Repurposing DNase I and alginate lyase to degrade the biofilm matrix of dual-species biofilms of Staphylococcus aureus and Pseudomonas aeruginosa grown in artificial sputum medium: In-vitro assessment of their activity in combination with broad-spectrum antibiotics.

BACKGROUND: Biofilm-associated pulmonary infections pose therapeutic challenges in cystic fibrosis patients, especially when involving multiple bacterial species. Enzymatic degradation of the biofilm matrix may offer a potential solution to enhance antibiotic efficacy. This study investigated the repurposing of DNase I, commonly used for its mucolytic activity in cystic fibrosis, to target extracellular DNA within biofilms, as well as potential synergies with alginate lyase and broad-spectrum antibiotics in dual-species biofilms of Pseudomonas aeruginosa and Staphylococcus aureus. METHODS: Dual-species biofilms were grown in artificial sputum medium using S. aureus and P. aeruginosa isolated by pairs from the same patients and exposed to various combinations of enzymes, meropenem, or tobramycin. Activity was assessed by measuring biofilm biomass and viable counts. Matrix degradation and decrease in bacterial load were visualized using confocal microscopy. Biofilm viscoelasticity was estimated by rheology. RESULTS: Nearly complete destruction of the biofilms was achieved only if combining the enzymatic cocktail with the two antibiotics, and if using supratherapeutic levels of DNase I and high concentrations of alginate lyase. Biofilms containing non-pigmented mucoid P. aeruginosa required higher antibiotic concentrations, despite low viscoelasticity. In contrast, for biofilms with pigmented mucoid P. aeruginosa, a correlation was observed between the efficacy of different treatments and the reduction they caused in elasticity and viscosity of the biofilm. CONCLUSIONS: In this complex, highly drug-tolerant biofilm model, enzymes prove useful adjuvants to enhance antibiotic activity. However, the necessity for high enzyme concentrations emphasizes the need for thorough concentration-response evaluations and safety assessments before considering clinical applications.

Nebulization of PEGylated recombinant human deoxyribonuclease I using vibrating membrane nebulizers: A technical feasibility study.

Recombinant human deoxyribonuclease I (rhDNase, Pulmozyme®) is the most frequently used mucolytic agent for the symptomatic treatment of cystic fibrosis (CF) lung disease. Conjugation of rhDNase to polyethylene glycol (PEG) has been shown to greatly prolong its residence time in the lungs and improve its therapeutic efficacy in mice. To present an added value over current rhDNase treatment, PEGylated rhDNase needs to be efficiently and less frequently administrated by aerosolization and possibly at higher concentrations than existing rhDNase. In this study, the effects of PEGylation on the thermodynamic stability of rhDNase was investigated using linear 20 kDa, linear 30 kDa and 2-armed 40 kDa PEGs. The suitability of PEG30-rhDNase to electrohydrodynamic atomization (electrospraying) as well as the feasibility of using two vibrating mesh nebulizers, the optimized eFlow® Technology nebulizer (eFlow) and Innospire Go, at varying protein concentrations were investigated. PEGylation was shown to destabilize rhDNase upon chemical-induced denaturation and ethanol exposure. Yet, PEG30-rhDNase was stable enough to withstand aerosolization stresses using the eFlow and Innospire Go nebulizers even at higher concentrations (5 mg of protein per ml) than conventional rhDNase formulation (1 mg/ml). High aerosol output (up to 1.5 ml per min) and excellent aerosol characteristics (up to 83% fine particle fraction) were achieved while preserving protein integrity and enzymatic activity. This work demonstrates the technical feasibility of PEG-rhDNase nebulization with advanced vibrating membrane nebulizers, encouraging further pharmaceutical and clinical developments of a long-acting PEGylated alternative to rhDNase for treating patients with CF.

Impact of the PEG length and PEGylation site on the structural, thermodynamic, thermal, and proteolytic stability of mono-PEGylated alpha-1 antitrypsin.

Conjugation to polyethylene glycol (PEG) is a widely used approach to improve the therapeutic value of proteins essentially by prolonging their body residence time. PEGylation may however induce changes in the structure and/or the stability of proteins and thus on their function(s). The effects of PEGylation on the thermodynamic stability can either be positive (stabilization), negative (destabilization), or neutral (no effect). Moreover, various factors such as the PEG length and PEGylation site can influence the consequences of PEGylation on the structure and stability of proteins. In this study, the effects of PEGylation on the structure, stability, and polymerization of alpha1-antitrypsin (AAT) were investigated, using PEGs with different lengths, different structures (linear or 2-armed) and different linking chemistries (via amine or thiol) at two distinct positions of the sequence. The results show that whatever the size, position, and structure of PEG chains, PEGylation (a) does not induce significant changes in AAT structure (either at the secondary or tertiary level); (b) does not alter the stability of the native protein upon both chemical- and heat-induced denaturation; and (c) does not prevent AAT to fully refold and recover its activity following chemical denaturation. However, the propensity of AAT to aggregate upon heat treatment was significantly decreased by PEGylation, although PEGylation did not prevent the irreversible inactivation of the enzyme. Moreover, conjugation to PEG, especially 2-armed 40 kDa PEG, greatly improved the proteolytic resistance of AAT. PEGylation of AAT could be a promising strategy to prolong its half-life after infusion in AAT-deficient patients and thereby decrease the frequency of infusions.

Production and characterization of mono-PEGylated alpha-1 antitrypsin for augmentation therapy.

Alpha-1 antitrypsin (AAT) is an endogenous inhibitor of serine proteases which, in physiological conditions, neutralizes the excess of neutrophil elastase and other serine proteases in tissues and especially the lungs. Weekly intravenous infusion of plasma-purified human AAT is used to treat AAT deficiency-associated lung disease. However, only 2 % of the AAT dose reach the lungs after intravenous infusion. Inhalation of AAT might offer an alternative route of administration. Yet, the rapid clearance of AAT from the respiratory tract results in high and frequent dosing by inhalation and limited efficacy. In the present study, we produced and characterized in vitro a PEGylated version of AAT which could offer a prolonged body residence time and thereby be useful for augmentation therapy by the intravenous and inhalation routes. Two PEGylation reactions - N-terminal and thiol PEGylation - and three polyethylene glycol (PEG) chains - linear 30 kDa, linear 40 kDa and 2-armed 40 kDa - were used. The yields of mono-PEGylated AAT following purification by anion exchange chromatography were 40-50 % for N-terminal PEGylation and 60-70% for thiol PEGylation. The PEG-AAT conjugates preserved the ability to form a protease-inhibitor complex with neutrophil elastase and proteinase 3 as well as the full inhibitory capacity to neutralize neutrophil elastase activity. These results open up interesting prospects for PEGylated AAT to achieve a prolonged half-life and an improved therapeutic efficacy in vivo.

Needle-free iontophoresis-driven ß-adrenergic sweat rate test.

OBJECTIVES: Two CFTR-dependent ß-adrenergic sweat rate tests applying intradermal drug injections were reported to better define diagnosis and efficacy of CFTR-directed therapies. The aim of this work was to develop and test a needle-free image-based test and to provide an accurate analysis of the responses. METHODS: The modified method was conducted by applying two successive iontophoresis sessions using the Macroduct device. Efficiency of drug delivery was tested by evaporimetry. Cholinergically stimulated sweating was evoked by pilocarpine iontophoresis. ß-adrenergically stimulated sweating was obtained by iontophoresis of isoproterenol and aminophylline in the presence of atropine and ascorbic acid. A nonlinear mixed-effects (NLME) approach was applied to model volumes of sweat and subject-specific effects displaying inter- and intra-subject variability. RESULTS: Iontophoresis provided successful transdermal delivery of all drugs, including almost neutral isoproterenol and aminophylline. Pilocarpine was used at a concentration ∼130-times lower than that used in the classical Gibson and Cooke sweat test. Addition of ascorbic acid lowered the pH of the solution, made it stable, prevented isoproterenol degradation and promoted drug iontophoresis. Maximal secretory capacity and kinetic rate of ß-adrenergic responses were blunted in CF. A cutoff of 5.2 minutes for ET50, the time to reach the half maximal secretion, discriminated CF from controls with a 100% sensitivity and specificity. Heterozygous showed an apparently reduced kinetic rate and a preserved secretory capacity. CONCLUSION: We tested a safe, well-tolerated needle-free image-based sweat test potentially applicable in children. Modelling responses by NLME allowed evaluating metrics of CFTR-dependent effects reflecting secretory capacity and kinetic rate.

Encapsulation of a CpG oligonucleotide in cationic liposomes enhances its local antitumor activity following pulmonary delivery in a murine model of metastatic lung cancer.

Immunotherapy brings new hope to the fight against lung cancer. General immunostimulatory agents represent an immunotherapy strategy that has demonstrated efficacy with limited toxicity when delivered intratumorally. The goal of this study was to enhance the antitumor efficacy of unmethylated oligodeoxynucleotides containing CpG motifs (CpG) and polyinosinic-polycytidylic acid (poly I:C) double-stranded RNA following their local delivery in lung cancer by encapsulating them in liposomes. Liposomes encapsulation of nucleic acids could increase their uptake by lung phagocytes and thereby the activation of toll-like receptors within endosomes. Liposomes were prepared using a cationic lipid, dioleoyltrimethylammoniumpropane (DOTAP), and dipalmitoylphosphatidylcholine (DPPC), the main phospholipid in lung surfactant. The liposomes permanently entrapped CpG but could not efficiently withhold poly I:C. Both poly I:C and CpG delayed tumor growth in the murine B16F10 model of metastatic lung cancer. However, only CpG increased IFN-γ levels in the lungs. Pulmonary administration of CpG was superior to its intraperitoneal injection to slow the growth of lung metastases and to induce the production of granzyme B, a pro-apoptotic protein, and IFNγ, MIG and RANTES, T helper type 1 cytokines and chemokines, in the lungs. These antitumor activities of CpG were strongly enhanced by CpG encapsulation in DOTAP/DPPC liposomes. Delivery of low CpG doses to the lungs induced increased inflammation markers in the airspaces but the inflammation did not reach the systemic compartment in a significant manner. These data support the use of a delivery carrier to strengthen CpG antitumor activity following its pulmonary delivery in lung cancer.

Biodistribution and elimination pathways of PEGylated recombinant human deoxyribonuclease I after pulmonary delivery in mice.

Conjugation of recombinant human deoxyribonuclease I (rhDNase) to polyethylene glycol (PEG) of 20 to 40 kDa was previously shown to prolong the residence time of rhDNase in the lungs of mice after pulmonary delivery while preserving its full enzymatic activity. This work aimed to study the fate of native and PEGylated rhDNase in the lungs and to elucidate their biodistribution and elimination pathways after intratracheal instillation in mice. In vivo fluorescence imaging revealed that PEG30 kDa-conjugated rhDNase (PEG30-rhDNase) was retained in mouse lungs for a significantly longer period of time than native rhDNase (12 days vs 5 days). Confocal microscopy confirmed the presence of PEGylated rhDNase in lung airspaces for at least 7 days. In contrast, the unconjugated rhDNase was cleared from the lung lumina within 24 h and was only found in lung parenchyma and alveolar macrophages thereafter. Systemic absorption of intact rhDNase and PEG30-rhDNase was observed. However, this was significantly lower for the latter. Catabolism, primarily in the lungs and secondarily systemically followed by renal excretion of byproducts were the predominant elimination pathways for both native and PEGylated rhDNase. Catabolism was nevertheless more extensive for the native protein. On the other hand, mucociliary clearance appeared to play a less prominent role in the clearance of those proteins after pulmonary delivery. The prolonged presence of PEGylated rhDNase in lung airspaces appears ideal for its mucolytic action in patients with cystic fibrosis.

PEGylation of recombinant human deoxyribonuclease I decreases its transport across lung epithelial cells and uptake by macrophages.

Conjugation to high molecular weight (MW ≥ 20 kDa) polyethylene glycol (PEG) was previously shown to largely prolong the lung residence time of recombinant human deoxyribonuclease I (rhDNase) and improve its therapeutic efficacy following pulmonary delivery in mice. In this paper, we investigated the mechanisms promoting the extended lung retention of PEG-rhDNase conjugates using cell culture models and lung biological media. Uptake by alveolar macrophages was also assessed in vivo. Transport experiments showed that PEGylation reduced the uptake and transport of rhDNase across monolayers of Calu-3 cells cultured at an air-liquid interface. PEGylation also decreased the uptake of rhDNase by macrophages in vitro whatever the PEG size as well as in vivo 4 h following intratracheal instillation in mice. However, the reverse was observed in vivo at 24 h due to the higher availability of PEGylated rhDNase in lung airways at 24 h compared with rhDNase, which is cleared faster. The uptake of rhDNase by macrophages was dependent on energy, time, and concentration and occurred at rates indicative of adsorptive endocytosis. The diffusion of PEGylated rhDNase in porcine tracheal mucus and cystic fibrosis sputa was slower compared with that of rhDNase. Nevertheless, no significant binding of PEGylated rhDNase to both media was observed. In conclusion, decreased transport across lung epithelial cells and uptake by macrophages appear to contribute to the longer retention of PEGylated rhDNase in the lungs.

Mind your assays: Misleading cytotoxicity with the WST-1 assay in the presence of manganese.

The WST-1 assay is the most common test to assess the in vitro cytotoxicity of chemicals. Tetrazolium-based assays can, however, be affected by the interference of tested chemicals, including carbon nanotubes or Mg particles. Here, we report a new interference of Mn materials with the WST-1 assay. Endothelial cells exposed to Mn particles (Mn alone or Fe-Mn alloy from 50 to 1600 µg/ml) were severely damaged according to the WST-1 assay, but not the ATP content assay. Subsequent experiments revealed that Mn particles interfere with the reduction of the tetrazolium salt to formazan. Therefore, the WST-1 assay is not suitable to evaluate the in vitro cytotoxicity of Mn-containing materials, and luminescence-based assays such as CellTiter-Glo® appear more appropriate.

Pulmonary immunization: deposition site is of minor relevance for influenza vaccination but deep lung deposition is crucial for hepatitis B vaccination.

Vaccination via the pulmonary route could be an attractive alternative to parenteral administration. Research towards the best site of antigen deposition within the lungs to induce optimal immune responses has conflicting results which might be dependent on the type of vaccine and/or its physical state. Therefore, in this study, we explored whether deep lung deposition is crucial for two different vaccines, i.e., influenza and hepatitis B vaccine. In view of this, influenza subunit vaccine and hepatitis B surface antigen were labeled with a fluorescent dye and then spray-dried. Imaging data showed that after pulmonary administration to mice the powders were deposited in the trachea/central airways when a commercially available insufflator was used while deep lung deposition was achieved when an in-house built aerosol generator was used. Immunogenicity studies revealed that comparable immune responses were induced upon trachea/central airways or deep lung targeting of dry influenza vaccine formulations. However, for hepatitis B vaccine, no immune responses were induced by trachea/central airways deposition whereas they were considerable after deep lung deposition. Thus, we conclude that deep lung targeting is not a critical parameter for the efficacy of pulmonary administered influenza vaccine whereas for hepatitis B vaccine it is.

HIF-1α is a key mediator of the lung inflammatory potential of lithium-ion battery particles.

BACKGROUND: Li-ion batteries (LIB) are increasingly used worldwide. They are made of low solubility micrometric particles, implying a potential for inhalation toxicity in occupational settings and possibly for consumers. LiCoO2 (LCO), one of the most used cathode material, induces inflammatory and fibrotic lung responses in mice. LCO also stabilizes hypoxia-inducible factor (HIF) -1α, a factor implicated in inflammation, fibrosis and carcinogenicity. Here, we investigated the role of cobalt, nickel and HIF-1α as determinants of toxicity, and evaluated their predictive value for the lung toxicity of LIB particles in in vitro assays. RESULTS: By testing a set of 5 selected LIB particles (LCO, LiNiMnCoO2, LiNiCoAlO2) with different cobalt and nickel contents, we found a positive correlation between their in vivo lung inflammatory activity, and (i) Co and Ni particle content and their bioaccessibility and (ii) the stabilization of HIF-1α in the lung. Inhibition of HIF-1α with chetomin or PX-478 blunted the lung inflammatory response to LCO in mice. In IL-1ß deficient mice, HIF-1α was the upstream signal of the inflammatory lung response to LCO. In vitro, the level of HIF-1α stabilization induced by LIB particles in BEAS-2B cells correlated with the intensity of lung inflammation induced by the same particles in vivo. CONCLUSIONS: We conclude that HIF-1α, stabilized in lung cells by released Co and Ni ions, is a mechanism-based biomarker of lung inflammatory responses induced by LIB particles containing Co/Ni. Documenting the Co/Ni content of LIB particles, their bioaccessibility and their capacity to stabilize HIF-1α in vitro can be used to predict the lung inflammatory potential of LIB particles.

Preclinical evaluation of topically-administered PEGylated Fab' lung toxicity.

PEGylation is a promising approach to increase the residence time of antibody fragments in the lungs and sustain their therapeutic effects. However, concerns arise as to the potential pulmonary toxicity of antibody fragments conjugated to high molecular weight (HMW) polyethylene glycol (PEG), notably after repeated administrations, and the possibility of PEG accumulation in the lungs. The purpose of this proof-of-concept study is to give insights about the safety of lung administration of a Fab' anti-IL17A antibody fragment conjugated to two-armed 40 kDa PEG (PEG40). The presence of the PEG40 moiety inside alveolar macrophages remained stable for at least 24 h after intratracheal administration of PEG40-Fab' to mice. PEG40 was then progressively cleared from alveolar macrophages. Incubation of PEG40 alone with macrophages in vitro did not significantly harm macrophages and did not affect phagocytosis or the production of inflammatory markers. After acute or chronic administration of PEG40-Fab' to mice, no signs of significant pulmonary toxicity or inflammatory cell accumulation were observed. A vacuolization of alveolar macrophages not associated with any inflammation was noticed when PEG40, PEG40-Fab', or unPEGylated Fab' were administered. To conclude this preliminary proof of concept study, acute or repeated pulmonary administrations of PEGylated Fab' appear safe in rodents.

Activity of Antibiotics against Staphylococcus aureus in an In Vitro Model of Biofilms in the Context of Cystic Fibrosis: Influence of the Culture Medium.

Staphylococcus aureus is a highly prevalent pathogen in the respiratory tract of young patients with cystic fibrosis (CF) and causes biofilm-related infections. Here, we set up an in vitro model of a biofilm grown in Trypticase soy broth supplemented with glucose and NaCl (TGN) or in artificial sputum medium (ASM) and used it to evaluate on a pharmacodynamic basis the activity of antibiotics used in CF patients and active on staphylococci (meropenem, vancomycin, azithromycin, linezolid, rifampin, ciprofloxacin, tobramycin). Rheological studies showed that ASM was more elastic than viscous, as was also observed for sputa from CF patients, with elastic and viscous moduli being, respectively, similar to and slightly lower than those of CF sputa. Biofilms formed by methicillin-sensitive S. aureus strain ATCC 25923 and methicillin-resistant S. aureus strain ATCC 33591 reached maturity after 24 h, with biomass (measured by crystal violet staining) and metabolic activity (assessed by following resazurin metabolization) being lower in ASM than in TGN and viability (assessed by bacterial counts) being similar in both media. Full concentration-response curves of antibiotics obtained after 24 h of incubation of biofilms showed that all antibiotics were drastically less potent and less efficient in ASM than in TGN toward viability, metabolic activity, and biomass. Tobramycin selected for small-colony variants, specifically in biofilms grown in ASM; the auxotrophism of these variants could not be established. These data highlight the major influence exerted by the culture medium on S. aureus responsiveness to antibiotics in biofilms. The use of ASM may help to determine effective drug concentrations or to evaluate new therapeutic options against biofilms in CF patients.

Cationic Nanoliposomes Are Efficiently Taken up by Alveolar Macrophages but Have Little Access to Dendritic Cells and Interstitial Macrophages in the Normal and CpG-Stimulated Lungs.

The purpose of this study was to assess whether cationic nanoliposomes could address tumor vaccines to dendritic cells in the lungs in vivo. Nanoliposomes were prepared using a cationic lipid, dimethylaminoethanecarbamoyl-cholesterol (DC-cholesterol) or dioleoyltrimethylammoniumpropane (DOTAP), and dipalmitoylphosphatidylcholine (DPPC), the most abundant phospholipid in lung surfactant. The liposomes presented a size below 175 nm and they effectively entrapped tumor antigens, an oligodeoxynucletotide containing CpG motifs (CpG) and the fluorescent dye calcein used as a tracer. Although the liposomes could permanently entrap a large fraction of the actives, they could not sustain their release in vitro. Liposomes made of DOTAP were safe to respiratory cells in vitro, while liposomes composed of DC-cholesterol were cytotoxic. DOTAP nanoliposomes were mainly taken up by alveolar macrophages following delivery to the lungs in mice. Few dendritic cells took up the liposomes, and interstitial macrophages did not take up liposomal calcein more than they took up soluble calcein. Stimulation of the innate immune system using liposomal CpG strongly enhanced uptake of calcein liposomes by all phagocytes in the lungs. Although a small percentage of dendritic cells took up the nanoliposomes, alveolar macrophages represented a major barrier to dendritic cell access in the lungs.

Advax augments B and T cell responses upon influenza vaccination via the respiratory tract and enables complete protection of mice against lethal influenza virus challenge.

Administration of influenza vaccines via the respiratory tract has potential benefits over conventional parenteral administration, inducing immunity directly at the site of influenza exposure as well as being needle free. In this study, we investigated the suitability of Advax™, a stable particulate polymorph of inulin, also referred to as delta inulin, as a mucosal adjuvant for whole inactivated influenza vaccine (WIV) administered either as a liquid or dry powder formulation. Spray freeze-drying produced Advax-adjuvanted WIV powder particles in a size range (1-5 µm) suitable for inhalation. The physical and biological characteristics of both WIV and Advax remained unaltered both by admixing WIV with Advax and by spray freeze drying. Upon intranasal or pulmonary immunization, both liquid and dry powder formulations containing Advax induced significantly higher systemic, mucosal and cellular immune responses than non-adjuvanted WIV formulations. Furthermore, pulmonary immunization with Advax-adjuvanted WIV led to robust memory B cell responses along with an increase of lung localization factors i.e. CXCR3, CD69, and CD103. A less pronounced but still positive effect of Advax was seen on memory T cell responses. In contrast to animals immunized with WIV alone, all animals pulmonary immunized with a single dose of Advax-adjuvanted WIV were fully protected with no visible clinical symptoms against a lethal dose of influenza virus. These data confirm that Advax is a potent mucosal adjuvant that boosts vaccine-induced humoral and cellular immune responses both in the lung and systemically with major positive effects on B-cell memory and complete protection against live virus. Hence, respiratory tract immunization, particularly via the lungs, with Advax-adjuvanted WIV formulation as a liquid or dry powder is a promising alternative to parenteral influenza vaccination.

Impact of PEGylation on the mucolytic activity of recombinant human deoxyribonuclease I in cystic fibrosis sputum.

Highly viscous mucus and its impaired clearance characterize the lungs of patients with cystic fibrosis (CF). Pulmonary secretions of patients with CF display increased concentrations of high molecular weight components such as DNA and actin. Recombinant human deoxyribonuclease I (rhDNase) delivered by inhalation cleaves DNA filaments contained in respiratory secretions and thins them. However, rapid clearance of rhDNase from the lungs implies a daily administration and thereby a high therapy burden and a reduced patient compliance. A PEGylated version of rhDNase could sustain the presence of the protein within the lungs and reduce its administration frequency. Here, we evaluated the enzymatic activity of rhDNase conjugated to a two-arm 40 kDa polyethylene glycol (PEG40) in CF sputa. Rheology data indicated that both rhDNase and PEG40-rhDNase presented similar mucolytic activity in CF sputa, independently of the purulence of the sputum samples as well as of their DNA, actin and ions contents. The macroscopic appearance of the samples correlated with the DNA content of the sputa: the more purulent the sample, the higher the DNA concentration. Finally, quantification of the enzymes in CF sputa following rheology measurement suggests that PEGylation largely increases the stability of rhDNase in CF respiratory secretions, since 24-fold more PEG40-rhDNase than rhDNase was recovered from the samples. The present results are considered positive and provide support to the continuation of the research on a long acting version of rhDNase to treat CF lung disease.

Respiratory hazard of Li-ion battery components: elective toxicity of lithium cobalt oxide (LiCoO2) particles in a mouse bioassay.

Rechargeable Li-ion batteries (LIB) are increasingly produced and used worldwide. LIB electrodes are made of micrometric and low solubility particles, consisting of toxicologically relevant elements. The health hazard of these materials is not known. Here, we investigated the respiratory hazard of three leading LIB components (LiFePO4 or LFP, Li4Ti5O12 or LTO, and LiCoO2 or LCO) and their mechanisms of action. Particles were characterized physico-chemically and elemental bioaccessibility was documented. Lung inflammation and fibrotic responses, as well as particle persistence and ion bioavailability, were assessed in mice after aspiration of LIB particles (0.5 or 2 mg); crystalline silica (2 mg) was used as reference. Acute inflammatory lung responses were recorded with the 3 LIB particles and silica, LCO being the most potent. Inflammation persisted 2 m after LFP, LCO and silica, in association with fibrosis in LCO and silica lungs. LIB particles persisted in the lungs after 2 m. Endogenous iron co-localized with cobalt in LCO lungs, indicating the formation of ferruginous bodies. Fe and Co ions were detected in the broncho-alveolar lavage fluids of LFP and LCO lungs, respectively. Hypoxia-inducible factor (HIF) -1α, a marker of fibrosis and of the biological activity of Co ions, was upregulated in LCO and silica lungs. This study identified, for the first time, the respiratory hazard of LIB particles. LCO was at least as potent as crystalline silica to induce lung inflammation and fibrosis. Iron and cobalt, but not lithium, ions appear to contribute to LFP and LCO toxicity, respectively.

Fate of PEGylated antibody fragments following delivery to the lungs: Influence of delivery site, PEG size and lung inflammation.

Pulmonary administration of anti-cytokine antibodies offers a targeted therapy in asthma. However, the rapid elimination of proteins from the lungs limits the efficacy of inhaled medications. PEGylation has been shown to increase the residence time of anti-interleukin (IL)-17A and anti-IL-13 antibody fragments in the lungs and to improve their therapeutic efficacy. Yet, little is known about the factors that affect the residence time of PEGylated antibody fragments in the lungs following pulmonary delivery. In this study, we showed that the molecular weight of polyethylene glycol (PEG), 20kDa or 40kDa, had a moderate effect on the residence time of an anti-IL-17A Fab' fragment in the lungs of mice. By contrast, the site of delivery of the anti-IL-17A and anti-IL-13 Fab' fragments within the lungs had a major impact on their residence time, with the deeper the delivery, the more prolonged the residence time. The nature of the Fab' fragment had an influence on its residence time as well and the anti-IL-17A Fab' benefited more from PEGylation than the anti-IL-13 Fab' did. Acute lung inflammation slightly shortened the residence time of the anti-IL-17A and anti-IL-13 Fab' fragments in the lungs but PEGylation was able to prolong their presence in both the healthy and inflamed lungs. Antibody fragments were predominately located within the airway lumen rather than the lung parenchyma. Transport experiments on monolayers of Calu-3 cells and studies of fluorescence recovery after photobleaching in respiratory mucus showed that mechanisms involved in the prolonged presence of PEGylated Fab' in the airway lumen might include binding to the mucus, reduced uptake by respiratory cells and reduced transport across lung epithelia. Finally, using I125-labeled anti-IL-17A Fab', we showed that the protein fragment hardly penetrated into the lungs following subcutaneous injection, as opposed to pulmonary delivery.

Production and characterization of a PEGylated derivative of recombinant human deoxyribonuclease I for cystic fibrosis therapy.

Recombinant human deoxyribonuclease I (rhDNase) is the mucolytic agent most widely used for the treatment of respiratory disease in cystic fibrosis. However, rhDNase is rapidly cleared from the lungs which implies a high dosing frequency and limited patient adherence. The aim of this study was to produce a long-acting PEGylated derivative of rhDNase presenting a preserved enzymatic activity. Site-specific PEGylation on the N-terminal (N-ter) leucine residue of rhDNase was achieved by reductive alkylation at acidic pH using linear 20kDa, linear 30kDa or two-arm 40kDa polyethylene glycol (PEG) propionaldehydes. Yields of mono-PEGylated products ranged between 45% and 61%. Conjugation to PEG fully preserved the secondary structure and the in vitro enzymatic activity of the native protein. These properties offer interesting perspectives for in vivo inhalation studies of the PEGylated enzyme.