RESUMEN
This systematic review aimed to assess the effectiveness of pre-harvest interventions to control the main foodborne pathogens in pork in the European Union. A total of 1180 studies were retrieved from PubMed® and Web of Science for 15 pathogens identified as relevant in EFSA's scientific opinion on the public health hazards related to pork (2011). The study selection focused on controlled studies where a cause-effect could be attributed to the interventions tested, and their effectiveness could be inferred. Altogether, 52 studies published from 1983 to 2020 regarding Campylobacter spp., Clostridium perfringens, Methicillin-resistant Staphylococcus aureus, Mycobacterium avium, and Salmonella spp. were retained and analysed. Research was mostly focused on Salmonella (n = 43 studies). In-feed and/or water treatments, and vaccination were the most tested interventions and were, overall, successful. However, the previously agreed criteria for this systematic review excluded other effective interventions to control Salmonella and other pathogens, like Yersinia enterocolitica, which is one of the most relevant biological hazards in pork. Examples of such successful interventions are the Specific Pathogen Free herd principle, stamping out and repopulating with disease-free animals. Research on other pathogens (i.e., Hepatitis E, Trichinella spiralis and Toxoplasma gondii) was scarce, with publications focusing on epidemiology, risk factors and/or observational studies. Overall, high herd health coupled with good management and biosecurity were effective to control or prevent most foodborne pathogens in pork at the pre-harvest level.
RESUMEN
Tonsils in the oral cavity are an important source of contamination during pig slaughter, but have not received as much attention as faecal contamination. In the present study, ten pigs were sampled from tonsils, faeces and three different areas on each carcass. The samples were analysed by both culturing of Escherichia coli and Yersinia enterocolitica and by 16S rRNA gene sequencing to characterize the bacterial communities. Comparing culture data from deep tonsil tissue and tonsil surface showed similar numbers of E. coli but significantly higher numbers of Y. enterocolitica in the deep tissue samples. Microbiota analysis showed similar bacterial communities in the two sample types at phylum level, while comparison at genus level showed significant differences between the relative abundance of several genera in the two sample types. The finding of a significantly higher relative abundance of Yersinia in tonsil tissue compared to tonsil surface supported the culture analysis. The microbiota analysis also investigated characteristics of the bacterial community that could discriminate bacterial transfer from tonsils and faeces to the carcass during slaughter. The microbiota analyses demonstrated that Fusobacteria and Proteobacteria are the most abundant phyla in tonsils, while Firmicutes showed the highest relative abundance in faeces. The dominating phylum on carcasses was Proteobacteria. Besides Proteobacteria, the swabbing area on the forepart of the carcass, showed a higher relative abundance of Firmicutes and Fusobacteria compared to swabbing areas on the rear part and mid-section of the carcass. Principal coordinate analysis showed clear clustering of samples based on sample source (tonsils, faeces and carcass). Carcass swab samples from the forepart tended to cluster closer to the tonsil samples compared to carcass swab samples from the rear part and mid-section. Identification of the genera Fusobacterium, Moraxella, Actinobacillus and non-E. coli genera of the family Enterobacteriaceae in carcass swabs could indicate tonsil contamination, while faecal contamination would more likely include higher prevalence of bacteria belonging to the class of Clostridia. The present study supports that it is possible to identify bacterial groups that are indicative for either tonsil or faecal carcass contamination. The level and composition of Enterobacteriaceae on the carcasses did, however, indicate that other sources of meat contamination than tonsils and faeces may be important, such as the process environment.
Asunto(s)
Fenómenos Fisiológicos Bacterianos , Microbiología de Alimentos , Carne/microbiología , Tonsila Palatina/microbiología , Mataderos , Animales , Bacterias/genética , Heces/microbiología , Microbiota/genética , Prevalencia , ARN Ribosómico 16S/genética , PorcinosRESUMEN
The aim of the study was to compare two analytical methods; 3M Petrifilm™ Select E. coli and SimPlate® Coliforms &E. coli, for detection and enumeration of E. coli using swab samples from naturally contaminated pork and lamb carcasses that were collected before and after chilling. Blast chilling was used for pork carcasses. Swab samples (n=180) were collected from 60 warm and 60 chilled pork carcasses, and 30 warm and 30 chilled lamb carcasses, and analysed in parallel. The concordance correlation coefficient between Petrifilm and SimPlate was 0.89 for pork and 0.81 for lamb carcasses. However, the correlation was higher for warm carcasses (0.90) than chilled carcasses (0.72). For chilled lamb carcasses, the correlation was only 0.50, and SimPlate gave slightly higher results than Petrifilm (P=0.09). Slower chilling gave slightly lesser agreement between methods than for blast chilling, however, both Petrifilm and SimPlate methodologies are suitable and recommended for use in small laboratories in abattoirs.
Asunto(s)
Escherichia coli/aislamiento & purificación , Microbiología de Alimentos/métodos , Carne Roja/microbiología , Mataderos , Animales , Recuento de Colonia Microbiana , Contaminación de Alimentos/análisis , Ovinos , Porcinos , TemperaturaRESUMEN
This study investigated the bacterial dynamics along the beef chain for clean and dirty cattle in the slaughter and processing lines, using classic quantitative methods and molecular analyses. In addition, the Norwegian national guidelines for Good Hygiene Practices in Norway were evaluated. In these guidelines, cattle presented for slaughter are categorised according to hide cleanliness, resulting in separate processing lines for meat from very dirty animals and reduced prices to farmers. The study was conducted in two commercial abattoirs in Norway. Two groups were compared; 40 visually clean cattle and 40 visually dirty cattle presented for slaughter, with 20 from each group at each abattoir. The same animals were sampled at five sampling sites: hides, carcass surfaces after dehiding, just before chilling, after chilling, and meat trimmings. Meat trimmings were sampled in only one abattoir. Three hundred and sixty samples were collected by swabbing 100 cm(2) of the brisket area at the first four sampling sites, and sampling 200 g of meat trimmings at the fifth site. The results showed that the hides of dirty cattle had more Enterobacteriaceae and higher Aerobic Plate Counts (APC) than visually clean cattle (P<0.05), however there was no significant difference for Escherichia coli. For the other sampling sites, there were no differences between the dirty and the clean group. An effect of chilling/drying of the carcass surfaces was demonstrated by the significant reduction in the number of carcasses on which E. coli and Enterobacteriaceae were detected; from 11% and 39% before chilling to 1% and 16% after chilling, respectively. Enterobacteriaceae and E. coli were detected in only three and one of the meat trimming samples, respectively. Amplification and sequencing of the 16S rRNA gene from 643 Enterobacteriaceae colonies derived from 107 samples demonstrated that Escherichia/Shigella were dominant within this family on the hides. However, after dehiding, after grading, and after chilling, the genera Citrobacter and Enterobacter dominated. The meat trimmings were dominated by the genera Kluyvera, Hafnia, and unclassified Enterobacteriaceae. The relative proportions of Escherichia/Shigella were higher for dirty animals than for clean animals, and were higher on hides than from sampling sites further down the chain (P<0.05). The minor differences in contamination on carcass surfaces and meat trimmings between clean and dirty cattle indicate that separate processing lines in Norwegian abattoirs seem to be unnecessary.
Asunto(s)
Mataderos/normas , Carga Bacteriana/métodos , Enterobacteriaceae/aislamiento & purificación , Carne Roja/microbiología , Animales , Bovinos , Recuento de Colonia Microbiana , Enterobacteriaceae/clasificación , Higiene , Noruega , ARN Ribosómico 16SRESUMEN
The aims of this study were to investigate bacterial dynamics in the sheep meat chain, from fleece to meat trimmings, using both quantitative and qualitative analyses, and to study the effects on microbial load associated with the hygienic interventions of: i) shearing sheep immediately before slaughter, ii) manual steam vacuum pasteurisation, iii) hot water pasteurisation of carcasses, followed by iv) chilling. A further aim was to provide evidence to determine whether or not unshorn sheep should be handled in a processing line separate from that of shorn sheep in Norwegian abattoirs. A total of 176 surface swab samples were collected from three sites along the value chain: i) on fleeces, ii) on carcasses at the end of the slaughter line, and iii) on carcasses after chilling for 24h, and 32 samples were collected from meat trimmings. The results showed that Aerobic Plate Counts (APC) were lower for the shorn group compared to the unshorn group, both on carcasses before chilling and after chilling (difference of 0.8 and 0.9logCFU/1000cm(2) (p≤0.05), respectively) and in meat trimmings (difference of 0.5logCFU/g (p≤0.05)). Hygienic treatments were used on carcasses derived from unshorn sheep, and steam vacuum treatment reduced Escherichia coli, Enterobacteriaceae, and APC before chilling by 1.2, 1.0, and 0.6logCFU/1000cm(2) (p≤0.05), respectively, and hot water pasteurisation, in addition to chilling, reduced E. coli, Enterobacteriaceae, and APC by 0.7, 1.0, and 0.9logCFU/1000cm(2) (p≤0.05), respectively, compared with untreated carcasses. The effect of chilling was shown by the significant reduction of number of carcasses where E. coli were detected; from 65% (13/20) of the shorn group before chilling to 35% (7/20) after chilling, and from 90% (36/40) to 45% (9/20) of the unshorn group. Sequencing of the 16S rRNA gene derived from 316 colonies of Enterobacteriaceae showed a tendency for the relative proportion of the genus Escherichia/Shigella, compared with other genera within Enterobacteriaceae, to be greater for unshorn, untreated sheep than from the other groups at the sampling locations along the meat chain. The study showed that steam vacuum and hot water pasteurisation reduced the contamination of carcasses derived from unshorn sheep, down to the level of the shorn group, and thus can replace the separate processing line for unshorn sheep. Indeed, the low microbial contamination in meat trimmings for all groups indicates that the separate processing line is unnecessary.
Asunto(s)
Mataderos/normas , Industria de Alimentos/métodos , Microbiología de Alimentos , Carne/microbiología , Vapor , Animales , Recuento de Colonia Microbiana , Enterobacteriaceae/genética , Enterobacteriaceae/aislamiento & purificación , Noruega , ARN Ribosómico 16S/genética , OvinosRESUMEN
The main objective of the study was to assess the effect of steam vacuum pasteurisation on carcass contamination with focus on Escherichia coli, Enterobacteriaceae and total plate count (TPC). Additionally, the effect of an additional tryptone soy agar (TSA) step for resuscitation of Enterobacteriaceae after steam vacuum pasteurisation was investigated. Steam vacuum pasteurisation was applied at a temperature of >82°C for a duration of 10s on sheep and lamb carcasses (n=120). Samples were taken immediately: i) after trimming just before the use of steam vacuum and ii) after use of steam vacuum. Nordic Committee on Food Analysis methods were used in microbial analyses. The differences in log reduction were found significant for all of the three microorganisms (p<0.05). For TPC, the general reduction was a 0.65 log10 in the number of colony forming units (CFU) per cm(2). For E. coli, the median reduction effect on carcasses positive before decontamination was 1.1 log10 CFU/cm(2). A large variability of the effect was however found, with 50% of the figures ranging from a 0.24 to 1.62 log10 CFU/cm(2) reduction and a 10-90% range of 0-2.1. The number of positive carcasses with Enterobacteriaceae after steam vacuum pasteurisation was higher in samples where TSA+violet red bile glucose agar (VRBGA) was used compared to samples where only VRBGA was used (p<0.01). Steam vacuum pasteurisation was found efficient in reducing the total count, read as TPC, as well as the level of E. coli and Enterobacteriaceae.
Asunto(s)
Mataderos , Escherichia coli/crecimiento & desarrollo , Microbiología de Alimentos , Carne/microbiología , Pasteurización , Vapor , Vacio , Animales , Recuento de Colonia Microbiana , Enterobacteriaceae/crecimiento & desarrollo , Humanos , OvinosRESUMEN
The meat industry in Norway has developed national guidelines for Good Hygiene Practices for slaughtering and skinning, based on categorisation of animals. These include shearing sheep and lambs in the abattoirs immediately before slaughter. The aim of this study was to investigate microbiological carcass contamination associated with: (i) different shearing regimes; (ii) fleece cleanliness; and (iii) the slaughter process. In addition, the efficacy of the national guidelines in reducing microbial contamination was evaluated. A total of 280 swab samples were collected from the brisket areas (100 cm(2)) of 140 naturally contaminated lamb carcasses in a commercial abattoir. Half the samples were collected at skinning of brisket areas at the start of the slaughter-line and half of them were collected at the end of slaughter-line, just before chilling. The lambs were divided into four groups (n=35) according to the duration of the period between shearing and slaughter: (i) 0 days (shorn at the abattoir immediately before slaughter); (ii) three days; (iii) seven days; and (iv) not shorn. Mean log colony forming units (CFU) per 100 cm(2) at skinning were 5.78 and 6.95 for aerobic plate count (APC) (P<0.05), 1.65 and 2.78 for Escherichia coli (P<0.05) for shorn and unshorn lambs, respectively. For shorn lambs, divided according to the period between shearing and slaughter, the mean log CFU per 100 cm(2) were 5.45, 5.75, 6.12 (APC) and 1.77, 1.46, 1.71 (E. coli) for the 0-days, 3-days and 7-days groups, respectively (P<0.05 for the difference between 0- and 7-days groups in APC results). A four-category scale (0-3) was used for assessing fleece cleanliness before skinning. Visually clean lambs (score '0') had lower levels of APC on the carcass surfaces than those categorised as dirty (score '2-3') (P<0.05). The carcasses at the end of the slaughter-line had lower levels of APC than they had at skinning. However, the statistical significant reduction of E. coli on carcass surfaces at skinning point for shorn lambs, were impaired and no longer significantly different from the unshorn group at the end of the slaughter-line. The increased E. coli level at the end of the slaughter-line might be explained by weaknesses related to slaughter hygiene in particular suboptimal evisceration in the abattoir which was used as a basis for our trial, and thus the national guidelines concerning shearing had not the fully intended effect on reducing microbial carcass contamination.
Asunto(s)
Manipulación de Alimentos/métodos , Microbiología de Alimentos/estadística & datos numéricos , Cabello/microbiología , Carne/microbiología , Mataderos/normas , Mataderos/estadística & datos numéricos , Animales , Recuento de Colonia Microbiana , Escherichia coli/crecimiento & desarrollo , Escherichia coli/aislamiento & purificación , Humanos , Higiene , Noruega , Ovinos/microbiologíaRESUMEN
Although hot water pasteurisation of carcasses is accepted as a general intervention in USA, this is not the case in Europe. The aims of this study were (i) to evaluate the microbiological effects of hot water pasteurisation of lamb carcasses, both after slaughtering and dressing and following subsequent chilling and storage; (ii) to discuss hot water pasteurisation from a public health and cost-benefit perspective; (iii) to discuss the benefits of hot water pasteurisation compared with use of separate meat processing streams for high-risk carcasses; (iv) to evaluate the use of recycled hot water in a hygienic context and in relation to EU regulations; and (v) to consider the technological and sensory aspects of hot water pasteurisation of lamb carcasses. Samples were collected from 420 naturally contaminated lamb carcasses, with 50% of the carcasses (n=210) subject to hot water pasteurisation at 82 °C for 8s immediately after slaughter. Surface swab samples from 4500 cm² areas on carcasses were collected at slaughter, after chilling for 24 h, and after chilling for five days. The microbial analyses included Escherichia coli, Enterobacteriaceae, Bacillus cereus, Clostridium perfringens and aerobic plate count (APC). A resuscitation step using Tryptone Soya Agar was included in the microbiological analyses. Hot water pasteurisation significantly reduced the levels of E. coli, Enterobacteriaceae, B. cereus and APC (all P<0.001). E. coli colony forming unit (CFU) reduction was 99.5%, corresponding to a reduction of 1.85 log CFU per carcass. E. coli was isolated from 66% of control carcasses and from 26% of pasteurised carcasses. After 24h storage, the reduction in E. coli was increased to 2.02 log, and after five days E. coli could not be isolated from the pasteurised carcasses. These results suggest that surface pasteurisation could be an important and efficient procedure (critical control point) for reducing generic E. coli and thereby shiga toxin-producing E. coli on carcasses, and thus the risk for disease among consumers. The recycled water had acceptable physical and chemical parameters and no spore-forming bacteria were detected. Although some carcass discolouration was observed, after 24h the colour was acceptable. Our data provide relevant input for some of the data gaps regarding hot water pasteurisation and indicate that replacing the expensive system of separate processing of high-risk carcasses with hot water surface pasteurisation should be considered as a serious option.
Asunto(s)
Enterobacteriaceae/crecimiento & desarrollo , Escherichia coli/crecimiento & desarrollo , Microbiología de Alimentos/métodos , Calor , Carne/microbiología , Agua , Animales , Recuento de Colonia Microbiana , Análisis Costo-Beneficio , Enterobacteriaceae/aislamiento & purificación , Escherichia coli/aislamiento & purificación , Europa (Continente) , Contaminación de Alimentos/economía , Contaminación de Alimentos/prevención & control , Microbiología de Alimentos/economía , Oveja DomésticaRESUMEN
Abattoirs have to enumerate Escherichia coli on carcass surfaces as part of compulsory HACCP monitoring and they therefore need rapid and reliable methods. The objective of this study was to compare a conventional plating method with a faster, simpler method for detection and enumeration of E. coli in samples from naturally contaminated carcasses. The two methods were the conventional pour plate method of the Nordic Committee on Food Analysis; NMKL Method No. 125, and the enzymatic method of SimPlate Coliforms &E. coli. Materials were 588 cotton-cloth samples used for swabbing 100 cm(2) areas on four sites on cattle and lamb carcasses in three commercial abattoirs in Norway. E. coli was detected by at least one of the methods in 270 (46%) of the samples. Forty-five samples (8%) were positive only by SimPlate while 28 samples (5%) were positive only by NMKL125. Cohen's kappa value was 0.74 for detection/non-detection results, which showed a high level of agreement between the two methods. E. coli counts determined by the conventional NMKL125 method showed a high concordance correlation (ccc 0.80, slope 0.99) with most probable number (MPN) values obtained with SimPlate. SimPlate is a rapid and reliable method for detection and enumeration of E. coli and a suitable alternative method for use with swab samples from cattle and lamb carcasses.
Asunto(s)
Recuento de Colonia Microbiana/métodos , Escherichia coli/crecimiento & desarrollo , Carne/microbiología , Mataderos , Animales , Bovinos , Escherichia coli/aislamiento & purificación , Contaminación de Alimentos/análisis , Noruega , OvinosRESUMEN
The aims of this study were to investigate the patterns of fungal growth on dry-cured meat products, identify the important sources and factors of contamination and recommend intervention measures. The production processes of two smoked dry-cured hams and one unsmoked dry-cured leg of lamb were studied. A longitudinal observational study was performed to collect 642 samples from the meat, production materials, room installations and indoor and outdoor air of the production facility. Standard mycological isolation and identification procedures were followed. Totally, 901 fungal isolates were obtained; of which 57% were moulds while 43% were yeast. Yeasts were dominant on meat surfaces by covering 64% of the isolates. Mould growth was not observed until late in the dry-ripening stage. Yeasts and moulds were isolated from half of the environmental samples, of which moulds contributed by 80%. More than 39 mould species were isolated from the entire production process with a 77% contribution by the species of Penicillium. Penicillium nalgiovense dominated the species composition of moulds isolated from the products and the production environment. A preliminary bioassay analysis on bacterial colonies indicated that most of the P. nalgiovense isolates have the ability to produce penicillin. Such isolates might produce penicillin on the products and can become potential food safety hazards. Improper pressing at the salting process, the air quality in salting, brining and smoking rooms and activities in the sorting room were identified as important factors and sources of fungal contamination. Technical solutions and organized production activities that reduce crack formation, airborne spore concentration and improve air circulation in the facility are recommended as intervention measures.
Asunto(s)
Contaminación de Alimentos/análisis , Industria de Procesamiento de Alimentos , Hongos/crecimiento & desarrollo , Hongos/aislamiento & purificación , Productos de la Carne/microbiología , Hongos/clasificación , Hongos/genéticaRESUMEN
This study investigate the diversity and dynamics of yeasts in the production processes of one unsmoked and two smoked dry-cured meat products of a Norwegian dry-cured meat production facility. A longitudinal observational study was performed to collect 642 samples from the meat, production materials, room installations and indoor and outdoor air of the production facility. Nutrient rich agar media were used to isolate the yeasts. Morphologically different isolates were re-cultivated in their pure culture forms. Both classical and molecular methods were employed for species identification. Totally, 401 yeast isolates belonging to 10 species of the following six genera were identified: Debaryomyces, Candida, Rhodotorula, Rhodosporidium, Cryptococcus and Sporidiobolus. Debaryomyces hansenii and Candida zeylanoides were dominant and contributed by 63.0% and 26.4% respectively to the total isolates recovered from both smoked and unsmoked products. The yeast diversity was higher at the pre-salting production processes with C. zeylanoides being the dominant. Later at the post-salting stages, D. hansenii occurred frequently. Laboratory studies showed that D. hansenii was more tolerant to sodium chloride and nitrite than C. zeylanoides. Smoking seems to have a killing or a temporary growth inhibiting effect on yeasts that extend to the start of the drying process. Yeasts were isolated only from 31.1% of the environmental samples. They belonged to six different species of which five of them were isolated from the meat samples too. Debaryomyces hansenii and Rhodotorula glutinis were dominant with a 62.6% and 22.0% contribution respectively. As none of the air samples contained D. hansenii, the production materials and room installations used in the production processes were believed to be the sources of contamination. The dominance of D. hansenii late in the production process replacing C. zeylanoides should be considered as a positive change both for the quality and safety of the products, as C. zeylanoides has been documented as an emerging pathogen.
Asunto(s)
Manipulación de Alimentos/métodos , Microbiología de Alimentos , Productos de la Carne/microbiología , Levaduras/aislamiento & purificación , Animales , Biodiversidad , Recuento de Colonia Microbiana , Equipos y Suministros/microbiología , Contaminación de Alimentos/análisis , Humanos , Noruega , Humo , Cloruro de Sodio , Nitrito de Sodio , Levaduras/crecimiento & desarrolloRESUMEN
Dry-cured meat production has a long tradition in Norway. However, uncontrolled mould growth on the surface of the dry-cured meat products is causing significant quality problems. As some moulds are mycotoxigenic, their growth on the dry-cured meat products could also pose a serious health risk. Such quality problems and potential health risks can be better handled if the types of moulds growing on the products are known. In total, 161 samples were collected from the ripening and packaging stages of production with the aim of identifying moulds contaminating smoked and unsmoked Norwegian dry-cured meat products. Moulds were isolated either by transferring aerial mycelium of each visible mould colonies on the products or by directly plating pieces of meat on suitable agar media. The isolates were identified at a species level by a polyphasic approach. In total, 264 isolates belonging to 20 species and four fungal genera were identified. The genus Penicillium covered 88.3% of the total isolates. This genus contributed to the isolates of smoked and unsmoked products by 91% and 84% respectively. Penicillium nalgiovense was the dominant species isolated from both smoked and unsmoked products and covered 38% of the total isolates. Penicillium solitum and P. commune were the next most frequently isolated species with a contribution of 13% and 10% respectively. Species of Cladosporium and Eurotium contributed to the total isolates by 6% and 4.9% respectively. Smoking seems to affect the growth of these dominating species differently. An increase in the isolation frequency of P. nalgiovense accompanied by the reduction in the occurrence of P. solitum, P. commune and species of Cladosporium was observed on smoked products. The survey showed that the species of Penicillium are associated with Norwegian dry-cured meat products in general. Penicillium nalgiovense, the dominating mould species, is a potential producer of penicillin and its presence could represent a threat to allergic consumers.
Asunto(s)
Cladosporium/aislamiento & purificación , Eurotium/aislamiento & purificación , Contaminación de Alimentos/análisis , Conservación de Alimentos/métodos , Productos de la Carne/microbiología , Penicillium/aislamiento & purificación , Cladosporium/clasificación , Recuento de Colonia Microbiana , Medios de Cultivo , Eurotium/clasificación , Fermentación , Microbiología de Alimentos , Noruega , Penicillium/clasificación , Filogenia , Humo , Especificidad de la EspecieRESUMEN
In this study, the occurrence of Yersinia enterocolitica on pig carcasses was compared to the occurrence of Campylobacter spp., and to the numbers of aerobic micro-organisms, coliform bacteria, thermotolerant coliform bacteria, and Escherichia coli before and after blast chilling. Y. enterocolitica O:3/biovar 4 was isolated from five (8.3%) of 60 carcasses before blast chilling, and also from five of them 1 h after blast chilling. Therefore this procedure does not seem to have a significant effect on the occurrence of pathogenic Y. enterocolitica on pig carcasses. Y. enterocolitica O:9/biovar 2 was isolated from a pig source in Norway for the first time when this sero/biovariant was isolated from one of the carcasses before blast chilling. Campylobacter spp. was isolated from 34 (56.7%) of 60 carcass samples before blast chilling. After blast chilling Campylobacter spp. was isolated from only one (1.7%) of the 60 carcasses. There was a significant decrease of the numbers of coliform bacteria, thermotolerant coliform bacteria and E. coli after blast chilling. The number of aerobic micro-organisms did not decrease after this step. In contrast to the drastic decrease in the occurrence of campylobacter-positive carcasses and the significant decrease of the numbers of coliform bacteria, thermotolerant coliform bacteria and E. coli, blast chilling does not seem to have a significant effect on the occurrence of human pathogenic Y. enterocolitica on pig carcasses.
Asunto(s)
Campylobacter/aislamiento & purificación , Frío , Contaminación de Alimentos/análisis , Manipulación de Alimentos/métodos , Porcinos/microbiología , Yersinia enterocolitica/aislamiento & purificación , Mataderos , Animales , Campylobacter/crecimiento & desarrollo , Recuento de Colonia Microbiana , Seguridad de Productos para el Consumidor , Microbiología de Alimentos , Humanos , Higiene , Yersinia enterocolitica/crecimiento & desarrolloRESUMEN
Pork products are a substantial source of human yersiniosis, a foodborne disease caused by Yersinia enterocolitica. Thus, the ability to eliminate this agent from pig herds would be an important step in producing human pathogen-free pork. Pig herds free from Y. enterocolitica O:3/biovar 4 have been established and maintained. According to serologic and cultural testing results, 15 of 16 specific pathogen-free herds were free from Y. enterocolitica O:3/biovar 4; this closed breeding pyramid has remained free from this organism since 1996. Pig herds free from human pathogenic Y. enterocolitica suggest that human pathogen-free herds could be attained to provide pork free from zoonotic agents.
Asunto(s)
Organismos Libres de Patógenos Específicos , Porcinos/microbiología , Yersinia enterocolitica/aislamiento & purificación , Animales , Anticuerpos Antibacterianos/sangre , Humanos , Porcinos/sangre , Porcinos/inmunologíaRESUMEN
This study was performed to evaluate testing methods of pathogenic Yersinia enterocolitica in pigs at different ages. Relevant tools and procedures are crucial if pig herds should be declared free from pathogenic Y. enterocolitica. Historical data based on serology showed that the two farms investigated in this study (herds A and B) were contaminated with Y. enterocolitica O:3 since at least 1995. Laboratory investigations of 60 pigs were sampled one to four times (herd A) and 20 pigs were sampled one to three times (herd B) at different ages were the basis for this report. The following testing procedures could be used to conclude that a herd is free from pathogenic Y. enterocolitica:--serological testing of pigs could be performed as a basis for categorisation for all ages from about 100 days including at slaughter when the pigs are 150-180 days old, --bacteriological examination of faeces could be used as a basis for categorisation at all ages from 85 days until about 135 days, --bacteriological examination of tonsils could be used as a basis for categorisation at all ages from 85 days including at slaughter when the pigs are 150-180 days old. However, due to animal welfare aspects, one should avoid sampling of tonsils. Accordingly, the serological method or bacteriological examination of faeces at relevant ages should be preferred. One aspect related to slaughter hygiene is that in pigs slaughtered at the age of 135 days or more, the tonsils may be a more significant source of human pathogenic Y. enterocolitica than faeces.
Asunto(s)
Seguridad de Productos para el Consumidor , Carne/microbiología , Enfermedades de los Porcinos/diagnóstico , Yersinia enterocolitica/aislamiento & purificación , Mataderos , Animales , Reservorios de Enfermedades/microbiología , Reservorios de Enfermedades/veterinaria , Heces/microbiología , Microbiología de Alimentos , Humanos , Tonsila Palatina/microbiología , Sensibilidad y Especificidad , Porcinos , Yersinia enterocolitica/inmunologíaRESUMEN
Compared with traditional boning of split refrigerated carcasses, hot boning of intact carcasses (the removal of meat from the skeleton prerigor) provides several commercially important cuts, may improve quality and reduce refrigeration costs, and may reduce the contamination of carcasses with central nervous system (CNS) tissue. In a comparative study of hot boning of intact and split carcasses, the CNS tissue contamination of intact carcasses was negligible (as measured with the CNS-related proteins glial fibrillary acidic protein and S-100 protein), but split carcasses were highly contaminated. The same trends were observed for dissection worktables used during the boning process. Most current boning plants have processing lines that are organized for boning carcass quarters, where the carcasses, in addition to transversal division, also are split horizontally. This part of the boning process was incorporated in the design of our study. Nine of the 18 intact carcasses were split horizontally between thoracic vertebrae 10 and 11 before they were hot boned. CNS tissue contamination was not detected on the carcass site related to this procedure. The amount of CNS tissue contamination was similar in boned cuts and minced meat from split and intact carcasses, except in the forerib. Boning of split carcasses appears to reduce CNS tissue contamination significantly to a level comparable to that of intact hot-boned carcasses.
Asunto(s)
Seguridad de Productos para el Consumidor , Contaminación de Alimentos/prevención & control , Manipulación de Alimentos/métodos , Proteína Ácida Fibrilar de la Glía/análisis , Carne/análisis , Animales , Bovinos , Industria de Procesamiento de Alimentos/métodos , Industria de Procesamiento de Alimentos/normas , Proteína Ácida Fibrilar de la Glía/aislamiento & purificación , Humanos , Productos de la Carne/análisis , Sensibilidad y EspecificidadRESUMEN
We have investigated the molecular epidemiology of Listeria monocytogenes from the meat processing industry producing cold cuts and from cases of human listeriosis by discriminative pulsed-field gel electrophoresis (PFGE). A subset of the isolates was also investigated for susceptibility to a disinfectant based on quaternary ammonium compounds (QAC) frequently used in the meat processing industry. The purpose of this investigation was to obtain knowledge of sources, routes of contamination and genetic types of L. monocytogenes present along the production line in the meat processing industry, and to compare meat industry isolates and human isolates. Of the 222 isolates from four meat-processing plants, 200 were from two plants responsible for nearly 50% of the production of cold cuts in the Norwegian market. The strain collection included historical routinely sampled isolates (1989-2002) and isolates systematically sampled through a one year period (November 2001 to November 2002) from fresh meat and production environments in three plants. No isolates were obtained in samples from employees (throat, faeces). Human strains included all available reported isolates from Norwegian patients in selected time periods. The L. monocytogenes PFGE data showed a large genetic heterogeneity, with isolates separated into two genetic lineages and further subdivided into 56 different PFGE profiles. Certain profiles were observed on both sides of production (before and after heat treatment) indicating contamination of end products by fresh meat or fresh meat environments. While fresh meat isolates almost exclusively grouped within lineage I, isolates from end products showed a more balanced distribution between lineages I and II. Ten profiles were common among isolates from human and meat industry. Typing of human isolates identified a previously unrecognised outbreak. Generally, a higher QAC resistance incidence was observed among isolates from the meat processing industry than among human isolates although large plant to plant differences were indicated. No correlation between resistance and PFGE profile or resistance and persistence was observed.
Asunto(s)
Desinfectantes/farmacología , Manipulación de Alimentos/métodos , Industria de Procesamiento de Alimentos/normas , Listeria monocytogenes , Productos de la Carne/microbiología , Compuestos de Amonio Cuaternario/farmacología , Animales , Farmacorresistencia Bacteriana , Electroforesis en Gel de Campo Pulsado , Contaminación de Alimentos/análisis , Humanos , Listeria monocytogenes/efectos de los fármacos , Listeria monocytogenes/genética , Listeria monocytogenes/aislamiento & purificación , Pruebas de Sensibilidad MicrobianaRESUMEN
The agreements between various culturing-method combinations and specimens to detect sheep naturally infected by Salmonella enterica IIIb 61:k:1,5,(7) were tested. Rectal swabs, faecal samples and ileo-caecal lymph nodes were collected from each individual. Rectal swabs called "group I" (n = 54) were cultured directly on selective media (selenite cysteine, SC). Rectal swabs called "group II" (n = 47) were pre-incubated in buffered peptone water. The four other combinations of culturing-method and specimen (one lymph node and three faecal) in each of the two groups were cultured directly on SC. The results from all the combinations of method and specimens were compared to the result from the rectal-swab test by kappa and McNemar's chi-square. Kappas for the agreement between rectal swabs and faecal sample tests were only 0.4. The lymph-node test agreed even-more poorly, with mean kappa value -0.02. The McNemar's test revealed that the discordancies between the rectal-swab test and all of the other tests went in both directions but sometimes did show bias (directionality) in the discordancies.
Asunto(s)
Técnicas Bacteriológicas/veterinaria , Salmonelosis Animal/microbiología , Salmonella enterica/aislamiento & purificación , Enfermedades de las Ovejas/microbiología , Animales , Técnicas Bacteriológicas/métodos , Técnicas Bacteriológicas/normas , Ciego/microbiología , Heces/microbiología , Femenino , Íleon/microbiología , Ganglios Linfáticos/microbiología , Noruega/epidemiología , Recto/microbiología , Reproducibilidad de los Resultados , Salmonelosis Animal/epidemiología , Salmonella enterica/clasificación , Ovinos , Enfermedades de las Ovejas/epidemiologíaAsunto(s)
Mataderos , Carne/microbiología , Enfermedades de los Porcinos/microbiología , Porcinos/microbiología , Yersiniosis/veterinaria , Yersinia enterocolitica , Agricultura/métodos , Animales , Manipulación de Alimentos , Yersiniosis/diagnóstico , Yersinia enterocolitica/aislamiento & purificaciónRESUMEN
The purpose of the present investigation was to assess the occurrence of Yersinia enterocolitica and Campylobacter spp. in the lymphoid tissues and intestinal tract in pigs and the risk for contamination during the compulsory meat inspection procedures and the procedures during slaughtering and dressing. Another objective of the investigation was to compare traditional isolation methods, the use of a polymerase chain reaction (PCR) method (BUGS'n BEADS bacterial DNA isolation kit) and an ELISA method (VIDAS CAM) as tools in risk management in the slaughterhouse. The results indicate that the compulsory procedure for the incision of the submaxillary lymph nodes represents a cross-contamination risk for virulent Yersinia. In the screening of 97 animals in 1999, 5.2% of the samples were positive, and by the sampling of 24 samples in 2000-2001, 12.5% of the samples were positive. In the last case, Y. enterocolitica O:3 was found in the kidney region in one of the subsequent carcasses that was only touched by the meat inspection personnel before sampling. In addition, incision of the mesenteric lymph nodes might represent a cross-contamination risk since 8.3% of the samples were positive. The association between antibody titres and the occurrence of virulent yersiniae in the tonsils (21-18) was striking, with virulent yersiniae found in the tonsils in most pigs with high titres. The contents of the stomach, ileum, caecum, and colon also represent contamination risks for Y. enterocolitica O:3 if the slaughterhouse personnel cuts into the viscera with their knives by accident; the frequency of virulent Yersinia varied from 4.2% to 16.7% within these sections. Campylobacter was detected in the gastrointestinal tract of all pigs, and the high contamination of tonsils (66.7%) and intestinal tract (100%) might represent an occupational health hazard. There was no statistical difference between the traditional method for isolation of Y. enterocolitica [International Organization for Standardization, 1994. Microbiology-General Guidance for the Detection of Presumptive Pathogenic Yersinia enterocolitica (ISO 10273). International Organization for Standardization, Genève, Switzerland (16 pp.)] and the BUGS'n BEADS detection method for virulent Y. enterocolitica. Likewise, there was no statistical difference between the traditional method for isolation of Campylobacter spp. [Nordic Committee on Food Analysis, 1990. Campylobacter jejuni/coli. Detection in Food. Method No. 119, 2nd ed. Nordic Committee on Food Analysis, Esbo (7 pp.)] and the BUGS'n BEADS detection method or the VIDAS CAM method for detection of Campylobacter spp.