Techno-economic assessment at full scale of a biogas refinery plant receiving nitrogen rich feedstock and producing renewable energy and biobased fertilisers.

Anaerobic digestion of nitrogen (N) rich substrates might be hindered when ammonia (NH3) formation reaches toxic levels for methanogenic microorganisms. One possible strategy to avoid inhibiting conditions is the removal of NH3 from digestate by stripping and scrubbing technology and by recirculating N depleted digestate back to the digester. This study aimed to i) monitor the performance (mass and energy balances) of a full scale digestate processing cascade that includes an innovative vacuum side stream NH3stripping and scrubbing system, ii) assess the production cost of ammonium sulphate (AS) solution and iii) evaluate its fertiliser quality. The use of gypsum to recover NH3 in the scrubbing unit, instead of the more common sulphuric acid, results in the generation of AS and a fertilising liming substrate. Mass and nutrient balances indicated that 57% and 7.5% of ammonium N contained in digestate was recovered in the form of a 22% AS and liming substrate, respectively. The energy balance showed that about 3.8 kWhel and 59 kWhth were necessary to recover 1 kg of N in the form of AS. Furthermore, the production cost of AS, including both capital and operational costs, resulted to be 5.8 € t-1 of digestate processed. According to the fertiliser quality assessment, this technology allows for the recovery of NH3in the form of salt solutions that can be utilised as a substitute for synthetic mineral nitrogen fertilisers.

Production and performance of bio-based mineral fertilizers from agricultural waste using ammonia (stripping-)scrubbing technology.

Development and optimization of nutrient recovery technologies for agricultural waste is on the rise. The full scale adoption of these technologies is however hindered by complex legal aspects that result from lack of science-based knowledge on characterization and fertilizer performance of recovered end-products. Ammonium sulfate (AS) and ammonium nitrate (AN), end-products of (stripping-)scrubbing technology, are currently listed by the European Commission as high priority products with the potential of replacing synthetic N fertilizers. The legal acceptance of AS and AN will be highly dependent on critical mass of scientific evidence. This study describes four different (stripping-)scrubbing pathways to recover ammonia with an aim to (i) assess product characteristics of ammonium nitrate (AN) and ammonium sulfate (AS) produced from different installations, (ii) evaluate fertilizer performance of recovered end-products in greenhouse (Lactuca sativa L.) and full field (Zea mays L.) scale settings and (iii) compare the observed performances with other published studies. Results have indicated that the recovered products might have a different legal status, as either mineral N fertilizer or yet as animal manure, depending on the used (stripping-)scrubbing process pathway. Nevertheless, no significant differences in respect to product characterization and fertilizer performance of AN and AS have been identified in this study as compared to the conventional use of synthetic N fertilizers. This indicates that recovered AS and AN are valuable N sources and therefore might be used as N fertilizers in crop cultivation.

Limitations for phytoextraction management on metal-polluted soils with poplar short rotation coppice-evidence from a 6-year field trial.

Poplar clones were studied for their phytoextraction capacity in the second growth cycle (6-year growth) on a site in the Belgian Campine region, which is contaminated with Cd and Zn via historic atmospheric deposition of nearby zinc smelter activities. The field trial revealed regrowth problems for some clones that could not be predicted in the first growth cycle. Four allometric relations were assessed for their capacity to predict biomass yield in the second growth cycle. A power function based on the shoot diameter best estimates the biomass production of poplar with R2 values between 0.94 and 0.98. The woody biomass yield ranged from 2.1 to 4.8 ton woody Dry Mass (DM) ha-1 y-1. The primary goal was to reduce soil concentrations of metals caused by phytoextraction. Nevertheless, increased metal concentrations were determined in the topsoil. This increase can partially be explained by the input of metals from deeper soil layers in the top soil through litterfall. The phytoextraction option with poplar short rotation coppice in this setup did not lead to the intended soil remediation in a reasonable time span. Therefore, harvest of the leaf biomass is put forward as a crucial part of the strategy for soil remediation through Cd/Zn phytoextraction.

Fertilizer performance of liquid fraction of digestate as synthetic nitrogen substitute in silage maize cultivation for three consecutive years.

Following changes over recent years in fertilizer legislative framework throughout Europe, phosphorus (P) is taking over the role of being the limiting factor in fertilizer application rate of animal manure. This results in less placement area for spreading animal manure. As a consequence, more expensive and energy demanding synthetic fertilizers are required to meet crop nutrient requirements despite existing manure surpluses. Anaerobic digestion followed by mechanical separation of raw digestate, results in liquid fraction (LF) of digestate, a product poor in P but rich in nitrogen (N) and potassium (K). A 3-year field experiment was conducted to evaluate the impact of using the LF of digestate as a (partial) substitute for synthetic N fertilizer. Two different fertilization strategies, the LF of digestate in combination with respectively animal manure and digestate, were compared to the conventional fertilization regime of raw animal manure with synthetic fertilizers. Results from the 3-year trial indicate that the LF of digestate may substitute synthetic N fertilizers without crop yield losses. Through fertilizer use efficiency assessment it was observed that under-fertilization of soils with a high P status could reduce P availability and consequently the potential for P leaching. Under conditions of lower K application, more sodium was taken up by the crop. In arid regions, this effect might reduce the potential risk of salt accumulation that is associated with organic fertilizer application. Finally, economic and ecological benefits were found to be higher when LF of digestate was used as a synthetic N substitute. Future perspectives indicate that nutrient variability in bio-based fertilizers will be one of the greatest challenges to address in the future utilization of these products.

Feasibility of grass co-digestion in an agricultural digester, influence on process parameters and residue composition.

This study investigated the potential of co-digestion of grass clippings in a typical Flemish agro-digester characterized by an input of 30% manure, 30% maize silage and 40% side streams. No significant adverse effects in the microbiological functioning of the reactors were detected when part of the maize input was replaced by 10-20% grass. However at the highest dosage of grass input, dry matter content and the viscosity of the reactor content increased substantially. These parameters could be reduced again by enzyme addition in the form of MethaPlus L100. It can be concluded that co-digestion of 20% grass in an agricultural digester would not pose any problem if dry matter content and viscosity are improved by the use of an enzyme mixture.

Safe use of metal-contaminated agricultural land by cultivation of energy maize (Zea mays).

Production of food crops on trace element-contaminated agricultural lands in the Campine region (Belgium) can be problematic as legal threshold values for safe use of these crops can be exceeded. Conventional sanitation of vast areas is too expensive and alternatives need to be investigated. Zea mays on a trace element-contaminated soil in the region showed an average yield of 53 ± 10 Mg fresh or 20 ± 3 Mg dry biomass ha(-1). Whole plant Cd concentrations complied with legal threshold values for animal feed. Moreover, threshold values for use in anaerobic digestion were met. Biogas production potential did not differ between maize grown on contaminated and non-contaminated soils. Results suggested favorable perspectives for farmers to generate non-food crops profitably, although effective soil cleaning would be very slow. This demonstrates that a valuable and sustainable alternative use can be generated for moderately contaminated soils on which conventional agriculture is impaired.

IL-4 is a critical determinant in the generation of allergic inflammation initiated by a constitutively active Stat6.

IL-4 is required for the pathogenesis of atopic diseases and immune regulation. Stat6 is critical for IL-4-induced gene expression and Th cell differentiation. Recently, we have generated mice expressing a mutant Stat6 (Stat6VT) under control of the CD2 locus control region that is transcriptionally active independent of IL-4 stimulation. To determine whether active Stat6 in T cells is sufficient to alter immune regulation in vivo, we mated Stat6VT transgenic mice to IL-4-deficient mice. Stat6VT expression in IL-4-deficient lymphocytes was sufficient to alter lymphocyte homeostasis and promote Th2 differentiation in vitro. HyperTh2 levels in Stat6 transgenic mice correlated with an atopic phenotype that manifested as blepharitis and pulmonary inflammation with a high level of eosinophilic infiltration. In the absence of endogenous IL-4, Stat6VT transgenic mice were protected from allergic inflammation. Thus, in mice with hyperTh2 immune responses in vivo, IL-4 is a critical effector cytokine.

Genome wide measurement of DNA copy number changes in neuroblastoma: dissecting amplicons and mapping losses, gains and breakpoints.

In the past few years high throughput methods for assessment of DNA copy number alterations have witnessed rapid progress. Both 'in house' developed BAC, cDNA, oligonucleotide and commercial arrays are now available and widely applied in the study of the human genome, particularly in the context of disease. Cancer cells are known to exhibit DNA losses, gains and amplifications affecting tumor suppressor genes and proto-oncogenes. Moreover, these patterns of genomic imbalances may be associated with particular tumor types or subtypes and may have prognostic value. Here we summarize recent array CGH findings in neuroblastoma, a pediatric tumor of the sympathetic nervous system. A total of 176 primary tumors and 53 cell lines have been analyzed on different platforms. Through these studies the genomic content and boundaries of deletions, gains and amplifications were characterized with unprecedented accuracy. Furthermore, in conjunction with cytogenetic findings, array CGH allows the mapping of breakpoints of unbalanced translocations at a very high resolution.

Changes in phototactic behavior of Daphnia magna clone C1 242 in response to copper, cadmium and pentachlorophenol.

In order to develop a sound biotechnique for monitoring water quality that builds on the previous experiments carried out in our laboratory, a specific D. magna clone C1 242 was used to study the effects of pollutants on phototactic behavior. In all experiments, the animals showed a stable and repeatable phototactic index approximated 0.2 in the presence and 0.4 in the absence of fish kairomones, which decreased significantly in response to pollutants. There existed no pollutant x fish kairomone interaction, indicating the changes in phototactic behavior of animals imposed by pollutants were independent of the presence of fish kairomones. The detection limits for changes in phototactic behavior of D. magna clone C1 242 are 0.04 mg/L for copper, 0.02 mg/L for cadmium, and 0.80 mg/L for PCP, respectively, quite lower than LC50 (48 h). The changes in phototactic behavior in presence to pollutants occurred quickly (3 h) compared to the period over whole acute toxicity tests. Therefore, D. magna clone C1 242 could be potentially used to monitor water quality. Moreover, the phototactic behavior did not decrease further in the pollutant mixtures employed in our experiments compared to individual pollutants, except in the Cd-PCP treatment. This fact suggests that the formation of water quality criteria must be based upon pollutant mixture tests.

Geographical and genetic distances among zooplankton populations in a set of interconnected ponds: a plea for using GIS modelling of the effective geographical distance.

In systems of interconnected ponds or lakes, the dispersal of zooplankton may be mediated by the active population component, with rivulets and overflows functioning as dispersal pathways. Using a landscape-based approach, we modelled the effective geographical distance among a set of interconnected ponds (De Maten, Genk, Belgium) in a Geographic Information System (GIS) environment. The first model (the Landscape Model; LM) corrects for the presence of direct connections among ponds and was based on the existing landscape structure (i.e. network of connecting elements among ponds, travelling distance and direction of the current). A second model (the Flow Rate Model; FRM) also incorporated field data on flow rates in the connecting elements as the driving force for the passive dispersal of the active zooplankton population component. Finally, the third model (the Dispersal Rate Model; DRM) incorporated field data on zooplankton dispersal rates. An analysis of the pattern of genetic differentiation among Daphnia ambigua populations inhabiting 10 ponds in the pond complex reveals that the effective geographical distance as modelled by the flow rate and the dispersal rate model provide a better approximation of the true rates of genetic exchange among populations than mere Euclidean geographical distances or the landscape model that takes into account solely the presence of physical connections.

Phototactic behavior of Daphnia and the continuous monitoring of water quality: interference of fish kairomones and food quality.

We carried out a laboratory study to evaluate the sensitivity of phototactic behavior of Daphnia magna to sublethal concentrations of pentachlorophenol (PCP) and copper. More specifically, we determined whether the sensitivity of a D. magna clone to those pollutants is influenced by food quality and the presence of fish kairomones. Test animals were fed either unicellular green algae (Scenedesmus acutus) or fresh baker's yeast (Saccharomyces cerevisiae) and were cultured in the presence or absence of fish kairomones. Four concentrations of PCP (0.4, 0.8, 1.2, and 1.6 mg/L PCP) and one concentration of copper (0.02 mg/L Cu2+) in International Standards Organisation (ISO, Geneva, Switzerland) standard medium were applied in the experiments. Animals were exposed for 3 h to the pollutants prior to the experiments. In the absence of fish kairomones, a strong negative relationship between the phototactic index and nominal sublethal concentrations of PCP was found in animals fed either algae or yeast. The sensitivity of the Daphnia clone to sublethal concentrations of PCP was, however, less clear cut in animals fed yeast than in animals fed algae. The detection limit was 0.4 mg/L PCP with algae as food but was as high as 1.2 mg/L PCP when yeast was used as food. The ability to detect sublethal concentrations of copper and PCP using phototactic behavior was lost when the clones were cultured in the presence of fish kairomones. At a concentration of 0.02 mg/L Cu2+ and in the absence of fish kairomones, the D. magna clone tested became significantly less positively phototactic than in the control treatment regardless of the quality of the food used to culture the test animals. These results suggest that assays using the phototactic behavior of Daphnia to monitor water quality should use genetically stable (clonal) material, positively phototactic, and insensitive to the presence of fish kairomones.

Effect of sublethal doses of cadmium on the phototactic behavior of Daphnia magna.

The effect of a sublethal concentration of cadmium (0.06 mg/ L) was tested on the phototactic behavior of a positively phototactic Daphnia magna clone. In experiments lasting 10 min, using animals that had been exposed to cadmium for 1 to 6 h, it was observed that the animals became significantly less positively phototactic after 4 h of exposure to 0.06 mg/L cadmium compared to control animals that had not been exposed to cadmium. In flow-through experiments that lasted for 6 h and during which there were repeated measurements, there was again a significant effect of cadmium exposure on the phototactic behavior of the animals. Irrespective of treatment, time had a significant effect. Results suggest that phototactic behavior can be used to detect sublethal concentrations of pollutant within a few hours, in short-term as well as in longer-lasting experiments with continuous flow-through and repeated stimulation of the animals.