RÉSUMÉ
To meet the high consumer demand, butter production has increased over the last few years. As a result, the buttermilk (BM) co-produced volumes require new ways of adding value, such as in cheese manufacturing. However, BM use in cheese milk negatively influences the cheesemaking process (e.g., altered coagulation properties) and the product's final quality (e.g., high moisture content). The concentration of BM by ultrafiltration (UF) could potentially facilitate its use in cheese manufacturing through an increased protein content while maintaining the milk salt balance. Simultaneously, little is known about the digestion of UF BM cheese. Therefore, this study aimed to characterize the impact of UF BM on cheese manufacture, its structure, and its behavior during in vitro digestion. A 2-fold UF concentrated BM was used for cheese manufacture (skim milk [SM] - control). Compositional, textural, and microstructural analyses of cheeses were first conducted. In a second step, the cheeses were fed into an in vitro TNO gastrointestinal digestion model (TIM-1) of the stomach and small intestine and protein and phospholipid (PL) bioaccessibility was studied. The results showed that UF BM cheese significantly differed from SM cheese regarding its composition, hardness (p < 0.05) and microstructure. However, in TIM-1, UF BM and SM cheeses showed similar digestion behavior as a percentage of protein and PL intake. Despite relatively more non-digested and non-absorbed PL in the ileum efflux of UF BM cheese, the initially higher PL concentration contributes to an enhanced nutritional value compared to SM cheese. To our knowledge, this study is the first to compare the bioaccessibility of proteins and PL from UF BM and SM cheeses.
Sujet(s)
Babeurre , Fromage , Digestion , Phospholipides , Ultrafiltration , Fromage/analyse , Phospholipides/analyse , Phospholipides/métabolisme , Phospholipides/composition chimique , Babeurre/analyse , Manipulation des aliments/méthodes , Animaux , Protéines de lait/métabolisme , Protéines de lait/analyse , Tube digestif/métabolisme , BiodisponibilitéRÉSUMÉ
The integration of spectroscopic techniques with chemometrics offers a means to monitor quality changes in dairy products throughout processing and storage. This study employed Attenuated Total Reflectance-Mid-Infrared Spectroscopy (ATR-MIR) coupled with Independent Components Analysis (ICA), and 3D Front-Face Fluorescence Spectroscopy (FFFS) paired with Common Components and Specific Weight Analysis (CCSWA). The research focused on Cheddar cheeses aged for 1, 2, 3, and 5 years, alongside Comté cheeses aged for 6, 9, and 12 months. The adopted approach offered valuable insights into the intricate cheese aging process within the food matrix. The ICA proportions and CCSWA scores highlighted the significant impact of biochemical transformations during maturation on the aging process. The extracted independent components (ICs) revealed variations in the vibration modes of amides, lipids, amino acids, and organic acids, facilitating the distinction between different cheese age categories. Additionally, CCSWA outcomes identified age-related differences through shifts in tryptophan fluorescence characteristics as the cheeses aged. These results were consistent with the observed alterations in the microstructure of cheese samples over time, corroborated by Scanning Electron Microscopy (SEM) imagery. The introduced multimodal methodology serves as a significant asset for determining the ripening stage of various types of cheese, offering a detailed perspective of cheese maturation beneficial to the dairy industry and researchers.
Sujet(s)
Fromage , Microscopie électronique à balayage , Spectrométrie de fluorescence , Fromage/analyse , Microscopie électronique à balayage/méthodes , Spectrométrie de fluorescence/méthodes , Chimiométrie/méthodes , Manipulation des aliments/méthodesRÉSUMÉ
A greater demand for high-quality food is being driven by the growth of economic and technological advancements. In this context, consumers are currently paying special attention to organoleptic characteristics such as smell, taste, and appearance. Motivated to mimic human senses, scientists developed electronic devices such as e-noses, e-tongues, and e-eyes, to spot signals relative to different chemical substances prevalent in food systems. To interpret the information provided by the sensors' responses, multiple chemometric approaches are used depending on the aim of the study. This review based on the Web of Science database, endeavored to scrutinize three e-sensing systems coupled to chemometric approaches for food quality evaluation. A total of 122 eligible articles pertaining to the e-nose, e-tongue and e-eye devices were selected to conduct this review. Most of the performed studies used exploratory analysis based on linear factorial methods, while classification and regression techniques came in the second position. Although their applications have been less common in food science, it is to be noted that nonlinear approaches based on artificial intelligence and machine learning deployed in a big-data context have generally yielded better results for classification and regression purposes, providing new perspectives for future studies.
Sujet(s)
Intelligence artificielle , Qualité alimentaire , Humains , Odorat , Perception du goûtRÉSUMÉ
Environmental short amplicon sequencing, or metabarcoding, is commonly used to characterize the bacterial and fungal microbiota of cheese. Comparisons between different metabarcoding studies are complicated by the use of different gene markers. Here, we systematically compare different metabarcoding molecular targets using V3-V4 and V6-V8 regions of the bacterial 16S rDNA and fungal ITS1 and ITS2 regions. Taxonomic profiles varied depending on the molecular markers used. Based on data quality and detection capacity of the markers toward microorganisms usually associated with the dairy environment, the ribosomal regions V3-V4 and ITS2 were selected and further used to evaluate variability in the microbial ecosystem of terroir cheeses from the province of Quebec in Canada. Both fungal and bacterial ecosystem profiles were described for 32 different ready-to-eat bloomy-, washed- and natural-rind specialty cheese varieties. Among them, 15 were studied over two different production years. Using the Bray-Curtis dissimilarity index as an indicator of microbial shifts, we found that most variations could be explained by either a voluntary change in starter or ripening culture composition, or by changes in the cheesemaking technology. Overall, our results suggest the persistence of the microbiota between the two years studied-these data aid understanding of cheese microbiota composition and persistence during cheese ripening.
RÉSUMÉ
Optimizing protein intake for very low birth weight (<1,500 g) infants is fundamental to prevent faltering postnatal growth with the potential association of impaired neurodevelopment. The protein content of human milk is not sufficient to support the growth of very low birth weight infants. To meet their elevated protein requirements, human milk is currently fortified using typically bovine milk-based protein isolates (>85% on a dry basis). However, these products have several limitations for use in this vulnerable population. To overcome the shortcomings of bovine milk-based protein supplement, a human milk protein concentrate (HMPC) was developed. In preliminary attempts using 10 kDa ultrafiltration (UF) membranes, it was not possible to reach the protein content of commercial protein isolates, presumably due to the retention of human milk oligosaccharides (HMO). Consequently, it was hypothesized that the use of a UF membrane with a higher molecular weight cut-off (50 kDa rather than 10 kDa) could improve the transmission of carbohydrates, including HMO, in the permeate, thus increasing the protein purity of the subsequent HMPC. The results showed that permeate fluxes during the concentration step were similar to either UF molecular weight cut-off, but the 50-kDa membrane had a higher permeate flux during the diafiltration sequence. However, it was not sufficient to increase the protein purity of the human milk retentate, as both membranes generated HMPC with similar protein contents of 48.8% (10 kDa) and 50% (50 kDa) on a dry basis. This result was related to the high retention of HMO, mainly during the concentration step, although the diafiltration step was efficient to decrease their content in the HMPC. As the major bioactive proteins (lactoferrin, lysozyme, bile salt stimulated lipase, and α1-antitrypsin) in human milk were detected in both HMPC, the 50-kDa membrane seems the most appropriate to the preparation of HMPC in terms of permeation flux values. However, improving the separation of HMO from proteins is essential to increase the protein purity of HMPC.
Sujet(s)
Protéines de lait , Ultrafiltration , Animaux , Bovins , Humains , Lait humain , Masse moléculaire , Lysozyme , Ultrafiltration/médecine vétérinaireRÉSUMÉ
Pressure-driven membrane separation processes are commonly used in cheese milk standardization. Using ultrafiltration (UF) or microfiltration (MF), membrane separation processes make it possible to concentrate the milk proteins and increase the yields of cheese vats. However, the contribution of membrane separation processes to the environmental impact and economical profitability of dairy processes is still unclear. The objective of this study was to evaluate the contribution of membrane separation processes to the eco-efficiency of cheddar cheese production in Québec (Canada) using process simulation. Three scenarios were compared: two included UF or MF at the cheese milk standardization step, and one did not incorporate membrane separation processes. The results showed that even if membrane separation processes make it possible to increase vat yields, they do not improve the eco-efficiency of cheddar cheese processes. However, membrane separation processes may benefit the eco-efficiency of the process more when used for byproduct valorization.
RÉSUMÉ
Despite extensive research on the topic, valorization of dairy by-products remains challenging. Cheese whey is of particular interest because it contains valuable proteins such as α-lactalbumin (α-LA) and ß-lactoglobulin (ß-LG). However, selective fractionation of these 2 proteins into pure fractions is complex because of their similar molecular weights. In this study, we proposed an innovative protein separation strategy based on coupling high hydrostatic pressure (HHP) with acidification of whey at pH 4.6. We investigated the effect of single-cycle HHP (600 MPa) for 5, 10, and 15 min and multiple-cycle HHP (1-3 cycles of 5 min at 600 MPa) on α-LA and ß-LG fractionation from cheese whey at initial pH (control, pH 6.66) and acidified to pH 4.6. All pressurization conditions with acidified whey induced a drastic aggregation of ß-LG compared with control whey. The highest degrees of purification (75 and 98%, respectively) and yields (95 and 88%, respectively) of α-LA and ß-LG were obtained with the application of single-cycle HHP treatment of acidified whey at pH 4.6 at 600 MPa for 5 min. Our results showed the strong potential of using HHP as an innovative tool for the fractionation of valuable proteins such as α-LA from cheese whey.
Sujet(s)
Fromage/analyse , Lactalbumine/isolement et purification , Lactoglobulines/isolement et purification , Lactosérum/composition chimique , Fractionnement chimique , Pression hydrostatique , Lactalbumine/composition chimique , Lactoglobulines/composition chimiqueRÉSUMÉ
Edible insects have garnered increased interest as alternative protein sources due to the world's growing population. However, the allergenicity of specific insect proteins is a major concern for both industry and consumers. This preliminary study investigated the capacity of high hydrostatic pressure (HHP) coupled to enzymatic hydrolysis by Alcalase® or pepsin in order to improve the in vitro digestion of mealworm proteins, specifically allergenic proteins. Pressurization was applied as pretreatment before in vitro digestion or, simultaneously, during hydrolysis. The degree of hydrolysis was compared between the different treatments and a mass spectrometry-based proteomic method was used to determine the efficiency of allergenic protein hydrolysis. Only the Alcalase® hydrolysis under pressure improved the degree of hydrolysis of mealworm proteins. Moreover, the in vitro digestion of the main allergenic proteins was increased by pressurization conditions that were specifically coupled to pepsin hydrolysis. Consequently, HHP-assisted enzymatic hydrolysis represents an alternative strategy to conventional hydrolysis for generating a large amount of peptide originating from allergenic mealworm proteins, and for lowering their immunoreactivity, for food, nutraceutical, and pharmaceutical applications.
Sujet(s)
Allergènes/immunologie , Antioxydants/métabolisme , Protéines d'insecte/métabolisme , Pepsine A/métabolisme , Protéome/analyse , Subtilisines/métabolisme , Tenebrio/métabolisme , Animaux , Hydrolyse , Pression hydrostatique , Protéines d'insecte/analyse , Tenebrio/immunologieRÉSUMÉ
Egg yolk granule phosvitin (45 kDa) is a phosphoprotein known for its emulsifying properties. Recently, high hydrostatic pressure (HHP) treatment of granule induced the transfer of phosvitin to the soluble plasma fraction. This project evaluated the performance of the ultrafiltration (UF) used to concentrate phosvitin from the plasma fraction to produce a natural emulsifier. Phosvitin was characterized in plasma from a pressure-treated granule (1.73 ± 0.07% w/w) and in its UF retentate (26.00 ± 4.12% w/w). The emulsifying properties of both retentates were evaluated. The emulsion prepared with phosvitin-enriched retentate was more resistant to flocculation and creaming. Confocal laser scanning microscopy showed a network of aggregated protein similar to a gel, which encapsulated oil droplets in emulsions made with UF-retentate of plasma from pressure-treated granule. However, although sodium dodecyl sulfate-polyacrylamide gel electrophoresis (SDS-PAGE) showed that ß-phosvitin is recovered in the cream, it is difficult to attribute the improved emulsifying properties of the UF-retentate of plasma from pressure-treated granules only to phosvitin.
Sujet(s)
Jaune d'Åuf/composition chimique , Émulsifiants/composition chimique , Émulsions , Pression hydrostatique , Ultrafiltration , Animaux , Poulets , Lipides/composition chimique , Taille de particule , Protéines/composition chimiqueRÉSUMÉ
Edible insects represent an interesting alternative source of protein for human consumption but the main hurdle facing the edible insect sector is low consumer acceptance. However, increased acceptance is anticipated when insects are incorporated as a processed ingredient, such as protein-rich powder, rather than presented whole. To produce edible insect fractions with high protein content, a defatting step is necessary. This study investigated the effects of six defatting methods (conventional solvents, three-phase partitioning, and supercritical CO2) on lipid extraction yield, fatty profiles, and protein extraction and purification of house cricket (Acheta domesticus) and mealworm (Tenebrio molitor) meals. Ethanol increased the lipid extraction yield (22.7%-28.8%), irrespective of the insect meal used or the extraction method applied. Supercritical CO2 gave similar lipid extraction yields as conventional methods for Tenebrio molitor (T. molitor) (22.1%) but was less efficient for Acheta domesticus (A. domesticus) (11.9%). The protein extraction yield ranged from 12.4% to 38.9% for A. domesticus, and from 11.9% to 39.3% for T. molitor, whereas purification rates ranged from 58.3% to 78.5% for A. domesticus and from 48.7% to 75.4% for T. molitor.
RÉSUMÉ
Ultrafiltration (UF) and microfiltration (MF) are widely-used technologies to standardize the protein content of cheesemilk. Our previous work demonstrated that protein retention of a 0.1-µm MF spiral-wound membrane (SWM) was lower, but close to that of a 10 kDa UF one. Considering that the permeability of MF membranes is expected to be higher than that of UF ones, it was hypothesized that the former could improve the efficiency of the cheesemaking process. Consequently, the objectives of this work were to compare 0.1-µm MF and 10 kDa UF spiral-wound membranes in terms of (1) hydraulic and separation performance, (2) energy consumption and fouling behavior, (3) cheesemaking efficiency of retentates enriched with cream, and (4) economic performance in virtual cheesemaking plants. This study confirmed the benefits of using MF spiral-wound membranes to reduce the specific energy consumption of the filtration process (lower hydraulic resistance and higher membrane permeability) and to enhance the technological performance of the cheesemaking process (higher vat yield, and protein and fat recoveries). However, considering the higher serum protein retention of the UF membrane and the low price of electricity in Canada, the UF scenario remained more profitable. It only becomes more efficient to substitute the 10 kDa UF SWM by the 0.1-µm MF when energy costs are substantially higher.
RÉSUMÉ
Ultrafiltration (UF) is largely used in the dairy industry to generate milk and whey protein concentrate for standardization of milk or production of dairy ingredients. Recently, it was demonstrated that high hydrostatic pressure (HHP) extended the shelf life of milk and improved rennet coagulation and cheese yield. Pressurization also modified casein micelle size distribution and promoted aggregation of whey proteins. These changes are likely to affect UF performance. Consequently, this study determined the effect of skim milk pressurization (300 and 600 MPa, 5 min) on UF performance in terms of permeate flux decline and fouling. The effect of HHP on milk proteins was first studied and UF was performed in total recycle mode at different transmembrane pressures to determine optimal UF operational parameters and to evaluate the effect of pressurization on critical and limiting fluxes. Ultrafiltration was also performed in concentration mode at a transmembrane pressure of 345 kPa for 130 or 140 min to evaluate the decline of permeate flux and to determine fouling resistances. It was observed that average casein micelle size decreased by 32 and 38%, whereas ß-lactoglobulin denaturation reached 30 and 70% at 300 and 600 MPa, respectively. These results were directly related to UF performance because initial permeate fluxes in total recycle mode decreased by 25% at 300 and 600 MPa compared with nonpressurized milk, critical flux, and limiting flux, which were lower during UF of milk treated with HHP. During UF in concentration mode, initial permeate fluxes were 30% lower at 300 and 600 MPa compared with the control, but the total flux decline was higher for nonpressurized milk (62%) compared with pressure-treated milk (30%). Fouling resistances were similar, whatever the treatment, except at 600 MPa where irreversible fouling was higher. Characterization of the fouling layer showed that caseins and ß-lactoglobulin were mainly involved in membrane fouling after UF of pressure-treated milk. Our results demonstrate that HHP treatment of skim milk drastically decreased UF performance.
Sujet(s)
Pression hydrostatique , Protéines de lait/composition chimique , Lait/composition chimique , Ultrafiltration , Animaux , Manipulation des alimentsRÉSUMÉ
Biofouling of filtration membranes is a major quality and performance issue for the dairy industry. Because biofilms that survive cleaning cycles become resistant over time, prevention strategies limiting the adhesion of bacteria to membranes should be prioritized for sustainable control of biofouling. However, this cannot be achieved because the pioneer bacteria colonizing these membranes are still unknown. Consequently, the objective of this study was to characterize pioneer bacteria on the filtration membrane surface and to measure the effect of filtration operational parameters on their diversity. Thus, milk and cheese whey were filtered for 5 h in concentration mode at 10 and 40°C using a laboratory-scale crossflow filtration system equipped with flat-sheet ultrafiltration membranes. Pioneer colonizer bacteria found on membranes after a chlorinated alkaline cleaning cycle were identified using a metabarcoding approach targeting the 16S ribosomal RNA genes. Our results suggested that prevention strategies targeting biofouling should consider the nature of the filtered fluid and the feed temperature (36.15 and 5.09% of the variances observed on membranes, respectively), as well as the microbial environment of the dairy processing plant. In the future, it is hypothesized that cleaning prevention strategies will be specific to each dairy processor and their operational parameters.