RESUMEN
Electrons with energies of 300 keV or lower have the potential to decontaminate the surfaces of various types of food products with minimal loss of quality. The aim of the present work was to determine the thickness of the layer inhabited by microorganisms. The food samples tested were black and white pepper irradiated with 200 keV, 230 keV, 300 keV and 9 MeV beams of electron energy. To determine the depth from the surface which can be inhabited by microorganisms two approaches were tested. The methods used were based on the application of different microbiological recovery techniques and the microbial effectiveness of the irradiation process depending on the energy of the electron beam. It was observed that the layer which microorganisms may contaminate differed for the tested samples it was estimated as being below 100 µm thick for white pepper and about 200 µm for black pepper. The penetration ability was significant in experiments performed, and as a result the electron beam at the lowest levels tested (200 and 230 keV) was found to be insufficient to effectively decontaminate the black pepper samples. The beam of energy 300 keV was found to have a similar microbial inactivation effect as the high energy electron beam (9 MeV).
Asunto(s)
Bacterias/efectos de la radiación , Contaminación de Alimentos/prevención & control , Irradiación de Alimentos/métodos , Piper nigrum/microbiología , Bacterias/crecimiento & desarrollo , Bacterias/aislamiento & purificación , Electrones , Contaminación de Alimentos/análisis , Irradiación de Alimentos/instrumentación , Viabilidad Microbiana/efectos de la radiación , Piper nigrum/efectos de la radiación , Verduras/microbiología , Verduras/efectos de la radiaciónRESUMEN
In this study the suitability of a thin-film reactor (TFR) equipped with special flow guiding elements (FGE) was examined to analyse its capability to inactivate microorganisms in milk. Experiments were carried out with UHT-milk inoculated with Escherichia coli (E. coli), DH5α and Listeria innocua (L. innocua) WS 2258. Furthermore, the inactivation of microorganisms originally occurring in raw milk was investigated. E. coli, DH5α and L. innocua serving as biodosimeter were reduced by 4.58-log and 3.19-log, respectively. In milk, the original microorganisms showed a 4-log reduction. Without FGE the reduction was below 0.13-log. Thus, it can be derived that the efficacy of a UV-C thin-film reactor processing absorptive media like milk can be highly improved using FGE.
Asunto(s)
Escherichia coli/efectos de la radiación , Irradiación de Alimentos/métodos , Listeria/efectos de la radiación , Leche/microbiología , Animales , Recuento de Colonia Microbiana , Escherichia coli/crecimiento & desarrollo , Irradiación de Alimentos/instrumentación , Microbiología de Alimentos , Listeria/crecimiento & desarrollo , Microbiota/efectos de la radiación , Leche/química , Rayos UltravioletaRESUMEN
Although due to their acidity some fruit juices are considered safe, several outbreaks have been reported. For processing fruit juices, microwave heating offers advantages such as shorter come-up time, faster and uniform heating, and energy efficiency. Thus, it could be a beneficial alternative to conventional pasteurization. The objective of this study was to study the inactivation kinetics of Escherichia coli O157:H7 and Salmonella Typhimurium under microwave pasteurization at temperatures between 80 and 90 °C, i.e., at conditions that are employed in conventional pasteurization. Inoculated juices were treated at different power levels (600 W, 720 W) and treatment times (5s, 10s, 15s, 20s, 25s). Time-temperature profiles were obtained by fiber-optic sensors in contact with the samples allowing continuous data collection. The log-logistic and Arrhenius equations were used to account for the influence of the temperature history; thus, resulting in two different modeling approaches that were compared in terms of their prediction abilities. Survival kinetics including non-isothermal conditions were described by a non-linear ordinary differential equation that was numerically solved by the Runge-Kutta method (ode45 in MATLAB ®). The lsqcurvefit function (MATLAB®) was employed to estimate the corresponding survival parameters, which were obtained from freshly made apple juice, whereas the prediction ability of these parameters was evaluated on commercial apple juices. Results indicated that inactivation increased with power level, temperature, and treatment time reaching a microbial reduction up to 7 Log10 cycles. The study is relevant to the food industry because it provides a quantitative tool to predict survival characteristics of pathogens at other non-isothermal processing conditions.
Asunto(s)
Escherichia coli O157/efectos de la radiación , Irradiación de Alimentos/métodos , Jugos de Frutas y Vegetales/microbiología , Malus/microbiología , Salmonella typhimurium/efectos de la radiación , Recuento de Colonia Microbiana , Escherichia coli O157/crecimiento & desarrollo , Irradiación de Alimentos/instrumentación , Microondas , Salmonella typhimurium/crecimiento & desarrollo , TemperaturaRESUMEN
In this study, we examined the change in resistance of Salmonella enterica serovar Typhimurium and Escherichia coli O157:H7 to 222-nm krypton-chlorine (KrCl) excilamp treatment as influenced by acid adaptation and identified a mechanism of resistance change. In addition, we measured changes in apple juice quality indicators, such as color, total phenols, and 2,2-diphenyl-1-picrylhydrazyl (DPPH) free radical scavenging activity, during treatment. Non-acid-adapted and acid-adapted pathogens were induced by growing the cells in tryptic soy broth without dextrose (TSB w/o D) at pH 7.3 and in TSB w/o D at pH 5.0 (adjusted with HCl), respectively. For the KrCl excilamp treatment, acid-adapted pathogens exhibited significantly (P < 0.05) higher D5d values, which indicate dosages required to achieve a 5-log reduction, than those for non-acid-adapted pathogens in both commercially clarified apple juice and phosphate-buffered saline (PBS), and the pathogens in the juice showed significantly (P < 0.05) higher D5d values than those for pathogens in PBS because of the UV-absorbing characteristics of apple juice. Through mechanism identification, it was found that the generation of lipid peroxidation in the cell membrane, inducing cell membrane destruction, was significantly (P < 0.05) lower in acid-adapted cells than in non-acid-adapted cells for the same amount of reactive oxygen species (ROS) generated at the same dose because the ratio of unsaturated to saturated fatty acids (USFA/SFA) in the cell membrane was significantly (P < 0.05) decreased as a result of acid adaptation. Treated apple juice showed no significant (P > 0.05) difference in quality indicators compared to those of untreated controls during treatment at 1,773 mJ/cm2IMPORTANCE There is a need for novel, mercury-free UV lamp technology to replace germicidal lamps containing harmful mercury, which are routinely utilized for UV pasteurization of apple juice. In addition, consideration of the changes in response to antimicrobial treatments that may occur when pathogens are adapted to the acid in an apple juice matrix is critical to the practical application of this technology. Based on this, an investigation using 222-nm KrCl excilamp technology, an attractive alternative to mercury lamps, was conducted. Our study demonstrated increased resistance to 222-nm KrCl excilamp treatment as pathogens adapted to acids, and this was due to changes in reactivity to ROS with changes in the fatty acid composition of the cell membrane. Despite increased resistance, the 222-nm KrCl excilamp achieved pathogen reductions of 5 log or more at laboratory scale without affecting apple juice quality. These results provide valuable baseline data for application of 222-nm KrCl excilamps in the apple juice industry.
Asunto(s)
Ácidos/metabolismo , Escherichia coli O157/fisiología , Escherichia coli O157/efectos de la radiación , Jugos de Frutas y Vegetales/microbiología , Salmonella typhimurium/fisiología , Salmonella typhimurium/efectos de la radiación , Adaptación Fisiológica , Cloro/química , Cloro/farmacología , Escherichia coli O157/crecimiento & desarrollo , Irradiación de Alimentos/instrumentación , Irradiación de Alimentos/métodos , Jugos de Frutas y Vegetales/análisis , Concentración de Iones de Hidrógeno , Criptón/química , Criptón/farmacología , Láseres de Excímeros , Malus/química , Malus/microbiología , Salmonella typhimurium/crecimiento & desarrolloRESUMEN
The object of this study was to elucidate the bactericidal mechanism of a 222â¯nm Krypton Chlorine (KrCl) excilamp compared with that of a 254â¯nm Low Pressure mercury (LP Hg) lamp. The KrCl excilamp had higher bactericidal capacity against Gram-positive pathogenic bacteria (Staphylococcus aureus and L. monocytogenes) and Gram-negative pathogenic bacteria (S. Typhimurium and E. coli O157:H7) than did the LP Hg lamp when cell suspensions in PBS were irradiated with each type of UV lamp. It was found out that the KrCl excilamp induced cell membrane damage as a form of depolarization. From the study of respiratory chain dehydrogenase activity and the lipid peroxidation assay, it was revealed that cell membrane damage was attributed to inactivation of enzymes related to generation of membrane potential and occurrence of lipid peroxidation. Direct absorption of UV radiation which led to photoreaction through formation of an excited state was one of the causes inducing cell damage. Additionally, generation of ROS and thus occurrence of secondary damage can be another cause. The LP Hg lamp only induced damage to DNA but not to other components such as lipids or proteins. This difference was derived from differences of UV radiation absorption by cellular materials.
Asunto(s)
Cloruros/química , Manipulación de Alimentos/instrumentación , Irradiación de Alimentos/instrumentación , Microbiología de Alimentos/instrumentación , Enfermedades Transmitidas por los Alimentos/prevención & control , Bacterias Gramnegativas/efectos de la radiación , Bacterias Grampositivas/efectos de la radiación , Criptón/química , Compuestos de Mercurio/química , Rayos Ultravioleta , Daño del ADN , Diseño de Equipo , Escherichia coli/crecimiento & desarrollo , Escherichia coli/metabolismo , Escherichia coli/efectos de la radiación , Enfermedades Transmitidas por los Alimentos/microbiología , Bacterias Gramnegativas/crecimiento & desarrollo , Bacterias Gramnegativas/metabolismo , Bacterias Grampositivas/crecimiento & desarrollo , Bacterias Grampositivas/metabolismo , Cinética , Peroxidación de Lípido/efectos de la radiación , Listeria monocytogenes/crecimiento & desarrollo , Listeria monocytogenes/metabolismo , Listeria monocytogenes/efectos de la radiación , Estrés Oxidativo/efectos de la radiación , Especies Reactivas de Oxígeno/metabolismo , Salmonella typhimurium/crecimiento & desarrollo , Salmonella typhimurium/metabolismo , Salmonella typhimurium/efectos de la radiación , Staphylococcus aureus/crecimiento & desarrollo , Staphylococcus aureus/metabolismo , Staphylococcus aureus/efectos de la radiaciónRESUMEN
BACKGROUND: High microbial load is a serious concern in terms of the health-related safety of products of animal origin. In this study, the microbial loads of commercial frozen duck-meat products, including bone-in whole raw, boneless sliced raw, and boneless whole smoked, were investigated for pathogenic contamination. The application of electron beam irradiation was also investigated. RESULTS: The samples revealed a serious microbial threat (102 -105 CFU g-1 for total aerobic bacteria and positive for foodborne pathogens), which required effective decontamination technology. Electron-beam irradiation (0, 1, 3, and 7 kGy) could potentially improve the hygienic quality of duck-meat samples. The D10 values for Listeria monocytogenes and Salmonella Typhi were 0.47 and 0.51 kGy, respectively. A direct epifluorescent filter technique and aerobic plate count (DEFT/APC) method was used for screening, while electron-spin resonance (ESR) spectroscopy and gas chromatography with mass spectrometry were effective as confirmatory techniques to identify radiation-induced markers in frozen duck meat. CONCLUSION: Electron-beam irradiation has the potential to ensure the microbial safety and hygienic quality of commercial duck meats. Identification of the samples for their irradiation history was also possible using radiation-induced detection markers, including the DEFT/APC, hydroxyapatite ESR radicals, and hydrocarbons. © 2018 Society of Chemical Industry.
Asunto(s)
Contaminación de Alimentos/prevención & control , Irradiación de Alimentos/métodos , Productos de la Carne/microbiología , Animales , Patos , Contaminación de Alimentos/análisis , Irradiación de Alimentos/instrumentación , Microbiología de Alimentos , Listeria monocytogenes/crecimiento & desarrollo , Listeria monocytogenes/efectos de la radiación , Productos de la Carne/efectos de la radiación , Control de Calidad , Salmonella typhi/crecimiento & desarrollo , Salmonella typhi/efectos de la radiaciónRESUMEN
In this study, the evaluation of the performance of two thin-film UV-C reactors (annular and Taylor-Couette) and a coiled tube system is presented using actinometry and biodosimetry methods. The iodide/iodate actinometry method was found suitable for comparison of the efficiency of UV-C dose delivery of the UV-C continuous flow systems. Inactivation kinetics of Escherichia coli ATCC 8739 in quarter-strength Ringer's solution (absorption coefficient α254 nm â¼ 0 cm-1) at various flow conditions at Reynolds numbers in the range of 26 to 3000 showed a good correlation between the different reactor types. In high UV-C absorbing liquids, the inactivation efficiency increases due to the improved radial mixing. The inactivation performance of the Taylor-Couette system correlates to the annular reactor when no rotation force is applied. The residence time distributions showed the narrowest distribution with the coiled tube system at comparable flow rates. The results indicate that, despite the laminar flow conditions, the performance of the Taylor-Couette unit becomes equal to the turbulent flow conditions of the coiled tube reactor by rotation of the inner cylinder.
Asunto(s)
Reactores Biológicos/microbiología , Desinfección/métodos , Irradiación de Alimentos/instrumentación , Irradiación de Alimentos/métodos , Rayos Ultravioleta , Recuento de Colonia Microbiana , Relación Dosis-Respuesta en la Radiación , Diseño de Equipo , Escherichia coli/crecimiento & desarrollo , Escherichia coli/efectos de la radiación , Cinética , Viabilidad Microbiana/efectos de la radiación , Radiometría , Movimientos del AguaRESUMEN
UVC light is a widely used sterilization technology. However, UV lamps have several limitations, including low activity at refrigeration temperatures, a long warm-up time, and risk of mercury exposure. UV-type lamps only emit light at 254 nm, so as an alternative, UV light-emitting diodes (UV-LEDs) which can produce the desired wavelengths have been developed. In this study, we validated the inactivation efficacy of UV-LEDs by wavelength and compared the results to those of conventional UV lamps. Selective media inoculated with Escherichia coli O157:H7, Salmonella enterica serovar Typhimurium, and Listeria monocytogenes were irradiated using UV-LEDs at 266, 270, 275, and 279 nm in the UVC spectrum at 0.1, 0.2, 0.5, and 0.7 mJ/cm(2), respectively. The radiation intensity of the UV-LEDs was about 4 µW/cm(2), and UV lamps were covered with polypropylene films to adjust the light intensity similar to those of UV-LEDs. In addition, we applied UV-LED to sliced cheese at doses of 1, 2, and 3 mJ/cm(2). Our results showed that inactivation rates after UV-LED treatment were significantly different (P < 0.05) from those of UV lamps at a similar intensity. On microbiological media, UV-LED treatments at 266 and 270 nm showed significantly different (P < 0.05) inactivation effects than other wavelength modules. For sliced cheeses, 4- to 5-log reductions occurred after treatment at 3 mJ/cm(2) for all three pathogens, with negligible generation of injured cells.
Asunto(s)
Queso/microbiología , Escherichia coli O157/efectos de la radiación , Irradiación de Alimentos/métodos , Listeria monocytogenes/efectos de la radiación , Salmonella typhimurium/efectos de la radiación , Queso/análisis , Escherichia coli O157/crecimiento & desarrollo , Contaminación de Alimentos/análisis , Contaminación de Alimentos/prevención & control , Irradiación de Alimentos/instrumentación , Microbiología de Alimentos , Calor , Listeria monocytogenes/crecimiento & desarrollo , Viabilidad Microbiana/efectos de la radiación , Pasteurización , Salmonella typhimurium/crecimiento & desarrollo , Rayos UltravioletaRESUMEN
This study evaluated the efficacy of a 915 MHz microwave with 3 different levels to inactivate 3 serovars of Salmonella in peanut butter. Peanut butter inoculated with Salmonella enterica serovar Senftenberg, S. enterica serovar Typhimurium and S. enterica serovar Tennessee were treated with a 915 MHz microwave with 2, 4 and 6 kW and acid and peroxide values and color changes were determined after 5 min of microwave heating. Salmonella populations were reduced with increasing treatment time and treatment power. Six kW 915 MHz microwave treatment for 5 min reduced these three Salmonella serovars by 3.24-4.26 log CFU/g. Four and two kW 915 MHz microwave processing for 5 min reduced these Salmonella serovars by 1.14-1.48 and 0.15-0.42 log CFU/g, respectively. Microwave treatment did not affect acid, peroxide, or color values of peanut butter. These results demonstrate that 915 MHz microwave processing can be used as a control method for reducing Salmonella in peanut butter without producing quality deterioration.
Asunto(s)
Arachis/microbiología , Irradiación de Alimentos/métodos , Salmonella typhimurium/efectos de la radiación , Salmonella/efectos de la radiación , Arachis/química , Color , Irradiación de Alimentos/instrumentación , Calor , Viabilidad Microbiana/efectos de la radiación , Microondas , Salmonella/crecimiento & desarrollo , Salmonella typhimurium/crecimiento & desarrolloRESUMEN
Low-pressure mercury UV (LP-UV) lamps have long been used for bacterial inactivation, but due to certain disadvantages, such as the possibility of mercury leakage, deep-UV-C light-emitting diodes (DUV-LEDs) for disinfection have recently been of great interest as an alternative. Therefore, in this study, we examined the basic spectral properties of DUV-LEDs and the effects of UV-C irradiation for inactivating foodborne pathogens, including Escherichia coli O157:H7, Salmonella enterica serovar Typhimurium, and Listeria monocytogenes, on solid media, as well as in water. As the temperature increased, DUV-LED light intensity decreased slightly, whereas LP-UV lamps showed increasing intensity until they reached a peak at around 30°C. As the irradiation dosage and temperature increased, E. coli O157:H7 and S. Typhimurium experienced 5- to 6-log-unit reductions. L. monocytogenes was reduced by over 5 log units at a dose of 1.67 mJ/cm(2). At 90% relative humidity (RH), only E. coli O157:H7 experienced inactivation significantly greater than at 30 and 60% RH. In a water treatment study involving a continuous system, 6.38-, 5.81-, and 3.47-log-unit reductions were achieved in E. coli O157:H7, S. Typhimurium, and L. monocytogenes, respectively, at 0.5 liter per minute (LPM) and 200 mW output power. The results of this study suggest that the use of DUV-LEDs may compensate for the drawbacks of using LP-UV lamps to inactivate foodborne pathogens.
Asunto(s)
Escherichia coli O157/efectos de la radiación , Irradiación de Alimentos/métodos , Listeria monocytogenes/efectos de la radiación , Salmonella typhimurium/efectos de la radiación , Escherichia coli O157/crecimiento & desarrollo , Contaminación de Alimentos/prevención & control , Irradiación de Alimentos/instrumentación , Microbiología de Alimentos , Listeria monocytogenes/crecimiento & desarrollo , Viabilidad Microbiana/efectos de la radiación , Salmonella typhimurium/crecimiento & desarrollo , Temperatura , Rayos UltravioletaRESUMEN
Nonthermal technologies are being investigated as viable alternatives to, or supplemental utilization, with thermal pasteurization in the food-processing industry. In this study, the effect of ultraviolet (UV)-C light on the inactivation of seven milkborne pathogens (Listeria monocytogenes, Serratia marcescens, Salmonella Senftenberg, Yersinia enterocolitica, Aeromonas hydrophila, Escherichia coli, and Staphylococcus aureus) was evaluated. The pathogens were suspended in ultra-high-temperature whole milk and treated at UV doses between 0 and 5000 J/L at a flow rate of 4300 L/h in a thin-film turbulent flow-through pilot system. Of the seven milkborne pathogens tested, L. monocytogenes was the most UV resistant, requiring 2000 J/L of UV-C exposure to reach a 5-log reduction. The most sensitive bacterium was S. aureus, requiring only 1450 J/L to reach a 5-log reduction. This study demonstrated that the survival curves were nonlinear. Sigmoidal inactivation curves were observed for all tested bacterial strains. Nonlinear modeling of the inactivation data was a better fit than the traditional log-linear approach. Results obtained from this study indicate that UV illumination has the potential to be used as a nonthermal method to reduce microorganism populations in milk.
Asunto(s)
Irradiación de Alimentos/instrumentación , Enfermedades Transmitidas por los Alimentos/prevención & control , Bacterias Gramnegativas/efectos de la radiación , Bacterias Grampositivas/efectos de la radiación , Leche/microbiología , Modelos Biológicos , Animales , Bovinos , Recuento de Colonia Microbiana , Relación Dosis-Respuesta en la Radiación , Enfermedades Transmitidas por los Alimentos/microbiología , Bacterias Gramnegativas/crecimiento & desarrollo , Bacterias Gramnegativas/aislamiento & purificación , Bacterias Grampositivas/crecimiento & desarrollo , Bacterias Grampositivas/aislamiento & purificación , Humanos , Viabilidad Microbiana/efectos de la radiación , Leche/efectos de la radiación , Tolerancia a Radiación , Rayos UltravioletaRESUMEN
The effects of a flexible thin-layer dielectric barrier discharge (DBD) plasma system using a sealed package on microbial inactivation and quality attributes of fresh pork and beef were tested. Following a 10-min treatment, the microbial-load reductions of Listeria monocytogenes, Escherichia coli O157:H7, and Salmonella Typhimurium were 2.04, 2.54, and 2.68 Log CFU/g in pork-butt samples and 1.90, 2.57, and 2.58 Log CFU/g in beef-loin samples, respectively. Colorimetric analysis showed that DBD-plasma treatment did not significantly affect L* values (lightness) of pork and beef samples, but lowered a* values (redness) significantly after 5- and 7.5-min exposures. The plasma treatment significantly influenced lipid oxidation only after a 10-min exposure. The texture of both types of meat was unaffected by plasma treatment. All sensory parameters of treated and non-treated samples were comparable except for taste, which was negatively influenced by the plasma treatment (P < 0.05). This thin-layer DBD-plasma system can be applied to inactivate foodborne pathogens. The observed minor deterioration of meat quality might be prevented by the use of hurdle technology.
Asunto(s)
Escherichia coli O157/efectos de la radiación , Irradiación de Alimentos/métodos , Listeria monocytogenes/efectos de la radiación , Carne/microbiología , Salmonella typhimurium/efectos de la radiación , Animales , Bovinos , Escherichia coli O157/crecimiento & desarrollo , Contaminación de Alimentos/análisis , Contaminación de Alimentos/prevención & control , Irradiación de Alimentos/instrumentación , Humanos , Listeria monocytogenes/crecimiento & desarrollo , Carne/análisis , Carne/efectos de la radiación , Viabilidad Microbiana/efectos de la radiación , Salmonella typhimurium/crecimiento & desarrollo , Porcinos , GustoRESUMEN
Pathogen inactivation induced by atmospheric pressure dielectric barrier discharge (DBD) (250 W, 15 kHz, air discharge) produced in a rectangular plastic container and the effect of post-treatment storage time on inactivation were evaluated using agar plates and cheese slices. When agar plates were treated with plasma, populations of Escherichia coli, Salmonella Typhimurium, and Listeria monocytogenes showed 3.57, 6.69, and 6.53 decimal reductions at 60 s, 45 s, and 7 min, respectively. When the pathogens tested were inoculated on cheese slices, 2.67, 3.10, and 1.65 decimal reductions were achieved at the same respective treatment times. The post-treatment storage duration following plasma treatment potently affected further reduction in pathogen populations. Therefore, the newly developed encapsulated DBD-plasma system for use in a container can be applied to improve the safety of sliced cheese, and increasing post-treatment storage time can greatly enhance the system's pathogen-inactivation efficiency.
Asunto(s)
Queso/microbiología , Escherichia coli O157/efectos de la radiación , Irradiación de Alimentos/métodos , Listeria monocytogenes/efectos de la radiación , Viabilidad Microbiana/efectos de la radiación , Salmonella typhimurium/efectos de la radiación , Queso/efectos de la radiación , Escherichia coli O157/crecimiento & desarrollo , Contaminación de Alimentos/análisis , Contaminación de Alimentos/prevención & control , Irradiación de Alimentos/instrumentación , Listeria monocytogenes/crecimiento & desarrollo , Salmonella typhimurium/crecimiento & desarrolloRESUMEN
The CiderSure 3500 is one of the most commonly used UV juice processing units in the United States for the nonthermal processing of apple cider and fulfills the 5-log performance standard established by the federal juice HACCP regulation. However, the appropriate validation frequency of this machine's quartz tubes is currently unknown by juice processors and regulatory agencies. Presently, an annual validation is recommended by the manufacturer. Historical validation data from 1998 to 2013 of commercially used quartz tubes underwent comprehensive statistical analysis. A total of 400 tubes were validated one time, and 212 of those units were revalidated at least once over the evaluated time frame. Validations were performed at 14 mJ·cm(-2) UV dose and under turbulent flow conditions. Every validation showed a greater than 5-log reduction of Escherichia coli ATCC 25922, a nonpathogenic surrogate for pathogenic E. coli O157:H7, in each of three replicates. For initial validations, a mixed-effect model with log reduction of E. coli as response was constructed (400 tubes analyzed in triplicate). The model showed that the year of analysis and the initial inoculum level significantly affected the log reduction of E. coli (P < 0.0001), which on average was 7.0 ± 0.7. A quadratic relationship between the year of analysis and the response was found. Likewise, for revalidations (212 tubes analyzed in triplicate), the constructed random coefficient model showed that the year of analysis, quadratic effect of year of analysis, and initial inoculum level significantly affected the log reduction of E. coli (P < 0.0001). For this model, the major source of variance was explained by the year of analysis. The models describe the UV reactor's performance over time and suggest that a validation frequency of every 3 years would be conservatively adequate during the first 8 years of quartz tube use. After that, due to the reported quadratic trend, yearly validation would be recommended.
Asunto(s)
Bebidas/microbiología , Irradiación de Alimentos/instrumentación , Irradiación de Alimentos/normas , Microbiología de Alimentos/estadística & datos numéricos , Frutas , Malus , Escherichia coli/aislamiento & purificación , Escherichia coli O157/aislamiento & purificación , Manipulación de Alimentos/instrumentación , Manipulación de Alimentos/métodos , Manipulación de Alimentos/estadística & datos numéricos , Irradiación de Alimentos/legislación & jurisprudencia , Microbiología de Alimentos/métodos , Control de Calidad , Factores de Tiempo , Estados UnidosRESUMEN
The aim of this study was to investigate the inactivation kinetics of Salmonella enterica serovar Typhimurium, Escherichia coli O157:H7, and Listeria monocytogenes on ready-to-eat sliced ham by near-infrared (NIR) heating as a function of the processing parameter, radiation intensity. Precooked ham slices inoculated with the three pathogens were treated at different NIR intensities (ca. 100, 150, and 200 µW/cm(2)/nm). An increase in the applied radiation intensity resulted in a gradual increase of inactivation of all pathogens. The survival curves of the three pathogens exhibited both shoulder and tailing behavior at all light intensities. Among nonlinear models, the Weibull distribution and log-logistic model were used to describe the experimental data, and the statistical results (mean square error and R(2) values) indicated the suitability of the model for prediction. The log-logistic model more accurately described survival curves of the three pathogens than did the Weibull distribution at all radiation intensities. The output of this study and the proposed kinetics model would be beneficial to the deli meat industry for selecting the optimum processing conditions of NIR heating to meet the target pathogen inactivation on ready-to-eat sliced ham.
Asunto(s)
Escherichia coli O157/efectos de la radiación , Comida Rápida/microbiología , Irradiación de Alimentos/métodos , Listeria monocytogenes/efectos de la radiación , Productos de la Carne/microbiología , Viabilidad Microbiana/efectos de la radiación , Salmonella typhimurium/efectos de la radiación , Animales , Escherichia coli O157/química , Escherichia coli O157/crecimiento & desarrollo , Irradiación de Alimentos/instrumentación , Rayos Infrarrojos , Cinética , Listeria monocytogenes/química , Listeria monocytogenes/crecimiento & desarrollo , Modelos Logísticos , Productos de la Carne/efectos de la radiación , Salmonella typhimurium/química , Salmonella typhimurium/crecimiento & desarrollo , PorcinosRESUMEN
Blue light irradiation was applied to postharvest strawberry fruit to explore its influence on anthocyanin content and anthocyanin biosynthetic enzyme activities. Strawberry fruit was irradiated with blue light at 40 µmol m(-2) s(-1) for 12 days at 5 °C. The results indicated that blue light treatment improved total anthocyanin content in strawberry fruit during storage. Meanwhile, the treatment increased the activities of glucose-6-phosphate, shikimate dehydrogenase, tyrosine ammonia-lyase, phenylalanine ammonia-lyase, cinnamate-4-hydroxylase, 4-coumarate/coenzyme A ligase, dihydroflavonol-4-reductase, chalcone synthase, flavanone-3-ß-hydroxylase, anthocyanin synthase, and UDP-glycose flavonoid-3-O-glycosyltranferase, which suggested that the enhancement of anthocyanin concentration by blue light might result from the activation of its related enzymes. Blue light might be proposed as a supplemental light source in the storage of strawberry fruit to improve its anthocyanin content.
Asunto(s)
Antocianinas/análisis , Irradiación de Alimentos/métodos , Fragaria/enzimología , Frutas/efectos de la radiación , Proteínas de Plantas/análisis , Irradiación de Alimentos/instrumentación , Fragaria/química , Fragaria/efectos de la radiación , Frutas/química , Frutas/enzimología , LuzRESUMEN
Inactivation of Listeria innocua by pulsed light (PL) was evaluated at different post-treatment temperature and illumination conditions. The impact of post-PL-treatment temperature on L. innocua culturability was evaluated for cells cultured at 37 °C (optimal growth temperature) and 4 °C (classical refrigerated food temperature). For both culture conditions, significant higher reductions (up to 3 log) were observed after post-PL-treatment temperature of 4 °C than of 37 °C. Contrarily, L. innocua culturability after PL treatment increased up to 2.2 log in presence of daylight illumination in comparison to dark storage. This photorepair mechanism was quickly activated reaching the maximum photoreactivation level after only 30 min of illumination. Moreover, photorepair capacity was rapidly reduced by increasing the time in darkness from PL treatment to samples illumination, being completely lost after time in darkness equal or greater than 5 h. According to these findings, the combination of PL with post-treatment temperature of 4 °C has a synergistic effect on the inactivation of L. innocua, whereas post-treatment daylight illumination has an antagonic effect on PL antimicrobial efficacy. Post-PL-treatment temperature and illumination conditions could be thereby considered important environmental factors to activate, inhibit or control the repair and/or growth of L. innocua survivors after PL treatment.
Asunto(s)
Irradiación de Alimentos/métodos , Listeria/efectos de la radiación , Viabilidad Microbiana/efectos de la radiación , Irradiación de Alimentos/instrumentación , Luz , Listeria/crecimiento & desarrollo , Temperatura , Factores de TiempoRESUMEN
Infant milk formula has recently been implicated as a transmission vehicle for an emerging foodborne pathogen, Enterobacter sakazakii, resulting in high mortality rates. Electron beam (e-beam) efficiently and non-thermally inactivates foodborne pathogens, including E. sakazakii, in infant milk formula. However, the effects of e-beam on chemical changes of nutrients in infant formula have not been determined. Therefore, the objective of this study was to fulfill this gap. Dehydrated infant milk formula was processed with e-beam at 0 (control) to 25 kGy. Amino acid, fatty acid, and mineral profiles (AAP, FAP, and MP, respectively), as well as protein degradation and lipid oxidation, were determined. There were no differences (P>0.05) in FAP, AAP, and MP. SDS-PAGE electrophoresis qualitatively detected three major protein bands in all samples up to 25 kGy. Densitometry analysis of SDS-PAGE gels confirmed no size degradation (P>0.05) as a function of increased e-beam dose. Totol-volatile-basic-nitrogen (TVBN) excluded (P>0.05) protein degradation due to microbial activity. There was no increase (P>0.05) in lipid oxidation, as assessed with thiobarbituric-reactive-substances (TBARS), except in samples processed at 25 kGy. Dehydrated formula has low water activity, which likely protected nutrients from e-beam-induced chemical changes. This study demonstrates that proteins, lipids, and minerals in infant milk formula are stable when processed with e-beam up to 25 kGy at low temperature and under anaerobic conditions.
Asunto(s)
Irradiación de Alimentos/métodos , Alimentos Infantiles/efectos de la radiación , Fórmulas Infantiles/química , Aminoácidos/análisis , Ácidos Grasos/análisis , Irradiación de Alimentos/instrumentación , Rayos gamma , Alimentos Infantiles/análisis , Minerales/análisis , Valor Nutritivo/efectos de la radiación , Proteínas/análisisRESUMEN
This is a study on the efficacy of pulsed light (PL) technology for the inactivation of Salmonella enterica serovar Enteritidis on shell eggs. In preliminary studies on noble agar, a PL treatment of 0.7 J/cm(2) gave an inactivation of 6.7 log CFU/cm(2). Photoreactivation of Salmonella (0.5-0.7 log CFU/cm(2)) was observed. Different results were obtained in eggs according to the state of the cuticle. When unwashed eggs were pulsed, 24 to 80% of the samples showed the maximum decontamination (3.6 log CFU/egg), depending on the fluence applied. This maximum was not obtained on washed eggs, in which the highest reduction was 1.8 log CFU/egg with a fluence of 12 J/cm(2). PL can be a useful method for egg processing since the integrity of the cuticle is preserved, and requires that the treatment should be applied as soon as possible after laying and on unwashed eggs. As Salmonella has shown the capability of photoreactivation, it is advisable to keep eggs protected from light once they have been pulsed.
Asunto(s)
Cáscara de Huevo/microbiología , Irradiación de Alimentos , Microbiología de Alimentos , Luz , Salmonella enteritidis/efectos de la radiación , Animales , Desinfección/métodos , Cáscara de Huevo/ultraestructura , Irradiación de Alimentos/instrumentación , Viabilidad MicrobianaRESUMEN
Radiation processing plants are designed to deliver a prescribed dose to product materials within the acceptable uniformity to meet the national standards. The dose uniformity ratios for four different product geometries of a proposed 37 PBq (10(6) Ci) 60Co-based, multi-product irradiator facility in India are evaluated using the Monte Carlo method for various product densities, 0.15 g cm-3, 0.4 g cm-3, and 0.6 g cm-3. The calculations are also carried out using the point kernel method for comparison purposes. The agreement between Monte Carlo and point kernel methods is within 3 to 15%. The suitable product geometry is identified based on dose uniformity ratios.