27 MHz constant field dielectric warming of kidneys cryopreserved by vitrification.

Organs cryopreserved by vitrification are exposed to the lowest possible concentration of cryoprotectants for the least time necessary to successfully avoid ice formation. Faster cooling and warming rates enable lower concentrations and perfusion times, reducing toxicity. Since warming rates necessary to avoid ice formation during recovery from vitrification are typically faster than cooling rates necessary for vitrification, warming speed is a major determining factor for successful vitrification. Dielectric warming uses an oscillating electric field to directly heat water and cryoprotectant molecules inside organs to achieve warming that's faster and more uniform than can be achieved by heat conduction from the organ surface. This work studied 27 MHz dielectric warming of rabbit kidneys perfused with M22 vitrification solution. The 27 MHz frequency was chosen because its long wavelength and penetration depth are suitable for human organs, because it had an anticipated favorable temperature of maximum dielectric absorption in M22, and because it's an allocated frequency for industrial and amateur use with inexpensive amplifiers available. Previously vitrified kidneys were warmed from -100 °C by placement in a 27 MHz electric field formed between parallel capacitor plates in a resonant circuit. Power was varied during warming to maintain constant electric field amplitude between the plates. Maximum power absorption occurred near -70 °C, with a peak warming rate near 150 °C/min in 50 mL total volume with approximately 500 W power. After some optimization, it was possible to warm ∼13 g vitrified kidneys with unprecedentedly little injury from medullary ice formation and a favorable serum creatinine trend after transplant. Distinct behaviors of power absorption and system tuning observed as a function of temperature during warming are promising for non-invasive thermometry and future automated control of the warming process at even faster rates with user-defined temperature dependence.

Model biological systems demonstrate the inducibility of pathways that strongly reduce cryoprotectant toxicity.

Cryoprotectant toxicity is a limiting factor for the cryopreservation of many living systems. We were moved to address this problem by the potential of organ vitrification to relieve the severe shortage of viable donor organs available for human transplantation. The M22 vitrification solution is presently the only solution that has enabled the vitrification and subsequent transplantation with survival of large mammalian organs, but its toxicity remains an obstacle to organ stockpiling for transplantation. We therefore undertook a series of exploratory studies to identify potential pretreatment interventions that might reduce the toxic effects of M22. Hormesis, in which a living system becomes more resistant to toxic stress after prior subtoxic exposure to a related stress, was investigated as a potential remedy for M22 toxicity in yeast, in the nematode worm C. elegans, and in mouse kidney slices. In yeast, heat shock pretreatment increased survival by 18-fold after exposure to formamide and by over 9-fold after exposure to M22 at 30 °C; at 0 °C and with two-step addition, treatment with 90% M22 resulted in 100% yeast survival. In nematodes, surveying a panel of pretreatment interventions revealed 3 that conferred nearly total protection from acute whole-worm M22-induced damage. One of these protective pretreatments (exposure to hydrogen peroxide) was applied to mouse kidney slices in vitro and was found to strongly protect nuclear and plasma membrane integrity in both cortical and medullary renal cells exposed to 75-100% M22 at room temperature for 40 min. These studies demonstrate for the first time that endogenous cellular defenses, conserved from yeast to mammals, can be marshalled to substantially ameliorate the toxic effects of one of the most toxic single cryoprotectants and the toxicity of the most concentrated vitrification solution so far described for whole organs.

The role of antifreeze glycoprotein (AFGP) and polyvinyl alcohol/polyglycerol (X/Z-1000) as ice modulators during partial freezing of rat livers.

Introduction: The current liver organ shortage has pushed the field of transplantation to develop new methods to prolong the preservation time of livers from the current clinical standard of static cold storage. Our approach, termed partial freezing, aims to induce a thermodynamically stable frozen state at high subzero storage temperatures (-10°C to -15°C), while simultaneously maintaining a sufficient unfrozen fraction to limit ice-mediated injury. Methods and results: Using glycerol as the main permeating cryoprotectant agent, this research first demonstrated that partially frozen rat livers showed similar outcomes after thawing from either -10°C or -15°C with respect to subnormothermic machine perfusion metrics. Next, we assessed the effect of adding ice modulators, including antifreeze glycoprotein (AFGP) or a polyvinyl alcohol/polyglycerol combination (X/Z-1000), on the viability and structural integrity of partially frozen rat livers compared to glycerol-only control livers. Results showed that AFGP livers had high levels of ATP and the least edema but suffered from significant endothelial cell damage. X/Z-1000 livers had the highest levels of ATP and energy charge (EC) but also demonstrated endothelial damage and post-thaw edema. Glycerol-only control livers exhibited the least DNA damage on Terminal deoxynucleotidyl transferase dUTP nick end labeling (TUNEL) staining but also had the lowest levels of ATP and EC. Discussion: Further research is necessary to optimize the ideal ice modulator cocktail for our partial-freezing protocol. Modifications to cryoprotective agent (CPA) combinations, including testing additional ice modulators, can help improve the viability of these partially frozen organs.

Vitrification and Nanowarming of Kidneys.

Vitrification can dramatically increase the storage of viable biomaterials in the cryogenic state for years. Unfortunately, vitrified systems ≥3 mL like large tissues and organs, cannot currently be rewarmed sufficiently rapidly or uniformly by convective approaches to avoid ice crystallization or cracking failures. A new volumetric rewarming technology entitled "nanowarming" addresses this problem by using radiofrequency excited iron oxide nanoparticles to rewarm vitrified systems rapidly and uniformly. Here, for the first time, successful recovery of a rat kidney from the vitrified state using nanowarming, is shown. First, kidneys are perfused via the renal artery with a cryoprotective cocktail (CPA) and silica-coated iron oxide nanoparticles (sIONPs). After cooling at -40 °C min-1 in a controlled rate freezer, microcomputed tomography (µCT) imaging is used to verify the distribution of the sIONPs and the vitrified state of the kidneys. By applying a radiofrequency field to excite the distributed sIONPs, the vitrified kidneys are nanowarmed at a mean rate of 63.7 °C min-1 . Experiments and modeling show the avoidance of both ice crystallization and cracking during these processes. Histology and confocal imaging show that nanowarmed kidneys are dramatically better than convective rewarming controls. This work suggests that kidney nanowarming holds tremendous promise for transplantation.

Principles of Ice-Free Cryopreservation by Vitrification.

Vitrification is an alternative to cryopreservation by freezing that enables hydrated living cells to be cooled to cryogenic temperatures in the absence of ice. Vitrification simplifies and frequently improves cryopreservation because it eliminates mechanical injury from ice, eliminates the need to find optimal cooling and warming rates, eliminates the importance of differing optimal cooling and warming rates for cells in mixed cell type populations, eliminates the need to find a frequently imperfect compromise between solution effects injury and intracellular ice formation, and can enable chilling injury to be "outrun" by using rapid cooling without a risk of intracellular ice formation. On the other hand, vitrification requires much higher concentrations of cryoprotectants than cryopreservation by freezing, which introduces greater risks of both osmotic damage and cryoprotectant toxicity. Fortunately, a large number of remedies for the latter problem have been discovered over the past 35 years, and osmotic damage can in most cases be eliminated or adequately controlled by paying careful attention to cryoprotectant introduction and washout techniques. Vitrification therefore has the potential to enable the superior and convenient cryopreservation of a wide range of biological systems (including molecules, cells, tissues, organs, and even some whole organisms), and it is also increasingly recognized as a successful strategy for surviving harsh environmental conditions in nature. But the potential of vitrification is sometimes limited by an insufficient understanding of the complex physical and biological principles involved, and therefore a better understanding may not only help to improve present outcomes but may also point the way to new strategies that may be yet more successful in the future. This chapter accordingly describes the basic principles of vitrification and indicates the broad potential biological relevance of this alternative method of cryopreservation.

Imaging the distribution of iron oxide nanoparticles in hypothermic perfused tissues.

PURPOSE: Herein, we evaluate the use of MRI as a tool for assessing iron oxide nanoparticle (IONP) distribution within IONP perfused organs and vascularized composite allografts (VCAs) (i.e., hindlimbs) prepared for cryopreservation. METHODS: Magnetic resonance imaging was performed on room-temperature organs and VCAs perfused with IONPs and were assessed at 9.4 T. Quantitative T1 mapping and T2∗ -weighted images were acquired using sweep imaging with Fourier transformation and gradient-echo sequences, respectively. Verification of IONP localization was performed through histological assessment and microcomputer tomography. RESULTS: Quantitative imaging was achieved for organs and VCAs perfused with up to 642 mMFe (36 mgFe /mL), which is above previous demonstrations of upper limit detection in agarose (35.7mMFe [2 mgFe /mL]). The stability of IONPs in the perfusate had an effect on the quality of distribution and imaging within organs or VCA. Finally, MRI provided more accurate IONP localization than Prussian blue histological staining in this system, wherein IONPs remain primarily in the vasculature. CONCLUSION: Using MRI, we were able to assess the distribution of IONPs throughout organs and VCAs varying in complexity. Additional studies are necessary to better understand this system and validate the calibration between T1 measurements and IONP concentration.

Reversal of epigenetic aging and immunosenescent trends in humans.

Epigenetic "clocks" can now surpass chronological age in accuracy for estimating biological age. Here, we use four such age estimators to show that epigenetic aging can be reversed in humans. Using a protocol intended to regenerate the thymus, we observed protective immunological changes, improved risk indices for many age-related diseases, and a mean epigenetic age approximately 1.5 years less than baseline after 1 year of treatment (-2.5-year change compared to no treatment at the end of the study). The rate of epigenetic aging reversal relative to chronological age accelerated from -1.6 year/year from 0-9 month to -6.5 year/year from 9-12 month. The GrimAge predictor of human morbidity and mortality showed a 2-year decrease in epigenetic vs. chronological age that persisted six months after discontinuing treatment. This is to our knowledge the first report of an increase, based on an epigenetic age estimator, in predicted human lifespan by means of a currently accessible aging intervention.

Genetic suppression of cryoprotectant toxicity.

We report here a new, unbiased forward genetic method that uses transposon-mediated mutagenesis to enable the identification of mutations that confer cryoprotectant toxicity resistance (CTR). Our method is to select for resistance to the toxic effects of M22, a much-studied whole-organ vitrification solution. We report finding and characterizing six mutants that are resistant to M22. These mutants fall into six independent biochemical pathways not previously linked to cryoprotectant toxicity (CT). The genes associated with the mutations were Gm14005, Myh9, Nrg2, Pura, Fgd2, Pim1, Opa1, Hes1, Hsbp1, and Ywhag. The mechanisms of action of the mutations remain unknown, but two of the mutants involve MYC signaling, which was previously implicated in CT. Several of the mutants may up-regulate cellular stress defense pathways. Several of the M22-resistant mutants were also resistant to dimethyl sulfoxide (Me2SO), and many of the mutants showed significantly improved survival after freezing and thawing in 10% (v/v) Me2SO. This new approach to overcoming CT has many advantages over alternative methods such as transcriptomic profiling. Our method directly identifies specific genetic loci that unequivocally affect CT. More generally, our results provide the first direct evidence that CT can be reduced in mammalian cells by specific molecular interventions. Thus, this approach introduces remarkable new opportunities for pharmacological blockade of CT.

Vitrification tendency and stability of DP6-based vitrification solutions for complex tissue cryopreservation.

Vitrification tendency and stability of the amorphous state were analyzed by means of differential scanning calorimetry (DSC) for the vitrification solution DP6, with and without additional solutes to enhance ice suppression. This study is a part of an ongoing research effort to characterize the thermophysical and mechanical properties of DP6 and its derivatives, and their qualities as cryoprotective solutions. DP6 was determined to have a critical cooling rate necessary to ensure vitrification of 2.7 °C/min. The following additional solutions were tested: DP6 + 6% (2R, 3R) 2,3-butanediol, DP6 + 6% 1,3-cyclohexanediol, DP6 + 6% (0.175M) sucrose, DP6 + 12% PEG 400, and DP6 + 17.1% (0.5 M) sucrose. The additives decreased the critical cooling rate of the DP6 solution to rates below 1 °C/min that were not quantifiable by the DSC techniques used. The following critical warming rates necessary to avoid devitrification were identified for DP6 and the modified solutions, respectively: 189 °C/min, 5 °C/min, ≈ 1 °C/min, 15 °C/min, <1 °C/min, and <1 °C/min. Glass transition temperatures and melting temperatures were also measured. Sucrose was the least effective additive on a per mass basis, with 1,3-cyclohexanediol appearing to be the most effective additive for suppressing ice formation in DP6.

Thermal Analyses of a Human Kidney and a Rabbit Kidney During Cryopreservation by Vitrification.

This study focuses on thermal analysis of the problem of scaling up from the vitrification of rabbit kidneys to the vitrification of human kidneys, where vitrification is the preservation of biological material in the glassy state. The basis for this study is a successful cryopreservation protocol for a rabbit kidney model, based on using a proprietary vitrification solution known as M22. Using the finite element analysis (FEA) commercial code ANSYS, heat transfer simulations suggest that indeed the rabbit kidney unquestionably cools rapidly enough to be vitrified based on known intrarenal concentrations of M22. Scaling up 21-fold, computer simulations suggest less favorable conditions for human kidney vitrification. In this case, cooling rates below -100 °C are sometimes slower than 1 °C/min, a rate that provides a clear-cut margin of safety at all temperatures based on the stability of rabbit kidneys in past studies. Nevertheless, it is concluded in this study that vitrifying human kidneys is possible without significant ice damage, assuming that human kidneys can be perfused with M22 as effectively as rabbit kidneys. The thermal analysis suggests that cooling rates can be further increased by a careful design of the cryogenic protocol and by tailoring the container to the shape of the kidney, in contrast to the present cylindrical container. This study demonstrates the critical need for the thermal analysis of experimental cryopreservation and highlights the unmet need for measuring the thermophysical properties of cryoprotective solutions under conditions relevant to realistic thermal histories.

The Grand Challenges of Organ Banking: Proceedings from the first global summit on complex tissue cryopreservation.

The first Organ Banking Summit was convened from Feb. 27 - March 1, 2015 in Palo Alto, CA, with events at Stanford University, NASA Research Park, and Lawrence Berkeley National Labs. Experts at the summit outlined the potential public health impact of organ banking, discussed the major remaining scientific challenges that need to be overcome in order to bank organs, and identified key opportunities to accelerate progress toward this goal. Many areas of public health could be revolutionized by the banking of organs and other complex tissues, including transplantation, oncofertility, tissue engineering, trauma medicine and emergency preparedness, basic biomedical research and drug discovery - and even space travel. Key remaining scientific sub-challenges were discussed including ice nucleation and growth, cryoprotectant and osmotic toxicities, chilling injury, thermo-mechanical stress, the need for rapid and uniform rewarming, and ischemia/reperfusion injury. A variety of opportunities to overcome these challenge areas were discussed, i.e. preconditioning for enhanced stress tolerance, nanoparticle rewarming, cyroprotectant screening strategies, and the use of cryoprotectant cocktails including ice binding agents.

Insights on cryoprotectant toxicity from gene expression profiling of endothelial cells exposed to ethylene glycol.

Cryopreservation consists of preserving living cells or tissues generally at -80 °C or below and has many current applications in cell and tissue banking, and future potential for organ banking. Cryoprotective agents such as ethylene glycol (EG) are required for successful cryopreservation of most living systems, but have toxic side effects whose mechanisms remain largely unknown. In this work, we investigated the mechanisms of toxicity of ethylene glycol in human umbilical vein endothelial cells (HUVECs) as a model of the vascular endothelium in perfused organs. Exposing cells to 60% v/v EG for 2 h at 4 °C resulted in only a slight decrease in subsequent cell growth, suggesting only modest toxicity of EG for this cell type. Gene expression analysis with whole genome microarrays revealed signatures indicative of a generalized stress response at 24 h after EG exposure and a trend toward partial recovery at 72 h. The observed changes involved signalling pathways, glycoproteins, and genes involved in extracellular and transmembrane functions, the latter suggesting potential effects of ethylene glycol on membranes. These results continue to develop a new paradigm for understanding cryoprotectant toxicity and reveal molecular signatures helpful for future experiments in more completely elucidating the toxic effects of ethylene glycol in vascular endothelial cells and other cell types.

Aldehyde-stabilized cryopreservation.

We describe here a new cryobiological and neurobiological technique, aldehyde-stabilized cryopreservation (ASC), which demonstrates the relevance and utility of advanced cryopreservation science for the neurobiological research community. ASC is a new brain-banking technique designed to facilitate neuroanatomic research such as connectomics research, and has the unique ability to combine stable long term ice-free sample storage with excellent anatomical resolution. To demonstrate the feasibility of ASC, we perfuse-fixed rabbit and pig brains with a glutaraldehyde-based fixative, then slowly perfused increasing concentrations of ethylene glycol over several hours in a manner similar to techniques used for whole organ cryopreservation. Once 65% w/v ethylene glycol was reached, we vitrified brains at -135 °C for indefinite long-term storage. Vitrified brains were rewarmed and the cryoprotectant removed either by perfusion or gradual diffusion from brain slices. We evaluated ASC-processed brains by electron microscopy of multiple regions across the whole brain and by Focused Ion Beam Milling and Scanning Electron Microscopy (FIB-SEM) imaging of selected brain volumes. Preservation was uniformly excellent: processes were easily traceable and synapses were crisp in both species. Aldehyde-stabilized cryopreservation has many advantages over other brain-banking techniques: chemicals are delivered via perfusion, which enables easy scaling to brains of any size; vitrification ensures that the ultrastructure of the brain will not degrade even over very long storage times; and the cryoprotectant can be removed, yielding a perfusable aldehyde-preserved brain which is suitable for a wide variety of brain assays.

Validation of microSecure vitrification (µS-VTF) for the effective cryopreservation of human embryos and oocytes.

A novel, aseptic closed system vitrification (VTF) technique for the cryopreservation of embryos and oocytes has been developed and clinically validated in this study. It combines the practicality of embryo-containing sterile flexipettes stored safely and securely with 0.3 ml CBS™ embryo straws possessing weld seals. The cooling and warming rates of this double container system were determined using a data logger. Upon direct plunging into LN(2), the flexipettes cool at an average rate of 1391°C/min, while warming occurs at an average rate of 6233°C/min in a 37°C 0.5 M sucrose bath. Direct deposition of the flexipette into a warming bath insured a rapid transition between -100 and -60°C to minimize potentially harmful recrystalization associated with devitrification. In conclusion, the µS-VTF system has exhibited higher (p<0.05) intact survival, implantation and live birth rates than conventional slow freezing methods. The effective embryo transfer of vitrified blastocysts proved similar to or better than fresh embryo transfer outcomes. The sustained clinical use of µS-VTF has justified a change in our infertility practice. Capsule: The microSecure vitrification (µS-VTF) procedure is a low-cost, non-commercial, aseptic, closed system that offers technical simplicity and repeatability, while effectively attaining an estimated 4:1 warming-to-cooling rate ratio, which supports excellent embryo survival and sustained viability.

Principles of cryopreservation by vitrification.

Vitrification is an alternative approach to cryopreservation that enables hydrated living cells to be cooled to cryogenic temperatures in the absence of ice. Vitrification simplifies and frequently improves cryopreservation because it eliminates mechanical injury from ice, eliminates the need to find optimal cooling and warming rates, eliminates the importance of differing optimal cooling and warming rates for cells in mixed cell type populations, eliminates the need to find a frequently imperfect compromise between solution effects injury and intracellular ice formation, and enables cooling to be rapid enough to "outrun" chilling injury, but it complicates the osmotic effects of adding and removing cryoprotective agents and introduces a greater risk of cryoprotectant toxicity during the addition and removal of cryoprotectants. Fortunately, a large number of remedies for the latter problem have been discovered over the past 30+ years, and the former problem can in most cases be eliminated or adequately controlled by careful attention to technique. Vitrification is therefore beginning to realize its potential for enabling the superior and convenient cryopreservation of most types of biological systems (including molecules, cells, tissues, organs, and even some whole organisms), and vitrification is even beginning to be recognized as a successful strategy of nature for surviving harsh environmental conditions. However, many investigators who employ vitrification or what they incorrectly imagine to be vitrification have only a rudimentary understanding of the basic principles of this relatively new and emerging approach to cryopreservation, and this often limits the practical results that can be achieved. A better understanding may therefore help to improve present results while pointing the way to new strategies that may be yet more successful in the future. To assist this understanding, this chapter describes the basic principles of vitrification and indicates the broad potential biological relevance of vitrification.

Cryopreservation of precision-cut tissue slices.

1.Cryopreservation of precision-cut tissue slices (PCTS) would have many advantages for drug development and would encourage more extensive use of the PCTS preparation. 2.Three methods have been studied to date: slow freezing, fast freezing, and vitrification. 3.Slow freezing can be very effective for some PCTS but is devastating to rat liver PCTS. Fast freezing can be successful for rat liver PCTS but is devastating to renal PCTS and has given inconsistent results even for rat liver PCTS. Vitrification has been effective for some slice systems but less effective for rat liver PCTS. Rat liver PCTS appear to be particularly difficult to cryopreserve well. 4.The general cryobiological principles of slow freezing, rapid freezing, and vitrification are reviewed. The empirical literature on the cryopreservation of PCTS has not taken sufficient account of these principles, and may, for example, include the effects of easily preventable osmotic injury. 5.More attention is needed to the effects of cryopreservation on specific cell types within PCTS and to the general integrity and viability of cryopreserved PCTS. Drug metabolism as a sole endpoint of study can be highly misleading. 6.Better application of cryobiological principles may enable improved results in the future.

Analysis of gene expression changes to elucidate the mechanism of chilling injury in precision-cut liver slices.

The exact mechanism of chilling injury (by a decrease of temperature to sub-physiological values), especially in the intact organ, is yet unknown. Precision-cut liver slices (PCLS), which closely resemble the organ from which they are derived, are an ideal in vitro model to study the mechanism of chilling injury in the intact organ. In the present study we were able to separate chilling injury from other damaging events such as cryoprotectant toxicity and ice-crystal injury and performed micro-array analysis of regulated genes. Pathway analysis revealed that different stress responses, lipid/fatty acid and cholesterol biosynthesis and metabolism were affected by chilling. This indicates that the cell-membrane might be the primary site and sensor for chilling, which may initiate and amplify downstream intracellular signaling events. Most importantly, we were able to identify gene expression responses from stellate cells and Kupffer cells suggesting the involvement of all liver cell types in the injury. In conclusion, a broad spectrum of previously unknown gene expression changes induced by chilling was identified in the tissue. This is the first report of a systematic investigation on the mechanism of chilling injury in integrated tissue by micro-array analysis under conditions in which other sources of injury are minimal.

Effects of cryoprotectant addition and washout methods on the viability of precision-cut liver slices.

Successful vitrification of organ slices is hampered by both osmotic stress and chemical toxicity of cryoprotective agents (CPAs). In the present study, we focused on the effect of osmotic stress on the viability of precision-cut liver slices (PCLS) by comparing different CPA solutions and different methods of loading and unloading the slices with the CPAs. For this purpose, we developed a gradient method to load and unload CPAs with the intention of minimizing sudden changes in osmolarity and thereby avoiding osmotic stress in the slices in comparison with the commonly used step-wise loading/unloading approach. With this gradient method, the CPA solution was introduced at a constant rate into a specially designed mixing chamber containing the slices. We showed that immediate mixing of the infused CPA and the chamber constituents occurred, which enabled us to control the CPA concentration to which PCLS were exposed as a function of time. With this method, CPA concentration versus time profiles were varied using various commercially available CPA mixtures [VMP, VM3, M22, and modified M22 (mM22)]. The viability of PCLS was determined after CPA loading and unloading and subsequent incubation during 3h at 37°C. Despite the reduction of osmotic stress, the viability of slices did not improve with gradual loading and unloading and remained considerably lower than that of untreated slices. The toxicity of the three CPA solutions did not correlate with either their potential osmotic effects or their total concentrations, and did not change strongly with exposure time in 100% CPA. The most likely explanation for these observations is that PCLS are not very sensitive to osmotic changes of the magnitude imposed in our study, and chemical toxicity of the CPA solutions is the main barrier to be overcome. The chemical toxicity of the CPAs used in this study probably originates from a source other than the total concentration of the solutions. The presented gradient method using the specially designed chamber is more time and cost effective than the step-wise method and can be universally applied to efficiently evaluate different CPA solutions.