Heterogeneous conditions in dissolved oxygen affect N-glycosylation but not productivity of a monoclonal antibody in hybridoma cultures.

It is known that heterogeneous conditions exist in large-scale animal cell cultures. However, little is known about how heterogeneities affect cells, productivities, and product quality. To study the effect of non-constant dissolved oxygen tension (DOT), hybridomas were subjected to sinusoidal DOT oscillations in a one-compartment scale-down simulator. Oscillations were forced by manipulating the inlet oxygen partial pressure through a feedback control algorithm in a 220-mL bioreactor maintained at a constant agitation. Such temporal DOT oscillations simulate spatial DOT gradients that can occur in large scales. Different oscillation periods, in the range of 800 to 12,800 s (axis of 7% (air saturation) and amplitude of 7%), were tested and compared to constant DOT (10%) control cultures. Oscillating DOT decreased maximum cell concentrations, cell growth rates, and viability indexes. Cultures at oscillating DOT had an increased glycolytic metabolism that was evidenced by a decrease in yield of cells on glucose and an increase in lactate yield. DOT gradients, even several orders of magnitude higher than those expected under practical large-scale conditions, did not significantly affect the maximum concentration of an IgG(1) monoclonal antibody (MAb). The glycosylation profile of the MAb produced at a constant DOT of 10% was similar to that reported in the literature. However, MAb produced under oscillating culture conditions had a higher amount of triantennary and sialylated glycans, which can interfere with effector functions of the antibody. It was shown that transient excursions of hybridomas to limiting DOT, as occurs in deficiently mixed large-scale bioreactors, is important to culture performance as the oscillation period, and thus the time cells spent at low DOT, affected cell growth, metabolism, and the glycosylation pattern of MAb. Such results underline the importance of monitoring protein characteristics for the development of large-scale processes.

Transfection of NS0 myeloma fusion partner cells with HSP70 gene results in higher hybridoma yield by improving cellular resistance to apoptosis.

Mouse myeloma NS0 cells widely used in hybridoma technology lack the expression of a major stress protein Hsp70 which is the principal component of the basic cellular defense mechanism. These cells rapidly undergo apoptosis at the late-stationary phase of batch culture following nutrient exhaustion. Since Hsp70 was recently demonstrated to protect cells against numerous apoptotic stimuli, the aim of the present study was to examine the protective potential of the protein expression in engineered myeloma NS0 cells and in resulting hybridomas. Myeloma cells were transfected with the hsp70 gene under beta-actin gene promoter. To imitate harmful conditions that hybridoma or myeloma cells often experience when cultivated in large scale for an antibody production, NS0(wt) and NS0(hsp70) cell cultures were maintained without changing the medium for a few days, and the expression of apoptotic markers has been studied. It was found that long-term cultivation induced apoptosis in original cells manifested by typical nuclei fragmentation, DNA ladders and activation of caspase-3. In contrast, in transfected cells under the same conditions the outcome of apoptosis was postponed for 24 hours. Most relevant was that the fusion of transfected myeloma cells with immune splenocytes resulted in twofold hybridomas output compared with wild-type fusion partner. Almost half of the hybridomas continued to be hsp70-positive and maintained higher robustness in culture. The level of monoclonal antibodies production by hybridoma cells obtained with the use of NS0(wt) and NS0(hsp70) was similar, however, the secreted product was better preserved in culture supernatants of Hsp70-positive cells. It is concluded that transfection of mouse myeloma cells with the hsp70 gene can be a novel means to increase hybridoma yield and reduce the sensitivity of myeloma and hybridoma cells to culture conditions insults accompanying monoclonal antibody production.

Costimulatory action of glycoinositolphospholipids from Trypanosoma cruzi: increased interleukin 2 secretion and induction of nuclear translocation of the nuclear factor of activated T cells 1.

The effects of the glycoinositolphospholipids (GIPLs) fromTrypanosoma cruzi on T lymphocyte activation were investigated in a mouse T cell hybridoma (DO-11.10). Purified GIPLs from T. cruzi strains Y and G markedly increased IL-2 mRNA transcripts and IL-2 secretion induced by mitogenic anti-CD3 and anti-Thy1 mAbs. This costimulatory function was also revealed by the induction of IL-2 secretion after the simultaneous addition of the T. cruzi GIPLs and either the calcium ionophore A23187 or phorbol ester. The capacity of the GIPL molecule to induce an increase in cytoplasmic calcium levels was also demonstrated. After exposure of T cell hybridoma to GIPL, the nuclear transcription factor NFAT1 became partially dephosphorylated, and its nuclear localization was demonstrated both in the T cell hybridoma and in Balb/c CD3(+) cells. These results demonstrate that T. cruzi GIPL molecules are capable of signaling to T cells and therefore could be valuable tools for the study of T cell activation, besides playing a potential role in subverting the T lymphocyte immune response during T. cruzi infection.

Algunas característiicas de la replicación in vivo de la línea de mieloma murino X63 Ag8.6.5.3. Comunicación preliminar / Soma characteristics of the replication in vivo of the murine mieloma X63 Ag8.6.5.3. line: preliminary report

Se discuten resultados obtenidos cultivando la línea de mieloma murino X63 Ag8.6.5.3. en ratones. Las células fueron inoculadas por vía subcutánea y por vía intraperitoneal, utilizando respectivamente ciclofosfamida y radiaciones gamma como agente inmunopresor. El cultivo intraperitoneal produce una mayor proporción de células viables, aptas para la hibridación por la vía subcutánea. Con el pase en ratón, se elimina la contaminación de las células por C. albicans