Double emulsions to improve frankfurter lipid content: impact of perilla oil and pork backfat.

BACKGROUND: The technology involving the use of water-in-oil-in-water double emulsions (DEs) offers an interesting approach to improve the fat content of foods. With this aim, the effect on frankfurter properties of replacing pork backfat with two different DEs prepared using perilla oil and pork backfat as lipid phases was assessed. This strategy was compared with straightforward addition of the lipid source and addition by means of an oil-in-water (O/W) emulsion. RESULTS: As compared with all-pork-fat frankfurters, the ones with perilla oil had a higher proportion of n-3 polyunsaturated fatty acids. Reduced-fat frankfurters had similar water- and fat-binding properties irrespective of the lipid source or the technological strategy used to incorporate it. Moreover, the oil source but not its mode of incorporation determined the oxidation levels of frankfurters. In reduced-fat samples, except in the case of frankfurters formulated with a perilla oil-in-water emulsion, hardness was unaffected either by the type of fat or by its mode of incorporation. The replacement of pork backfat by perilla oil reduced the overall acceptability of products when perilla oil was added by means of the O/W emulsion and DE approaches. CONCLUSION: This technology is suitable for labelling meat products with specific nutritional and health claims.

Antigenicity of Anisakis simplex s.s. L3 in parasitized fish after heating conditions used in the canning processing.

BACKGROUND: Some technological and food processing treatments applied to parasitized fish kill the Anisakis larvae and prevent infection and sensitization of consumers. However, residual allergenic activity of parasite allergens has been shown. The aim here was to study the effect of different heat treatments used in the fish canning processing industry on the antigen recognition of Anisakis L3. Bigeye tuna (Thunnus obesus) and yellowfin tuna (Thunnus albacares) were experimentally infected with live L3 Anisakis. After 48 h at 5 ± 1 °C, brine was added to the muscle, which was then canned raw (live larvae) or heated (90 °C, 30 min) (dead larvae) and treated at 113 °C for 60 min or at 115 °C for 90 min. Anisakis antigens and Ani s 4 were detected with anti-crude extract and anti-Ani s 4 antisera respectively. RESULTS: Ani s 4 decreased in all lots, but the muscle retained part of the allergenicity irrespective of the canning method, as observed by immunohistochemistry. Dot blot analysis showed a high loss of Ani s 4 recognition after canning, but residual antigenicity was present. CONCLUSION: The results indicate that heat treatment for sterilization under the conditions studied produces a decrease in Ani s 4 and suggest a potential exposure risk for Anisakis-sensitized patients.

Viability and antigenicity of anisakis simplex after conventional and microwave heating at fixed temperatures.

Inactivation of parasites in food by microwave treatment may vary due to differences in the characteristics of microwave ovens and food properties. Microwave treatment in standard domestic ovens results in hot and cold spots, and the microwaves do not penetrate all areas of the samples depending on the thickness, which makes it difficult to compare microwave with conventional heat treatments. The viability of Anisakis simplex (isolated larvae and infected fish muscle) heated in a microwave oven with precise temperature control was compared with that of larvae heated in a water bath to investigate any additional effect of the microwaves. At a given temperature, less time was required to kill the larvae by microwaves than by heated water. Microwave treatment killed A. simplex larvae faster than did conventional cooking when the microwaves fully penetrated the samples and resulted in fewer changes in the fish muscle. However, the heat-stable allergen Ani s 4 was detected by immunohistochemistry in the fish muscle after both heat treatments, even at 70°C, suggesting that Ani s 4 allergens were released from the larvae into the surrounding tissue and that the tissues retained their allergenicity even after the larvae were killed by both heat treatments. Thus, microwave cooking will not render fish safe for individuals already sensitized to A. simplex heat-resistant allergens.

Sugarcane glycoproteins may act as signals for the production of xanthan in the plant-associated bacterium Xanthomonas albilineans.

Visual symptoms of leaf scald necrosis in sugarcane (Saccharum officinarum) leaves develop in parallel to the accumulation of a fibrous material invading exocellular spaces and both xylem and phloem. These fibers are produced and secreted by the plant-associated bacterium Xanthomonas albilineans. Electron microscopy and specific staining methods for polysaccharides reveal the polysaccharidic nature of this material. These polysaccharides are not present in healthy leaves or in those from diseased plants without visual symptoms of leaf scald. Bacteria in several leaf tissues have been detected by immunogold labelling. The bacterial polysaccharide is not produced in axenic culture but it is actively synthesized when the microbes invade the host plant. This finding may be due to the production of plant glycoproteins after bacteria infection, which inhibit microbial proteases. In summary, our data are consistent with the existence of a positive feedback loop in which plant-produced glycoproteins act as a cell-to-bacteria signal that promotes xanthan production, by protecting some enzymes of xanthan biosynthesis against from bacterial proteolytic degradation. 

Low-fat frankfurters formulated with a healthier lipid combination as functional ingredient: microstructure, lipid oxidation, nitrite content, microbiological changes and biogenic amine formation.

Oil (healthier lipid combination of olive, linseed and fish oils)-in-water emulsions stabilized with different protein systems (prepared with sodium caseinate (SC), soy protein isolate (SPI), and microbial transglutaminase (MTG)) were used as pork backfat replacers in low-fat frankfurters. Microstructure, lipid oxidation, nitrite content, microbiological changes and biogenic amine formation of frankfurters were analyzed and found to be affected by the type of oil-in-water emulsion and by chilling storage (2° C, 41 days). Although the lipid oxidation levels attained were low, replacement of animal fat by healthier oil combinations in frankfurter formulation did promote a slight increase in lipid oxidation. Residual nitrite was affected (P < 0.05) by formulation and storage. Only 51-61% of the added nitrite was detectable in the product after processing and 17-46% at the end of storage. The microbial population was low in all formulations during chilling storage. Spermine was the most abundant amine (19-20 mg/kg), but similar in level to all samples.

Antigenicity and viability of Anisakis larvae infesting hake heated at different time-temperature conditions.

Heat treatments (40 to 94 degrees Celsius, 30 s to 60 min) were applied to different batches of Anisakis simplex L3 larvae isolated from hake ovaries and viscera to study the effect of heat on the viability of the larvae measured as mobility, emission of fluorescence under UV light, and changes in color after staining with specific dyes, and on A. simplex antigenic proteins. The aim was to determine the lowest time-temperature conditions needed to kill the larvae to avoid anisakiasis in consumers, and to evaluate whether high temperature modifies the antigenicity of A. simplex extracts. Heating at 60 degrees Celsius for 10 min (recommended by some authors) was considered unsafe, as differences in viability between batches were found, with some larvae presenting spontaneous movements in one batch. At higher temperatures (> or = 70 degrees Celsius for > or = 1 min), no movement of the larvae was observed. Antigenic protein Ani s 4 and A. simplex crude antigens were detected in the larvae heated at 94 + or - 1 degrees Celsius for 3 min. This indicates that allergic symptoms could be provoked in previously sensitized consumers, even if the larvae were killed by heat treatment.

Scanning electron microscopy of Anisakis larvae following different treatments.

Ingestion of fish parasitized with Anisakis larvae can produce infestation and/or allergy in consumers. Technological and food processing treatments have been applied to parasitized fish in order to kill the larvae and avoid the infestation; however, their influence on allergenicity has not been studied. Four lots of hake (Merluccius merluccius) steaks artificially parasitized with Anisakis larvae were subjected to two storage chilling (5 degrees C +/- 1 degrees C) and freezing (-20 degrees C +/- 1 degrees C) treatments and two food processing treatments of heat (final temperature 86.3 degrees C) and microwave (final temperature 66.9 degrees C) and studied by scanning electron microscopy, environmental scanning electron microscopy (ESEM) (acid [pH = 2] and water preparations), and emission of fluorescence. Anisakis larvae were resistant to acid conditions, remaining alive after treatment. Larvae in the heat- and microwave-treated lots presented coagulated and disrupted zones in the cuticle with release of fluids. The cylindrical shape changed to a dehydrated appearance mainly observed by ESEM. Fluorescence was only noticeable in the frozen larvae. Larvae without apparent changes, together with dehydrated ones, were observed by ESEM in the frozen lot; nevertheless, no disruptions in the cuticle were perceptible. Further studies are needed in order to elucidate if the changes observed in the cuticle reduce the resistance of the parasites to the action of gastric enzymes in the gastrointestinal tract and to determine the release of allergens to the flesh by the live larvae during chilled storage of the fish.

Gluconacetobacter diazotrophicus, a sugar cane endosymbiont, produces a bacteriocin against Xanthomonas albilineans, a sugar cane pathogen.

Gluconacetobacter diazotrophicus in liquid culture secretes proteins into the medium. Both medium containing Gluconacetobacter protein and a solution of this protein after acetone precipitation appeared to inhibit the growth of Xanthomonas albilineans in solid culture. This apparent inhibition of bacterial growth has, in fact, been revealed to be lysis of bacterial cells, as demonstrated by transmission electron microscopy. Fractionation of the Gluconacetobacter protein mixture in size-exclusion chromatography reveals a main fraction with lysozyme-like activity which produces lysis of both living bacteria and isolated cell walls.