RESUMEN
Size-dependent phenomena at the nanoscale influence many applications, notably in the science of heterogeneous catalysis. In cobalt-based Fischer-Tropsch synthesis (FTS), the size of Co nanoparticles (NPs) dictates to a high degree catalyst's performance in terms of activity, selectivity, and stability. Here, a highly dispersed Re/Co/γ-Al2O3 catalyst with high Co surface area per gram of catalyst was exposed to industrially relevant FTS conditions and monitored in situ by synchrotron X-ray radiation. X-ray absorption near-edge structure spectra were obtained on the cobalt K edge and Re L3 edge of the working catalyst. The experimental results demonstrate development of tetrahedrally coordinated Co2+ forming at the expense of metallic Co(0). The structure of the oxide resembles CoAl2O4 and appears at the onset (first 5-10 h) of the reaction. Reoxidation of Co(0) is more pronounced close to the outlet of the reactor, where higher pH2O is anticipated. The state of the Re promoter does not change during the FT process. We propose that reoxidation of small Co NPs is followed by spreading of Co oxide that leads to the formation of CoxAlyOz phases. Hence, in order to avoid an irreversible loss of the active phase during process start-up, catalyst design should be restricted to Co NPs larger than 5.3 nm.
RESUMEN
Cobalt-based Fischer-Tropsch systems are widely used to convert synthesis gas to clean hydrocarbon fuel. However, surprisingly little is known about the morphology of the catalysts on the nanoscale. Here we show that scanning transmission electron tomography reveals their true 3-D morphology and provides direct evidence that the support controls the final morphology of the catalyst. Such direct local three-dimensional measurements provide unprecedented insight into catalysis, and can henceforth transform our understanding of these complex materials.
RESUMEN
Ethene polymerization with bis(2-dimethylsilyl-indenyl)zirconium(IV) dichloride (1)/MAO and bis(2-trimethylsilyl-indenyl)zirconium(IV) dichloride (2)/MAO and ethene-co-1-hexene polymerization with 1/MAO are presented. The end group analysis of homopolymers reveals a pronounced dependence of the termination rate on temperature changes. In combination with the high molecular weights obtained, these results are in accord with theoretical predictions. Gel permeation chromatography, Fourier transform infrared, and 13C NMR analyses of copolymerization products from 1/MAO as a function of comonomer concentration at two different temperature series denote its tendency to form inhomogeneous polymer blends. Thermal analysis and fractionation results of one such blend indicate an inhomogeneity in the enchainment process and the existence of multiple active sites of differing geometry. These indications are further supported by AMBER force field and density functional theory studies of the catalyst precursors and the active site of 1/MAO. For this system, delta-agostic interactions for the stabilization of the zirconium cation are favored over beta-agostic interactions, which, in contrast to the situation in studies on bis-Cp systems, is a sparsely populated species. The gap in activation enthalphies for beta-hydride transfer and elimination is marginalized for these bulky zirconocenes, and conceptually new mechanisms for the isomerization of the vinyl end groups are discussed. Further, unexpected activation of the silicon-hydrogen bond within the ligand framework is observed with an activation enthalpy as low as 14 kcal/mol.
RESUMEN
Binary mixtures of Cp2ZrMe2, Cp2ZrCl2, dimethylaluminum chloride, trimethylaluminum, and methylaluminoxane (MAO), as well as Cp2ZrMe2 with boron-based activators, have been studied by in situ IR spectroscopy (Cp = cyclopentadienyl, Me = methyl). The position of a strong band near 800 cm(-1), corresponding to the out-of-plane vibration of the Cp hydrogen atoms, is sensitive to the bonding environment around Zr and can be used to monitor reactions and the formation of new products in these mixtures. Harmonic frequencies determined by density functional theory correlate well with experimental values and have been used to assist in the interpretation of the data. The frequency of the Cp out-of-plane vibration, ranging from 797 to 832 cm(-1) in our experiments, is found to increase with increasing electron density on the Cp ring and decreasing Zr-Cp distance. In the mixture of MAO and Cp2ZrMe2, a stable complex is rapidly formed at low Al/Zr ratios. A mechanism that may explain the need for a large MAO excess is proposed for the activation of metallocenes with MAO. The proposed mechanism involves the formation of dimers or oligomers of MAO cages that tend to dissipate the charge of the anion. This destabilization of the Cp2ZrMe2-MAO complex facilitates the formation of the catalytically active cation.
