An improved cleaning system to reduce microbial contamination of poultry transport crates in the United Kingdom.

AIM: Following previous research on improving the cleaning of crates used to transport broiler chickens from the farm to the abattoir, a demonstration project was undertaken to investigate improvements in crate washing on a commercial scale. METHODS AND RESULTS: The soak tank of a conventional crate washing system was replaced with a high-performance washer fitted with high-volume, high-pressure nozzles. The wash water could be heated, and a greatly improved filtration system ensured that the nozzles did not lose performance or become blocked. Visual cleanliness scores and microbial counts were determined for naturally contaminated crates which had been randomly assigned to different cleaning protocols. CONCLUSIONS: When a combination of mechanical energy, heat and chemicals (i.e. detergent and disinfectant) was used, the results showed significant improvements to crate cleaning. Reductions of up to 3·6 and 3·8 log10 CFU per crate base were achieved for Campylobacter and Enterobacteriaceae, respectively, along with a marked improvement in visual cleanliness. SIGNIFICANCE AND IMPACT OF THE STUDY: Broiler transport crates may become heavily contaminated with faeces and this may contribute to the spread of disease between farms. The results of this trial may be of use in reducing the spread of zoonotic pathogens in the poultry meat supply chain.

Persistent environmental reservoirs on farms as risk factors for Campylobacter in commercial poultry.

Campylobacter is the most common known source of human bacterial enteritis in the developed world and poultry is considered the main source. Broilers often become colonized with Campylobacter during rearing, and then contaminate the farm environment. The objective of this study was to identify Campylobacter-positive environmental reservoirs on farms, as these pose a risk to broiler flocks becoming colonized with Campylobacter. We considered the temporal aspects of exposure and colonization. A longitudinal study monitored six conventional rearing farms over 2 years. The broiler flocks, catchers' equipment, vehicles, shed surrounds, shed entrance, other equipment, farm entrance, other animals, puddles, dead birds, mains water and drinkers were systematically sampled 2-4 times per flock. A multivariable generalized estimating equation model was used to assess associations between contaminated environmental sites and colonized broiler flocks. The associations were adjusted for confounders and other known risk factors. To further assess temporality of contamination, the sequence of contamination of the different environmental sites and the flocks was established. Contaminated shed entrances and anterooms, contaminated drinkers and shedding of Campylobacter by other animals such as cattle, dogs, wildlife and rodents were significantly associated with positive flocks. The reservoir of 'other animals' was also the reservoir most commonly positive before the flock became colonized. The other sites usually became contaminated after the flock was colonized.

Effect of delivery method on the efficacy of Salmonella vaccination in chickens.

To investigate whether the efficacy of live vaccines is influenced by the mode of vaccine delivery, a widely-used UK live commercial Salmonella Enteritidis vaccine was delivered to pullet chicks either by spray, in drinking water, or in combination with a bivalent vaccine containing inactivated Salmonella Enteritidis and Salmonella Typhimurium. The birds were subsequently challenged with 10(2) or 10(8) colony-forming units (cfu) of Salmonella Enteritidis through drinking water at either six or 20 weeks of age. Ten days after the challenge, the birds were euthanased and their caecal contents cultured for Salmonella. All of the vaccinated groups contained fewer Salmonella Enteritidis-positive birds than the unvaccinated groups. The 'spray-vaccinated' group contained significantly fewer Salmonella Enteritidis-positive birds than the 'water-vaccinated' group after challenge with 10(8) cfu at 20 weeks. However, there was little or no difference at the other challenge time points between the groups that received vaccine through different modes of delivery.

Salmonella colonisation of laying hens following vaccination with killed and live attenuated commercial Salmonella vaccines.

The aim of this study was to determine the efficacy of a killed Salmonella vaccine and three live vaccines in preventing caecal colonisation of Hy-line Brown pullets by Salmonella Enteritidis PT 4. The lowest number of Salmonella-positive birds following the largest challenge (10(8) cfu) was recorded for live vaccine 1. However, birds treated with the killed vaccine had a significantly lower number of salmonellae in their caeca compared with both the control group and the other vaccine groups (P<0.05).

Bacteriophage biocontrol in animals and meat products.

Since their discovery almost a century ago, bacterial viruses (bacteriophages or 'phages') have been used to prevent and treat a multitude of bacterial infections (phage therapy: PT). In addition, they have been the basis for many advances in genetics and biochemistry. Phage therapy was performed on human subjects in the United States, Europe and Asia in the few decades following their discovery. However, Western countries largely abandoned PT in favour of antibiotics in the 1940s. The relatively recent renaissance of PT in the West can be attributed partly to the increasing prevalence of antibiotic resistance in human and animal pathogens. However, the stringent controls on human trials now required in the United States and Europe have led to a greater number of domestic animal and agricultural applications as an alternative to PT in man. This trend is set to continue, at least in the short term, with recent approval from the Food and Drug Administration allowing commercial phage treatments to be used in human food in the USA. Nevertheless, despite these significant milestones and the growing number of successful PT trials, significant obstacles remain to their widespread use in animals, food and ultimately medicine in many parts of the world. This review will provide a brief overview of the history of PT in the West and will summarize some of the key findings of phage biocontrol studies in animals and meat products.

Effect of ultrasonic treatment during cleaning on the microbiological condition of poultry transport crates.

1. Small sections cut from commercial crates used to transport live poultry to the processing plant were artificially contaminated with effluent taken from a commercial crate-cleaning system. 2. Laboratory trials, involving the immersion of these sections in an ultrasonic water bath (4 kW energy) showed that aerobic plate counts (APC) and counts of Enterobacteriaceae were progressively reduced as the immersion time was increased from 0 to 120 s and the water temperature raised from 35 to 58 degrees C. 3. In subsequent trials at a processing plant, using commercially cleaned crates, there was relatively little effect of ultrasound (or pressure washing) on the biofilm present. However, ultrasonic treatment in combination with an immersion temperature of 60 degrees C reduced counts of Enterobacteriaceae to below the detection limit (log(10) 2.3 cfu) within 1 to 3 min, while APC were reduced by >2 log(10) units after 3 min. 4. It was concluded that ultrasonic treatment has a possible role in the crate-cleaning process, when used in conjunction with higher immersion temperatures. In this way, it could contribute significantly to hygiene control.

Bacteriophage therapy to reduce salmonella colonization of broiler chickens.

Acute enteric infections caused by salmonellas remain a major public health burden worldwide. Poultry, particularly chickens, are known to be the main reservoir for this zoonotic pathogen. Although some progress has been made in reducing Salmonella colonization of broiler chickens by using biosecurity and antimicrobials, it still remains a considerable problem. The use of host-specific bacteriophages as a biocontrol is one possible intervention by which Salmonella colonization could be reduced. A total of 232 Salmonella bacteriophages were isolated from poultry farms, abattoirs, and wastewater in 2004 and 2005. Three phages exhibiting the broadest host ranges against Salmonella enterica serotypes Enteritidis, Hadar, and Typhimurium were characterized further by determining their morphology and lytic activity in vitro. These phages were then administered in antacid suspension to birds experimentally colonized with specific Salmonella host strains. The first phage reduced S. enterica serotype Enteritidis cecal colonization by > or = 4.2 log10 CFU within 24 h compared with controls. Administration of the second phage reduced S. enterica serotype Typhimurium by > or = 2.19 log10 CFU within 24 h. The third bacteriophage was ineffective at reducing S. enterica serotype Hadar colonization. Bacteriophage resistance occurred at a frequency commensurate with the titer of phage being administered, with larger phage titers resulting in a greater proportion of resistant salmonellas. The selection of appropriate bacteriophages and optimization of both the timing and method of phage delivery are key factors in the successful phage-mediated control of salmonellas in broiler chickens.

Bacteriophage therapy to reduce Campylobacter jejuni colonization of broiler chickens.

Colonization of broiler chickens by the enteric pathogen Campylobacter jejuni is widespread and difficult to prevent. Bacteriophage therapy is one possible means by which this colonization could be controlled, thus limiting the entry of campylobacters into the human food chain. Prior to evaluating the efficacy of phage therapy, experimental models of Campylobacter colonization of broiler chickens were established by using low-passage C. jejuni isolates HPC5 and GIIC8 from United Kingdom broiler flocks. The screening of 53 lytic bacteriophage isolates against a panel of 50 Campylobacter isolates from broiler chickens and 80 strains isolated after human infection identified two phage candidates with broad host lysis. These phages, CP8 and CP34, were orally administered in antacid suspension, at different dosages, to 25-day-old broiler chickens experimentally colonized with the C. jejuni broiler isolates. Phage treatment of C. jejuni-colonized birds resulted in Campylobacter counts falling between 0.5 and 5 log10 CFU/g of cecal contents compared to untreated controls over a 5-day period postadministration. These reductions were dependent on the phage-Campylobacter combination, the dose of phage applied, and the time elapsed after administration. Campylobacters resistant to bacteriophage infection were recovered from phage-treated chickens at a frequency of <4%. These resistant types were compromised in their ability to colonize experimental chickens and rapidly reverted to a phage-sensitive phenotype in vivo. The selection of appropriate phage and their dose optimization are key elements for the success of phage therapy to reduce campylobacters in broiler chickens.

Correlation of Campylobacter bacteriophage with reduced presence of hosts in broiler chicken ceca.

Campylobacter jejuni and Campylobacter-specific bacteriophage were enumerated from broiler chicken ceca selected from 90 United Kingdom flocks (n = 205). C. jejuni counts in the presence of bacteriophage (mean log(10) 5.1 CFU/g) were associated with a significant (P < 0.001) reduction compared to samples with Campylobacter alone (mean log(10) 6.9 CFU/g).

The effect of pH on glucoamylase production, glycosylation and chemostat evolution of Aspergillus niger.

The effect of ambient pH on production and glycosylation of glucoamylase (GAM) and on the generation of a morphological mutant produced by Aspergillus niger strain B1 (a transformant containing an additional 20 copies of the homologous GAM glaA gene) was studied. We have shown that a change in the pH from 4 to 5.4 during continuous cultivation of the A. niger B1 strain instigates or accelerates the spontaneous generation of a morphological mutant (LB). This mutant strain produced approx. 50% less extracellular protein and GAM during both chemostat and batch cultivation compared to another strain with parental-type morphology (PS). The intracellular levels of GAM were also lower in the LB strain. In addition, cultivation of the original parent B1 strain in a batch-pulse bioreactor at pH 5.5 resulted in a 9-fold drop in GAM production and a 5-fold drop in extracellular protein compared to that obtained at pH 4. Glycosylation analysis of the glucoamylases purified from shake-flask cultivation showed that both principal forms of GAM secreted by the LB strain possessed enhanced galactosylation (2-fold), compared to those of the PS. Four diagnostic methods (immunostaining, mild methanolysis, mild acid hydrolysis and beta-galactofuranosidase digestion) provided evidence that the majority of this galactose was of the furanoic conformation. The GAMs produced during batch-pulse cultivation at pH 5.5 similarly showed an approx. 2-fold increase in galactofuranosylation compared to pH 4. Interestingly, in both cases the increased galactofuranosylation appears primarily restricted to the O-linked glycan component. Ambient pH therefore regulates both GAM production and influences its glycosylation.

The use of verbal relaxation therapy for sedation during dental therapy.

Verbal relaxation therapy is a valuable auxiliary aid in dentistry and oral surgery in the preparation of the patient prior to local anesthesia, operative dental procedures, or conscious sedation, with or without pharmacological adjuncts and in reducing the number of dental phobic patients.