Comparison of the Bactericidal Effect of Ultrasonic and Heat Combined with Ultrasonic Treatments on Egg Liquids and Additional Analysis of Their Effect by NIR Spectral Analysis.

Eggs are a valuable source of nutrients, but they represent a food safety risk due to the presence of microbes. In this work, three types of egg liquids (albumen, yolk and whole egg) previously contaminated with E. coli were treated with ultrasound (US) and a combination of ultrasound and low (55 °C) temperature (US+H). The US treatment parameters were 20 and 40 kHz and 180 and 300 W power and a 30, 45 or 60 min treatment time. The ultrasonic treatment alone resulted in a reduction in the microbial count of less than 1 log CFU, while the US+H treatment resulted in a reduction in CFU counts to below detectable levels in all three egg liquids. Heat treatment and ultrasound treatment had a synergistic effect on E. coli reduction. For all measurements, except for the whole egg samples treated with US, the 20 kHz treated samples showed a significantly (>90% probability level) lower bactericidal effect than the 40 kHz treated samples. PCA and aquaphotometric analysis of NIR spectra showed significant differences between the heat-treated groups' (H and US+H) and the non-heat-treated groups' (US and control) NIR spectra. LDA results show that heat-treated groups are distinguishable from non-heat-treated groups (for albumen 91% and for egg yolk and whole egg 100%).

Estimating the optimal efflux inhibitor concentration of carvacrol as a function of the bacterial physiological state.

Our aim was to find the optimal efflux inhibitor concentration of a natural component, carvacrol, as a function of the physiological state of Escherichia coli. Using fluorescence-based measurements with two strains of E. coli, the effect of carvacrol was assessed at 17 sub-inhibitory concentrations, at which the bacterial efflux mechanism was compromised. The efficacy of carvacrol, as an efflux inhibitor, was compared to synthetic inhibitors and we found carvacrol the most efficient one. We considered the accumulation of Ethidium Bromide (EtBr) as a proxy for drugs spreading in the cell, thus measuring the efflux activity indirectly. The change in membrane integrity caused by the exposure to carvacrol was monitored using the LIVE/DEAD BacLight Bacterial Viability kit. To find the optimal inhibitory concentration of carvacrol, we used predictive microbiology methods. This optimum varied with the bacterial physiological state, as non-growing cultures were less susceptible to the effect of carvacrol than growing cultures were. Moreover, we point out, for the first time, that the efflux-mediated resistance of untreated cultures was also stronger in the non-growing than in the growing phase at population level.

Combined Effect of Ultrasound and Low-Heat Treatments on E. coli in Liquid Egg Products and Analysis of the Inducted Structural Alterations by NIR Spectroscopy.

In this study, sonication with mild heat treatment was used to reduce the E. coli count in inoculated liquid whole egg, egg yolk and albumen. Ultrasonic equipment (20/40 kHz, 180/300 W) has been used for 30/60 min with a 55 °C water bath. The combination of sonication and low-heat treatment was able to reduce the concentration of E. coli from 5-log CFU × mL-1 below 10 CFU × mL-1 at 300 W, 40 kHz and 60 min of sonication in liquid egg products. The 60 min treatment was able to reduce the E. coli concentration below 10 CFU × mL-1 in the case of egg yolk regardless of the applied frequency, absorbed power or applied energy dose. The 30 min treatment of sonication and heating was able to reduce significantly the number of E. coli in the egg products, as well. Our results showed that sonication with mild heat treatment can be a useful technique to decrease the number of microorganisms in liquid egg products to a very low level. Near-infrared spectroscopy was used to investigate structural changes in the samples, induced by the combined treatment. Principal component analysis showed that this method can alter the C-H, C-N, -OH and -NH bonds in these egg products.