The effect of operational conditions on the hydrodynamic characteristics of the sludge bed in UASB reactors.

This work aims to evaluate the hydrodynamic properties of the sludge bed of Upflow Anaerobic Sludge Blanket (UASB) reactors based on its settleability and expansion characteristics. The methodologies used for the evaluation of the settleability of aerobic activated sludge, and for the expansibility of a sludge bed of Expanded Granular Sludge Bed reactors and Fluidised Bed Reactors were adapted and applied to the particular characteristics of the sludge of UASB reactors. An easy-to-build experimental set-up was developed to assess the parameters necessary for the equations of settleability and of expansibility. The results obtained from the sludges of seven differently operated reactors show that, for the treatment of low strength wastewater, settleability increased and expansibility decreased at decreased hydraulic retention time, from 6 to 1 h, and/or increased influent concentrations, from 136 to approximately 800 mg chemical oxygen demand/L. The results also show that it is useless to design an UASB reactor with a longer hydraulic retention time to cope with hydraulic shock loads, as a more expansible sludge will develop at such condition.

The effect of operational conditions on the sludge specific methanogenic activity and sludge biodegradability.

The effects of hydraulic retention time (HRT) and influent COD concentration (CODInf) on Specific Methanogenic Activity (SMA) and the biodegradability of an anaerobic sludge need to be elucidated because of the discordant results available in literature. This information is important for the operation of anaerobic reactors and design of the sludge post-treatment unit. For this study, sludge samples obtained from eight pilot-scale Upflow Anaerobic Sludge Blanket (UASB) reactors were tested. The reactors were fed with municipal wastewater and operated with different sets of HRT and influent concentrations until the steady state was established. The results show that at a lower HRT, sludge with relatively higher SMA develops. A slight trend of declining SMA at increasing CODInf was found for reactors operated at longer HRTs; however, further experiments are necessary for more definitive conclusions. The sludge from reactors operated at longer HRTs and with lower CODInf resulted in lower biodegradability. Results also showed that it is ineffective to design a UASB reactor with a longer HRT to cope with organic shock loads.

The effects of hydraulic and organic shock loads on the robustness of upflow anaerobic sludge blanket reactors treating sewage.

In this investigation, the robustness and stability of UASB reactors was evaluated on the basis of four indicators: (i) COD removal efficiency; (ii) effluent variability; (iii) pH stability; and (iv) recovery time. The experiments were carried out using six pilot-scale UASB reactors fed with domestic sewage and operated under different operational conditions. After establishment of a "steady-state", organic and hydraulic shock loads (six times the loading rate during six hours) were imposed. The results show that the UASB reactors are robust systems with regards to COD removal efficiency and pH stability when exposed to shock loads. However, this reactor cannot attenuate the imposed fluctuation in the influent COD. A secondary treatment unit is needed to retain the expelled sludge occurring as a result of a hydraulic shock load, or prior to the shock, a sufficient amount of sludge needs to be discharged from the reactor.