Occurrence of modified mycotoxins in Latin America: an up-to-date review.

The Latin America region has a considerable extent of varied climate conditions: from tropical, subtropical, and warm temperate to temperate. Among the surface territory, different agricultural products are produced, making them an important food source for human consumption. Fungal species commonly colonize those important agricultural products and often contaminate them with mycotoxins that have a major impact on health, welfare, and productivity. Nowadays, special attention is paid to modified mycotoxins, which are those that cannot be detected by conventional analytical methods. However, little data about their natural occurrence in food and feed is available, especially in Latin American countries, where, among all the countries in this region, only a few of them are working on this subject. Thus, the present review summarizes the published information available in order to determine the possible human exposure risk to these toxins.

Factors influencing fumonisin B1 contamination in maize: insights from two production regions in Costa Rica.

Maize (Zea mays L.) is an important cereal crop worldwide. Contaminated maize kernels pose a significant mycotoxin exposure risk for humans in Latin America. Fumonisins, the most prevalent mycotoxin in maize, typically occur during pre-harvest conditions leading to significant economic losses. Various factors, including weather conditions, may influence this contamination. This study aimed to determine the association between fumonisin B1 (FB1) contamination, prevalence of Fusarium verticillioides, weather conditions and kernel quality in the two primary maize production areas in Costa Rica (Brunca and Chorotega). All maize samples (100%) showed FB1 contamination, with higher concentrations in samples from Brunca region, consistent with the presence of F. verticilliodes. Weather conditions appeared to play an important role in this contamination, since Brunca region had the highest mean temperature and relative humidity after maize silking (R1) and the total monthly rainfall in this region was significantly higher during the last two months of maize cultivation (grain-filling and physiological maturity stages R3 to R6). Interestingly, this study found a negative correlation between grain damage and kernel contamination with FB1 and F. verticillioides. The concentration of mineral nutrients in kernels from both regions was largely similar. Most nutrients in kernels exhibited a negative correlation with FB1, particularly nitrogen. Zinc and phosphorus were the only nutrients in kernels showing a positive correlation with FB1 in samples from the Brunca region. The results highlight elevated levels of FB1 contamination in maize and contribute to a better understanding of pre-harvest factors influencing FB1 contamination in tropical conditions.

Mycotoxins and coccidiosis in poultry - co-occurrence, interaction, and effects.

Avian coccidiosis, a common disease caused by Eimeria species, results in significant losses in global poultry production. Mycotoxins are low-molecular-weight natural products (i.e., small molecules) produced as secondary metabolites by filamentous fungi and they have the potential to economically and significantly affect global poultry production. Little is known about the relationship between mycotoxins and avian coccidiosis, although they often co-occur in the field. This comprehensive review examines the intricate relationship between mycotoxins and avian coccidiosis, in particular how mycotoxins, including aflatoxins, ochratoxins, trichothecenes as well as Fusarium mycotoxins, compromise the health of the poultry flock and open the door to Eimeria parasites in the gut. In addition, this review sheds light on the immunosuppressive effects of mycotoxins, their disruption of cellular signaling pathways, and the consequent exacerbation of coccidiosis infections. The mechanisms of mycotoxin toxicity are also reviewed, emphasizing direct damage to intestinal epithelial cells, impaired nutrient absorption, inflammation, oxidative stress, and changes in the gut microbiota. Finally, the consequences for the prevention and treatment of coccidiosis when mycotoxins are present in the feed are discussed. This review emphasizes the need for effective management strategies to mitigate the combined risks of mycotoxins and coccidiosis and highlights the complexity of diagnosing and controlling these interrelated problems in poultry. The review advocates a holistic approach that includes strict feed management, disease prevention measures and regular monitoring to maintain the health and productivity of poultry against these significant challenges.

A miniaturized QuEChERS and UPLC-MS/MS method for the determination of mycotoxins in cashew nuts.

This study aimed to develop and validate a multi-mycotoxin analysis method applied to cashew nuts by employing a miniaturized QuEChERS method followed by determination by ultra-performance liquid chromatography tandem mass spectrometry (UHPLC-MS/MS). Satisfactory recoveries for the concentrations 1, 10 and 30 ng g-1, ranging from 66% (fumonisin B1) to 110% (ochratoxin A) and relative standard deviations lower than 9% (fumonisin B2) were obtained for the target compounds. Limits of quantification ranged from 0.004 ng g-1 (sterigmatocystin) to 0.59 ng g-1 (alternariol). The applicability of the analytical method was verified by analyzing 30 cashew nut samples from the city of Rio de Janeiro, RJ, southeastern Brazil. Aflatoxins M1, G2, G1, B2, B1, ochratoxin A and sterigmatocystin were detected, respectively, in 27%, 10%, 17%, 30%, 30%, 30% and 50% of the analyzed samples, at maximum concentrations of 0.56, 0.67, 1.43, 2.02, 4.93, 4.81, and 0.35 ng g-1. The maximum limit established by Brazilian legislation for aflatoxins was not exceeded by any of the analyzed samples.

Increased Dissemination of Aflatoxin- and Zearalenone-Producing Aspergillus spp. and Fusarium spp. during Wet Season via Houseflies on Dairy Farms in Aguascalientes, Mexico.

Crops contamination with aflatoxins (AFs) and zearalenone (ZEA) threaten human and animal health; these mycotoxins are produced by several species of Aspergillus and Fusarium. The objective was to evaluate under field conditions the influence of the wet season on the dissemination of AF- and ZEA-producing fungi via houseflies collected from dairy farms. Ten dairy farms distributed in the semi-arid Central Mexican Plateau were selected. Flies were collected in wet and dry seasons at seven points on each farm using entomological traps. Fungi were isolated from fly carcasses via direct seeding with serial dilutions and wet chamber methods. The production of AFs and ZEA from pure isolates was quantified using indirect competitive ELISA. A total of 693 Aspergillus spp. and 1274 Fusarium spp. isolates were obtained, of which 58.6% produced AFs and 50.0% produced ZEA (491 ± 122; 2521 ± 1295 µg/kg). Houseflies and both fungal genera were invariably present, but compared to the dry season, there was a higher abundance of flies as well as AF- and ZEA-producing fungi in the wet season (p < 0.001; 45.3/231 flies/trap; 8.6/29.6% contaminated flies). These results suggest that rainy-weather conditions on dairy farms increase the spread of AF- and ZEA-producing Aspergillus spp. and Fusarium spp. through houseflies and the incorporation of their mycotoxins into the food chain.

Detection of foodborne pathogens in contaminated food using nanomaterial-based electrochemical biosensors.

Foodborne pathogens are a grave concern for the for food, medical, environmental, and economic sectors. Their ease of transmission and resistance to treatments, such as antimicrobial agents, make them an important challenge. Food tainted with these pathogens is swiftly rejected, and if ingested, can result in severe illnesses and even fatalities. This review provides and overview of the current status of various pathogens and their metabolites transmitted through food. Despite a plethora of studies on treatments to eradicate and inhibit these pathogens, their indiscriminate use can compromise the sensory properties of food and lead to contamination. Therefore, the study of detection methods such as electrochemical biosensors has been proposed, which are devices with advantages such as simplicity, fast response, and sensitivity. However, these biosensors may also present some limitations. In this regard, it has been reported that nanomaterials with high conductivity, surface-to-volume ratio, and robustness have been observed to improve the detection of foodborne pathogens or their metabolites. Therefore, in this work, we analyze the detection of pathogens transmitted through food and their metabolites using electrochemical biosensors based on nanomaterials.

A review on mycotoxins and mycotoxicoses in ruminants and Equidae in South America.

Of the mycotoxicoses caused by molds contaminating grains or their byproducts, leukoencephalomalacia of horses and less frequently aflatoxicosis in cattle have been reported in South America. However, the most important group of mycotoxins in the region are those caused by fungi that infect forages and other types of plants and have regional distribution. In this group, ergotism is important, both caused by Claviceps purpurea infecting grains or by Epichloë coenophiala infecting Schedonorus arundinaceus. Other important mycotoxicoses are those caused by indole-diterpenes produced by Clavicipitaceous fungi including Claviceps paspali in Paspalum spp., Claviceps cynodontes in Cynodon dactylon, and by Periglandula a seed transmitted symbiont associated with the tremorgenic plant Ipomoea asarifolia. The latter is an important poisoning in the northeastern and northern Brazil. Other important mycotoxicoses are those caused by swainsonine containing plants. It was demonstrated that swainsonine contained in Ipomoea carnea var. fistulosa is produced by an epibiotic fungus of the order Chaetothyriales whose mycelia develop on the adaxial surface of the leaves. Swainsonine is also produced by the symbiotic, endobiotic fungi Alternaria section Undifilum spp., which is associated with Astragalus spp. in the Argentinian Patagonia causing poisoning. Another form of mycotoxicosis occurs in poisoning by Baccharis spp., mainly B. coridifolia, a very important toxic plant in South America that contains macrocyclic trichothecenes probably produced by an endophytic fungus that has not yet been identified. Pithomycotoxicosis caused by Pithomyces chartarum used to be an important mycotoxicosis in the region, mainly in cattle grazing improved pastures of legumes and grasses. Slaframine poisoning, diplodiosis and poisoning by barley contaminated by Aspergillus clavatus has been rarely diagnosed in Brazil, Uruguay and Argentina.

Comprehensive analysis of contaminants in Brazilian infant formulas: Application of QuEChERS coupled with UHPLC-QqQ-MS/MS and suspect screening-unknown analysis by UHPLC-Q-Orbitrap-MS.

Infant formulas (IF) can contain harmful chemical substances, such as pesticides and mycotoxins, resulting from the contamination of raw materials and inputs used in the production chain, which can cause adverse effects to infants. Therefore, the quick, easy, cheap, effective, rugged, and safe (QuEChERS) methodology prior ultra-high performance liquid chromatography coupled to triple quadrupole mass spectrometry (UHPL-QqQ-MS/MS) analysis was applied for the determination of 23 contaminants, in 30 samples of Brazilian IF. The method was validated in terms of limit of detection (0.2 to 0.4 µg/kg), limits of quantification (1 and 10 µg/kg), and recovery (64 % to 122 %); precision values, in terms of relative standard deviation (RSD), were ≤ 20 %. Fenitrothion, chlorpyrifos, and bifenthrin were the pesticides detected in the samples, but the values did not exceed the limit set by the European Union (EU), and ANVISA, and they were detected under their limits of quantification. Additionally, suspect screening and unknown analysis were conducted to tentatively identify 32 substances, including some compounds not covered in this study, such as pesticides, hormones, and veterinary drugs. Carbofuran was identified, confirmed and quantified in 10 % of the samples.

Infant exposure to ochratoxin A, zearalenone, and deoxynivalenol from the consumption of milk formula and baby cereal in Chile.

Ochratoxin A (OTA), zearalenone (ZEN), and deoxynivalenol (DON) are mycotoxins whose exposure is associated with various adverse health effects, including cancer and renal disorders, estrogenic effects, and immunosuppressive and gastrointestinal disorders, respectively. Infants (<2 years) are the most vulnerable group to mycotoxins, representing a unique combination of restricted food consumption types, low body weight, lower ability to eliminate toxins, and more future years to accumulate toxins. This study aimed to estimate the infant́s exposure to OTA, DON, and ZEN due to the consumption of milk formula and baby cereals in Chile. Milk formula samples (n = 41) and baby cereals (n = 30) were collected and analyzed using commercial ELISA kits for OTA, DON, and ZEA determination. Exposure was assessed by the Estimated Daily Intake (EDI) approach (mean and worst-case scenario, WCS) with the levels found in a modified Lower Bound (mLB) and Upper Bound (UB); ideal consumption (<6m, 7-12 m, and 13-24 m); adjusted by the weight of each group. The risk was estimated by comparing the EDI with a reference tolerable daily intake or by the margin of exposure (MOE) in the case of OTA. DON and OTA occurrence in infant formula were 34 % and 41 %, respectively. The co-occurrence between these mycotoxins was 22 %. Mycotoxin contents were below LOQ values except for OTA determined in one sample (0.29 ng/ml). No milk formulae were contaminated with ZEN. In the case of baby cereals, the occurrences were 17 % for OTA, 30 % for DON, and 7 % for ZEN, all below LOQ. Co-occurrence was seen in two samples between ZEN and OTA. According to exposure calculations, the MOE for OTA was less than 10,000 in all models for milk formula between 0 to 12 months of age and in the UB and WCS for cereal consumption. Health concerns were observed for DON in the WCS and UB for milk consumption in all ages and only in the UB WCS for cereal consumption. Considering the high consumption of milk formula in these age groups, regulation of OTA and other co-occurring mycotoxins in infant milk and food is strongly suggested.

The Response of Naturally Based Coatings and Citrus Fungicides to the Development of Four Postharvest Fungi.

The tomato (Licopersicon esculentum Mill.) is considered to be one of the products with the highest demand due to its nutritional value; however, it is susceptible to infection by fungi during its pre- and postharvest stages. In this research, three commercial products (1% Citrocover, 1% Citro 80, and 0.002% Microdyn) and two coatings based on 1.0% chitosan/0.1% lime or 0.1% orange essential oils were evaluated in vitro and on Saladette tomatoes that were previously inoculated with four postharvest fungi. The application of the commercial citrus-based product Citrocover was highly effective in reducing the in vitro development of Aspergillus flavus, Fusarium oxysporum, and Colletotrichum gloeosporioides, but not Rhizopus stolonifer. The sanitizer Microdyn promoted infections with most fungi. Citrus-based products were effective in reducing infections with A. flavus in the tomatoes during storage. Overall, mycotoxin production was very low for all treatments. The use of commercial citrus-based products and coatings did not alter the weight loss, firmness, or total soluble solid contents of the treated tomatoes. The changes observed were, rather, associated with the normal ripening process of Saladette tomatoes. The commercial citrus-based products satisfactorily controlled the in vitro growth of the fungi Aspergillus flavus, Fusarium oxysporum, and Colletotrichum gloeosporioides.

Addressing the Concern of Orange-Yellow Fungus Growth on Palm Kernel Cake: Safeguarding Dairy Cattle Diets for Mycotoxin-Producing Fungi.

Palm kernel cake (PKC), a byproduct of palm oil extraction, serves an important role in Ecuador's animal feed industry. The emergence of yellow-orange fungal growth in PKC on some cattle farms in Ecuador sparked concerns within the cattle industry regarding a potential mycotoxin-producing fungus on this substrate. Due to the limited availability of analytical chemistry techniques in Ecuador for mycotoxin detection, we chose to isolate and identify the fungus to determine its association with mycotoxin-producing genera. Through molecular identification via ITS region sequencing, we identified the yellow-orange fungus as the yeast Candida ethanolica. Furthermore, we isolated two other fungi-the yeast Pichia kudriavzevii, and the fungus Geotrichum candidum. Molecular identification confirmed that all three species are not classified as mycotoxin-producing fungi but in contrast, the literature indicates that all three have demonstrated antifungal activity against Aspergillus and Penicillium species, genera associated with mycotoxin production. This suggests their potential use in biocontrol to counter the colonization of harmful fungi. We discuss preventive measures against the fungal invasion of PKC and emphasize the importance of promptly identifying fungi on this substrate. Rapid recognition of mycotoxin-producing and pathogenic genera holds the promise of mitigating cattle intoxication and the dissemination of mycotoxins throughout the food chain.

Electrochemical microfluidic immunosensor with graphene-decorated gold nanoporous for T-2 mycotoxin detection.

T-2 is one of the most potent cytotoxic food-borne mycotoxins. In this work, we have developed and characterized an electrochemical microfluidic immunosensor for T-2 toxin quantification in wheat germ samples. T-2 toxin detection was carried out using a competitive immunoassay method based on monoclonal anti-T-2 antibodies immobilized on the poly(methyl methacrylate) (PMMA) microfluidic central channel. The platinum wire working electrode at the end of the channel was in situ modified by a single-step electrodeposition procedure with reduced graphene oxide (rGO)-nanoporous gold (NPG). T-2 toxin in the sample was allowed to compete with T-2-horseradish peroxidase (HRP) conjugated for the specific recognizing sites of immobilized anti-T-2 monoclonal antibodies. The HRP, in the presence of hydrogen peroxide (H2O2), catalyzes the oxidation of 4-tert-butylcatechol (4-TBC), whose back electrochemical reduction was detected on the nanostructured electrode at -0.15 V. Thus, at low T-2 concentrations in the sample, more enzymatically conjugated T-2 will bind to the capture antibodies, and, therefore, a higher current is expected. The detection limits found for electrochemical immunosensor, and commercial ELISA procedure were 0.10 µg kg-1 and 10 µg kg-1, and the intra- and inter-assay coefficients of variation were below 5.35% and 6.87%, respectively. Finally, our microfluidic immunosensor to T-2 toxin will significantly contribute to faster, direct, and secure in situ analysis in agricultural samples.

Aflatoxins and fumonisins in conventional and organic corn: a comprehensive review.

This review analyzes the occurrence and co-exposure of aflatoxins and fumonisins in conventional and organic corn, and compares the vulnerability to contamination of both. The risks of fungal contamination in corn are real, mainly by the genera Aspergillus and Fusarium, producers of aflatoxins and fumonisins, respectively. Aflatoxins, especially AFB1, are related to a high incidence of liver cancer, and the International Agency Research of Cancer (IARC) classified them in group 1A 'carcinogenic to humans'. The occurrence in conventional corn is reported in many countries, including at higher levels than those established by legislation. IARC classified fumonisins in group 2B 'possibly carcinogenic to humans' due to their link with incidence of esophageal cancer. However, comparing corn and organic and conventional by-products from different regions, different results are observed. The co-occurrence of both mycotoxins is a worldwide problem; nevertheless, there is little data on the comparison of the co-exposure of these mycotoxins in corn and derivatives between both systems. It was found that the agricultural system is not a decisive factor in the final contamination, indicating the necessity of effective strategies to reduce contamination and co-exposure at levels that do not pose health risks.

Aflatoxins in maize flour produced in Mozambique and its risk assessment.

This study investigated the occurrence of aflatoxins (B1, B2, G1, and G2) in maize flour produced in Mozambique and to assess the associated carcinogenic risk. At different opportunities, 30 samples of maize flour were collected in five flour processing factories. These were determined by high-performance liquid chromatography (HPLC) with fluorescence detection. AFB1 concentrations ranged from 0.25 to 0.33 µg kg-1. The levels of total aflatoxins ranged from 0.55 to 1.05 µg kg-1, with a mean of 0.89 µg kg-1, for which maximum limits (MLs) are 10 and 4 µg kg-1 for Mozambique and the European Union, respectively. The calculated Margin of Exposure (MOE) for men and women was 243 and 231, respectively, so several folds below the risk cut-off level, indicating that consumption of such maize flour poses a potential risk of hepatocarcinoma related to aflatoxin exposure due to high intake of this food, a staple diet in most African countries.

A Three-Year Study on the Nutritional Composition and Occurrence of Mycotoxins of Corn Varieties with Different Transgenic Events Focusing on Poultry Nutrition.

Corn is one of the most produced cereals in the world and plays a major role in poultry nutrition. As there is limited scientific information regarding the impact of transgenic technology on the quality and nutrient composition of the grains, this study investigated the effect of three major transgenic corn varieties-VT PRO3®, PowerCore® ULTRA, and Agrisure® Viptera 3-on the field traits, nutrient composition, and mycotoxin contamination of corn grains cultivated in southern Brazil during three consecutive harvests. VT PRO3®, while demonstrating superior crop yield, showed susceptibility to mycotoxins, particularly fumonisins. In contrast, PowerCore® ULTRA, with the lowest yield, consistently exhibited lower levels of fumonisins. VT PRO3® had higher AMEn than the other varieties, while PowerCore® ULTRA had the highest total and digestible amino acid contents over the three years. The study's comprehensive analysis reveals the distinct impact of transgenic corn technologies on both productivity and nutritional levels. Balancing the crops yield, mycotoxin resistance, and nutritional content of corn is crucial to meet the demands of the poultry feed industry. Such insights are essential for decision-making, ensuring sustainability and efficiency in agricultural production as well as meeting the demands of the poultry industry.

Exposure assessment of children to dietary mycotoxins: A pilot study conducted in Ribeirão Preto, São Paulo, Brazil.

Exposure to mycotoxins through food is a major health concern, especially for youngsters. This study performed a preliminary investigation on children's exposure to dietary mycotoxins in Ribeirão Preto, Brazil. Sampling procedures were conducted between August and December 2022, to collect foods (N = 213) available for consumption in the households of children (N = 67), including preschoolers (aged 3-6 years, n = 21), schoolers (aged 7-10 years, n = 15), and adolescents (aged 11-17 years, n = 31) cared in the Vila Lobato Community Social Medical Center of Ribeirão Preto. Ultra-performance liquid chromatography coupled to tandem mass spectrometry (UPLC-MS/MS) was used to determine concentrations of the mycotoxins in foods. Mycotoxins measured in all foods comprised aflatoxins (AFs), fumonisins (FBs), zearalenone (ZEN), T-2 toxin, deoxynivalenol (DON) and ochratoxin A (OTA). Higher incidence and levels were found for FBs, ZEN, and DON in several commonly consumed foods. Furthermore, 32.86 % foods had two to four quantifiable mycotoxins in various combinations. The mean estimated daily intake (EDI) values were lower than the tolerable daily intake (TDI) for AFs, FBs, and ZEN, but higher than the TDI (1.0 µg/kg bw/day) for DON, hence indicating a health risk for all children age groups. Preschoolers and adolescents were exposed to DON through wheat products (EDIs: 2.696 ± 7.372 and 1.484 ± 2.395 µg/kg body weight (bw)/day, respectively), while schoolers were exposed through wheat products (EDI: 1.595 ± 1.748 µg/kg bw/day) and rice (EDI: 1.391 ± 1.876 µg/kg bw/day). The results indicate that wheat-based foods and rice may be risky to children, implying the need for stringent measures to avoid DON contamination in these products.

Modulation of Broiler Intestinal Changes Induced by Clostridium perfringens and Deoxynivalenol through Probiotic, Paraprobiotic, and Postbiotic Supplementation.

Deoxynivalenol (DON) is a predisposing factor for necrotic enteritis. This study aimed to investigate the effects of a DON and Clostridium perfringens (CP) challenge on the intestinal morphology, morphometry, oxidative stress, and immune response of broilers. Additionally, we evaluated the potential of a Lactobacillus spp. mixture as an approach to mitigate the damage induced by the challenge. One-day-old broiler chickens (n = 252) were divided into seven treatment groups: Control, DON, CP, CP + DON, VL (DON + CP + viable Lactobacillus spp. mixture), HIL (DON + CP + heat-inactivated Lactobacillus spp. mixture), and LCS (DON + CP + Lactobacillus spp. mixture culture supernatant). Macroscopic evaluation of the intestines revealed that the CP + DON group exhibited the highest lesion score, while the VL and HIL groups showed the lowest scores. Microscopically, all Lactobacillus spp. treatments mitigated the morphological changes induced by the challenge. DON increased levels of reactive oxygen species (ROS) in the jejunum, and CP increased ROS levels in the jejunum and ileum. Notably, the Lactobacillus spp. treatments did not improve the antioxidant defense against CP-induced oxidative stress. In summary, a Lactobacillus spp. mixture, whether used as a probiotic, paraprobiotic, or postbiotic, exerted a partially protective effect in mitigating most of the intestinal damage induced by DON and CP challenges.

Contamination of Fusarium spp. and mycotoxins at different ear physiological stages of maize in Argentina.

Maize is one of the most important crops worldwide, being affected by several fungal species under field conditions. The study of plant-pathogen interaction plays a key role because fungal diseases are responsible for reducing grain yield and quality by increasing mycotoxin production. Thus, the present work aimed to evaluate the interaction of F. graminearum and F. verticillioides and mycotoxin production under field conditions along different physiological stages. During the 2019/2020 and 2020/2021 growing seasons, twelve maize genotypes were inoculated at the flowering stage (silking). Four treatments were applied using one isolate of each species: (i) F. graminearum; (ii) F. verticillioides; (iii) a combined inoculum (F. graminearum + F. verticillioides); (iv) and control treatment. Fungal diversity, disease evaluation, and mycotoxin contamination were evaluated at three different physiological stages: T1 (from R2 to R4), T2 (from R4 to R6), and T3 (at harvest time). A total of 15,907 Fusarium isolates were obtained. The results showed a predominance of F. verticillioides over F. graminearum in both years evaluated, reporting an increase in the occurrence of this species at late stages. Regarding mycotoxin contamination, no evidence was found supporting antagonism or synergism regarding isolates of both species used as inoculum under field conditions. The results reported in the present manuscript point out a major influence of climatic conditions on F. verticillioides predominance over F. graminearum, mainly during the late physiological stages. Furthermore, no clear relationship between mycotoxin concentration and physiological stages was established, suggesting that other grain factors, such as water activity and pH, could modulate mycotoxin production and accumulation under field conditions.

Evaluation of the brown alga, Sargassum muticum extract as an antimicrobial and feeding additives / Avaliação da alga marrom, extrato de Sargassum muticum, como antimicrobiano e aditivo alimentar

Plant disease administration is difficult due to the nature of phytopathogens. Biological control is a safe method to avoid the problems related to fungal diseases affecting crop productivity and some human pathogenic bacteria. For that, the antimicrobial activity of the seaweed Sargassum muticum methanol and water extracts were investigated against human bacterial pathogens and fungal plant pathogens. By using 70 percent methanol, the seaweed powder was extracted, feeding additives assay, ultrastructure (TEM). Results revealed significant inhibition of S. muticum methanol extract against Salmonella typhi (25.66 mm), Escherichia coli (24.33 mm), Staphylococcus aureus (22.33 mm) and Bacillus subtilis. (19.66 mm), some fungal phytopathogens significantly inhibited Fusarium moniliforme (30.33mm), Pythium ultimum (26.33 mm), Aspergillus flavus (24.36mm), and Macrophomina phaseolina (22.66mm). Phytochemical investigation of S. muticum extract showed the presence of phenolic and flavonoid compounds. Results suggested that there is an appreciable level of antioxidant potential in S. muticum (79.86%) DPPH scavenging activity. Ultrastructural studies of Fusarium moniliforme hypha grown on a medium containing S. muticum extract at concentration 300mg/ml showed a thickening cell wall, disintegration of cytoplasm, large lipid bodies and vacuoles. In conclusion, our study revealed The antibacterial activity of S. muticum extract significantly against some Gram positive, Gram negative bacteria and antifungal activity against some phytopathogenic and some mycotoxin producer fungi. Flavonoids, phenolic play an important role as antioxidants and antimicrobial properties. Such study revealed that S. muticum methanol extract could be used as ecofriendly biocontrol for phytopathogenic fungi and feeding additives to protect livestock products.

A administração de doenças de plantas é difícil devido à natureza dos fitopatógenos. O controle biológico é um método seguro para evitar problemas relacionados a doenças fúngicas que afetam a produtividade das culturas e algumas bactérias patogênicas ao homem. Para isso, a atividade antimicrobiana da alga marinha Sargassum muticum metanol e de extratos aquosos foi investigada contra patógenos bacterianos humanos e fitopatógenos fúngicos. Usando metanol a 70%, o pó de algas marinhas foi extraído do ensaio de aditivos alimentares, a ultraestrutura (TEM). Os resultados revelaram inibição significativa do extrato metanólico de S. muticum contra Salmonella typhi (25,66 mm), Escherichia coli (24,33 mm), Staphylococcus aureus (22,33 mm) e Bacillus subtilis (19,66 mm). Alguns fitopatógenos fúngicos inibiram significativamente Fusarium moniliforme (30,33 mm), Pythium ultimum (26,33 mm), Aspergillus flavus (24,36 mm) e Macrophomina phaseolina (22,66 mm). A investigação fitoquímica do extrato de S. muticum mostrou a presença de compostos fenólicos e flavonoides. Os resultados sugeriram que há um nível apreciável de potencial antioxidante na atividade de eliminação de DPPH de S. muticum (79,86%). Estudos ultraestruturais da hifa de Fusarium moniliforme cultivada em meio contendo extrato de S. muticum na concentração de 300 mg/ml mostraram espessamento da parede celular, desintegração do citoplasma, grandes corpos lipídicos e vacúolos. Em conclusão, nosso estudo revelou a atividade antibacteriana do extrato de S. muticum significativamente contra algumas bactérias Gram-positivas, Gram-negativas e atividade antifúngica contra alguns fungos fitopatogênicos e alguns produtores de micotoxinas. Flavonoides e fenólicos desempenham papel importante como antioxidantes e propriedades antimicrobianas. Tal estudo revelou que o extrato metanólico de S. muticum pode ser usado como biocontrole ecologicamente correto para fungos fitopatogênicos e aditivos alimentares para proteger os produtos pecuários.

Monitoring of carbon dioxide and equilibrium moisture content for early detection of physicochemical and morphological changes in soybeans stored in vertical silos.

In the context of grain storage, impurities and soybeans defects in soybeans can significantly impact the equilibrium moisture content. This, cause moisture migration and heating of the stored product, leading to increased respiratory activity. Furthermore, temperature measurements within stored grain mass do not provide sufficient information for effective grain quality monitoring, primarily due to the grains excellent thermal insulating properties. To address this issue, we propose a different approach: monitoring the equilibrium moisture content and CO2 concentration as indicators of soybean respiration within the intergranular spaces of the stored grain mass. This study propose monitoring the CO2 concentration in the intergranular air along with environmental variables for early detection of physicochemical and morphological changes in soybeans stored in vertical silos using near infrared spectroscopy, X-ray diffraction and scanning electron microscopy. Thermogravimetry and spectrometry analyses revealed that the interrelationships among variables had a direct impact on soybean quality attributes. Specifically, the presence of soybeans with 5.2 % impurities led to an increased in respiration rates, resulting in a CO2 concentration of up to 5000 ppm and the consumption of up to 3.6 % of dry matter. Consequently, there were changes in the percentage of ash, proteins, fibers, and oils compositions. These findings highlight the potential for indirect assessments, enabling the prediction of physicochemical quality and contamination of soybeans stored in vertical silos through continuous monitoring of CO2 concentration and equilibrium moisture content.