Treatment of Synthetic Wastewater Containing Polystyrene (PS) Nanoplastics by Membrane Bioreactor (MBR): Study of the Effects on Microbial Community and Membrane Fouling.

The persistent presence of micro- and nanoplastics (MNPs) in aquatic environments, particularly via effluents from wastewater treatment plants (WWTPs), poses significant ecological risks. This study investigated the removal efficiency of polystyrene nanoplastics (PS-NPs) using a lab-scale aerobic membrane bioreactor (aMBR) equipped with different membrane types: microfiltration (MF), commercial ultrafiltration (c-UF), and recycled ultrafiltration (r-UF) membranes. Performance was assessed using synthetic urban wastewater spiked with PS-NPs, focusing on membrane efficiency, fouling behavior, and microbial community shifts. All aMBR systems achieved high organic matter removal, exceeding a 97% COD reduction in both the control and PS-exposed reactors. While low concentrations of PS-NPs did not significantly impact the sludge settleability or soluble microbial products initially, a higher accumulation increased the carbohydrate concentrations, indicating a protective bacterial response. The microbial community composition also adapted over time under polystyrene stress. All membrane types exhibited substantial NP removal; however, the presence of nano-sized PS particles negatively affected the membrane performance, enhancing the fouling phenomena and increasing transmembrane pressure. Despite this, the r-UF membrane demonstrated comparable efficiency to c-UF, suggesting its potential for sustainable applications. Advanced characterization techniques including pyrolysis gas chromatography/mass spectrometry (Py-GC/MS) were employed for NP detection and quantification.

Validation of Recycled Nanofiltration and Anion-Exchange Membranes for the Treatment of Urban Wastewater for Crop Irrigation.

One of the alternative sources to tackle the problem of water shortage is the use of reclaimed water from wastewater treatment plants for irrigation purposes. However, when the wastewater has a high conductivity value, it becomes unusable for crop irrigation and needs a more specific treatment. In this work, recycled nanofiltration (rNF) membranes and anion-exchange membranes (rAEMs) obtained from end-of-life RO membranes were validated to evaluate their application capability in saline wastewater treatment. The use of recycled membranes may represent an advantage due to their lower cost and reduced environmental impact associated with their production, which integrates membrane-based technology into a circular economy model. Both recycled membranes were tested in crossflow filtration and electrodialysis (ED) systems. The results of the rNF membrane showed a high selective rejection of divalent ions (SO42− (>96%) and Ca2+ and Mg2+ (>93%)). In the case of the ED process, the comparison between rAEMs and commercial membranes showed an appropriate demineralization rate without compromising the power consumption. Finally, the quality of both system effluents was suitable for irrigation, which was compared to the WHO guideline and validated by the 7-week lettuce crop study.