Amino acids as stabilizers for lysozyme during the spray-drying process and storage.

Amino acids (AAs) have been used as excipients in protein formulations both in solid and liquid state products due to their stabilizing effect. However, the mechanisms by which they can stabilize a protein have not been fully elucidated yet. The purpose of this study was to investigate the effect of AAs with distinct physicochemical properties on the stability of a model protein (lysozyme, LZM) during the spray-drying process and subsequent storage. Molecular descriptor based multivariate data analysis was used to select distinct AAs from the group of 20 natural AAs. Then, LZM and the five selected AAs (1:1 wt ratio) were spray-dried (SD). The solid form, residual moisture content (RMC), hygroscopicity, morphology, secondary/tertiary structure and enzymatic activity of LZM were evaluated before and after storage under 40 °C/75 % RH for 30 days. Arginine (Arg), leucine (Leu), glycine (Gly), tryptophan (Trp), aspartic acid (Asp) were selected because of their distinct properties by using principal component analysis (PCA). The SD LZM powders containing Arg, Trp, or Asp were amorphous, while SD LZM powders containing Leu or Gly were crystalline. Recrystallization of Arg, Trp, Asp and polymorph transition of Gly were observed after the storage under accelerated conditions. The morphologies of the SD particles vary upon the different AAs formulated with LZM, implying different drying kinetics of the five model systems. A tertiary structural change of LZM was observed in the SD powder containing Arg, while a decrease in the enzymatic activity of LZM was observed in the powders containing Arg or Asp after the storage. This can be attributed to the extremely basic and acidic conditions that Arg and Asp create, respectively. This study suggests that when AAs are used as stabilizers instead of traditional disaccharides, not only do classic vitrification theory and water replacement theory play a role, but the microenvironmental pH conditions created by basic or acidic AAs in the starting solution or during the storage of solid matter are also crucial for the stability of SD protein products.

Heterogeneous and Surface-Catalyzed Amyloid Aggregation Monitored by Spatially Resolved Fluorescence and Single Molecule Microscopy.

Amyloid aggregation is associated with many diseases and may also occur in therapeutic protein formulations. Addition of co-solutes is a key strategy to modulate the stability of proteins in pharmaceutical formulations and select inhibitors for drug design in the context of diseases. However, the heterogeneous nature of this multicomponent system in terms of structures and mechanisms poses a number of challenges for the analysis of the chemical reaction. Using insulin as protein system and polysorbate 80 as co-solute, we combine a spatially resolved fluorescence approach with single molecule microscopy and machine learning methods to kinetically disentangle the different contributions from multiple species within a single aggregation experiment. We link the presence of interfaces to the degree of heterogeneity of the aggregation kinetics and retrieve the rate constants and underlying mechanisms for single aggregation events. Importantly, we report that the mechanism of inhibition of the self-assembly process depends on the details of the growth pathways of otherwise macroscopically identical species. This information can only be accessed by the analysis of single aggregate events, suggesting our method as a general tool for a comprehensive physicochemical characterization of self-assembly reactions.

Ion-Mediated Morphological Diversity in Protein Amyloid Systems.

Salt ions are considered among the major determinants ruling protein folding, stability, and self-assembly in the context of amyloid-related diseases, protein drug development, and functional biomaterials. Here, we report that Hofmeister ions not only determine the rate constants of the aggregation reaction for human insulin and hen egg white lysozyme but also control the generation of a plethora of amyloid-like morphologies ranging from the nanoscale to the microscale. We anticipate that the latter is a result of a balance between colloidal and conformational stability combined with an ion-specific effect and highlight the importance of salt ions in controlling the biological functions of protein aggregates.

Interchangeability of biosimilars: A study of expert views and visions regarding the science and substitution.

Healthcare systems have reached a critical point regarding the question of whether biosimilar substitution should become common practice. To move the discussion forward, the study objective was to investigate the views of experts from medicines agencies and the pharmaceutical industry on the science underpinning interchangeability of biosimilars. We conducted an empirical qualitative study using semi-structured interviews informed by a cross-disciplinary approach encompassing regulatory science, law, and pharmaceutical policy. In total 25 individuals with experience within biologics participated during September 2018-August 2019. Eight participants were EU national medicines authority regulators, and 17 had pharmaceutical industry background: five from two originator-only companies, four from two companies with both biosimilar and originator products, and eight from seven biosimilar-only companies. Two analysts independently conducted inductive content analysis, resulting in data-driven themes capturing the meaning of the data. The participants reported that interchangeability was more than a scientific question of likeness between biosimilar and reference products: it also pertained to regulatory practices and trust. Participants were overall confident in the science behind exchanging biosimilar products for the reference products via switching, i.e., with physician involvement. However, their opinions differed regarding the scientific risk associated with biosimilar substitution, i.e., without physician involvement. Almost all participants saw no need for additional scientific data to support substitution. Moreover, the participants did not believe that switching studies, as required in the US, were appropriate for obtaining scientific certainty due to their small size. It is unclear why biosimilar switching is viewed as scientifically safer than substitution; therefore, we expect greater policy debate on biosimilar substitution in the near future. We urge European and UK policymakers and regulators to clarify their visions for biosimilar substitution; the positions of these two frontrunners are likely to influence other jurisdictions on the future of biosimilar use.

Polysorbate 80 controls Morphology, structure and stability of human insulin Amyloid-Like spherulites.

Amyloid protein aggregates are not only associated with neurodegenerative diseases and may also occur as unwanted by-products in protein-based therapeutics. Surfactants are often employed to stabilize protein formulations and reduce the risk of aggregation. However, surfactants alter protein-protein interactions and may thus modulate the physicochemical characteristics of any aggregates formed. Human insulin aggregation was induced at low pH in the presence of varying concentrations of the surfactant polysorbate 80. Various spectroscopic and imaging methods were used to study the aggregation kinetics, as well as structure and morphology of the formed aggregates. Molecular dynamics simulations were employed to investigate the initial interaction between the surfactant and insulin. Addition of polysorbate 80 slowed down, but did not prevent, aggregation of insulin. Amyloid spherulites formed under all conditions, with a higher content of intermolecular beta-sheets in the presence of the surfactant above its critical micelle concentration. In addition, a denser packing was observed, leading to a more stable aggregate. Molecular dynamics simulations suggested a tendency for insulin to form dimers in the presence of the surfactant, indicating a change in protein-protein interactions. It is thus shown that surfactants not only alter aggregation kinetics, but also affect physicochemical properties of any aggregates formed.

Evolving Biosimilar Clinical Requirements: A Qualitative Interview Study with Industry Experts and European National Medicines Agency Regulators.

BACKGROUND: A biosimilar is a biological medicine highly similar to another already approved biological medicine (reference product). The availability of biosimilars promotes competition and subsequently lower prices. Changing the current biosimilar clinical comparability trial requirements may lead to lower biosimilar development costs that potentially could increase patients' access to biologics. OBJECTIVE: The aim was to determine the perceptions of industry and medicines agency regulators regarding the value, necessity, and future developments of the European biosimilar clinical comparability trial requirements for establishing biosimilarity. METHODS: Semi-structured interviews were conducted with eight European national medicines agency regulators and 17 pharmaceutical company employees or consultants with experience in biologics between September 2018 and August 2019. Data were subjected to content analysis. RESULTS: In general, the participants expected that clinical comparability trial requirements will continue to be reduced, in particular based on advancements in analytical testing and knowledge generated from prior biosimilar approvals. However, there are also competing issues at play, such as competition, physician's trust, and ethical considerations. Participants also reported that any new initiative to reduce or waive biosimilar clinical requirements needs to be scientifically sound and could potentially lower biosimilar development costs. CONCLUSION: The main findings are that biosimilar clinical comparability trial requirements are likely to change in the near future. Clarity is needed on how to ensure adequate correlation between physicochemical data, pharmacokinetic/pharmacodynamic studies, and the drugs' performance in the clinic, as well as how to continue sufficient immunogenicity assessment. Obtaining this clarity can facilitate regulatory assessment of the next biosimilars.

Effect of excipients on encapsulation and release of insulin from spray-dried solid lipid microparticles.

The study aimed at investigating the potential of spray drying method for encapsulation of protein drugs into solid lipid microparticles (MP) and evaluating effects of excipients on encapsulation and release of protein from MP. After transformation of model protein insulin to insulin-phospholipid complex, it was dissolved together with lipid excipients in organic solvent, which was spray-dried to form solid lipid MP. Polymeric MP with D, L-lactic-co-glycolic acid (PLGA) were prepared similarly. Around 90% of insulin was encapsulated in glycerol monostearate MP and glycerol distearate MP, whereas the encapsulation efficiency was 60% and 35% for tristearate (TG18) MP and tribehenate (TG22) MP, respectively. The secondary structure of insulin in the spray-dried MP was substantially similar to that of the insulin control solution, suggesting that only minor alterations occurred during the spray drying process. Sustained release of insulin was observed from both TG18 MP and TG22 MP. The burst release of insulin from TG18 MP and TG22 MP was around 30% and 10%, respectively, which was significantly lower than that from PLGA MP (40%). In conclusion, spray drying a solution containing both lipids and protein-phospholipid complex is a promising method for encapsulating protein into solid lipid MP, which can be used for sustained delivery of protein drugs.

Spray dried cubosomes with ovalbumin and Quil-A as a nanoparticulate dry powder vaccine formulation.

Subunit vaccine formulations are often produced as liquid dispersions through complicated processes. It is desirable, however, to have simple, cheap and up-scalable methods to produce nanoparticulate subunit vaccines in powder form. Here, a simple single-step spray drying process for production of powder cubosome precursors with the model antigen ovalbumin (OVA) and the adjuvant Quil-A is presented. The cubosomes were characterized in vitro and evaluated in vivo by subcutaneous and oral administration for their potential as a vaccine formulation. Hydrated cubosomes had average particle size of 257 ±â€¯8 nm and zeta potential of -18.0 ±â€¯0.6 mV. The powder contained 10.6 ±â€¯0.7% w/w OVA prior to hydration, of which 65 ±â€¯1% was released within the first 20 min in 9.5 mM PBS at pH 7.3, with the remaining OVA gradually released over the following 24 h. Immunization with cubosomes resulted in significantly stronger antigen-specific serum IgG responses (p < 0.01), CD8+ T cell expansion (p < 0.0001) and target T cell killing compared to controls when given s.c., and was ineffective orally. This study shows that spray drying is a suitable method for producing nanoparticulate vaccine formulations in dry powder form.

Manipulating Aggregation Behavior of the Uncharged Peptide Carbetocin.

Peptides are usually administered through subcutaneous injection. For low potency drugs, this may require high concentration formulations increasing the risk of peptide aggregation, especially for compounds without any intrinsic chargeable groups. Carbetocin was used as a model to study the behavior of uncharged peptides at high concentrations. Manipulation of the aggregation behavior of 70 mg/mL carbetocin was attempted by selecting excipients which interact with hydrophobic groups in carbetocin, and cover hydrophobic surfaces and interfaces. Peptide aggregation was induced by shaking stress and followed over time. Carbetocin solutions showed significant visible particle formation already after 4 h of shaking stress. This particle formation was not due to supersaturation or phase separation but suggested a nucleated aggregation process. None of the excipients prevented carbetocin aggregation, though altered aggregation behavior was observed, such as induction of fibril formation for most, but not all, charged excipients. Sodium dodecyl sulfate was found to accelerate peptide aggregation both below and above the critical micelle concentration in half-filled vials. However, in the absence of an air headspace, sodium dodecyl sulfate above the critical micelle concentration was capable of preventing shaking-induced carbetocin aggregation. Our study highlights the complexity in rational excipient selection to stabilize uncharged peptides at high concentration.

Investigation of factors affecting the stability of lysozyme spray dried from ethanol-water solutions.

Formulation composition and processing conditions can be adjusted to enhance the structural integrity as well as the bioactivity of proteins in the spray drying process. In this study, lysozyme was chosen as a model pharmaceutical protein to study these aspects when spray drying from water-ethanol mixtures. The effect of formulation additives (trehalose, Tween 20 and phosphate-buffered saline) and processing conditions (inlet temperature and storage time of lysozyme in the feed solution before the spray drying process) on the protein bioactivity was investigated. The results showed that the bioactivities of spray dried lysozyme with these additives were about 5-10% higher than that without additives. The bioactivity of the spray dried lysozyme was found to increase with a decrease in the inlet temperature from 130°C to 80°C, with similar findings when shortening the storage time of the feed solutions prior to spray drying. Fourier Transform Infrared (FTIR) and Circular Dichroism (CD) results showed that the native structures of lysozyme were largely restored upon reconstitution of the spray dried powder in water after the spray drying process. This suggests that the bioactivity of lysozyme could be preserved adequately by optimization of both the formulation composition and process conditions even when spray drying from a water-ethanol mixture.

Correlation between calculated molecular descriptors of excipient amino acids and experimentally observed thermal stability of lysozyme.

A quantitative structure-property relationship (QSPR) between protein stability and the physicochemical properties of excipients was investigated to enable a more rational choice of stabilizing excipients than prior knowledge. The thermal transition temperature and aggregation time were determined for lysozyme in combination with 13 different amino acids using high throughput fluorescence spectroscopy and kinetic static light scattering measurements. On the theoretical side, around 200 2D and 3D molecular descriptors were calculated based on the amino acids' chemical structure. Multivariate data analysis was applied to correlate the descriptors with the experimental results. It was possible to identify descriptors, i.e. amino acids properties, with a positive influence on either transition temperature or aggregation onset time, or both. A high number of hydrogen bond acceptor moieties was the most prominent stabilizing factor for both responses, whereas hydrophilic surface properties and high molecular mass density mostly had a positive influence on the unfolding temperature. A high partition coefficient (logP(o/w)) was identified as the most prominent destabilizing factor for both responses. The QSPR shows good correlation between calculated molecular descriptors and the measured stabilizing effect of amino acids on lysozyme.

Screening of plants used in the European traditional medicine to treat memory disorders for acetylcholinesterase inhibitory activity and anti amyloidogenic activity.

ETHNOPHARMACOLOGICAL RELEVANCE: Plants used in the traditional medicine of Europe to treat memory dysfunction and/or to enhance memory were investigated for activity against the underlying mechanisms of Alzheimer's disease. AIM OF THE STUDY: To investigate 35 ethanolic extracts of plants, selected using an ethnopharmacological approach, for anti-amyloidogenic activity as well as an ability to inhibit the enzymatic activity of acetylcholinesterase. MATERIALS AND METHODS: The anti-amyloidogenic activity of the extracts against amyloid beta was investigated by Thioflavin T fibrillation assays and the ability to inhibit the enzymatic activity of acetylcholinesterase was evaluated monitoring the hydrolysis of acetylthiocholine RESULTS: Under the experimental conditions investigated, extracts of two plants, Carum carvi and Olea sylvestris, inhibited amyloid beta fibrillation considerably, eight plant extracts inhibited amyloid beta fibrillation to some extent, 16 plant extracts had no effect on amyloid beta fibrillation and nine extracts accelerated fibrillation of amyloid beta. Furthermore, five plant extracts from Corydalis species inhibited the enzymatic activity of acetylcholinesterase considerably, one plant extract inhibited the enzymatic activity of acetylcholinesterase to some extent and 29 plant extract had no effect on the enzymatic activity of acetylcholinesterase. CONCLUSIONS: An optimal extract in this study would possess acetylcholinesterase inhibitory activity as well as anti-amyloidogenic activity in order to address multiple facets of Alzheimer's disease, until the molecular origin of the disease is unraveled. Unfortunately no such extract was found.

Rhamnogalacturonan-I Based Microcapsules for Targeted Drug Release.

Drug targeting to the colon via the oral administration route for local treatment of e.g. inflammatory bowel disease and colonic cancer has several advantages such as needle-free administration and low infection risk. A new source for delivery is plant-polysaccharide based delivery platforms such as Rhamnogalacturonan-I (RG-I). In the gastro-intestinal tract the RG-I is only degraded by the action of the colonic microflora. For assessment of potential drug delivery properties, RG-I based microcapsules (~1 µm in diameter) were prepared by an interfacial poly-addition reaction. The cross-linked capsules were loaded with a fluorescent dye (model drug). The capsules showed negligible and very little in vitro release when subjected to media simulating gastric and intestinal fluids, respectively. However, upon exposure to a cocktail of commercial RG-I cleaving enzymes, ~ 9 times higher release was observed, demonstrating that the capsules can be opened by enzymatic degradation. The combined results suggest a potential platform for targeted drug delivery in the terminal gastro-intestinal tract.

Effect of ethanol as a co-solvent on the aerosol performance and stability of spray-dried lysozyme.

In the spray drying process, organic solvents can be added to facilitate drying, accommodate certain functional excipients, and modify the final particle characteristics. In this study, lysozyme was used as a model pharmaceutical protein to study the effect of ethanol as a co-solvent on the stability and aerosol performance of spray-dried protein. Lysozyme was dissolved in solutions with various ratios of ethanol and water, and subsequently spray-dried. A change from spherical particles into wrinkled and folded particles was observed upon increasing the ratio of ethanol in the feed. The aerosol performance of the spray-dried lysozyme from ethanol-water solution was improved compared to that from pure water. The conformation of lysozyme in the ethanol-water solution and spray dried powder was altered, but the native structure of lysozyme was restored upon reconstitution in water after the spray drying process. The enzymatic activities of the spray-dried lysozyme showed no significant impact of ethanol; however, the lysozyme enzymatic activity was ca. 25% lower compared to the starting material. In conclusion, the addition of ethanol as a co-solvent in the spray drying feed for lysozyme did not compromise the conformation of the protein after drying, while it improved the inhaled aerosol performance.

Rapid Conformational Analysis of Protein Drugs in Formulation by Hydrogen/Deuterium Exchange Mass Spectrometry.

Hydrogen deuterium exchange coupled to mass spectrometry (HDX-MS) has become an established method for analysis of protein higher order structure. Here, we use HDX-MS methodology based on manual solid-phase extraction (SPE) to allow fast and simplified conformational analysis of proteins under pharmaceutically relevant formulation conditions. Of significant practical utility, the methodology allows global HDX-MS analyses to be performed without refrigeration or external cooling of the setup. In mode 1, we used dimethyl sulphoxide-containing solvents for SPE, allowing the HDX-MS analysis to be performed at acceptable back-exchange levels (<30%) without the need for cooling any components of the setup. In mode 2, SPE and chromatography were performed using fast isocratic elution at 0°C resulting in a back-exchange of 10%-30%. Real-world applicability was demonstrated by HDX-MS analyses of interferon-ß-1a in formulation, using an internal HDX reference peptide (P7I) to control for any sample-to-sample variations in back-exchange. Advantages of the methodology include low sample use, optimized excipient removal using multiple solvents, and fast data acquisition. Our results indicate that HDX-MS can provide a reliable approach for fast conformation analysis of proteins in their intended formulations, which could facilitate an increased use of the technique in pharmaceutical development research.

Effect of the Freezing Step in the Stability and Bioactivity of Protein-Loaded PLGA Nanoparticles Upon Lyophilization.

PURPOSE: The freezing step in lyophilization is the most determinant for the quality of biopharmaceutics. Using insulin as model of therapeutic protein, our aim was to evaluate the freezing effect in the stability and bioactivity of insulin-loaded PLGA nanoparticles. The performance of trehalose, sucrose and sorbitol as cryoprotectants was evaluated. METHODS: Cryoprotectants were co-encapsulated with insulin into PLGA nanoparticles and lyophilized using an optimized cycle with freezing at -80°C, in liquid nitrogen, or ramped cooling at -40°C. Upon lyophilization, the stability of protein structure and in vivo bioactivity were assessed. RESULTS: Insulin was co-encapsulated with cryoprotectants resulting in particles of 243-394 nm, zeta potential of -32 to -35 mV, and an association efficiency above 90%. The cryoprotectants were crucial to mitigate the freezing stresses and better stabilize the protein. The insulin structure maintenance was evident and close to 90%. Trehalose co-encapsulated insulin-loaded PLGA nanoparticles demonstrated enhanced hypoglycemic effect, comparatively to nanoparticles without cryoprotectant and added with trehalose, due to a superior insulin stabilization and bioactivity. CONCLUSIONS: The freezing process may be detrimental to the structure of protein loaded into nanoparticles, with negative consequences to bioactivity. The co-encapsulation of cryoprotectants mitigated the freezing stresses with benefits to protein bioactivity.

Taylor Dispersion Analysis as a promising tool for assessment of peptide-peptide interactions.

Protein-protein and peptide-peptide (self-)interactions are of key importance in understanding the physiochemical behavior of proteins and peptides in solution. However, due to the small size of peptide molecules, characterization of these interactions is more challenging than for proteins. In this work, we show that protein-protein and peptide-peptide interactions can advantageously be investigated by measurement of the diffusion coefficient using Taylor Dispersion Analysis. Through comparison to Dynamic Light Scattering it was shown that Taylor Dispersion Analysis is well suited for the characterization of protein-protein interactions of solutions of α-lactalbumin and human serum albumin. The peptide-peptide interactions of three selected peptides were then investigated in a concentration range spanning from 0.5mg/ml up to 80mg/ml using Taylor Dispersion Analysis. The peptide-peptide interactions determination indicated that multibody interactions significantly affect the PPIs at concentration levels above 25mg/ml for the two charged peptides. Relative viscosity measurements, performed using the capillary based setup applied for Taylor Dispersion Analysis, showed that the viscosity of the peptide solutions increased with concentration. Our results indicate that a viscosity difference between run buffer and sample in Taylor Dispersion Analysis may result in overestimation of the measured diffusion coefficient. Thus, Taylor Dispersion Analysis provides a practical, but as yet primarily qualitative, approach to assessment of the colloidal stability of both peptide and protein formulations.

Mechanistic study of the inhibitory activity of Geum urbanum extract against α-Synuclein fibrillation.

The presence of Lewy bodies and Lewy neurites is a major pathological hallmark of Parkinson's disease and is hypothesized to be linked to disease development, although this is not yet conclusive. Lewy bodies and Lewy neurites primarily consist of fibrillated α-Synuclein; yet, there is no treatment available targeting stabilization of α-Synuclein in its native state. The aim of the present study was to investigate the inhibitory activity of an ethanolic extract of Geum urbanum against α-Synuclein fibrillation and examine the structural changes of α-Synuclein in the presence of the extract. The anti-fibrillation and anti-aggregation activities of the plant extract were monitored by thioflavin T fibrillation assays and size exclusion chromatography, while structural changes were followed by circular dichroism, Fourier transform infrared spectroscopy, intrinsic fluorescence, small angle X-ray scattering and electron microscopy. Since the extract is a complex mixture, structure-function relationships could not be determined. Under the experimental conditions investigated, Geum urbanum was found to inhibit α-Synuclein fibrillation in a concentration dependent way, and to partly disintegrate preformed α-Synuclein fibrils. Based on the structural changes of α-Synuclein in the presence of extract, we propose that Geum urbanum delays α-Synuclein fibrillation either by reducing the fibrillation ability of one or more of the aggregation prone intermediates or by directing α-Synuclein aggregation towards a non-fibrillar state. However, whether these alterations of the fibrillation pathway lead to less pathogenic species is yet to be determined.