Electrolyzed oxidizing anode water as a sanitizer for use in abattoirs.

The effectiveness of electrolyzed oxidizing anode (EOA) water (oxidation-reduction potential, 1,120 mV; pH 2.0) as a sanitizer for use in abattoirs was compared with the iodophor (IOD) Mikroklene (25 ppm), a sanitizer approved for use by regulatory authorities in Canada and the United States. A total of 240 swab (100 cm2) samples were obtained from 4 sites on the kill floor and 16 sites in the secondary processing areas, during two visits within a 4-week period to each of three meat packing plants, processing < or =50 animals per week. Swabs were obtained 12 h after the application of IOD and EOA and were analyzed for the presence of total aerobic bacteria, total coliforms, and total Escherichia coli. Total aerobic bacteria (log CFU/ 100 cm2) recovered from the 20 sample sites were lower (P < 0.0001) in EOA as compared with IOD (2.94 +/- 0.12 versus 3.75 +/- 0.12, respectively). Plant A was 1.5 times more likely (P < 0.0001) to have a sampling site positive for the presence of coliforms and E. coli than plants B and C. There was no difference (P > 0.05) between treatment IOD or EOA in the likelihood of obtaining a positive sample for the presence of total coliforms or E. coli among the three plants. When the kill floor and secondary processing areas are compared, the likelihood of obtaining a sample positive for coliforms or E. coli was similar (P > or = 0.05). Results indicate that EOA was more effective than IOD in reducing populations of total aerobic bacteria on equipment surfaces in the three meat packing plants studied. Because the likelihood of obtaining a positive sample for coliforms or E. coli in EOA as compared with IOD was similar, EOA may be a suitable alternative or complement to IOD as a sanitizer in small- to medium-sized abattoirs. Additional research is required to further evaluate the effectiveness of EOA to sanitize processing equipment on the basis of subsequent isolation of aerobes, coliforms, and E. coli from meat products.

Ecology of Escherichia coli O157:H7 in commercial dairies in southern Alberta.

Shedding of Escherichia coli O157:H7 was monitored monthly over a 1-yr period by collecting pooled fecal pats (FECAL) and manila ropes orally accessed for 4 h (ROPE) from multiple pens of cattle in 5 commercial dairies in southern Alberta, Canada. Using immunomagnetic separation, E. coli O157:H7 was isolated from cows on 4 of the dairies and from 13.5% of FECAL and 1.1% of ROPE samples. Pulsed-field gel electrophoresis of XbaI- and SpeI-digested bacterial DNA of the 65 isolates produced 23 unique restriction endonuclease digestion patterns, although 92% of the isolates belonged to 3 restriction endonuclease digestion pattern clusters sharing a minimum 90% homology. Collection of positive isolates was 15 times more likely from June through September. Across dairies, peak somatic cell count occurred in July, August, September, and November. The likelihood of positive isolates was 2.6 times higher in calves and heifers compared with mature cows. This study indicates that ROPE would be of little value for the detection of E. coli O157:H7 in dairy herds unless oral contact with ROPE could be increased in mature animals. Additionally, mitigation strategies for E. coli O157:H7 should be targeted to the months of July, August, and September and toward immature animals for maximum impact. All farms displayed unique combinations of seasonality of shedding and diversity of E. coli O157:H7 subtypes. The fact that seasonal prevalence of E. coli O157:H7 largely coincided with peak somatic cell count within climatically controlled dairy barns suggests that similar environmental factors may be enhancing fecal shedding E. coli O157:H7 and the incidence of mastitis.

Monitoring Escherichia coli O157:H7 in inoculated and naturally colonized feedlot cattle and their environment.

On-farm methods of monitoring Escherichia coli O157:H7 were assessed in 30 experimentally inoculated steers housed in four pens over a 12-week period and in 202,878 naturally colonized feedlot cattle housed in 1,160 pens on four commercial Alberta feedlots over a 1-year period. In the challenge study, yearling steers were experimentally inoculated with 10(10) CFU of a four-strain mixture of nalidixic acid-resistant E. coli O157:H7. After inoculation, shedding of E. coli O157:H7 was monitored weekly by collecting rectal fecal samples (FEC), oral swabs (ORL), pooled fecal pats (PAT), manila ropes (ROP) orally accessed for 4 h, feed samples, water, and water bowl interface. Collection of FEC from all animals per pen provided superior isolation (P < 0.01) of E. coli O157:H7 compared with other methods, although labor and animal restraint requirements for fecal sample collection were high. When one sample was collected per pen of animals, E. coli O157:H7 was more likely to be detected from the ROP than from the FEC, PAT, or ORL (P < 0.001). In the commercial feedlot study, samples were limited to ROP and PAT, and E. coli O157:H7 was isolated in 18.8% of PAT and 6.8% of ROP samples. However, for animals that had been resident in the feedlot pen for at least 1 month, isolation of E. coli O157:H7 from ROP was not different from that from PAT (P = 0.35). Pens of animals on feed for <30 days were six times more likely to shed E. coli O157:H7 than were animals on feed for >30 days. However, change in diet did not affect shedding of the organism (P > 0.23) provided that animals had acclimated to the feedlot for 1 month or longer. Findings from this study indicate the importance of introduction of mitigation strategies early in the feeding period to reduce transference and the degree to which E. coli O157:H7 is shed into the environment.