Epithelial Alteration Associated With Recovery From Laryngeal Squamous Metaplasia in Rats: Kinetics of Recovery From a Test Item-Related Change.

Squamous metaplasia is a nonspecific adaptive response to chronic irritation in the larynx and is often diagnosed as a test item-related change in rat inhalation studies. Investigating scientists are frequently asked to assess the adversity of laryngeal squamous metaplasia and to interpret its relevance to human risk. One factor in predicting relevance to human risk is the kinetics (degree and speed) of recovery following the cessation of exposure to the test item. Most reports describing recovery from squamous metaplasia in the rat larynx discuss the more severe end of the spectrum of metaplastic change (moderate to severe) and include relatively long (6 weeks or more) recovery periods. We conducted 2 studies to evaluate the toxicity and recovery from any potential effects of 4-(Chloro-2-methylphenoxy) butyric (MCPB) acid, a herbicide, when administered by inhalation to young male Sprague Dawley rats for 3 to 4 weeks. The studies resulted in minimal to moderate laryngeal squamous metaplasia for which we describe the kinetics of recovery over 1 to 4 weeks. We found that the microscopic change epithelial alteration, which is normally considered to be a precursor in the development of squamous metaplasia, can occur as a transitional stage between squamous and normal epithelium during recovery.

Health assessment of gasoline and fuel oxygenate vapors: subchronic inhalation toxicity.

Sprague Dawley rats were exposed via inhalation to vapor condensates of either gasoline or gasoline combined with various fuel oxygenates to assess whether their use in gasoline influences the hazard of evaporative emissions. Test substances included vapor condensates prepared from an EPA described "baseline gasoline" (BGVC), or gasoline combined with methyl tertiary butyl ether (G/MTBE), ethyl t-butyl ether (G/ETBE), t-amyl methyl ether (G/TAME), diisopropyl ether (G/DIPE), ethanol (G/EtOH), or t-butyl alcohol (G/TBA). Target concentrations were 0, 2000, 10,000 or 20,000mg/m(3) and exposures were for 6h/day, 5days/week for 13weeks. A portion of the animals were maintained for a four week recovery period to determine the reversibility of potential adverse effects. Increased kidney weight and light hydrocarbon nephropathy (LHN) were observed in treated male rats in all studies which were reversible or nearly reversible after 4weeks recovery. LHN is unique to male rats and is not relevant to human toxicity. The no observed effect level (NOAEL) in all studies was 10,000mg/m(3), except for G/MTBE (<2000) and G/TBA (2000). The results provide evidence that use of the studied oxygenates are unlikely to increase the hazard of evaporative emissions during refueling, compared to those from gasoline alone.

Health assessment of gasoline and fuel oxygenate vapors: micronucleus and sister chromatid exchange evaluations.

Micronucleus and sister chromatid exchange (SCE) tests were performed for vapor condensate of baseline gasoline (BGVC), or gasoline with oxygenates, methyl tert-butyl ether (G/MTBE), ethyl tert butyl ether (G/ETBE), t-amyl methyl ether (G/TAME), diisopropyl ether (G/DIPE), t-butyl alcohol (TBA), or ethanol (G/EtOH). Sprague Dawley rats (the same 5/sex/group for both endpoints) were exposed to 0, 2000, 10,000, or 20,000mg/m(3) of each condensate, 6h/day, 5days/week over 4weeks. Positive controls (5/sex/test) were given cyclophosphamide IP, 24h prior to sacrifice at 5mg/kg (SCE test) and 40mg/kg (micronucleus test). Blood was collected from the abdominal aorta for the SCE test and femurs removed for the micronucleus test. Blood cell cultures were treated with 5µg/ml bromodeoxyuridine (BrdU) for SCE evaluation. No significant increases in micronucleated immature erythrocytes were observed for any test material. Statistically significant increases in SCE were observed in rats given BGVC alone or in female rats given G/MTBE. G/TAME induced increased SCE in both sexes at the highest dose only. Although DNA perturbation was observed for several samples, DNA damage was not expressed as increased micronuclei in bone marrow cells. Inclusion of oxygenates in gasoline did not increase the effects of gasoline alone or produce a cytogenetic hazard.

The toxicological properties of petroleum gases.

To characterize the toxicological hazards of petroleum gases, 90-day inhalation toxicity (Organization for Economic Cooperation and Development [OECD] 413) and developmental toxicity (OECD 414) tests were conducted with liquefied propane gas (LPG) at concentrations of 1000, 5000, or 10,000 ppm. A micronucleus test (OECD 474) of LPG was also conducted. No systemic or developmental effects were observed; the overall no observed adverse effect concentration (NOAEC) was 10,000 ppm. Further, there was no effect of LPG exposure at levels up to 10,000 ppm on micronucleus induction and no evidence of bone marrow toxicity. Other alkane gases (ethane, propane, n-butane, and isobutane) were then evaluated in combined repeated exposure studies with reproduction/development toxicity screening tests (OECD 422). There were no toxicologically important changes in parameters relating to systemic toxicity or neurotoxicity for any of these gases at concentrations ranging from 9000 to 16,000 ppm. There was no evidence of effects on developmental or reproductive toxicity in the studies of ethane, propane, or n-butane at the highest concentrations tested. However, there was a reduction in mating in the high-exposure group (9000 ppm) of the isobutane study, which although not significantly different was outside the range previously observed in the testing laboratory. Assuming the reduction in mating to have been toxicologically significant, the NOAEC for the isobutane reproductive toxicity screening test was 3000 ppm (7125 mg/m(3)). A method is proposed by which the toxicity of any of the 106 complex petroleum gas streams can be estimated from its composition.

Toxicological assessment of green petroleum coke.

Green petroleum coke is primarily inorganic carbon with some entrained volatile hydrocarbon material. As part of the petroleum industry response to the high production volume challenge program, the potential for reproductive effects was assessed in a subchronic toxicity/reproductive toxicity screening test in rats (OECD 421). The repeated-dose portion of the study provided evidence for dust accumulation and inflammatory responses in rats exposed to 100 and 300 mg/m(3) but there were no effects at 30 mg/m(3). In the reproductive toxicity screen, the frequency of successful matings was reduced in the high exposure group (300 mg/m(3)) and was not significantly different from control values but was outside the historical experience of the laboratory. The postnatal observations (external macroscopic examination, body weight, and survival) did not indicate any treatment-related differences. Additional tests conducted to assess the potential hazards to aquatic (fish, invertebrates, and algae) and soil dwelling organisms (earthworms and vascular plants) showed few effects at the maximum loading rates of 1000 mg coke/L in aquatic studies and 1000 mg coke/kg soil in terrestrial studies. The only statistically significant finding was an inhibition of algal growth measured as either biomass or growth rate.

The acute, genetic, developmental and inhalation toxicology of trans-1-chloro,3,3,3-trifluoropropene (HCFO-1233zd(E)).

Trans-1-chloro,3,3,3-trifluoropropene (HCFO-1233zd(E)) is being developed as a foam blowing agent, refrigerant and solvent because it has a very low global warming potential (<10), as contrasted to the hydrofluorocarbons (>500). The toxicology profile is described. The acute 4-hour 50% lethal concentration value in rats receiving HCFO-1233zd(E) was 120 000 ppm. The no observed effect level (NOEL) in cardiac sensitization studies in dogs was 25 000 ppm. In a 2-week range-finding study, rats were exposed to HCFO-1233zd(E) at levels of 0, 2000, 7500 and 20 000 ppm 6 hours/day for 5 days/week. Histopathological changes in the heart described as multifocal mononuclear infiltrates were observed in males (mid- and high-exposure group) and females (high-exposure group), suggesting this organ was the target for HCFO-1233zd(E) toxicity. In a 4-week study, rats were exposed to 0, 2000, 4500, 7500 and 10 000 ppm. The only finding was an increase in potassium (mid- and high-exposure males). No increase was observed after a 2-week recovery period, nor in a subsequent 13-week toxicity study. In a 13-week study, rats were exposed to 4000, 10 000 and 15 000 ppm 6 hours/day for 5 days/week. Findings consisted of multifocal mononuclear cell infiltrates in the heart with a NOEL/lowest observed adverse effect level of 4000 ppm. No genetic toxicity was observed in a battery of genetic toxicity studies. In a rat prenatal developmental toxicity study, dilated bladders were observed in the high-exposure group fetuses (15 000 ppm), a finding of unclear significance. HCFO-1233zd(E) was not a developmental toxin in rabbits, even at exposure levels up to 15 000 ppm.

The acute, genetic, developmental and inhalation toxicology of trans-1,3,3,3-tetrafluoropropene (HFO-1234ze).

HFO-1234ze is being developed as a refrigerant, propellant, and foam-blowing agent because it has a very low global warming potential (less than 10), as contrasted to the hydrofluorocarbons with values of over 500. Several toxicology studies were conducted to develop a toxicology profile for this material. There was no lethality in mice and rats receiving single 4-hour exposures up to 103,300 or 207,000 ppm, respectively. Exposures up to 120,000 ppm did not induce cardiac sensitization to adrenalin. Rats were exposed to HFO-1234ze at levels of 5,000, 20,000, and 50,000 ppm 6 hours/day 5 days/week for 2 weeks. Predominate findings of increased liver and kidney weights and histopathological changes in the liver and heart suggested that these organs were the targets for HFO-1234ze toxicity. In a 4-week study at 1000, 5000, 10,000, and 15,000 ppm, the only organ showing treatment-related effects was the heart. In a 90-day study with exposures of 1500, 5000, and 15,000 ppm 6 hours/day 5 days/week, again, the heart was the only target organ. The findings consisted of focal and multifocal mononuclear cell infiltrates in the heart. There was no evidence of fibrosis, and, when compared to the 2- and 4-week studies, there did not appear to be an increase in severity with length of exposure. HFO-1234ze was inactive in a mouse and rat micronucleus assay, an Ames assay, and an unscheduled DNA synthesis assay and was not clastogenic in human lymphocytes. It was also not a developmental toxin in either the rat or rabbit, even at exposure levels up to15,000 ppm.

Biotransformation of 2,3,3,3-tetrafluoropropene (HFO-1234yf) in male, pregnant and non-pregnant female rabbits after single high dose inhalation exposure.

2,3,3,3-Tetrafluoropropene (HFO-1234yf) is a novel refrigerant intended for use in mobile air conditioning. It showed a low potential for toxicity in rodents studies with most NOAELs well above 10,000 ppm in guideline compliant toxicity studies. However, a developmental toxicity study in rabbits showed mortality at exposure levels of 5,500 ppm and above. No lethality was observed at exposure levels of 2,500 and 4,000 ppm. Nevertheless, increased subacute inflammatory heart lesions were observed in rabbits at all exposure levels. Since the lethality in pregnant animals may be due to altered biotransformation of HFO-1234yf and to evaluate the potential risk to pregnant women facing a car crash, this study compared the acute toxicity and biotransformation of HFO-1234yf in male, female and pregnant female rabbits. Animals were exposed to 50,000 ppm and 100,000 ppm for 1h. For metabolite identification by (19)F NMR and LC/MS-MS, urine was collected for 48 h after inhalation exposure. In all samples, the predominant metabolites were S-(3,3,3-trifluoro-2-hydroxypropanyl)-mercaptolactic acid and N-acetyl-S-(3,3,3-trifluoro-2-hydroxypropanyl)-L-cysteine. Since no major differences in urinary metabolite pattern were observed between the groups, only N-acetyl-S-(3,3,3-trifluoro-2-hydroxypropanyl)-L-cysteine excretion was quantified. No significant differences in recovery between non-pregnant (43.10 ± 22.35 µmol) and pregnant female (50.47 ± 19.72 µmol) rabbits were observed, male rabbits exposed to 100,000 ppm for one hour excreted 86.40 ± 38.87 µmol. Lethality and clinical signs of toxicity were not observed in any group. The results suggest that the lethality of HFO-1234yf in pregnant rabbits unlikely is due to changes in biotransformation patterns or capacity in pregnant rabbits.

A 13-week nose-only inhalation toxicity study for perfluoro-n-butyl iodide (PFBI) in rats with recommended occupational exposure levels.

A 13-week study was conducted to develop occupational exposure limits (OELs) for the solvent perfluoro-n-butyl iodide (PFBI). Fischer 344 rats (15 males & 10 females per group) were exposed for 6 h/day to 0 (air control), 500, 1500, or 5000 ppm PFBI vapor for 5 days/week for 13 consecutive weeks (at least 65 exposures) followed by a 4-week recovery period. Clinical observations, body weights, clinical pathology, organ weights, and histopathology as well as detailed evaluations of neurotoxicity and thyroid function parameters were conducted at the end of the treatment period for up to 10 animals/sex/group with 5 males/group held for a 4-week recovery period. Findings in the thyroid target tissue consisted of a minimal thyroid follicular cell hypertrophy occasionally accompanied by hyperplasia, but without an increase in thyroid weight in the 500, 1500, and 5000 ppm males. At > or = 500 ppm, there was also increased thyroid stimulating hormone in females and increased T(3) and T(4) in animals of both sexes. These effects resolved following a 4-week recovery period in the males evaluated. Minor clinical pathology variations in all PFBI exposure groups were not considered biologically significant. A 9.4% reduction in absolute body weight in the 5000 ppm males was observed. Dosimetric adjustments for daily exposure time and uncertainty factors were selected to provide a basis for the proposed OELs. For acute (single event) exposures, a ceiling OEL of 3900 ppm, and for repeated exposures, an 8-h time-weighted average of 40 ppm PFBI were proposed.