Effects of Impeller Geometry on the 11α-Hydroxylation of Canrenone in Rushton Turbine-Stirred Tanks.

The 11α-hydroxylation of canrenone can be catalyzed by Aspergillus ochraceus in bioreactors, where the geometry of the impeller greatly influences the biotransformation. In this study, the effects of the blade number and impeller diameter of a Rushton turbine on the 11α-hydroxylation of canrenone were considered. The results of fermentation experiments using a 50 mm four-blade impeller showed that 3.40% and 11.43% increases in the conversion ratio were achieved by increasing the blade number and impeller diameter, respectively. However, with an impeller diameter of 60 mm, the conversion ratio with a six-blade impeller was 14.42% lower than that with a four-blade impeller. Data from cold model experiments with a large-diameter six-blade impeller indicated that the serious leakage of inclusions and a 22.08% enzyme activity retention led to a low conversion ratio. Numerical simulations suggested that there was good gas distribution and high fluid flow velocity when the fluid was stirred by large-diameter impellers, resulting in a high dissolved oxygen content and good bulk circulation, which positively affected hyphal growth and metabolism. However, a large-diameter six-blade impeller created overly high shear compared to a large-diameter four-blade impeller, thereby decreasing the conversion ratio. The average shear rates of the former and latter cases were 43.25 s-1 and 35.31 s-1, respectively. We therefore concluded that appropriate shear should be applied in the 11α-hydroxylation of canrenone. Overall, this study provides basic data for the scaled-up production of 11α-hydroxycanrenone.

Ocular Biodistribution of Spironolactone after a Single Intravitreal Injection of a Biodegradable Sustained-Release Polymer in Rats.

Sustained-release formulations for ocular delivery are of increasing interest given their potential to significantly improve treatment efficacy and patient adherence. The objectives of this study were (i) to develop a sustained-release formulation of spironolactone (SPL) using a biodegradable and injectable polymer, hexyl-substituted poly-lactic acid (hexPLA) and (ii) to investigate the ocular biodistribution and tolerability of SPL and its metabolites in rats in vivo over 1 month following a single intravitreal injection (IVT inj). The concentrations of SPL and its two principal active metabolites, 7α-thiomethylspironolactone and canrenone (CAN), in the different ocular compartments were determined at different time points (3, 7, and 31 days after IVT inj) using a validated ultra-high-performance liquid chromatography-mass spectrometry method. Systemic exposure following a single IVT inj of 5% SPL-hexPLA formulation was evaluated by quantifying SPL and its metabolites in the plasma. Ocular tolerability of the formulation was evaluated using in vivo retinal imaging and histology. In vitro release studies revealed a sustained release of SPL from 5% SPL-hexPLA for up to 65 days. In vivo studies showed that SPL and its metabolites were detected in all ocular tissues at 3 and 7 days post-IVT inj. At 31 days post-IVT inj, SPL and CAN were mainly detected in the retina. These results also highlighted the clearance pathway of SPL and its metabolite involving the anterior and posterior routes in the first week (days 3 and 7), then mainly the posterior segment in the last week (day 31). This study showed that a single IVT inj of 5% SPL-hexPLA in rats enabled sustained delivery of therapeutic amounts of SPL for up to 1 month to the retina without systemic exposure. This formulation may be of interest for the local treatment of diseases involving overactivation of the mineralocorticoid receptor in the chorioretina such as chronic central serous chorioretinopathy.

Stability-indicating analytical method of quantifying spironolactone and canrenone in dermatological formulations and iontophoretic skin permeation experiments.

A simple, stability-indicating, chromatographic method of quantifying spironolactone (SPI) and its metabolite, canrenone (CAN), in the presence of excipients typical in dermatological formulations and skin matrices in studies of passive and iontophoretic permeation was proposed and validated here. SPI and CAN were separated using a reversed-phase column with a mobile phase of methanol-water (60:40, v/v) at a flow rate of 1.0 mL/min. Data were collected with a UV detector at 238 and 280 nm, with retention times of 6.2 and 7.9 min for SPI and CAN, respectively. The method was precise, accurate and linear (r2 > 0.99) in a concentration range of 1-30 µg/mL, and recovery rates of SPI and CAN from the different skin layers exceeded 85%. The method was not only sensitive (LOD of 0.05 and 0.375 µg/mL and LOQ of 0.157 and 1.139 µg/mL for SPI and CAN, respectively) but also selective against skin matrices and highly representative components of topical formulations. The method moreover demonstrated SPI's degradation in iontophoresis by applying Pt-AgCl electrodes and its continued drug stability using Ag-AgCl electrodes. Altogether, the method proved valuable for quantifying SPI and CAN and may be applied in developing and controlling the quality of dermatological products.

Development and validation of HPTLC and green HPLC methods for determination of furosemide, spironolactone and canrenone, in pure forms, tablets and spiked human plasma.

Two selective and accurate chromatographic methods are presented for simultaneous quantitation of spironolactone (SP) and furosemide (FR) and canrenone (CN), the main degradation product and the main active metabolite of SP. Method A was HPTLC, where separation was completed on silica gel HPTLC F254 plates using ethyl acetate-triethylamine-acetic acid (9:0.7:0.5, by volume) as a developing system and UV detection at 254 nm. Method B was a green isocratic RP-HPLC utilizing a C18 (4.6 × 100 mm) column, the mobile phase consisting of ethanol-deionized water (45: 55, v/v) and UV estimation at 254 nm. Adjustment of flow rate at 1 mL/min and pH at 3.5 with glacial acetic acid was done. Regarding the greenness profile, the proposed RP-HPLC method is greener than the reported one. ICH guidelines were followed to validate the developed methods. Successful applications of the developed methods were revealed by simultaneous determination of FR, SP and CN in pure forms and plasma samples in the ranges of 0.2-2, 0.05-2.6 and 0.05-2 µg/band for method A and 5-60, 2-60 and 2-60 µg/mL for method B for FR, SP and CN, respectively.

Successive ratio subtraction as a novel manipulation of ratio spectra for quantitative determination of a mixture of furosemide, spironolactone and canrenone.

Furosemide and spironolactone are commonly prescribed antihypertensive drugs. Canrenone is the main degradation product and main metabolite of spironolactone. Ratio subtraction and extended ratio subtraction spectrophotometric methods were previously applied for quantitation of only binary mixtures. An extension of the above mentioned methods; successive ratio subtraction, is introduced in the presented work for quantitative determination of ternary mixtures exemplified by furosemide, spironolactone and canrenone. Manipulating the ratio spectra of the ternary mixture allowed their determination at 273.6nm, 285nm and 240nm and in the concentration ranges of (2-16µgmL-1), (4-32µgmL-1) and (1-18µgmL-1) for furosemide, spironolactone and canrenone, respectively. Method specificity was ensured by the application to laboratory prepared mixtures. The introduced method was ensured to be accurate and precise. Validation of the developed method was done with respect to ICH guidelines and its validity was further ensured by the application to the pharmaceutical formulation. Statistical comparison between the obtained results and those obtained from the reported HPLC method was achieved concerning student's t-test and F ratio test where no significant difference was observed.

Synthetic approaches towards the multi target drug spironolactone and its potent analogues/derivatives.

Spironolactone is a well-known multi-target drug and is specifically used for the treatment of high blood pressure and heart failure. It is also used for the treatment of edema, cirrhosis of the liver, malignant, pediatric, nephrosis and primary hyperaldosteronism. Spironolactone in association with thiazide diuretics treats hypertension and in association with furosemide treats bronchopulmonary dyspepsia. The therapeutic mechanism of action of spironolactone involves binding to intracellular mineralocorticoids receptors (MRs) in kidney epithelial cells, thereby inhibiting the binding of aldosterone. Since its first synthesis in 1957 there are several synthetic approaches have been reported throughout the years, Synthetic community has devoted efforts to improve the synthesis of spironolactone and to synthesize its analogues and derivatives. This review aims to provide comprehensive insight for the synthetic endeavors devoted towards the synthesis of a versatile drug spironolactone and its analogues/derivatives.

Development of a high-yielding bioprocess for 11-α hydroxylation of canrenone under conditions of oxygen-enriched air supply.

A high yielding bioprocess for 11-α hydroxylation of canrenone (1a) using Aspergillus ochraceus ATCC 18500 was developed. The optimization of the biotransformation involved both fermentation (for achieving highly active mycelium of A. ochraceus) and biotransformation with the aim to obtain 11-α hydroxylation with high selectivity and yield. A medium based on sucrose as C-source resulted particularly suitable for conversion of canrenone into the corresponding 11-hydroxy derivative, whereas the use of O2-enriched air and dimethyl sulfoxide (DMSO) as a co-solvent for increasing substrate solubility played a crucial role for obtaining high yields (>95%) of the desired product in high chemical purity starting from 30mM (10.2g/L) of substrate. The structure of the hydroxylated product was confirmed by a combination of two-dimensional NMR proton-proton correlation techniques.

Clinically insignificant negative interferences of spironolactone, potassium canrenoate, and their common metabolite canrenone in new dimension vista LOCI digoxin immunoassay.

Spironolactone, a potassium-sparing diuretic metabolized to canrenone is often used with digoxin to treat various conditions including congestive heart failure. Potassium canrenoate is a similar drug, which is also metabolized to canrenone. Due to reported both positive and negative interference of spironolactone, potassium canrenoate, and their common metabolite canrenone with digoxin immunoassays, we investigated potential interference of these compounds with the new homogenous sequential chemiluminescent assay for digoxin based on the luminescent oxygen channeling technology (LOCI digoxin) for application on the Dimension and Vista platform. When aliquots of a drug-free serum pool were supplemented with various amounts of spironolactone, potassium canrenoate, or canrenone and apparent digoxin values were measured using Dimension Vista LOCI digoxin assay, we observed no detected value except when aliquots were supplemented with very high amounts of potassium canrenoate or canrenone. However, we observed that apparent digoxin concentrations were very low. When aliquots of a serum digoxin pool (prepared by pooling specimens from patients receiving digoxin), were further supplemented with various amounts of spironolactone, potassium canrenoate, or canrenone and serum digoxin concentrations were remeasured using the LOCIdigoxin assay, only statistically significant falsely lower digoxin values (negative interference) were observed in specimens containing very high amounts of canrenone or potassium canrenoate. However, such small bias may not have any clinical significance. We conclude that new Dimension Vista LOCI digoxin assay is virtually free from interferences of spironolactone, potassium canrenoate, and their common metabolite canrenone.

A diastereoselective synthesis of 7α-nitromethyl steroid derivative and its use for an efficient synthesis of eplerenone.

A novel and efficient method of stereoselectively introducing α-nitromethyl group to C-7 position of 11α-hydroxyl canrenone 4 was described. In addition, this method was successfully applied in a total synthesis of Eplerenone 8. The route was characteristic of simple operation, moderate reaction conditions with 5 steps and 55% total yield, at the same time, without any expensive or toxic reagent in use.

Effect of spironolactone, potassium canrenoate, and their common metabolite canrenone on Dimension Vista Digoxin Assay.

Spironolactone, a potassium sparing diuretic metabolized to canrenone, is often used with digoxin to treat various conditions including congestive heart failure. Potassium canrenoate is a similar drug that is also metabolized to canrenone. Due to reported interference of spironolactone, potassium canrenoate, and their common metabolite canrenone with digoxin immunoassays, we investigated potential interference of these compounds with Dimension Vista Digoxin immunoassay using Flex reagent cartridge. Aliquots of a drug-free serum pool were supplemented with various amounts of spironolactone, potassium canrenoate, or canrenone and apparent digoxin values were measured using Dimension Vista digoxin assay, we observed none-detected value except when aliquots were supplemented with higher amounts of spironolactone or canrenone. Similarly, when aliquots of a serum digoxin pool (prepared by pooling specimens from patients receiving digoxin) where further supplemented with various amounts of spironolactone, potassium canrenoate, or canrenone, we observed moderately falsely elevated digoxin values only in specimens containing higher amounts of spironolactone or canrenone. We conclude that spironolactone and canrenone but not potassium canrenoate may cause modest interference with Dimension Vista digoxin assay but such interferences may not be clinically significant except with very high amounts of canrenone.

Development and validation of an HPLC method for the determination of spironolactone and its metabolites in paediatric plasma samples.

An HPLC method has been developed and validated for the determination of spironolactone, 7 alpha-thiomethylspirolactone and canrenone in paediatric plasma samples. The method utilises 200 microl of plasma and sample preparation involves protein precipitation followed by Solid Phase Extraction (SPE). Determination of standard curves of peak height ratio (PHR) against concentration was performed by weighted least squares linear regression using a weighting factor of 1/concentration2. The developed method was found to be linear over concentration ranges of 30-1000 ng/ml for spironolactone and 25-1000 ng/ml for 7 alpha-thiomethylspirolactone and canrenone. The lower limit of quantification for spironolactone, 7 alpha-thiomethylspirolactone and canrenone were calculated as 28, 20 and 25 ng/ml, respectively. The method was shown to be applicable to the determination of spironolactone, 7 alpha-thiomethylspirolactone and canrenone in paediatric plasma samples and also plasma from healthy human volunteers.

Effects of canrenone on myocardial reactive fibrosis in a rat model of postinfarction heart failure.

BACKGROUND: Spironolactone reduces overall mortality by 30% in advanced congestive heart failure. Nevertheless, few data are available with regard to the effects of mineral corticoid inhibition in postinfarction heart failure. MATERIALS AND METHODS: Experimental myocardial infarction was induced by left coronary ligation in 70 male rats with body weights ranging from 180 to 200 gr. The day after surgery, animals were randomized to either placebo or canrenone-gamma-cyclodestrin 8 mg/kg/die or canrenone-gamma-cyclodestrin 18 mg/kg/die. Twelve animals served as the control group. After two weeks, the rats underwent closed chest left ventricular catheterization. The heart was the rapidly excised for subsequent histological analysis. RESULTS: Compared with controls, infarcted rats had reduced left ventricular systolic pressures (-6%) and higher left ventricular end-diastolic pressures (+600%), associated with a marked increase of mean collagen fraction (+446%) and perivascular fibrosis (+72%). Compared with placebo-infarcted rats, in the group treated with high canrenone dose there was a significant reduction of left ventricular systolic and end-diastolic pressures (-6.5% and -23%, respectively) and an attenuation of interstitial and perivascular fibrosis (-47% and -34%, respectively). The low-dose canrenone group did not show differences compared with the placebo infarcted rats, except for a slight reduction of mean collagen fraction (-21%). CONCLUSIONS: Canrenone attenuates LV interstitial remodeling and reduces filling pressures in rats with postinfarction heart failure.

Partial synthetic derivatization of canrenone and characterization of its impact on the inhibitory effect on Na+/K(+)-ATPase activity in human heart muscle.

To improve the weak inhibitory effect of 3-oxo-17 alpha-pregna-4,6-diene-21,17-carbolactone (canrenone, II) on Na+/K(+)-ATPase activity in human heart muscle, we have investigated the impact of hydrogenation, reduction, glycosidation, and the introduction of a 3-sulfonamido residue on the inhibitory potency of canrenone. The greatest increase in potency (> 20 times) was found for 3 beta-(alpha-L-rhamnopyranosyloxy)-5 beta, 17 alpha-pregnane-21, 17-carbolactone (IX). The 3-O-glycosides IX-XI are the first representatives of C/D-trans steroids with effector-receptor complex decay half-times longer than those of therapeutically used cardenolides.

The nitration of canrenone with acetic anhydride/nitric acid.

3-Oxo-17 alpha-pregna-4,6-diene-21,17-carbolactone (canrenone, II) is produced from the potassium salt of 17-hydroxy-3-oxo-17 alpha-pregna-4,6-diene-21-carboxylic acid (I) by acid catalyzed lactonization. II reacts with acetic anhydride/nitric acid to give one main product (III) and some minor products. The structure of III was determined by chemical and spectral analysis to the 4-nitro derivative of canrenone. This result is in contrast to the known reactions of II with most other reagents that were found to add at delta(6), and also in contrast to the reactions of acetic anhydride/nitric acid with alkenes. Electrophilic substitution at the ambident C4 is discussed as the reaction path. The 4-nitro group enhances the inhibitory activity of II against Na+/K(+)-ATPase, the target enzyme of the cardioactive digitalis glycosides, which appears to indicate increased cardioactivity.

[Acetylation of spironolactone, canrenone and 2-methyl-canrenone]. / Zur Acetylierung von Spironolacton, Canrenon und 2-Methylencanrenon.

Reaction of the title compounds with acetic anhydride and acetyl chloride yields the 3,5-dien-3-yl acetate 2, the isomeric 2,4,6- and 3,5,7-trien-3-yl acetates 3 and 4 as well as the 2,4,6,8(14)-tetraen-3-yl acetate 7. The 2 alpha-methyl-8,14-didehydro-canrenone (9) is obtained by hydrolysis of 7. Binding affinities of 7 and 9 to hormone receptors as well as serum proteins (SHBG, CBG) are investigated. The compounds are inactive.