Recombinant human N-acetylgalactosamine-6-sulfate sulfatase (GALNS) produced in the methylotrophic yeast Pichia pastoris.

Mucopolysaccharidosis IV A (MPS IV A, Morquio A disease) is a lysosomal storage disease (LSD) produced by mutations on N-acetylgalactosamine-6-sulfate sulfatase (GALNS). Recently an enzyme replacement therapy (ERT) for this disease was approved using a recombinant enzyme produced in CHO cells. Previously, we reported the production of an active GALNS enzyme in Escherichia coli that showed similar stability properties to that of a recombinant mammalian enzyme though it was not taken-up by culture cells. In this study, we showed the production of the human recombinant GALNS in the methylotrophic yeast Pichia pastoris GS115 (prGALNS). We observed that removal of native signal peptide and co-expression with human formylglycine-generating enzyme (SUMF1) allowed an improvement of 4.5-fold in the specific GALNS activity. prGALNS enzyme showed a high stability at 4 °C, while the activity was markedly reduced at 37 and 45 °C. It was noteworthy that prGALNS was taken-up by HEK293 cells and human skin fibroblasts in a dose-dependent manner through a process potentially mediated by an endocytic pathway, without any additional protein or host modification. The results show the potential of P. pastoris in the production of a human recombinant GALNS for the development of an ERT for Morquio A.

Enzyme replacement in a human model of mucopolysaccharidosis IVA in vitro and its biodistribution in the cartilage of wild type mice.

Mucopolysaccharidosis IVA (MPS IVA; Morquio A syndrome) is a lysosomal storage disorder caused by deficiency of N-acetylgalactosamine-6-sulfatase (GALNS), an enzyme that degrades keratan sulfate (KS). Currently no therapy for MPS IVA is available. We produced recombinant human (rh)GALNS as a potential enzyme replacement therapy for MPS IVA. Chinese hamster ovary cells stably overexpressing GALNS and sulfatase modifying factor-1 were used to produce active ( approximately 2 U/mg) and pure (>or=97%) rhGALNS. The recombinant enzyme was phosphorylated and was dose-dependently taken up by mannose-6-phosphate receptor (K(uptake) = 2.5 nM), thereby restoring enzyme activity in MPS IVA fibroblasts. In the absence of an animal model with a skeletal phenotype, we established chondrocytes isolated from two MPS IVA patients as a disease model in vitro. MPS IVA chondrocyte GALNS activity was not detectable and the cells exhibited KS storage up to 11-fold higher than unaffected chondrocytes. MPS IVA chondrocytes internalized rhGALNS into lysosomes, resulting in normalization of enzyme activity and decrease in KS storage. rhGALNS treatment also modulated gene expression, increasing expression of chondrogenic genes Collagen II, Collagen X, Aggrecan and Sox9 and decreasing abnormal expression of Collagen I. Intravenous administration of rhGALNS resulted in biodistribution throughout all layers of the heart valve and the entire thickness of the growth plate in wild-type mice. We show that enzyme replacement therapy with recombinant human GALNS results in clearance of keratan sulfate accumulation, and that such treatment ameliorates aberrant gene expression in human chondrocytes in vitro. Penetration of the therapeutic enzyme throughout poorly vascularized, but clinically relevant tissues, including growth plate cartilage and heart valve, as well as macrophages and hepatocytes in wild-type mouse, further supports development of rhGALNS as enzyme replacement therapy for MPS IVA.

Characterization and pharmacokinetic study of recombinant human N-acetylgalactosamine-6-sulfate sulfatase.

Mucopolysaccharidosis IVA (MPS IVA) is an autosomal recessive disorder caused by a deficiency of N-acetylgalactosamine-6-sulfate sulfatase (GALNS). The aims of this study were to establish Chinese hamster ovary (CHO) cells overexpressing recombinant human GALNS (rhGALNS) and to assess pharmacokinetics and tissue distribution of purified enzymes by using MPS IVA knock-out mouse (Galns(-/-)). The CHO-cell derived rhGALNS was purified from the media by a two-step affinity chromatography procedure. The rhGALNS was administered intravenously to 3-month-old Galns(-/-) mice at a single dose of 250U/g of body weight. The treated mice were examined by assaying the GALNS activity at baseline and up to 240min to assess clearance of the enzyme from blood circulation. The mice were sacrificed 4h after infusion of the enzyme to study the enzyme distribution in tissues. The rhGALNS was purified 1317-fold with 71% yield. The enzyme was taken up by Galns(-/-) chondrocytes (150U/mg/15h). The uptake was inhibited by mannose-6-phosphate. The enzyme activity disappeared from circulation with a half-life of 2.9min. After enzyme infusion, the enzyme was taken up and detected in multiple tissues (40.7% of total infused enzymes in liver). Twenty-four hours after a single infusion of the fluorescence-labeled enzymes into MPS IVA mice, biodistribution pattern showed the amount of tagged enzyme retained in bone, bone marrow, liver, spleen, kidney, and heart. In conclusion, we have shown that the phosphorylated rhGALNS is delivered to multiple tissues, including bone, and that it functions bioactively in Galns(-/-) chondrocytes implying a potential enzyme replacement treatment.

Recombinant caprine 3H-[N-acetylglucosamine-6-sulfatase] and human 3H-[N-acetylgalactosamine-4-sulfatase]: plasma clearance, tissue distribution, and cellular uptake in the rat.

The use of recombinant lysosomal enzymes for enzyme replacement therapy (ERT) is likely to be a necessary component of effective treatment regimens for lysosomal storage diseases (LSDs). The mechanism and rate of uptake into target cells, rate of disappearance of the enzyme from plasma, and its tissue distribution are important factors to assess the need for possible modifications to the enzyme, particularly for LSDs that affect the central nervous system (CNS). Two recombinant lysosomal enzymes, caprine N-acetylglucosamine-6-sulfatase (rc6S) and human N-acetylgalactosamine-4-sulfatase (rh4S), deficient in MPS IIID and MPS VI, respectively, were radiolabeled and purified. The major portion (>77%) of each recombinant enzyme contained the mannose-6-phosphate (M6P) recognition marker as demonstrated by their ability to bind to a M6P receptor affinity column. The uptake of 3H-rc6S and 3H-rh4S into cultured rat brain cells was also inhibited by the addition of 5 mM M6P to the culture medium. After iv administration of 0.4-0.5 mg/kg of 3H-rc6S and 1 mg/kg of 3H-rh4S to the rat, both enzymes were rapidly lost from the circulation in a biphasic fashion (t1/2 for 3H-rc6S = 1.25+/-0.15 min and 37.17+/-23.29 min; t1/2 for 3H-rh4S = 0.41 and 5.3 min). At this dose, about 6% of 3H-rc6S, but only 0.49% of 3H-rh4S, remained in the plasma 4 h after administration, whereas approx 30% of 3H-rc6S and more than 50% of 3H-rh4S was found in the liver. At doses of 1.6-2.0 mg/kg of 3H-rc6S and 1 mg/kg 3H-rh4S, but not at the lower dose of 3H-rc6S, trace levels of both 3H-rc6S and 3H-rh4S were detected in the brain. The low level of enzyme recovered from the brain suggests that modification of rc6S will be necessary to achieve sufficient enzyme uptake into the CNS for effective therapy of MPS IIID.

Expression, purification and characterization of recombinant human N-acetylgalactosamine-6-sulphatase.

Full-length cDNA sequences encoding human N-acetylgalactosamine-6-sulphatase were stably expressed in Chinese hamster ovary cells under the transcriptional control of the human polypeptide chain elongation factor 1 alpha gene promoter. A clonal cell line overexpressing recombinant N-acetylgalactosamine-6-sulphatase to a level of approx. 3 mg/l of culture medium was isolated. The secreted precursor enzyme was purified to homogeneity by a two-column procedure with an overall yield of 53% of the activity. The physical and catalytic parameters of the recombinant enzyme were similar to those of the mature form isolated from liver. On SDS/PAGE and gel filtration, recombinant N-acetylgalactosamine-6-sulphatase had a native molecular mass of 58-60 kDa. Recombinant N-acetylgalactosamine-6-sulphatase was endocytosed by mucopolysaccharidosis IVA fibroblasts via the mannose-6-phosphate receptor-mediated pathway and was efficiently localized to lysosomes.

Production and characterization of monoclonal antibodies to shark cartilage proteoglycan

1. Two proteoglycans, PG1 and PG2, have been isolated from shark cartilage. Both are highly polydisperse and large (molecular mass: 1-10 x 10**6 Daltons) and contain chondroitin sulfate and keratan sulfate side chains, but PG2 is somewhat smaller tham PG1 and contains less keratan sulfate. 2. Monoclonal antibodies were raised against PG1. Many antibodies were obtained and one of them, MST1, was subcloned and furter characterized. This monoclonal antibody reacts with PG1 and PG2 from shark cartilage and also with aggrecan from bovine trachea cartilage. Chondroitinase AC-treated proteglycans react MST1, indicating that the antibody does not reconize chondroitin sulfate. MST1 also recognizes aggrecan from human cartilage and a proteoglycan from bovine brain (neurocan) but it does reconize proteoglycans from rat Walker tumor, fetal calf muscle and decorin from human myoma. 3. Using MST1 we were able to demonstrate that both PG1 aggregate with hyaluronic acid

N-acetylgalactosamine-6-sulfate sulfatase in human placenta: purification and characteristics.

N-Acetylgalactosamine-6-sulfate sulfatase from human placenta was purified 33,600-fold using beta-N-acetyl-D-galactosamine 6-sulfate-(1----4)-beta-D-glucuronic acid-(1----3)-N-acetyl-D-[3H]galactosaminitol 6-sulfate as the substrate. This enzyme is an oligomer with a molecular mass of 120 kDa and consists of polypeptides of 40 and 15 kDa. The 15 kDa polypeptide is a glycoprotein. This purified protein has activities of N-acetylgalactosamine-6-sulfate sulfatase and galactose-6-sulfate sulfatase. Rabbit antiserum was raised against the purified protein. The antibody titrated N-acetylgalactosamine-6-sulfate sulfatase and galactose-6-sulfate sulfatase. The size of the precursor of the enzyme is 60 kDa, as determined by cell-free translation. The optimal pH values of the N-acetylgalactosamine-6-sulfate sulfatase and galactose-6-sulfate sulfatase activities are pH 3.8-4.0, and the Kms are 8 and 13 microM, respectively. Sulfate and phosphate ions are potent competitive inhibitors for the enzyme and their inhibition constants are 35 and 200 microM, respectively. Cross-reactive materials of 40 and 15 kDa were detected by immunoblot analysis, in the placenta, liver, and normal fibroblasts, but not in fibroblasts from a patient with Morquio disease.

Human liver N-acetylgalactosamine 6-sulphatase. Purification and characterization.

Human N-acetylgalactosamine 6-sulphatase (EC 3.1.6.14), which is involved in the lysosomal degradation of the glycosaminoglycans keratan sulphate and chondroitin 6-sulphate, was purified more than 130,000-fold in 2.8% yield from liver by an eight-step column procedure. One major form was identified with a pI of 5.7 and a native molecular mass of 62 kDa by gel filtration. When analysed by SDS/PAGE, dithioerythritol-reduced enzyme contained polypeptides of molecular masses 57 kDa, 39 kDa and 19 kDa, whereas non-reduced enzyme contained a major polypeptide of molecular mass 70 kDa. It is proposed that active enzyme contains either the 57 kDa polypeptide or disulphide-linked 39 kDa and 19 kDa polypeptides. Minor amounts of other enzyme forms separated during the chromatofocusing step and the Blue A-agarose step were not further characterized. Purified N-acetylgalactosamine 6-sulphatase was inactive towards 4-methylumbelliferyl sulphate, but was active, with pH optima of 3.5-4.0, towards 6-sulphated oligosaccharide substrates. Km values of 12.5 and 50 microM and Vmax. values of 1.5 and 0.09 mumol/min per mg were determined with oligosaccharide substrates derived from chondroitin 6-sulphate and keratan sulphate respectively. Sulphate, phosphate and chloride ions were inhibitors of enzyme activity towards both substrates, with 50 microM-Na2SO4 giving 50% inhibition towards the chondroitin 6-sulphate trisaccharide substrate.

Purification and properties of human N-acetylgalactosamine-6-sulfate sulfatase.

1. Human N-acetylgalactosamine-6-sulfate sulfatase (EC 3.1.6.-) from human placenta has been purified more than 3000-fold by gel filtration, ion-exchange and substrate affinity chromatography. The enzyme has a molecular weight of 90 000 by gel filtration chromatography and 85 000 by sodium dodecyl sulfate (SDS)-polyacrylamide gel electrophoresis. Enzyme purified from cultured human skin fibroblasts has similar properties. 2. The tritium-labeled chrondroitin 6-sulfate trisaccharide N-acetylgalactosamine 6-sulfate-(beta, 1-4)-glucuronic acid-(beta, 1-3(-N-acetyl[1-3H]galactosaminitol 6-sulfate as substrate demonstrated a Km of 0.12 mM at pH 4.5. Sulfate was hydrolyzed only from the non-reducing terminal of this disulfated trisaccharide. Hyaluronic acid, dermatan sulfate, chondroitin 4-sulfate, heparin and chondroitin 6-sulfate tetrasaccharide were slightly inhibitory, whereas 6-sulfated pentasaccharides and heptasaccharides were strongly inhibitory. The enzyme dose not hydrolyze sulfate from N-acetylglucosamine 6-sulfate.

Purification and properties of N-acetylgalactosamine 6-sulphate sulphatase from human placenta.

1. N-Acetylgalactosamine 6-sulphate sulphatase was purified about 20000-fold from the soluble extract of human placenta with N-acetylgalactosamine 6-sulphate-glucuronic acid-N-acetyl[1-(3)H]galactosaminitol 6-sulphate as substrate in the activity assay. The enzyme appears to be a glycoprotein with a mol.wt. of about 100000 as determined by gel filtration. On gel electrophoresis in the presence of sodium dodecyl sulphate the major protein band had a mol.wt. of 78000. Variable charge heterogeneity was observed in several enzyme preparations. 2. The purified enzyme released up to one sulphate molecule from the disulphated trisaccharide. It was active towards N-acetylgalactosamine 6-sulphate and exhibited no measurable N-acetylglucosamine 6-sulphate sulphatase or any other known lysosomal sulphatase activity. Hydrolysis of [1-(3)H]galactitol 6-sulphate was achieved by incubation neither with a crude nor with a purified enzyme preparation. Chondroitin 6-sulphate and keratan sulphate, as well as heparin and heparan sulphate, served as competitive inhibitors of the enzyme. 3. Purified N-acetylgalactosamine 6-sulphate sulphatase activity was optimal at pH4.9 and 4.4 when assayed in 0.02m-sodium acetate buffer and at pH4.2 and 5.2 in 0.1m-sodium acetate buffer. A single pH-optimum at pH4.8 was observed for the crude enzyme and for the purified enzyme after mild periodate treatment. The sulphatase activity was inhibited by a variety of anions and cations and activated by thiol-specific and thiol reagents.