Access to bedding and outdoor runs for growing-finishing pigs: is it possible to improve welfare without increasing environmental impacts?

Providing bedding or access to an outdoor run are husbandry aspects intended to improve pig welfare, which is currently financially supported through animal welfare schemes in several European countries. However, they may significantly affect the environment through changes in feed efficiency and manure management. Therefore, the aim of this paper was to compare farms differing in animal welfare relevant husbandry aspects regarding (1) the welfare of growing-finishing pigs and (2) environmental impact categories such as global warming (GW), acidification (AC), and freshwater (FE) and marine eutrophication (ME), by employing an attributional Life Cycle Assessment. We collected data on 50 farms with growing-finishing pigs in seven European countries. Ten animal-based welfare indicators were aggregated into three pig welfare indices using principal component analysis. Cluster analysis of farms based on husbandry aspects resulted in three clusters: NOBED (31 farms without bedding or outdoor run), BED (11 farms with bedding only) and BEDOUT (eight farms with bedding and outdoor run). Pigs on farms with bedding (BED and BEDOUT) manipulated enrichment more often (P < 0.001), pen fixtures less frequently (P = 0.003) and showed fewer oral stereotypies (P < 0.001) than pigs on NOBED farms. There were fewer pigs with a short(er) tail on farms with than without bedding (P < 0.001). Acidification of BEDOUT and BED farms was significantly higher (compared to NOBED farms P = 0.002) due to higher ammonia emissions related to farmyard manure. Also, BEDOUT farms had higher ME than NOBED farms (P = 0.035). There were no significant differences regarding GW and FE between husbandry clusters, due to the large variability within clusters regarding feed composition and conversion. Therefore, both husbandry aspects associated with improved animal welfare have a significant influence on some environmental impacts, such as acidification and marine eutrophication. Nevertheless, the large variation within clusters suggests that trade-offs may be minimised through e.g. AC and ME.

Comparisons of recycled manure solids and wood shavings/sawdust as bedding material-Implications for animal welfare, herd health, milk quality, and bedding costs in Swedish dairy herds.

Increasing shortages and costs of common bedding materials have led dairy farmers in Sweden to consider using recycled manure solids (RMS), which are readily available and low cost, as an alternative bedding material. The main risks are effects on udder health and milk quality, but RMS could also affect animal welfare and claw health. The advantages and disadvantages of using RMS bedding have not been fully investigated, and findings in other countries cannot be directly applied to Swedish conditions and climate. This observational cross-sectional study investigated the use of RMS as bedding, regarding associations with certain aspects of animal welfare, herd health, milk quality, and bedding costs in Swedish dairy herds. Thirty-four dairy farms using RMS or wood shavings/sawdust (each n = 17) were compared. Each farm was visited 2 times during the housing period from 2020 to 2021, once from October to December and once from March to May. Dairy barns were observed, animal welfare was assessed, and freestall dimensions were measured. Farm owners were interviewed about housing system characteristics, herd performance, and herd management. Data on milk production and herd health were obtained from the Swedish official milk recording scheme for the indoor period from October to March. The prevalence of claw disorders and abnormal claw conformation were collected from the national claw health database for the period from October to May. On each farm visit, composite samples of unused bedding outside the barn and used bedding material from the freestalls, respectively, were taken for total bacterial count and DM analysis. Samples of bulk tank milk for determination of total bacterial count were taken in connection to the visits. In addition, samples of unused and used bedding material and manure from alleys for analysis of 3 Treponema species associated with digital dermatitis (DD) were gathered and analyzed. Total bacterial count was significantly higher in unused (8.50 log10 cfu/g) and used RMS bedding (9.75 log10 cfu/g) than in wood shavings/sawdust (used 4.74; unused 8.63 log10 cfu/g), but there were no significant differences in bulk milk total bacterial count (median 4.07 vs. 3.89 log10 cfu/mL) or SCC (median 243,800 vs. 229,200 cells/mL). The aspects of animal welfare assessed did not differ significantly between the 2 bedding systems, whereas the prevalence of total claw disorders (25.9% vs. 38.0% of trimmed cows), dermatitis (6.9% vs. 16.2% of trimmed cows) and sole ulcers (2.0% vs. 4.0% of trimmed cows) were significantly lower in the RMS herds. Treponema spp. were not detected in unused RMS material, but all RMS herds had presence of DD recorded at foot trimming. An economic assessment based on the interview results and price level from winter 2021 revealed that the costs of RMS bedding varied with amount of RMS produced. Thus, RMS is a potential alternative bedding material for dairy cows in Sweden and can be a profitable option for large dairy herds. However, the high level of total bacteria in the material requires attention to bedding and milking routines as well as regular monitoring of herd health.

Ability of unsterilized recycled manure solids bedding to support growth of Klebsiella pneumoniae and Escherichia coli.

Although recycled manure solids (RMS) bedding is used on dairy farms, it could allow bacterial growth when contaminated by feces and thus increase the incidence of clinical mastitis in cows. The objective of this study was to describe bacterial growth in three different types of RMS bedding, as well as in sand, when samples were experimentally inoculated with Escherichia coli and Klebsiella pneumoniae. Two 3-day trials were conducted, during which treatments included inoculating bedding samples with E. coli and K. pneumoniae, as well as no inoculation. The trial was repeated 3 times for each bedding sample on each day. Samples were incubated at 15°C for 3 d and bacterial counts were measured every day. After inoculation, there was no significant K. pneumoniae or E. coli growth phase during the trial in those RMS samples that were prepared either in a container or in a heap. Recycled manure solids and sand samples prepared in a rotary drum, however, showed a similar active growth phase of K. pneumoniae during the first 24 h of the trial. Moreover, a significant E. coli growth phase was observed in the samples of sand bedding in the first 24 h. The 3 different types of RMS bedding samples did not react in a similar manner to coliform inoculation. No active growth phase was observed in bedding samples already containing a high bacterial concentration following inoculation with coliforms.

Bien que la litière de fumier recyclé (LFR) soit utilisée dans les fermes laitières, elle pourrait permettre la croissance bactérienne lorsqu'elle est contaminée par des matières fécales et augmenter ainsi l'incidence de mammite clinique chez les vaches. L'objectif de cette étude était de décrire la croissance bactérienne dans trois types de LFR, ainsi que dans du sable, lorsque des échantillons étaient inoculés expérimentalement avec Escherichia coli et Klebsiella pneumoniae. Deux essais de trois jours ont été réalisés, au cours desquels les échantillons de litière ont été inoculés ou non avec E. coli et K. pneumoniae. L'essai a été répété trois fois pour chaque échantillon de litière, chaque jour. Les échantillons ont été incubés à 15 °C pendant 3 jours et la numération bactérienne a été mesurée chaque jour. Après inoculation, il n'y a pas eu de phase de croissance significative de K. pneumoniae ou d'E. coli au cours de l'essai dans les échantillons de LFR préparés dans un conteneur ou en tas. Les échantillons de sable et de LFR préparés dans un tambour rotatif ont cependant montré une phase de croissance active similaire de K. pneumoniae pendant les premières 24 heures de l'essai. En outre, une phase de croissance significative d'E. coli a été observée dans les échantillons de litière de sable au cours des premières 24 h. Les trois différents types d'échantillons de LFR n'ont pas réagi de la même manière à l'inoculation de coliformes. Aucune phase de croissance active n'a été observée dans les échantillons de litière contenant déjà une concentration bactérienne élevée après l'inoculation de coliformes.(Traduit par Docteur Simon Dufour).

Exploring herd-level perinatal calf mortality risk factors in eastern Canadian dairy farms.

This closed cohort study aimed to identify the associations between dairy calf management practices and herd-level perinatal calf mortality risk. From February 2020 to June 2021, predominantly Holstein dairy farms in Québec (n = 1,832) and New Brunswick (n = 52), Canada, that were registered in the dairy herd improvement program were visited once. A questionnaire covering all aspects of precalving, calving, and colostrum management was administered. Data regarding perinatal mortality were retrieved from the dairy herd improvement program database for each farm for 2021. Perinatal mortality was calculated for each farm as the proportion of calves dead at birth or dying within 24 h after birth. A multivariable negative binomial model was used to assess herd-level factors associated with the risk of perinatal mortality. The final model included the lying surface in the calving area, the typical time to first colostrum intake, typical cow-calf contact time, the proportion of males born, the proportion of assisted calvings, and herd size. Herd-level perinatal mortality risk ranged from 0% to 38.1% (mean ± SE = 7.6% ± 0.1%). A greater proportion of males born, a higher proportion of assisted calvings, and delayed colostrum feeding were associated with increased herd-level perinatal mortality. Factors associated with a decreased herd-level perinatal mortality risk were having a typical cow-calf contact time between 7 and 12 h after calving compared with reduced cow-calf contact time, soft lying surfaces in the calving area compared with concrete and mat-lying surfaces, and an increased number of calvings per year. Our results show that although some of the significant risk factors are not well understood (i.e., calving area lying surface, typical cow-calf contact time), Canadian farmers could focus on the factors under their control (i.e., time to first colostrum feeding, proportion of difficult calvings, males born, and calvings per year) to reduce the risk of perinatal mortality. Future work should focus on qualitative research to understand the dairy farmer motivations and limitations to implementing practices identified in this and other studies to reduce perinatal mortality.

Using Filter Media and Soiled Bedding in Disposable Individually Ventilated Cages as a Refinement to Specific Pathogen-free Mouse Health Monitoring Programs.

Molecular-based methods have shown potential for improving pathogen detection and reducing animal use. While increasing evidence supports rodent-free environmental health PCR pathogen detection, limited information is available regarding efficacy for disposable individually ventilated caging systems. In such systems, testing of plenum exhaust air dust is ineffective, and the use of collection media is optimal. We performed a series of studies to compare PCR infectious agent detection with dust collected on media placed in a mouse-free soiled bedding cage, the cage exhaust filter of an occupied sentinel cage, and direct sampling from colony and sentinel mice with traditional soiled bedding mouse sentinels. We hypothesized that after a 3-mo period, testing of filter media agitated in a soiled bedding cage would be equal to or more sensitive than more traditional methods. Agitated media detected Astrovirus-1, segmented filamentous bacteria and Helicobacter ganmani to a degree comparable to testing lid exhaust filter PCR from a sentinel mouse cage, but opportunists such as Staphylococcus aureus and Proteus mirabilis were not detected consistently, and H. hepaticus was not detected at all. Direct sampling of pooled fecal pellets and body swabs from sentinel mice and testing using PCR also failed to reliably detect opportunists and Helicobacter spp. While further work is needed to refine use of filter media in soiled bedding for detection of lower prevalence opportunists, this report provides evidence that a rodent-free method of reliably detecting murine agents in a disposable individually ventilated cage system with cage-level filtration outperforms direct sampling of soiled bedding sentinel mice.

Distribution of staphylococcal and mammaliicoccal species from compost-bedded pack or sand-bedded freestall dairy farms.

The purpose of this prospective observational study was to determine whether dairy cattle housing types were associated with staphylococcal and mammaliicoccal populations found on teat skin, bedding, and in bulk tank milk. Twenty herds (n = 10 sand-bedded freestall herds; n = 10 compost-bedded pack herds) were enrolled. Each herd was visited twice for sample collection, and at each visit, 5 niches were sampled, including bulk tank milk, composite teat skin swab samples collected before premilking teat preparation, composite teat skin swab samples collected after premilking teat preparation, unused fresh bedding, and used bedding. All samples were plated on Mannitol salt agar and Columbia blood agar and staphylococcal-like colonies were selected for further evaluation. Bacterial colonies were speciated using MALDI-TOF mass spectrometry. All species were grouped into 4 categories included host-adapted, opportunistic, environmental, and unclassified. Absolute numbers and proportions of each genus and species were calculated. Proportional data were compared between groups using Fisher's exact test. Data representing 471 staphylococcal-like organisms were analyzed. Overall, 27 different staphylococcal and mammaliicoccal species were identified. Staphylococcus chromogenes was the only species identified from all 20 farms. A total of 20 different staphylococcal-like species were identified from bulk tank milk samples with the most prevalent species being S. chromogenes, followed by Staphylococcus aureus and Mammaliicoccus sciuri. Overall, more staphylococcal and mammaliicoccal isolates were identified among used bedding than unused bedding. The increased numbers of isolates within used bedding were primarily from used sand bedding samples, with 79% (76/96) of used bedding isolates being identified from sand bedding and only 20.8% (20/96) from used compost-bedded pack samples. When comparing categories found among sample types, more unclassified species were found in used sand bedding than in used compost-bedded pack samples. This finding is possibly related to the composting temperatures resulting in reduced growth or destruction of bacterial species. The prevalence of S. aureus was high in bulk tank milk for all herds, regardless of herd type, which may represent the influence of unmeasured management factors. Overall, staphylococcal and mammaliicoccal species were highly prevalent among samples from both farm types.

Supplemental reflective blankets and wool socks help maintain body temperature in dogs undergoing celiotomy procedures: a prospective randomized controlled clinical trial.

OBJECTIVE: To compare results for body (esophageal) temperature measurements obtained during celiotomy in normothermic (presurgical) canine patients receiving routine heat support versus routine heat support plus supplemental support (consisting of covering the thorax in a reflective blanket and placing reflective blankets plus wool socks on 3 limbs) in a prospective randomized controlled clinical trial. ANIMALS: 44 dogs requiring celiotomy that were presented sequentially to an emergency and specialty referral veterinary hospital. PROCEDURES: The 44 dogs undergoing celiotomy were randomly assigned to 2 groups. The control group received routine intraoperative heat support consisting of a circulating warm water blanket and either a towel or blanket. The supplemental group received the same routine heat support plus a reflective blanket covering the cervical and thoracic regions and reflective blankets wrapped around 3 limbs and covered with wool socks from the digits to the axillary or inguinal region. RESULTS: Mean esophageal temperature for both the control and supplemental groups dropped throughout celiotomy. Esophageal temperature measurements at several time points were significantly higher for the supplemental group than for the control group. The lowest temperature measurement for the supplemental group, adjusted for initial esophageal temperature and procedure duration, was significantly higher by 0.8 °C than that for the control group. CLINICAL RELEVANCE: Covering the cervical and thoracic regions with a reflective blanket and wrapping limbs in reflective blankets and wool socks is an affordable adjunctive method to provide passive heat support and minimize perioperative hypothermia in canine patients undergoing celiotomy.

Bedding system influences lying behaviour in dairy cows.

BACKGROUND: The nature and depth of bedding material have an important influence on cow lying behaviour and comfort. Increasing use of recycled manure solids (RMS) as bedding led to an investigation of the influence of this material on cow lying behaviour. METHODS: Leg mounted accelerometers were used to estimate daily lying time and number and duration of lying bouts in four groups of 40 cows. Each group spent two 2-week periods on each of four bedding systems: deep sand, deep RMS, sawdust on mattresses and RMS on mattresses. RESULTS: Total daily lying times were significantly shorter on both RMS treatments than on sawdust. Number of lying bouts per day was greater on sawdust than any other treatment, while lying bouts were 2.6 min longer on deep RMS and 9.3 min longer on sand, than on sawdust. CONCLUSIONS: Greater depth and apparent softness of bedding material does not necessarily result in longer total daily lying times. RMS may have some characteristics that reduce its attraction as a bedding material for cows. The influence of bedding system on number and duration of lying bouts and the resulting total lying time appear complex.

Characterization of different types of broiler bedding including dehydrated grass and their influence on production.

The objective is to evaluate different bedding materials, including dehydrated grass, on performance and carcass yield and verify the physicochemical and microbiological characteristics of materials. The completely randomized experiment comprised 1,080 chicks in a 3 × 2 factorial design with three levels of dehydrated grass (0%, 25%, and 50%) and two bedding materials (rice husks and shavings). Total microorganism count and physicochemical characteristics, surface temperature of birds, and performance of birds were analyzed up to 42 days of age, when birds were slaughtered, and carcass yield was evaluated. The inclusion of grass showed a higher microbiological count after 1 day, stabilizing with materials after 28 days. The inclusion of 50% of dehydrated grass resulted in a higher surface bed temperature at 42 days. Inclusions above 25% of grass have a lower density and a greater water retention capacity, pH, moisture, and total nitrogen, in addition to a lower FDA in its structure. The highest ammonia emissions occurred with the inclusion of 25% of grass. The inclusion of dehydrated grass did not affect performance and carcass yield, favoring feed conversion at the initial stages. The inclusion of grass can replace up to 25% of shavings without harming physicochemical parameters of materials and birds' performance.

Infrared radiation from cage bedding moderates rat inflammatory and autoimmune responses in collagen-induced arthritis.

The development of collagen type II (CII)-induced arthritis (CIA), a model of rheumatoid arthritis, in rats housed in cages with bedding composed of Celliant fibres containing ceramic particles, which absorb body heat and re-emit the energy back to the body in the form of infrared radiation (+IRF rats), and those housed in cages with standard wooden shaving bedding (-IRF control rats) was examined. The appearance of the first signs of CIA was postponed, while the disease was milder (judging by the arthritic score, paw volume, and burrowing behaviour) in +IRF compared with -IRF rats. This correlated with a lower magnitude of serum anti-CII IgG antibody levels in +IRF rats, and lower production level of IL-17, the Th17 signature cytokine, in cultures of their paws. This could be partly ascribed to impaired migration of antigen-loaded CD11b + dendritic cells and their positioning within lymph nodes in +IRF rats reflecting diminished lymph node expression of CCL19 /CCL21. Additionally, as confirmed in rats with carrageenan-induced paw inflammation (CIPI), the infrared radiation from Celliant fibres, independently from immunomodulatory effects, exerted anti-inflammatory effects (judging by a shift in pro-inflammatory mediator to anti-inflammatory/immunoregulatory mediator ratio towards the latter in paw cultures) and ameliorated burrowing behaviour in CIA rats.

Making tiestalls more comfortable: IV. Increasing stall bed length and decreasing manger wall height to heal injuries and increase lying time in dairy cows housed in deep-bedded tiestalls.

Poor stall configuration can negatively affect cow welfare by impairing lying behavior and leading to injuries in dairy cows. The comfort of the stall bed in tiestalls is affected by the material components of the stall bed (stall base and bedding), but also by the amount of space provided. The amount of space cows are able to access lengthwise in a tiestall is determined by the stall bed length and the height of the manger wall (the front limit of the stall bed), which can limit access into the space available at the front of the stall. This project aimed to maximize cow comfort in deep-bedded tiestalls by investigating the combined effect of increased bed length and decreased manger wall height in a crossover experiment (2 periods with 1 wk habituation + 6 wk data collection). Two rows of 12 tiestalls were modified (n = 24 cows). Each row was a different length, short (178 cm; length commonly found in Quebec) or long (188 cm), and cows remained on the same row (same stall bed length) for the entire experiment. In each row, there were 6 stalls of each manger wall height treatment: high (20 cm, upper limit recommended) or low (5 cm). During period 2, cows switched manger wall height treatments. A 7.6-cm-deep straw bedding layer was added to all stalls by adding a bedding keeper to the ends of stalls. All initially injured locations healed over the 14-wk study, and 2 patterns of healing emerged. Improvement in hock injury (lateral tarsal and calcanei) was observed from wk 1 to 6 for all treatments. A plateau in injury severity score reduction was observed in period 2 for the hock (lateral, dorsal, and medial calcanei), anatomical knee, carpal joints (front knees), and proximal and medial neck, which was likely the result of the insensitivity of the injury scoring scheme rather than healing not occurring. Cows in long stalls were found to spend more time lying (14.1 vs. 13.3 h/d) and had longer lying bouts than cows in short stalls (74.1 vs. 52.9 min/bout). Manger wall height did not affect injury or lying time, but may affect how cows position themselves while lying. Higher lying times in our study were comparable to those reported in deep-bedded loose pens, indicating that cows with more bedding, especially those in long stalls, were more comfortable. Our results suggest that deep-bedded straw stalls with bedding keepers have the potential to be beneficial to cow comfort on tiestall farms.

Potential contaminants and hazards in alternative chicken bedding materials and proposed guidance levels: a review.

Bedding material or litter is an important requirement of meat chicken production which can influence bird welfare, health, and food safety. A substantial increase in demand and cost of chicken bedding has stimulated interest in alternative bedding sources worldwide. However, risks arising from the use of alternative bedding materials for raising meat chickens are currently unknown. Organic chemicals, elemental, and biological contaminants, as well as physical and management hazards need to be managed in litter to protect the health of chickens and consequently that of human consumers. This requires access to information on the transfer of contaminants from litter to food to inform risk profiles and assessments to guide litter risk management. In this review, contaminants and hazards of known and potential concern in alternative bedding are described and compared with existing standards for feed. The contaminants considered in this review include organic chemical contaminants (e.g., pesticides), elemental contaminants (e.g., arsenic, cadmium, and lead), biological contaminants (phytotoxins, mycotoxins, and microorganisms), physical hazards, and management hazards. Reference is made to scientific literature for acceptable levels of the above contaminants in chicken feed that can be used for guidance by those involved in selecting and using bedding materials.

Validating a heat stress model: The effects of an electric heat blanket and nutritional plane on lactating dairy cows.

The efficacy of an electric heat blanket (EHB) has previously been confirmed as an alternative method to evaluate heat stress (HS). However, a pair-feeding design has not been used with the EHB model. Therefore, study objectives were to determine the contribution of the nutritional plane to altered metabolism and productivity during EHB-induced HS. Multiparous Holstein cows (n = 18; 140 ± 10 d in milk) were subjected to 2 experimental periods (P); during P1 (4 d), cows were in thermoneutral conditions with ad libitum feed intake. During P2 (4 d), cows were assigned to 1 of 2 treatments: (1) thermoneutral conditions and pair-fed (PF; n = 8) or (2) EHB-induced HS with ad libitum feed intake (n = 10). Overall, the EHB increased rectal temperature, vaginal temperature, skin temperature, and respiration rate (1.4°C, 1.3°C, 0.8°C, and 42 breaths/min, respectively) relative to PF cows. The EHB reduced dry matter intake (DMI; 47%) and, by design, PF cows had a similar pattern and extent of decreased DMI. Milk yield decreased in EHB and PF cows by 27.3% (12.1 kg) and 13.4% (5.4 kg), respectively, indicating that reduced DMI accounted for only ∼50% of decreased milk synthesis. Milk fat content tended to increase (19%) in the EHB group, whereas in the PF cows it remained similar relative to P1. During P2, milk protein and lactose contents tended to decrease or decreased (1.3 and 2.2%, respectively) in both EHB and PF groups. Milk urea nitrogen remained unchanged in PF controls but increased (34.2%) in EHB cows relative to P1. The EHB decreased blood partial pressure of CO2, total CO2, HCO3, and base excess levels (17, 16, 17, and 81%, respectively) compared with those in PF cows. During P2, the EHB and PF cows had similar decreases (4%) in plasma glucose content, but no differences in circulating insulin were detected. However, a group by day interaction was detected for plasma nonesterified fatty acids; levels progressively increased in PF controls but remained unaltered in the EHB cows. Blood urea nitrogen increased in the EHB cows (61%) compared with the PF controls. In summary, utilizing the EHB model indicated that reduced nutrient intake explains only about 50% of the decrease in milk yield during HS, and the postabsorptive changes in nutrient partitioning are similar to those obtained in climate-controlled chamber studies. Consequently, the EHB is a reasonable and economically feasible model to study environmental physiology of dairy cows.

Effect of recycled manure solids as bedding on bulk tank milk and implications for cheese microbiological quality.

The dairy farm environment influences the raw milk microbiota and consequently affects milk processing. Therefore, it is crucial to investigate farm management practices such as the bedding materials. The aim of this study was to evaluate the effect of recycled manure solids (RMS) as bedding material on bulk tank milk and microbiological implications for cheese quality. Bulk tank samples were collected from 84 dairy farms using RMS or straw bedding. The use of RMS did not influence thermophilic and mesophilic aerobic viable counts from spores. However, straw-milk samples gave higher values for mesophilic anaerobic spore-forming bacteria (0.44 log cfu/mL) than RMS-milk samples (0.17 log cfu/mL). The presence of thermoresistant lactic acid bacteria was not increased in milk from farms using RMS. Nevertheless, taxonomic profiles of thermoresistant bacteria isolated were different between the 2 types of milk. More Enterococcus faecalis and Streptococcus spp. were identified in RMS-milk samples. Thermoresistant enterococci and streptococci could easily end up in cheese. Therefore, milk proteolytic activities of these isolates were tested. Neither Streptococcus spp. nor Enterococcus faecium isolates exhibited proteolytic activities, whereas 53% of E. faecalis showed some. Also, only 1 vancomycin-resistant enterococcus was detected. Survival of selected RMS-milk samples isolates (3 E. faecalis and 1 Streptococcus thermophilus) was evaluated during a model Cheddar cheese manufacture. Although those strains survived well, they did not modify the acidification curve of milk. However, they might cause organoleptic defects during cheese maturing.

Short communication: Use of the Clegg hammer measure as an indicator of stall-surface compressibility in tie-stall housing and its relationship with stall comfort.

Stall base and stall surface (i.e., with or without bedding) are key risk factors in cow comfort in dairy herds. In Canada, rubber mats, concrete floors, and mattresses are the most common stall bases used in tie-stall systems. Straw, wood shavings, and sand, at variable depths, are the most commonly used type of bedding. The Clegg hammer (Clegg Impact Soil Tester Hammer; Lafayette Instrument Company, Lafayette, IN) is a tool used by engineers to test the compressibility of pavement or golf course surfaces. Recently, this tool has also been used to measure the compressibility of the stall surface on freestall dairy farms. A total of 32 tie-stall dairy herds were selected in Québec to test the usefulness of the Clegg hammer as a tool to assess stall surface compressibility in tie-stall housing. This study had 2 main objectives: (1) identify the location and the number of measurements needed to obtain a stable indicator of compressibility, and (2) identify differences in the compressibility of the stall surface depending on the stall base and bedding depth. On each farm, we tested the compressibility of 10 stalls. No significant differences were found between the front and the back of the stall for the location of the Clegg hammer measures. The differences in readings of the Clegg hammer were nonsignificant after the third measure taken at the same location, meaning that 3 measures are sufficient at one location to obtain a compressibility measure. Significant differences were found among the different stall base and surface combinations tested. Rubber mats were less compressible than mattresses. When a large quantity of bedding (>7.5 cm) was added on top of rubber mats, the compressibility results were equal to those of mattresses ≥10 yr old without bedding. To appropriately test the compressibility of stall surface in tie-stall farms, we recommend measuring the compressibility of the stall base on its own and with the usual amount of bedding used on the farm. Our study establishes that both stall base and surface affect compressibility, and that a large quantity of bedding helps increase the compressibility of the bed, especially on a harder stall base.

Production, economic viability and risks associated with switching dairy cows from drylots to compost bedded pack systems.

The use of compost bedded pack systems (CBS) has increased over the past 5 years in tropical countries, and studies associating production traits with economical outcomes of this system are warranted. Our objectives were to evaluate productive traits, economic outcomes and the risks of losses of dairy farms that switched from a drylot system (DLS) to a CBS and to compare these with similar farms that did not change their system. We collected data from 18 farms over 36 consecutive months (August 2014 to July 2017). All farms started the study as DLS, and six farms switched to CBS in the second year. The other 12 farms kept their DLS during the 36 months of evaluation. Annual technical and economic indexes per farm were collected and calculated. Additionally, a risk analysis was performed based on a 10-year historical series of milk prices. The results were analysed using a regression model including year and herd as categorical variables (fixed), system and herd size as quantitative variables (fixed), and system × herd as a random variable. Furthermore, a non-metric multidimensional scaling plot was used to evaluate producers' profiles in each year. Milk fat, milk total solids, and somatic cell count did not change when farms switched from DLS to CBS, and averaged 3.80%, 12.04%, and 256 500 cells/ml, respectively. However, milk protein (%) decreased in CBS farms. The majority of milk production variables were not affected. Nevertheless, farms that switched to CBS increased milk production per cow by 13.3% compared with DLS farms. Total operation costs (296 076.83 $/year) were not affected by the system, and neither were the costs of concentrates, roughage, labour or medicines. Net margin per litre (0.09 $/l), operating profit (14.95%), assets per litre (398.68 $/l per day) and return on assets (10.27%) did not change when farms switched from DLS to CBS. Net margin ($/l and $/cow) and asset turnover rate increased in CBS farms. Risk analysis indicated that the risk was reduced by 38% in CBS farms. Furthermore, our analysis showed that producers who switched to CBS had similar technical and economic indexes in the first year before switching their system. In conclusion, this study demonstrates that CBS systems might be promising for producers in tropical countries who are looking for a more productive and less risky system. We did not observe improvements in animal health as previously reported in the literature.

Cross-sectional study of the relationships among bedding materials, bedding bacteria counts, and intramammary infection in late-lactation dairy cows.

Objectives of this study were to (1) describe the intramammary infection (IMI) prevalence and pathogen profiles in quarters of cows approaching dry-off in US dairy herds, (2) compare IMI prevalence in quarters of cows exposed to different bedding material types, and (3) identify associations between bedding bacteria count and IMI in cows approaching dry-off. Eighty herds using 1 of 4 common bedding materials (manure solids, organic non-manure, new sand, and recycled sand) were recruited in a multi-site cross-sectional study. Each herd was visited twice for sampling. At each visit, aseptic quarter-milk samples were collected from 20 cows approaching dry-off (>180 d pregnant). Samples of unused and used bedding were also collected. Aerobic culture was used to determine the IMI status of 10,448 quarters and to enumerate counts (log10 cfu/mL) of all bacteria, Staphylococcus spp., Streptococcus spp. and Streptococcus-like organisms (SSLO), coliforms, Klebsiella spp., noncoliform gram-negatives, Bacillus spp., and Prototheca spp. in unused (n = 148) and used (n = 150) bedding. The association between bedding bacteria count and IMI was determined using multivariable logistic regression with mixed effects. Quarter-level prevalence of IMI was 21.1%, which was primarily caused by non-aureus Staphylococcus spp. (11.4%) and SSLO (5.6%). Only modest differences in IMI prevalence were observed between the 4 common bedding material types. Counts of all bacteria in unused bedding was positively associated with odds of IMI caused by any pathogen [ALL-IMI; odds ratio (OR) = 1.08]. A positive association was also observed for counts of SSLO in unused bedding and SSLO-IMI (OR = 1.09). These patterns of association were generally consistent across the 4 common bedding materials. In contrast, the association between counts of all bacteria in used bedding and ALL-IMI varied by bedding type, with positive associations observed in quarters exposed to manure solids (OR = 2.29) and organic non-manure (OR = 1.51) and a negative association in quarters exposed to new sand (OR = 0.47). Findings from this study suggest that quarter-level IMI prevalence in late-lactation cows is low in US dairy herds. Furthermore, bedding material type may not be an important risk factor for IMI in late lactation. Higher levels of bacteria in bedding may increase IMI prevalence at dry-off in general, but this relationship is likely to vary according to bedding material type.

Relationships among bedding materials, bedding bacteria counts, udder hygiene, milk quality, and udder health in US dairy herds.

Bedding is an important source of teat end exposure to environmental mastitis pathogens. To better control environmental mastitis, we need an improved understanding of the relationships among bedding selection and management, bedding bacteria counts (BBC), and udder health (UH). The objectives of this cross-sectional observational study were (1) to describe BBC, bedding characteristics, udder hygiene scores, bulk tank milk (BTM) quality, and UH in US dairy herds using 1 of 4 bedding materials; (2) describe the relationship between BBC and herd measures of UH; and (3) identify benchmarks for monitoring bedding hygiene. Local dairy veterinarians and university researchers enrolled and sampled 168 herds from 17 states. Herds were on a Dairy Herd Improvement Association (DHIA) testing program and used 1 of 4 bedding types for lactating cows: new sand, reclaimed sand, manure solids (MNS), or organic non-manure materials. Each herd was sampled twice (winter and summer) in 2016. Samples and data collected included unused and used bedding, BTM samples, udder hygiene scores, DHIA test data, and descriptions of facilities and herd management practices. Bedding was cultured to determine the total bacteria count and counts of Bacillus spp., coliforms, Klebsiella spp., non-coliform gram-negative organisms, streptococci or streptococci-like organisms (SSLO), and Staphylococcus spp. Bedding dry matter, organic matter, and pH were also measured. Bulk tank milk samples were cultured to determine counts of coliforms, NAS, SSLO, Staphylococcus aureus, and Mycoplasma spp. Udder health measures included DHIA test-day average linear score (LS); the proportion of cows with an intramammary infection (IMI), where infection was defined as LS ≥4.0; the proportion of cows with a new IMI, where new IMI was defined as LS changing from <4.0 to ≥4.0 in the last 2 tests; the proportion of cows with a chronic infection, where chronic was defined as LS ≥4.0 on the last 2 tests; and the cumulative incidence of clinical mastitis in the 30-d period preceding sample collection. Although much variation existed within and among bedding types, mixed linear regression showed the use of MNS bedding to be generally associated with higher BBC, dirtier udders, increased coliform and SSLO counts in BTM, and poorer UH measures compared with organic non-manure materials, reclaimed sand, or new sand bedding materials. While controlling for important farm traits and management practices, mixed linear regression showed that increased counts of coliforms, Klebsiella spp., SSLO, and Staphylococcus spp. in both unused and used bedding were associated with poorer values for 1 or more herd-level measures of UH. Achievable benchmarks identified for counts of coliforms (unused: ≤500 cfu/cm3; used: ≤10,000 cfu/cm3), Klebsiella spp. (0 cfu/cm3 for unused and used), Staphylococcus spp. (0 cfu/cm3 for unused and used), and SSLO (unused: 0 cfu/cm3; used: ≤500,000 cfu/cm3) can be used to monitor bedding hygiene in most bedding materials, with minor variations suggested for SSLO in unused MNS (≤1,000 cfu/cm3).

Rumen fluid, feces, milk, water, feed, airborne dust, and bedding microbiota in dairy farms managed by automatic milking systems.

Microbiota of the gut, milk, and cowshed environment were examined at two dairy farms managed by automatic milking systems (AMS). Feed, rumen fluid, feces, milk, bedding, water, and airborne dust were collected and the microbiota on each was assessed by Illumina MiSeq sequencing. The most abundant taxa in feed, rumen fluid, feces, bedding, and water were Lactobacillaceae, Prevotellaceae, Ruminococcaceae, Ruminococcaceae, and Lactobacillaceae, respectively, at both farms. Aerococcaceae was the most abundant taxon in milk and airborne dust microbiota at farm 1, and Staphylococcaceae and Lactobacillaceae were the most abundant taxa in milk and airborne dust microbiota at farm 2. The three most prevalent taxa (Aerococcaceae, Staphylococcaceae, and Ruminococcaceae at farm 1 and Staphylococcaceae, Lactobacillaceae, and Ruminococcaceae at farm 2) were shared between milk and airborne dust microbiota. Indeed, SourceTracker indicated that milk microbiota was related with airborne dust microbiota. Meanwhile, hierarchical clustering and canonical analysis of principal coordinates demonstrated that the milk microbiota was associated with the bedding microbiota but clearly separated from feed, rumen fluid, feces, and water microbiota. Although our findings were derived from only two case studies, the importance of cowshed management for milk quality control and mastitis prevention was emphasized at farms managed by AMS.

Production of recycled manure solids for use as bedding in Canadian dairy farms: II. Composting methods.

Recent technological advances in the dairy industry have enabled Canadian farms with liquid manure systems to use mechanical solid-liquid separation paired with composting of the separated solids for on-farm production of low-cost bedding material. However, because several approaches are available, it is difficult for farmers to select the appropriate one to achieve high quality recycled manure solids (RMS). Whereas 3 solid-liquid manure separators were compared in part I of the series (companion paper in this issue), the present study (part II) aims to assess the performance of 4 composting methods (static or turned windrow and drum composter for 24 or 72 h) under laboratory conditions. Parameters evaluated included temperature, physico-chemical characteristics, and bacterial composition of RMS, as well as airborne microorganisms, dust, and gases associated with composting RMS. Because each treatment attained the desired composting temperature range of 40 to 65°C (either in heaps or in the drum composter), reductions in bacteria were a better indicator of the sanitation efficiency. The treatment of fresh RMS in a drum composter for 24 h showed decreased bacterial counts, especially for Escherichia coli (from 1.0 × 105 to 2.0 × 101 cfu/g of dry matter) and Klebsiella spp. (from 3.2 × 104 to 4.0 × 102 cfu/g of dry matter). Increasing the time spent in the rotating vessel to 72 h did not result in further decreases of these pathogens. Composting in a static or turned windrow achieved similar E. coli and Klebsiella spp. reductions as the 24-h drum composting but in 5 or 10 d, and generally showed the lowest occupational exposure risk for dairy farmers regarding concentrations of airborne mesophilic bacteria, mesophilic and thermotolerant fungi, and total dust. Drum-composted RMS stored in piles exhibited intermediate to high risk. Composting approaches did not have a major influence on the physico-chemical characteristics of RMS and gas emissions. Drum composting for 24 h was the best compromise in terms of product quality, temperature reached, decreased bacterial numbers, and emitted airborne contaminants. However, because levels of pathogenic agents rapidly increase once composted RMS are spread in stalls, bacteriological characteristics of RMS along with milk quality and animal health and welfare features should be monitored in Canadian dairy barns applying recommended separation (part I) and composting (part II) systems to evaluate health risk and optimize management practices.