Quantitative determination of bioactive proteins in diphtheria tetanus acellular pertussis (DTaP) vaccine by liquid chromatography tandem mass spectrometry.

A liquid chromatography tandem mass spectrometry method (LC-MS/MS) was developed to determine simultaneously the bioactive proteins including pertussis toxin (PT) subunits, filamentous hemagglutinin (FHA), pertactin (PRN) and fimbriae (FIM) in diphtheria, tetanus and acellular pertussis combined vaccine (DTaP). The trypsin digestion conditions were investigated in detail using PT reference to achieve satisfactory results in detection of the peptides on LC-MS/MS with a Bio-C18 column. The performance of the described method was evaluated using reference proteins and the results showed a wide linear range (0.15-24 ng µL-1), a high sensitivity (0.038 ng. µL-1 for FHA) and a good precision (RSD of peak area <3.3%). This novel LC-MS/MS method was applied to determine PT subunits, FHA, PRN and FIM in DTaP vaccines, a total of ten batches, obtained from five manufacturers. The results revealed clearly that batch-to-batch consistency of the DTaP vaccines in terms of the protein amounts was stable, while those from manufacturers were varied significantly. On the other hand, the amount of bioactive proteins in component DTaP vaccines was generally higher than those in co-purified DTaP vaccines. The described LC-MS/MS method was compared with Chinese Pharmacopeia method (Lowry method) and it was found that FHA and PRN amounts measured by the two methods were in good agreement. The LC-MS/MS method could provide the amounts of PT subunits. However, the Lowry method could not differentiate the subunits. The LC-MS/MS method was not only more selective and sensitive, but it can be used to determine simultaneously different bioactive proteins in complex matrix-formulated vaccines. The method was extended successfully in other purposes, such as the effect of detoxification on bioactive proteins and characterization of PT references from four organizations worldwide.

[SAFETY AND IMMUNOGENICITY OF A NATIONAL COMBINED VACCINE AGAINST PERTUSSIS, DIPHTHERIA, TETANUS, HEPATITIS B AND Hib-INFECTION, CONTAINING ACELLULAR PERTUSSIS COMPONENT, DURING IMMUNIZATION OF ADULTS].

AIM: Study safety, reactogenicity and immunologic effectiveness of a national combined vaccine against diphtheria, pertussis (acellular component), tetanus, hepatitis B and Hib-infection during immunization of volunteers aged 18-60 years. MATERIALS AND METHODS: The study was carried out in accordance with ethical standards and requirements, regulated by Helsinki declaration and Good clinical practice (ICHGCP). In a simple non-randomized clinical trial 20 adult volunteers took part, the mean age of those was 46.9 years. RESULTS: Registered: post-vaccination reactions (both local and systemic) were mild and of moderate degree of severity, stopped independently after 2-3 days without administration of drug treatment. Postvaccinal complications were not noted. Parameters of general and biochemical analysis of blood, urine, IgE content in dynamics of immunization were within normal limits. A single administration of aAPDT--HepB+Hib to individuals aged 18-60 years resulted in development of antibodies against all the components of the preparation. Seroconversion factor fluctuated from 6.9 to 53.5: CONCLUSION: The results obtained allow to recommend the vaccine for evaluation of its safety, reactogenicity, immunologic and prophylaxis effectiveness in randomized clinical observation trials in children.

New Insight into Filamentous Hemagglutinin Secretion Reveals a Role for Full-Length FhaB in Bordetella Virulence.

UNLABELLED: Bordetella filamentous hemagglutinin (FHA), a primary component of acellular pertussis vaccines, contributes to virulence, but how it functions mechanistically is unclear. FHA is first synthesized as an ~370-kDa preproprotein called FhaB. Removal of an N-terminal signal peptide and a large C-terminal prodomain (PD) during secretion results in "mature" ~250-kDa FHA, which has been assumed to be the biologically active form of the protein. Deletion of two C-terminal subdomains of FhaB did not affect production of functional FHA, and the mutant strains were indistinguishable from wild-type bacteria for their ability to adhere to the lower respiratory tract and to suppress inflammation in the lungs of mice. However, the mutant strains, which produced altered FhaB molecules, were eliminated from the lower respiratory tract much faster than wild-type B. bronchiseptica, suggesting a defect in resistance to early immune-mediated clearance. Our results revealed, unexpectedly, that full-length FhaB plays a critical role in B. bronchiseptica persistence in the lower respiratory tract. IMPORTANCE: The Bordetella filamentous hemagglutinin (FHA) is a primary component of the acellular pertussis vaccine and an important virulence factor. FHA is initially produced as a large protein that is processed during secretion to the bacterial surface. As with most processed proteins, the mature form of FHA has been assumed to be the functional form of the protein. However, our results indicate that the full-length form plays an essential role in virulence in vivo. Furthermore, we have found that FHA contains intramolecular regulators of processing and that this control of processing is integral to its virulence activities. This report highlights the advantage of studying protein maturation and function simultaneously, as a role for the full-length form of FHA was evident only from in vivo infection studies and not from in vitro studies on the production or maturation of FHA or even from in vitro virulence-associated activity assays.

How common are long-lasting, intensely itching vaccination granulomas and contact allergy to aluminium induced by currently used pediatric vaccines? A prospective cohort study.

UNLABELLED: The frequency of long-lasting, intensely itching subcutaneous nodules at the injection site for aluminium (Al)-adsorbed vaccines (vaccination granulomas) was investigated in a prospective cohort study comprising 4,758 children who received either a diphtheria-tetanus-pertussis-polio-Haemophilus influenzae type b vaccine (Infanrix®, Pentavac®) alone or concomitant with a pneumococcal conjugate (Prevenar). Both vaccines were adsorbed to an Al adjuvant. Altogether 38 children (0.83 %) with itching granulomas were identified, epicutaneously tested for Al sensitisation and followed yearly. Contact allergy to Al was verified in 85 %. The median duration of symptoms was 22 months in those hitherto recovered. The frequency of granulomas induced by Infanrix® was >0.66 % and by Prevenar >0.35 %. The risk for granulomas increased from 0.63 to 1.18 % when a second Al-adsorbed vaccine was added to the schedule. CONCLUSION: Long-lasting itching vaccination granulomas are poorly understood but more frequent than previously known after infant vaccination with commonly used diphtheria-tetanus-pertussis-polio-Haemophilus influenzae type b and pneumococcal conjugate vaccines. The risk increases with the number of vaccines given. Most children with itching granulomas become contact allergic to aluminium. Itching vaccination granulomas are benign but may be troublesome and should be recognised early in primary health care to avoid unnecessary investigations, anxiety and mistrust.

A freeze-stable formulation for DTwP and DTaP vaccines.

Inadvertent vaccine freezing often occurs in the cold chain and may cause damage to freeze­sensitive vaccines. Liquid vaccines that contain aluminum salt adjuvants are particularly vulnerable. Polyol cryoprotective excipients have been shown to prevent freeze damage to hepatitis B vaccine. In this study, we examined the freeze-protective effect of propylene glycol on diphtheria-tetanus-pertussis-whole-cell (DTwP) and acellular (DTaP) vaccines. Pilot lots of DTwP and DTaP formulated with 7.5% propylene glycol underwent 3 freeze-thaw treatments. The addition of propylene glycol had no impact on pH, particle size distribution, or potency of the vaccines prior to freeze-thaw treatment; the only change noted was an increase in osmolality. The potencies and the physical properties of the vaccines containing cryoprotectant were maintained after freeze-thawing and for 3 months in accelerated stability studies. The results from this study indicate that formulating vaccines with propylene glycol can protect diphtheria-tetanus-pertussis vaccines against freeze damages.

The immunogenicity and safety of DTaP interchangeable immunization among Korean children.

Since the production of various vaccine formulations by different pharmaceutical companies and interruptions in vaccine supply cannot be fully regulated, problems caused by DTaP interchangeability may occur. However, the interchangeability data on the first primary series of DTaP vaccination have not been well described. In this study we investigated immunogenicity and overall safety of diphtheria, tetanus, pertussis in children who had adventitiously received an interchangeable DTaP vaccination. A total 97 of participants were enrolled (mean age, 11 months). High immunogenicity (1.8 ± 0.4 IU/mL, 100%) was noted against diphtheria toxoid, and similar high immunogenicity (3.2 ± 2.1 IU/mL, 100%) was noted against tetanus toxoid. Immunogenicity against pertussis antigen was significantly greater in the interchangeable vaccinated group compared to the control group, and 57% of the interchangeable vaccinated subjects achieved high levels of protective immunity (45.2 ± 21.5 E U/mL). No serious adverse effects were noted, and most adverse effects resolved without treatment. The immunogenicity against each antigen was high in patients who were interchangeably vaccinated for DTaP. Our results provide clinical evidence affirming the non-inferiority of interchangeable vaccination when it cannot be avoided such as in limited vaccine supply situations or different prices.

Highly sensitive histamine-sensitization test for residual activity of pertussis toxin in acellular pertussis vaccine.

Histamine-sensitization test method based on histamine-sensitizing death is widely used for controlling residual activity of pertussis toxin in acellular pertussis vaccines. The test method evaluates the residual activity according to the death of mice injected with a test vaccine after histamine challenge and the test result, therefore, depends on the sensitivity of mice. A highly sensitive test method based on change in rectal temperature of mice has been used in Japan for many years but has limited feasibility in other countries. We examined the possibility of a test method using dermal temperature measured by infrared thermometer to reduce animal suffering instead of rectal temperature. The dermal temperature method was shown to be as sensitive as the rectal temperature method. Furthermore, the dermal as well as rectal temperature methods can evaluate the activity of a test vaccine in relative to a reference preparation so as to allow direct comparison of the test results among different laboratories. The activity by means of the dermal temperature method was also found to be well consistent with that by the rectal temperature method.

An adolescent-adult formulation tetanus and diptheria toxoids adsorbed combined with acellular pertussis vaccine has comparable immunogenicity but less reactogenicity in children 4-6 years of age than a pediatric formulation acellular pertussis vaccine and diphtheria and tetanus toxoids adsorbed combined with inactivated poliomyelitis vaccine.

In Canada, the fifth dose of the routine childhood immunization schedule against diphtheria, tetanus, pertussis and polio is given at 4-6 years of age. Up to 30% of children may have significant local reactions (redness, swelling) and this may be related to pertussis and diphtheria antigen content. We sought to determine if a combination product with lower content of pertussis and diphtheria toxoids (dTap) would result in fewer local reactions and not have inferior immunogenicity to a combination vaccine with higher pertussis and diphtheria content (diphtheria-tetanus-acellular pertussis-inactivated polio virus, DTaP-IPV). Healthy children aged 4-6 years with complete primary immunization series and a fourth dose of diphtheria and tetanus toxoids component pertussis inactivated polio and Haemophilus influenzae type B conjugate vaccine were randomized to one dose of dTap, followed in 4-6 weeks by one dose of IPV or control DTaP-IPV. Immediate reactions within 30 min, solicited injection site and systemic reactions within 14 days, and unsolicited adverse events (AE) within 6 weeks post-vaccination were monitored. Serum was collected prior to immunization, and 4-6 weeks after vaccine for diphtheria, tetanus and pertussis antibodies (Ab). Sample size was designed to detect > or =10% difference in injection site erythema, pain or swelling between groups 593 children at eight Canadian sites completed the study; no participant withdrew because of an AE. All safety endpoints on days 0-14 were less frequent in children randomized to the dTap than DTaP-IPV group: erythema (34.6% versus 51.7%), swelling (24.2% versus 33.8%) and pain (39.6% versus 67.2%). Fever was also less common (8.72% versus 16.9%). All children in both study groups had seroprotective Ab levels to diphtheria and tetanus at 4-6 weeks (> or =0.10 IU/mL). The majority of children in each vaccine arm had a four-fold increase in pertussis antibodies. Fever and injection site reactions are less common in 4-6 year-old-children who receive a dTap vaccine compared to DTaP-IPV, without inferior immunogenicity.

How soon after a prior tetanus-diphtheria vaccination can one give adult formulation tetanus-diphtheria-acellular pertussis vaccine?

BACKGROUND: Adult formulation tetanus and diphtheria toxoids and acellular pertussis vaccines (Tdap) have been developed to prevent pertussis in adolescents and adults. There are concerns that unacceptable rates of severe injection site reactions, including Arthus-type reactions might occur if Tdap is administered too soon after a previous tetanus and diphtheria toxoid-containing vaccine formulated for infants and younger children (TD) or older children and adults (Td). METHODS: To evaluate whether adverse reactions after Tdap might be related to time since last receipt of TD/Td, we performed an open label, province-wide, clinical trial comparing the reactogenicity of Tdap given 18 months-9 years versus > or = 10 years after a previous TD/Td. RESULTS: Seven thousand one hundred fifty-six children and adolescents were enrolled in the study (464-963 subjects per cohort), and 7001 had documented dates of the previous immunization within the specified intervals; adverse event data were provided by 5931 (84.7%). No whole limb swelling, Arthus-like reactions or serious adverse events related to vaccination were reported. No differences in reports of fever were found by interval since last immunization. Injection site erythema and swelling were slightly and statistically significantly increased among those participants with most recent prior TD/Td. Compared with the 10-year interval group, the maximum increase for any other group was < or = 8.6% for any erythema, < or = 6% for erythema > 10 mm, < or = 10.3% for any swelling, < or = 6.9% for swelling > 10 mm, < or = 5.2% for any pain and < or = 3.7% for moderate/severe pain. CONCLUSION: Although there is a slight increase in injection site events with decreasing interval since a previous immunization, Tdap can be safely administered at intervals of > or = 18 months since a previous TD/Td vaccine.

In vitro pyrogenicity of the diphtheria, tetanus and acellular pertussis components of a trivalent vaccine.

We have earlier found that a trivalent vaccine, containing antigenic components from both Gram-positive and Gram-negative bacteria, induced secretion of the endogenous pyrogen interleukin 6 (IL-6) when added to fresh human blood in vitro. The results of the present study showed that the IL-6 secretion was induced by toxoids derived from the Gram-positive bacterium Corynebacterium diphtheriae. However, fresh whole blood from different donors reacted differently to the stimulation. The blood from some donors induced secretion of large concentrations of IL-6, while the blood from other donors induced essentially no IL-6 secretion as a response to stimulation with diphtheria toxoid or a mixture of diphtheria and tetanus toxoids. Repeated testing over several years using blood from the same donor confirmed a donor-dependency of the reaction. This donor-dependency was only found for the toxoid, since blood from all donors reacted with approximately similar IL-6 production to stimulation by endotoxin from the Gram-negative bacterium Escherichia coli, known to be mediated via the toll-like receptor (TLR) 4. Also, no donor-dependecy was found to highly purified lipoteichoic acid from the Gram-positive bacteria Bacillus subtilis and Staphylococcus aureus, known to be mediated via TLR-2 and TLR-6. The receptors involved in stimulation by diphtheria toxoid are not known, but may differ from those used by endotoxin and lipoteichoic acid.

Effects of lowering the aluminium content of a dTpa vaccine on its immunogenicity and reactogenicity when given as a booster to adolescents.

As aluminium in vaccines has been associated with the incidence of local side effects occurring after vaccination, this observer-blind randomised clinical trial was designed to evaluate the effect of lowering the aluminium content of a combined reduced-antigen-content dTpa vaccine on immunogenicity and safety when administered to healthy adolescents aged 10-18 years. A total of 647 subjects were enrolled, 224 (35%) received a dTpa formulation with 0.5 mg aluminium, 209 (32%) a formulation with 0.3 mg aluminium and 214 (33%) a formulation with 0.133 mg aluminium. One month after boostering, all subjects were seroprotected against diphtheria and tetanus toxoids. All subjects were seropositive for anti-FHA and anti-PRN but 4% of the initially seronegatives in both reduced aluminium groups did not seroconvert for anti-PT. Booster responses did not differ significantly between groups for any antibody, but post booster vaccination anti-PT GMC's differed significantly between groups and decreased when vaccine aluminium content decreased. No clear difference between study groups in local or general side effects was demonstrated. The most frequently reported symptoms after vaccination were injection site pain (89.5-90.7%), fatigue (42.1-47.4%) and headache (41.1-45.1%). This study showed that the aluminium content has a specific influence on the immunogenicity of this dTpa vaccine.

Neurodevelopmental disorders following thimerosal-containing childhood immunizations: a follow-up analysis.

The authors previously published the first epidemiological study from the United States associating thimerosal from childhood vaccines with neurodevelopmental disorders (NDs) based upon assessment of the Vaccine Adverse Event Reporting System (VAERS). A number of years have gone by since their previous analysis of the VAERS. The present study was undertaken to determine whether the previously observed effect between thimerosal-containing childhood vaccines and NDs are still apparent in the VAERS as children have had a chance to further mature and potentially be diagnosed with additional NDs. In the present study, a cohort of children receiving thimerosal-containing diphtheria-tetanus-acellular pertussis (DTaP) vaccines in comparison to a cohort of children receiving thimerosal-free DTaP vaccines administered from 1997 through 2000 based upon an assessment of adverse events reported to the VAERS were evaluated. It was determined that there were significantly increased odds ratios (ORs) for autism (OR = 1.8, p < .05), mental retardation (OR = 2.6, p < .002), speech disorder (OR = 2.1, p < .02), personality disorders (OR = 2.6, p < .01), and thinking abnormality (OR = 8.2, p < .01) adverse events reported to the VAERS following thimerosal-containing DTaP vaccines in comparison to thimerosal-free DTaP vaccines. Potential confounders and reporting biases were found to be minimal in this assessment of the VAERS. It was observed, even though the media has reported a potential association between autism and thimerosal exposure, that the other NDs analyzed in this assessment of the VAERS had significantly higher ORs than autism following thimerosal-containing DTaP vaccines in comparison to thimerosal-free DTaP vaccines. The present study provides additional epidemiological evidence supporting previous epidemiological, clinical and experimental evidence that administration of thimerosal-containing vaccines in the United States resulted in a significant number of children developing NDs.

Neurodevelopmental disorders after thimerosal-containing vaccines: a brief communication.

We were initially highly skeptical that differences in the concentrations of thimerosal in vaccines would have any effect on the incidence rate of neurodevelopmental disorders after childhood immunization. This study presents the first epidemiologic evidence, based upon tens of millions of doses of vaccine administered in the United States, that associates increasing thimerosal from vaccines with neurodevelopmental disorders. Specifically, an analysis of the Vaccine Adverse Events Reporting System (VAERS) database showed statistical increases in the incidence rate of autism (relative risk [RR] = 6.0), mental retardation (RR = 6.1), and speech disorders (RR = 2.2) after thimerosal-containing diphtheria, tetanus, and acellular pertussis (DTaP) vaccines in comparison with thimerosal-free DTaP vaccines. The male/female ratio indicated that autism (17) and speech disorders (2.3) were reported more in males than females after thimerosal-containing DTaP vaccines, whereas mental retardation (1.2) was more evenly reported among male and female vaccine recipients. Controls were employed to determine if biases were present in the data, but none were found. It was determined that overall adverse reactions were reported in similar-aged populations after thimerosal-containing DTaP (2.4 +/- 3.2 years old) and thimerosal-free DTaP (2.1 +/- 2.8 years old) vaccinations. Acute control adverse reactions such as deaths (RR = 1.0), vasculitis (RR = 1.2), seizures (RR = 1.6), ED visits (RR = 1.4), total adverse reactions (RR = 1.4), and gastroenteritis (RR = 1.1) were reported similarly after thimerosal-containing and thimerosal-free DTaP vaccines. An association between neurodevelopmental disorders and thimerosal-containing DTaP vaccines was found, but additional studies should be conducted to confirm and extend this study.

Evaluation of endotoxin content of diphtheria-tetanus-acellular pertussis combined (DTaP) vaccines that interfere with the bacterial endotoxin test.

Applicability of the endotoxin test to diphtheria-tetanus-acellular pertussis combined (DTaP) vaccines was examined. We found some DTaP vaccines that strongly interfered with Limulus amoebocyte lysate (LAL) activity of endotoxin without affecting lethal activity of endotoxin in D-galactosamine-treated mice. LAL activity that was interfered in such vaccines increased apparently after the treatment with phosphate buffer at 4 degrees C for a week. The DTaP vaccines that interfered with the endotoxin test showed no significant effect on endotoxin activity in inducing tumor necrosis factor-alpha (TNF-alpha) in rabbit peripheral blood. The in vitro TNF-alpha induction assay was, therefore, suggested to be an appropriate assay method for the quantitative detection of the endotoxin activity in DTaP vaccines.