Distribution of molybdenum in soft tissues and blood of rats after intratracheal instillation of molybdenum(IV) sulfide nano- and microparticles.

There is still little literature data on the toxicity and safety of the commonly used molybdenum (Mo) disulfide which is present in the working as well as living environments. Thus, an experiment was carried out involving rats, with single and repeated intratracheal exposure (in the latter case, 7 administrations at 2-week intervals with the analysis performed after 90 days) to lower (1.5 mg Mo kg-1 b.w.) and higher (5 mg Mo kg-1 b.w.) doses of molybdenum(IV) sulfide nanoparticles (MoS2-NPs) and microparticles (MoS2-MPs). The analysis of Mo concentrations in the tail and heart blood as well as in soft tissues (lung, liver, spleen, brain), after mineralization and bioimaging, was meant to facilitate an assessment of its accumulation and potential effects on the body following short- and long-term exposure. The multi-compartment model with an exponential curve of Mo concentration over time with different half-lives for the distribution and elimination phases of MoS2-MPs and MoS2-NPs was observed. After 24 h of exposure, a slight increase in Mo concentration in blood was observed. Next, Mo concentration indicated a decrease in blood concentration from 24 h to day 14 (the Mo concentration before the second administration), below the pre-exposure concentration. The next phase was linear, less abrupt and practically flat, but with an increasing trend towards the end of the experiment. Significantly higher Mo concentrations in MoS2-NPs and MoS2-MPs was found in the lungs of repeatedly exposed rats compared to those exposed to a single dose. The analysis of Mo content in the liver and the spleen tissue showed a slightly higher concentration for MoS2-NPs compared to MoS2-MPs. The results for the brain were below the calculated detection limit. Results were consistent with results obtained by bioimaging technique.

Environmental mercury exposure and selenium-associated biomarkers of antioxidant status at molecular and biochemical level. A short-term intervention study.

Mercury (Hg) is a potent toxicant. In the field of public health a chronic-low-level environmental Hg exposure resulting from fish consumption in general population is still being discussed. The objective of the study was to assess the influence of real Hg exposure on biomarkers of selenium (Se) status and selected biomarkers of pro-oxidant/anti-oxidant effects in healthy men (n = 67) who participated in the short-term intervention study consisting in daily fish consumption for two weeks. The analysis included Se level, Se-associated antioxidants at molecular (profile of 7 genes encoding selected proteins related to antioxidant defense) and biochemical levels (Se-dependent glutathione peroxidases activities and plasma selenoprotein P concentration). A pro-oxidant/anti-oxidant balance was explored using a biomarker of plasma lipid peroxidation and total antioxidant activity. The study revealed significant correlations (p < 0.05) between the biomarkers of exposure to Hg, Se level and Se-dependent antioxidants. Even though the risk of adverse effects of Hg for volunteers was substantially low, biomarkers of Hg altered levels of circulation selenoproteins and their genes expression. Changes in genes expression during study differed between the main enzymes involved in two systems: downregulation of thioredoxin reductase1 and upregulation of glutathione peroxidases. Hg exposure caused imbalance between the biomarkers of pro-oxidant/anti-oxidant effects.

Clara cells protein, prolactin and transcription factors of protein NF-ĸB and c-Jun/AP-1 levels in rats inhaled to stainless steel welding dust and its soluble form.

OBJECTIVES: Welding processes that generate fumes containing toxic metals, such as hexavalent chromium (Cr(VI)), manganese, and nickel (Ni), have been implicated in lung injury, inflammation, and lung tumor promotion in animal models. Bronchiolar epithelium Clara cells/club cells, coordinate these inflammatory responses. Clara cells secretory protein (CC16) with ant-inflammatory role. MATERIAL AND METHODS: The pulmonary toxicity of welding dust (WD) was assessed for Wistar rats exposed to 60 mg/m3 of respirable-size welding dust (mean diameter 1.17 µm for 1 and 2 weeks (6 h/day, 5 days/week)) or the aerosols of soluble form (SWD) in the nose-only exposure chambers. Additionally the effect of antiinflammatory betaine supplementation was assessed. Clara cells secretory protein, differential cell counts, total protein concentrations and cellular enzyme (lactate dehydrogenase - LDH) activities were determined in bronchoalveolar lavage fluid, and corticosterone and thiobarbituric acid reactive substances (TBARS) and prolactin concentrations were assessed in serum. Histopathology examination of lung, brain, liver, kidney, spleen was done. Additionally slices of brain and lung were exanimated in laser ablation inductively coupled plasma mass spectrometry. RESULTS: Both WD and SWD exposure evoked large bronchiolar infiltration shoved in histopathology examination. In this study, TBARS inversely correlated with a significant decrease of CC16 concentration that occurred after instillation of both WD and SWD indicating decreased anti- inflammatory potential in the lung. In WD exposed rats prolactin correlated with nuclear factor-kappa B (NF-κB), LDH, TBARS and serum levels Cr, Ni and inversely with c-Jun. In SWD exposed rats prolactin correlated with CC16 indicated effect of prolactin on the population of epithelial cells. CONCLUSIONS: In the current study, deleterious effects of repeated inhalation stainless steel welding dust form on club (Clara) cell secretory protein (CC16) were demonstrated. Clara cells secretory protein relation with prolactin in exposed rats to welding dust were shown and explored whether the NF-κB and c-Jun/activator protein 1 related pathway was involved. Int J Occup Med Environ Health 2018;31(5):613-632.

Biomarkers of selenium status and antioxidant effect in workers occupationally exposed to mercury.

The present observation based research was designed to evaluate the influence of occupational human exposure to metallic mercury (Hg°) vapor on the biomarkers of selenium status involved in the antioxidant defense system. For this purpose we determined Hg and selenium (Se) concentrations in body fluids, the markers of antioxidant effect measured as an activity of Se-dependent enzymes (red blood cell and plasma glutathione peroxidase: GPx1-RBC and GPx3-P), concentration of selenoprotein P in the plasma (SeP-P) and total antioxidant activity in the plasma (TAA-P) in 131 male workers from a chloralkali plant exposed to Hg° and 67 non-exposed males (control group). The mRNA expression levels of glutathione peroxidases (GPX1, GPX3), selenoprotein P (SEPP1), thioredoxin reductase 1 (TRXR1), thioredoxin 1 (TRX1), peroxiredoxins (PRDX1, PRDX2) were also examined in the leukocytes of peripheral blood. Hg concentration in the blood (Hg-B) and urine (Hg-U) samples was determined using the thermal decomposition amalgamation/atomic absorption spectrometry (TDA-AAS) method and Se concentrations in plasma (Se-P) and urine (Se-U) using the inductively coupled plasma mass spectrometry (ICP-MS) method. Activities of GPx1-RBC, GPx3-P and TAA-P were determined using the kinetic and spectrophotometric method, respectively. Gene expression analysis was performed using the quantitative Real-Time PCR. The results showed significant higher Hg levels among the Hg°-exposed workers in comparison to control group (12-times higher median for Hg-B and almost 74-times higher median for Hg-U concentration in chloralkali workers). Se-P was also significantly higher (Me (median): 82.85 µg/L (IQR (interquartile range) 72.03-90.28 µg/L) for chloralkali workers vs. Me: 72.74 µg/L (IQR 66.25-80.14 µg/L) for control group; p = 0.0001) but interestingly correlated inversely with Hg-U in chloralkali workers suggesting depletion of the Se protection among the workers with the highest Hg-U concentration. The mRNA level for GPX1, PRXD1 were markedly but significantly higher in the workers compared to the control group. Moreover, concentrations of Hg-B and Hg-U among the workers were significantly positively correlated with the levels of selenoprotein P at both the mRNA and selenoprotein levels. In the multivariate model, after adjusting to cofounders (dental amalgam fillings, age, BMI, job seniority time, smoking), we confirmed that Hg-U concentration was inversely correlated with genes expression of TRXR1. This is the first comprehensive assessment of the impact of occupational exposure of workers to Hg° at both the mRNA and selenoprotein levels, with investigation of fish intake obtained by means of a questionnaire. These findings suggest that exposure to Hg° alters gene expression of the antioxidant enzymes and the level of Se-containing selenoproteins.

Revision of reciprocal action of mercury and selenium.

Diverse forms of mercury (Hg) have various effects on animals and humans because of a variety of routes of administration. Inorganic mercury (iHg) binds to thiol groups of proteins and enzymes in one's body or is methylated by microorganisms. Organic form of Hg, contrary to the iHg, is more stable but may be demethylated to Hg2+ in the tissue of intestinal flora. Selenium (Se) also occurs in a variety of chemical forms in one's body but both of these elements behave very differently from one another. Mercury binding to selenide or Se-containing ligands is a primary molecular mechanism that reduces toxicity of Hg. Complexes formed in such a way are irreversible, and thus, biologically inactive. Se deficiency in a human body may impair normal synthesis of selenoproteins and its expression because expression of mRNA may be potentially regulated by the Se status. This paper provides a comprehensive review concerning Hg-Se reciprocal action as a potential mechanism of protective action of Se against Hg toxicity as well as a potential detoxification mechanism. Although interactions between Hg-Se have been presented in numerous studies concerning animals and humans, we have focused mainly on animal models so as to understand molecular mechanisms responsible for antagonism better. The review also investigates what conclusions have been drawn by researchers with respect to the chemical species of Se and Hg (and their relationship) in biological systems as well as genetic variations and expression and/or activity of selenoproteins related to the thioredoxin (thioredoxin Trx/TrxR) system and glutathione metabolism. Int J Occup Med Environ Health 2018;31(5):575-592.

Effect of Arsenic Exposure on NRF2-KEAP1 Pathway and Epigenetic Modification.

Arsenic (As) is a known toxic element and carcinogen. Transcription factor nuclear factor-erythroid 2-related factor 2 (NRF2) controls cellular adaptation to oxidants and electrophiles by inducing antioxidant genes in response to redox stress. To explore associations between As level and NRF2-regulated cytoprotective genes expression, an observational study was conducted in a population of 61 occupationally exposed men with median (Me) age 50 years (interquartile range (IQR) 42-54) and in a control group of 52 men aged 40 (IQR 31-51.5) without occupational exposure. NRF2, KEAP1, GSTP1, HMOX1, NQO1, PRDX1, and TXNRD1 transcript levels were determined by means of quantitative real-time PCR along with the gene expression, methylation of NRF2 and KEAP1, as well as global DNA methylation were assessed. The median urine As tot. level in the exposed and control group was found to be 21.8 µg/g creat. (IQR 15.5-39.8 µg/g creat.) and 3.8 µg/g creat. (IQR 2.5-9.3) (p < 0.001). Global DNA methylation was significantly higher in occupationally exposed workers than in controls (Me 14.1 (IQR 9.5-18.1) vs Me 8.5 (IQR 5.9-12.6) p < 0.0001). NRF2 mRNA level was positively correlated with expression of all investigated NRF2-target genes in both groups (0.37 > R < 0.76, all p values < 0.0001). The multivariate linear regression adjusting for global methylation showed that As(III) level was significantly associated with expression of TXNRD1, GSTP1, HMOX1, and PRDX1. The results of this study indicate that arsenic occupational exposure is positively associated with global DNA methylation. The findings provide evidence for rather inactivation of NRF2-KEAP1 pathway in response to chronic arsenic exposure.

Relationship between arsenic and selenium in workers occupationally exposed to inorganic arsenic.

The interaction between arsenic (As) and selenium (Se) has been one of the most extensively studied. The antagonism between As and Se suggests that low Se status plays an important role in aggravating arsenic toxicity in diseases development. The objective of this study was to assess the Se contents in biological samples of inorganic As exposed workers (n=61) and in non-exposed subjects (n=52). Median (Me) total arsenic concentration in urine of exposed workers was 21.83µg/g creat. (interquartile range (IQR) 15.49-39.77) and was significantly higher than in the control group - (Me 3.75µg/g creat. (IQR 2.52-9.26), p<0.0001). The median serum Se concentrations in the study group and the control were: 54.20µg/l (IQR 44.2-73.10µg/l) and 55.45µg/l (IQR 38.5-69.60µg/l) respectively and did not differ significantly between the groups. In the exposed group we observed significantly higher urine concentrations of selenosugar 1 (SeSug 1) and selenosugar 3 (SeSug3) than in the control group Me: 1.68µg/g creat. (IQR 1.25-2.97 vs Me: 1.07µg/g creat. (IQR 0.86-1.29µg/g), p<0.0001 for SeSug1; Me: 0.45µg/g creat. (IQR 0.26-0.69) vs Me: 0.28µg/g creat. (IQR 0.17-0.45µg/g), p=0.0021). In the multivariate model, after adjusting to cofounders (age, BMI, job seniority time, consumption of fish and seafood and smoking habits) the high rate of arsenic urine wash out (measured as a sum of iAs+MMA+DMA) was significantly associated with the high total selenium urine excretion (B=0.14 (95%CI (confidence interval) 0.05-0.23)). Combination of both arsenic and selenium status to assess the risk of arsenic-induced diseases requires more studies with regard to both the analysis of speciation, genetics and the influence of factors such as nutritional status.

Assessment of Mercury Intake from Fish Meals Based on Intervention Research in the Polish Subpopulation.

The paper's objective was to estimate weekly Hg intake from fish meals based on intervention research. Total Hg (THg) concentrations in blood and hair samples collected from men (n = 67) from an intervention study as well as muscular tissues of fresh and after heat-treating fish were determined using the thermal decomposition amalgamation atomic absorption spectrometry method (TDA-AAS) using direct mercury analyzer (DMA-80). The mean of the estimated weekly intake (EWI) was estimated at 0.62 µg/kg bw/week in the range 0.36-0.96 µg/kg body weight (bw) /week through the consumption of 4 edible marine fish species every day (for 10 days) by the participants from the intervention research in Lodz, Poland. The Hg intake in the volunteers in our intervention study accounted for 38.6% of the provisional tolerable weekly intake (PTWI) (1.6 µg/kg bw, weekly) value. The average Hg concentration in the analyzed fish ranged from 0.018 ± 0.006 mg/kg wet weight (Gadus chalcogrammus) to 0.105 ± 0.015 mg/kg wet weight (Macruronus magellanicus). The results for the average consumers were within PTWI of methylmercury (MeHg). Moreover, the average concentration of Hg in the selected fish after heat treatment did not exceed the maximum permitted concentrations for MeHg (MPCs = 0.5 mg/kg wet weight) in food set by the European Commission Regulation (EC/1881/2006). Hence, the risk of adverse effects of MeHg for the participants is substantially low.

The time-dependent health and biochemical effects in rats exposed to stainless steel welding dust and its soluble form.

Welding processes that generate fumes containing toxic metals, such as hexavalent chromium (Cr(VI)), manganese (Mn), and nickel (Ni), have been implicated in lung injury, inflammation, and lung tumor promotion in animal models. The principal objective of this study was to determine the dynamics of toxic effects of inhalation exposure to morphologically rated welding dust from stainless steel welding and its soluble form in TSE System with a dynamic airflow. We assessed the pulmonary toxicity of welding dust in Wistar rats exposed to 60.0 mg/m3 of respirable-size welding dust (mean diameter 1.17 µm) for 2 weeks (6 h/day, 5 days/week); the aerosols were generated in the nose-only exposure chambers (NOEC). An additional aim included the study of the effect of betaine supplementation on oxidative deterioration in rat lung during 2 weeks of exposure to welding dust or water-soluble dust form. The animals were divided into eight groups (n = 8 per group): control, dust, betaine, betaine + dust, soluble-form dust, soluble-form dust + betaine, saline and saline + betaine groups. Rats were euthanized 1 or 2 weeks after the last exposure for assessment of pulmonary toxicity. Differential cell counts, total protein concentrations and cellular enzyme (lactate dehydrogenase-LDH) activities were determined in bronchoalveolar lavage (BAL) fluid, and corticosterone and thiobarbituric acid reactive substances (TBARS) concentrations were assessed in serum. The increase in polymorphonuclear (PMN) leukocytes in BAL fluid (a cytological index of inflammatory responses of the lung) is believed to reflect pulmonary toxicity of heavy metals. Biomarkers of toxicity assessed in bronchoalveolar fluids indicate that the level of the toxic effect depends mainly on the solubility of studied metal compounds; biomarkers that showed treatment effects included: total cell, neutrophil and lymphocyte counts, total protein concentrations, and cellular enzyme (lactate dehydrogenase) activity. Betaine supplementation at 250 mg/kg/day in all study rats groups attenuated stress indices, and corticosterone and TBARS serum levels, and simultaneously stimulated increase of polymorphonuclear cells in BALF of rats. The study confirmed deleterious effect of transitory metals and particles during experimental inhalation exposure to welding dusts, evidenced in the lungs and brain by increased levels of total protein, higher cellular influx, rise of LDH in BALF, elevated TBARS and increased corticosterone in serum of rats. Our result confirm also the hypothesis about the effect of the welding dusts on the oxidative stress responsible for disturbed systemic homeostasis and impairment of calcium regulation.

Biological monitoring and the influence of genetic polymorphism of As3MT and GSTs on distribution of urinary arsenic species in occupational exposure workers.

PURPOSE: To examine the differences in urinary arsenic metabolism patterns in men affected by occupational exposure, we performed a study on 149 participants­workers of a copper mill and 52 healthy controls without occupational exposure. To elucidate the role of genetic factors in arsenic (As) metabolism, we studied the associations of six polymorphisms: As3MT Met287Thr (T>C) in exon 9; As3MT A>G in 5'UTR; As3MT C>G in intron 6; As3MT T>G in intron 1; GSTP1 Ile105Val and GSTO2 T>C. METHODS: Air samples were collected using individual samplers during work shift. Urine samples were analyzed for total arsenic and arsenic chemical forms (As(III); As(V), MMA, DMA, AsB) using HPLC-ICP-MS. A specific polymerase chain reaction was done for the amplification of exons and flanking regions of As3MT and GSTs. RESULTS: The geometric mean arsenic concentrations in the air were 27.6 ± 4.9 µg/m(3). A significant correlation (p < 0.05) was observed between arsenic in air and sum of iAs +MMA and iAs. As3MT (rs3740400) GG homozygotes showed significantly (p < 0.05) higher %iAs (21.8 ± 2.0) in urine than GC+CC heterozygotes (16.0 ± 2.1). A strong association between the gene variants and As species in urine was observed for GSTO2 (rs156697) polymorphism. CONCLUSIONS: The findings of the study point out that the concentration of iAs or the sum of iAs + MMA in urine can be a reliable biological indicator of occupational exposure to arsenic. This study demonstrates that As3MT and/or GSTs genotype may influence As metabolism. Nevertheless, further studies investigating genetic polymorphism in occupational conditions are required.

Neurological and neurophysiological examinations of workers exposed to arsenic levels exceeding hygiene standards.

OBJECTIVES: The assessment of the neurotoxic effect of arsenic (As) and its inorganic compounds is still the subject of interest due to a growing As application in a large array of technologies and the need to constantly verify the principles of prevention and technological parameters. The aim of this study was to determine the status of the nervous system (NS) in workers exposed to As at concentrations exceeding hygiene standards (Threshold Limit Values (TLV) - 10 µg/m(3), Biological Exposure Index (BEI) - 35 µg/l) and to analyze the relationship between the NS functional state, species of As in urine and As levels in the workplace air. MATERIAL AND METHODS: The study group comprised 21 men (mean age: 47.43±7.59) employed in a copper smelting factory (mean duration of employment: 22.29±11.09). The control group comprised 16 men, matched by age and work shifts. Arsenic levels in the workplace air (As-A) ranged from 0.7 to 92.3 µg/m(3); (M = 25.18±28.83). The concentration of total arsenic in urine (As(tot)-U) ranged from 17.35 to 434.68 µg/l (M = 86.82±86.6). RESULTS: Syndrome of peripheral nervous system (PNS) was manifested by extremity fatigue (28.6%), extremity pain (33.3%) and paresthesia in the lower extremities (33.3%), as well as by neuropathy-type mini-symptoms (23.8%). Electroneurographic (ENeG) tests of peroneal nerves showed significantly decreased response amplitude with normal values of motor conduction velocity (MCV). Stimulation of sural nerves revealed a significantly slowed sensory conduction velocity (SCV) and decreased sensory potential amplitude. Neurophysiological parameters and the results of biological and environmental monitoring showed a relationship between As(tot), As(III) (trivalent arsenic), the sum of iAs (As(III)+As(V) (pentavalent arsenic))+MMA (monomethylarsonic acid) concentration in urine and As levels in the air. CONCLUSIONS: The results of the study demonstrate that occupational exposure to inorganic arsenic levels exceeding hygiene standards (TLV, BEI) generates disorders typical of peripheral neuropathy.

Application of high performance liquid chromatography with inductively coupled plasma mass spectrometry (HPLC-ICP-MS) for determination of chromium compounds in the air at the workplace.

The toxicity and bioavailability of chromium species are highly dependable on the form or species, therefore determination of total chromium is insufficient for a complete toxicological evaluation and risk assessment. An analytical method for determination of soluble and insoluble Cr (III) and Cr (VI) compounds in welding fume at workplace air has been developed. The total chromium (Cr) was determined by using quadruple inductively coupled plasma mass spectrometry (ICP-MS) equipped with a dynamic reaction cell (DRC(®)). Soluble trivalent and hexavalent chromium compounds were determined by high performance liquid chromatography with inductively coupled plasma mass spectrometry (HPLC-ICP-MS). A high-speed, reversed-phase CR C8 column (PerkinElmer, Inc., Shelton, CT, USA) was used for the speciation of soluble Cr (III) and soluble Cr (VI). The separation was accomplished by interaction of the chromium species with the different components of the mobile phase. Cr (III) formed a complex with EDTA, i.e. retained on the column, while Cr (VI) existed in the solutions as dichromate. Alkaline extraction (2% KOH and 3% Na2CO3) and anion exchange column (PRP-X100, PEEK, Hamilton) were used for the separation of the total Cr (VI). The results of the determination of Cr (VI) were confirmed by the analysis of the certified reference material BCR CRM 545 (Cr (VI) in welding dust). The results obtained for the certified material (40.2±0.6 g kg(-1)) and the values recorded in the examined samples (40.7±0.6 g kg(-1)) were highly consistent. This analytical method was applied for the determination of chromium in the samples in the workplace air collected onto glass (Whatman, Ø 37 mm) and membrane filters (Sartorius, 0.8 µm, Ø 37 mm). High performance liquid chromatography with inductively coupled plasma mass spectrometry is a remarkably powerful and versatile technique for determination of chromium species in welding fume at workplace air.

[Assessment of occupational exposure of welders based on determination of fumes and their components produced during stainless steel welding]. / Ocena narazenia zawodowego spawaczy na podstawie oznaczania dymów i ich skladników powstajácych podczas spawania stali chromowo-niklowej.

BACKGROUND: Occupational exposure to welding fumes is a known health hazard. The aim of this study was to determine concentrations of welding fumes components such as: iron, manganese, nickel and chromium (including chromium speciation) to assess exposure of stainless steel welders. MATERIALS AND METHODS: The survey covered 14 workers of two metallurgic plants engaged in welding stainless steel (18% Cr and 8% Ni) by different techniques: manual metal arc (MMA), metal inert gas (MIG) and tungsten inert gas (TIG). Personal air samples were collected in the welders' breathing zone over a period of about 6-7 h (dust was collected on a membrane and glass filter) to determine time weighted average (TWA) concentration of welding fumes and its components. The concentrations of welding fumes (total particulate) were determined with use of the gravimetric method. Concentrations and welding fume components, such as: iron, manganese, nickel and chromium were determined by ICP-MS technique. The total hexavalent chromium was analyzed by applying the spectrophotometry method according to NIOSH. The water-soluble chromium species were analyzed by HPLC-ICP-MS. RESULTS: Time weighted average concentrations of the welding fumes and its components at the worker's breathing zone were (mg/m3): dust, 0.14-10.7; iron, 0.004-2.9; manganese, 0.001-1.12; nickel, < 0.001-0.2; and chromium <0.002-0.85 (mainly Cr(III) and insoluble Cr(VI)). The maximum admissible limits for workplace pollutants (TLV-TWA) were exceeded for manganese and for insoluble chromium Cr (VI). For Cr (III) the limit was exceeded in individual cases. CONCLUSIONS: The assessment of the workers' occupational exposure, based on the determined time weighted average (TWA) of fumes and their components, shows that the stainless steel welders worked in conditions harmful to their health owing to the significantly exceeded maximum admissible limits for manganese and the exceeded TLV value for insoluble chromium (VI).

[Determination of fumes and their elements from flux cored arc welding]. / Oznaczanie dymów i ich skladników powstajacych podczas spawania drutami proszkowymi.

BACKGROUND: The aim of this work was to assay the concentration levels and composition of welding fumes, released during flux cored arc welding, to assess exposure of welders. MATERIALS AND METHODS: Concentrations and welding fume components, such as iron, manganese, chromium (including the soluble and chromium VI), nickel, copper, calcium, aluminium, barium, and fluorides (including hydrogen fluoride) were determined in the air of six industrial plants (shipyards, mechanical engineering plants and a power station) at the breathing zones of the welders who used 10 types of wires during flux cored arc welding. The following determination methods were used: gravimetry (fumes), AAS (metals), and spectrophotometry (chromium VI, fluorides--including hydrogen fluoride). RESULTS: The results made it possible to determine the relationship between concentrations of welding fume and its elements, and to assess worker's exposure. Time weighted average concentrations of the welding fumes and its elements at the worker's breathing zone were: mg/m3: dust 0.2-24.3; Fe 0.2-6.7; Mn 0.01-1.8; Cr 0.004-0.5 (mainly Cr III); Ca 0.004-2.5; Ni < or = 0.004; Cu < 0.002-0.05; Al < 0.14-0.4; Ba < 0.14; F- 0.07-0.43. CONCLUSIONS: The welders using some types of flux cored welding wires worked in conditions harmful to their health owing to the considerably exceeded TLV value for fume and MAC values for manganese, and occasional slightly excessive MAC values for calcium and iron.