibility.

A feedlot (Exp. 1) experiment was conducted to evaluate the effects of an essential oil mixture (EOM), experimental essential oil mixture (EXP), tylosin, and monensin (MON) on performance, carcass characteristics, and liver abscesses. A metabolism experiment (Exp. 2) was conducted to evaluate the effects of EOM, EXP, and MON on ruminal fermentation and digestibility in finishing steers. In Exp. 1, 468 yearling steers (398 +/- 34 kg initial BW) were used in 50 pens (10 pens/treatment) and received their respective dietary treatments for 115 d. Five dietary treatments were compared in Exp. 1: 1) control, no additives (CON); 2) EOM, 1.0 g/steer daily; 3) EXP, 1.0 g/steer daily; 4) EOM, 1.0 g/steer daily plus tylosin, 90 mg/steer daily (EOM+T); and 5) monensin, 300 mg/steer daily plus tylosin, 90 mg/steer daily (MON+T). Compared with CON, steers fed MON+T had decreased DMI (P < 0.01), and steers fed EOM+T and MON+T had improved G:F (P 0.58). There was a trend (P = 0.09) for a treatment effect on 12th-rib fat thickness, which resulted in a significant increase in calculated yield grade for the EOM+T treatment. No other carcass characteristics were affected by treatment (P >/= 0.10). Prevalence of total liver abscesses was reduced for steers fed tylosin compared with no tylosin (P < 0.05). In Exp. 2, 8 ruminally fistulated steers (399 +/- 49 kg initial BW) were assigned randomly to 1 of 4 treatments in a replicated 4 x 4 Latin square designed experiment. Treatments were 1) CON, 2) EOM, 3) EXP, and 4) MON with feeding rates similar to Exp. 1. There were no differences in DMI, OM intake, and apparent total tract DM or OM digestibilities among treatments (P > 0.30). Feed intake patterns were similar among feed additive treatments (P > 0.13). Total VFA (P = 0.10) and acetate (P = 0.06) concentrations tended to be affected by treatment with EOM numerically greater than CON. Average ruminal pH ranged from 5.59 to 5.72 and did not differ among treatments. Addition of a EOM or monensin to a diet containing tylosin improves G:F, but little difference was observed in metabolism or digestibility.

Influence of corn hybrid and processing method on nutrient digestibility, finishing performance, and carcass characteristics.

A finishing trial and a digestion trial were conducted to evaluate the effects of corn hybrid and processing method on nutrient digestibility, finishing performance, and carcass characteristics. A 2 x 5 factorial arrangement of treatments was used for both trials. Factors included 2 processing methods, dry-rolled (DRC) or high-moisture (HMC), and 5 commercially available corn hybrids. The finishing trial (Exp. 1) utilized 475 yearling steers (379 +/- 15 kg initial BW), stratified by BW into 2 blocks then assigned randomly to 1 of 60 pens (8 steers/pen). Treatments were assigned randomly to pens with 6 pens/treatment. Diets consisted of 67.5% corn (each hybrid processed as DRC or HMC), 20% wet corn gluten feed, 7.5% alfalfa hay, and 5% supplement. The digestion trial (Exp. 2) used 2 ruminally and duodenally fistulated Holstein steers (560 kg of BW) and the mobile bag technique. Bags were ruminally incubated for 22 h. For total tract digestibility, bags were subjected to a simulated abomasal pepsin digestion, inserted into the duodenum, and collected in the feces. No significant interactions between corn hybrid and processing method were observed in Exp. 1; therefore, only main effects are presented. Feeding HMC decreased (P < 0.01) DMI and increased (P < 0.01) G:F compared with cattle fed DRC. Hybrid tended to affect (P = 0.12) G:F, but did not affect (P > 0.36) any other variable. For Exp. 2, feeding HMC increased (P < 0.01) DM and starch digestibility compared with DRC, but to varying degrees depending on the hybrid. Correlating the results of the 2 trials across processing methods, strong relationships were observed between G:F and postruminal starch digestibility (r = 0.84) and total-tract starch digestibility (r = 0.73). When evaluated within processing method, these relationships weakened and were not significant. The results of these trials indicate that processing method had a larger effect on performance and digestibility than hybrid, and no interaction was observed between processing method and hybrid, suggesting hybrid effects were consistent across processing methods.