At present, whole grains are usually obtained by adding bran and middlings to refined flours, and this recombination leads to certain variations in the ratio of endosperm, bran and germ, resulting in flours with very different compositional characteristics and rheological properties. Therefore, this study focuses on the identification of specific lipid markers in different debranning fractions of Italian and Canadian durum wheat blends. The by-products obtained from five different debranning levels (3, 6, 9, 12 and 15%) had a high content of monounsaturated fatty acids and a higher concentration of tocopherols and sterols than the corresponding debranned grains. The Italian and Canadian durum wheat samples did not show significant differences in the content of these bioactive lipid compounds. In particular, palmitic acid, oleic acid, tocopherol isomers and total sterols could be useful biomarkers for evaluating the grain-to-tissue ratio in recombined flours.
Durum wheat debranning fractions (fine and coarse bran) were obtained and included as an ingredient in the formulation of whole-meal spaghetti to study their chemical-nutritional characteristics, in particular folate levels and sensorial properties. Experimental raw pasta had a higher folate content (40.5 µg/100 g) than commercial whole-meal pasta (28.3 µg/100 g), meeting the requirements for the health claim on folate (Reg. EU 432/2012) and for the nutritional claim on dietary fiber. After cooking, folate retention in pasta formulated with coarse bran was 80% and scored an overall "good" sensorial acceptability. Results indicate that whole-meal pasta formulated with folate-rich debranning fractions may represent a natural functional food that, integrated into the diet, could improve the health status of the population.
Evaluating the nutritional quality and thermal damage effects of gluten-free foods is essential to ensure that people with gluten intolerance or celiac disease can safely meet their needs. In this work, fifteen different commercial gluten-free pasta samples made from cereals, pseudocereals, and pulses, alone or in mixed combinations, were analyzed to assess their nutritional value, essential amino acids composition, and protein chemical score. The occurrence of the Maillard reaction was investigated, and the levels of heat treatment markers (furosine, maltulose, hydroxymethylfurfural, and glucosylisomaltol) were determined. Analysis of the furosine values showed that pasta made with the same raw materials can have different degrees of thermal damage. There was no evidence of the Maillard reaction progressing in the advanced phase in any of the samples tested. Finally, the correlation between maltulose and furosine levels demonstrated the usefulness of combining the two markers to assess the extent of thermal damage.
Both Glycaemic index (GI) and Glycaemic Load (GL) were introduced to measure the impact of a carbohydrate-containing food on blood glucose. From this perspective, high-amylose (HA) flours, with a higher percentage of resistant starch (RS), may represent a suitable raw material to improve the glycaemic response. The present work aims to investigate the GI of HA bakery products (biscuits, taralli and bread) compared to products obtained from conventional flour. Ten healthy volunteers were enrolled and their capillary blood glucose was measured every 15 min for 2 h after the consumption of HA and control products containing 50 g of available carbohydrates. On average, in the three bakery products, the amount of total starch replaced by RS was equal to 12%. HA biscuits and HA bread showed significantly lower GI than their control counterparts (p = 0.0116 and p = 0.011, respectively) and better glycaemic control. From the survey to assess liking and willingness to pay on HA snacks, HA packages received an average premium of 0.66 compared to control products. Although HA flour results in lower GI in both biscuits and bread, further studies are needed to evaluate the correct composition of HA products to have beneficial effects on post-prandial glycaemia.
Folate is a fundamental vitamin for human health in prevention of many diseases; however, unfortunately its deficiency is widespread, so a greater availability of folate rich foods is desirable. The aim of this study was to design new cereal products naturally enriched in folate using barley flour from pearling as ingredient. Folate content of unfortified and fortified commercial grain-based products was considered to identify the best ingredients for new formulation and for folate content comparisons. Nineteen Italian barley cultivars were evaluated for their folate content and Natura was chosen for its highest folate levels = 69.3 µg/100 g f.w. Application of pearling gave a by-product flour with a high folate level: 221.7 ± 7.0 µg/100 g; this flour was employed to design pasta and biscuits naturally enriched in folate: 87.1 µg/100 g and 70.1 ± 3.7 µg/100 g f.w., respectively. Folate content of new products is higher than commercial samples: 39.2 µg/100 g in refined pasta, 60.4 µg/100 g in wholemeal pasta, 62.1 µg/100 g in fortified biscuits and 10.4 µg/100 g in unfortified ones. Enriched pasta had higher folate retention (68.5%) after cooking compared to the fortified one (27.8%). This research shows promising results concerning the pearling technique to design new cereal products naturally enriched in folates.
Edible Grain , Hordeum , Flour/analysis , Folic Acid , Food, Fortified/analysis , Humans , Triticum , Vitamins
Brewer's spent grains are one of the principal by-products of the brewing industry. For protein and fibre content, this by-product represents an interesting raw material to be reused for manufacturing many other products. To maximize the nutritional characteristics of this by-product, in this study, ingredients derived from brewer's spent grains were included in the design of innovative dry pasta. Two brewer's spent grains derivative ingredients, one enriched in proteins and the other in fibre were blended with semolina. Based on the rheological evaluation, the optimal amount of the two ingredients for producing pasta was determined. In particular, pasta responding to the claims "High Protein" and "High Fibre" was realized using the formulation enriched with 15% of protein-rich ingredient and the claim "High Fibre" and "Source of proteins" using the formulation enriched with 10% of fibre-rich ingredient. The final products were compared to 100% semolina and 100% wholegrain semolina pasta for composition, color, texture, and cooking quality, revealing excellent quality characteristics. The newly formulated pasta represents a successful match of technological aptitude, nutritional/sensorial quality, and sustainability.
In this study, the evolution of the safety, nutritional, and volatile profile of a traditional Italian anchovy sauce with protected designation of origin (PDO), called "colatura di alici di Cetara", is investigated after 12, 24, and 48 months of aging in wooden barrels. Some physicochemical parameters, free amino acids, volatile compounds, and histamine contents were evaluated during the aging of the samples. Glutamate, which together with aspartate is responsible for the umami taste, was the predominant free amino acid in the tested fish sauce, with a significant increase during the 48 months of maturation. The total amino acid content of the anchovy sauce increased from 24 to 48 months of aging. The histamine content decreased significantly from 12 to 48 months of ripening. This point is particularly interesting for the sauce safety and confirms the importance of the maturation time of at least 9 months reported in the disciplinary of production. A total of 44 volatile compounds were found in the anchovy sauce samples, of which the largest class was acids, mainly isovaleric acid. The results show that prolonged maturation improves the safety, nutritional, and volatile components of the seasoning "colatura di alici".
Pasta has an important role in human nutrition for its high content of complex carbohydrates and its widespread use. It can be an efficient delivery system or carrier of non-traditional raw material, including additional health-promoting ingredients. The partial replacement of semolina with high-protein raw materials leads to the improvement of the biological value of pasta proteins. In order to obtain pasta with high nutritional protein value and with excellent cooking properties, various recipes have been formulated with different percentages of semolina and unconventional high-protein raw materials (peas and soy isolate proteins, egg white, whey proteins and Spirulina platensis). High-protein pasta was produced using a pasta making pilot plant and the nutritional quality (protein content and quality) and sensorial properties were assessed. All experimental pastas showed optimal performances. Pasta prepared with pea protein isolate, whey proteins and Spirulina platensis showed improved chemical score and digestible indispensable amino acid scores, an eye-catching color, and an excellent cooking quality.
Dysphagia that involves difficulty swallowing food and liquids is a symptom of different diseases. In some cases, patients who experience this symptom should be fed with modified consistency foods. Dysphagia is often accompanied by malnutrition and dehydration and an interesting approach to dealing with these conditions is to provide patients with nutrient-rich foods. In this study, two new food formulations for dysphagia patients are proposed: a cereal-based protein meal and a vegetable cream. The nutritional and rheological characteristics of the two innovative preparations were assessed and compared with those of commercial products. The proposed protein meal formulations meet the criteria for the "high protein" claim and the vegetable cream meets those of the "source of fiber" claim. The rheological investigation revealed that the flow properties of the innovative formulations were comparable to those of the commercial ones. Based on these preliminary outcomes, this investigation represents an interesting perspective potentially valuable to enlarge the offer of possibilities for people suffering from swallowing disorders.
Several companies have focused their attention on the development of technologies able to enrich/isolate the wheat aleuronic layer because it is a source of bioactive compounds. In this work two different wheat bran fractions enriched in aleurone (AF1, 55-70% aleurone and AF2, 75-90% aleurone) were obtained by a dry fractionation based on air classification. Free and bound phenolic compounds, and alkylresorcinols were determined in the two fractions by HPLC-DAD-ESI-TOF-MS and GC-MS, respectively. To our knowledge, feruloyl di-hexoside was described for the first time in wheat aleurone and flavonoids were quantified for the first time in this fraction. The results have shown that the most concentrated free phenolic compounds were flavonoids, and AF1 was the fraction that presented the highest flavonoid content; whereas trans ferulic acid was the most abundant bound phenolic acid, which highest content was obtained in AF2. Besides, total content of ferulic acid monomers in AF2 was 33.63% higher than in AF1, whereas total content of ferulic acid dimers/trimers in AF1 was 33.9% higher than in AF2. The highest content of alkylresorcinols was obtained in AF1 and it was 10.30% higher than the obtained in AF2. Therefore, it can be stated that this green technology could be used to produce enriched aleurone fractions as source of phenolic and alkylresorcinol compounds. These fractions could be of great interest for the formulation of enriched foods.
Phenols , Plant Proteins , Chromatography, High Pressure Liquid , Dietary Fiber/analysis , Phenols/analysis
Egg products are one of the main ingredients used in bakery industries, and they contain cholesterol. Cholesterol suffers several chemical changes during the food processes, allowing some potentially toxic compounds called cholesterol oxidized products (COPs). Thus, the aim of this work was to study the evolution of lipid oxidation from eggs to egg products, and to evaluate the influence of egg products on COPs formation in biscuits formulated with them. The results confirmed that spray-drying technology improves the cholesterol oxidation 2.6 times compared to pasteurized eggs. Biscuit samples showed a COPs content that is strictly related to the egg products used. Samples formulated with spray-dried eggs noticed lower amounts of COPs compared to those formulated with pasteurized eggs. It is important to stress that COPs composition was different between the two samples, underlining that the kinetic of COPs formation is dependent on the type of egg products.
The aim of this study was to evaluate the content of free and bound phenols and alkylresorcinols in functional couscous enriched with barley coarse fraction obtained by air classification. Two different levels of enriched barley flour (20 and 30%) were used for the formulation of couscous and they were compared with a control couscous made with 100% of semolina. HPLC-ESI-TOF-MS was used to determine the phenolic composition in couscous samples. Total free phenolic compounds content in control couscous was 182 µg/100 g d.m. This amount increases significantly when coarse barley flour is added reaching value of 2273 µg/100 g d.m. and 2978 µg/100 g d.m. when 20 and 30% of barley coarse fraction was used, respectively. Moreover, the main free phenolic compounds in enriched barley samples are represented by flavan-3-ols. Bound phenols ranged from 5242 µg/100 g d.m. for control couscous to 27,092 µg/100 g d.m. for couscous with 30% of barley coarse fraction with a strong prevalence of phenolic acids. Finally, regarding alkylresorcinol compounds, they ranged from 1.01 mg/g d.m. for control couscous to 2.46 mg/g d.m. for couscous with 30% of barley coarse fraction. In conclusion, on the basis of obtained results, barley coarse fraction can be considered a good ingredient to develop functional couscous naturally enriched of phenolic compounds and alkylresorcinols.
Functional Food/analysis , Hordeum/chemistry , Phenols/chemistry , Phytochemicals/chemistry , Resorcinols/chemistry , Chromatography, High Pressure Liquid , Mass Spectrometry
Buckwheat is a rich source of phenolic compounds that have shown to possess beneficial effect to reduce some diseases due to their antioxidant power. Phenolic compounds are present in the free and in the bound form to the cell wall that are concentrated mainly in the outer layer (hull and bran). Hull is removed before the milling of buckwheat to obtain flours. In order to evaluate the phenolic composition in dehulled buckwheat milling fractions, it was carried out a determination of free and bound phenolic compounds in dehulled whole buckwheat flour, light flour, bran flour, and middling flour by high-performance liquid chromatography-mass spectrometry (HPLC-MS). The most abundant free phenolic compounds were rutin and epiafzelchin-epicatechin-O-dimethylgallate, whereas the most abundant bound phenolic compounds were catechin and epicatechin in all buckwheat flours. Besides, the highest content of free phenolic compounds was obtained in bran flour (1249.49 mg/kg d.w.), whereas the greatest bound phenolic content was in middling (704.47 mg/kg d.w.) and bran flours (689.81 mg/kg d.w.). Thus, middling and bran flours are naturally enriched flours in phenolic compounds that could be used to develop functional foods.
Fractionation processes based on physical separation are a good strategy to produce enriched cereal flours. Therefore, the aim of this work is to evaluate the suitability of sieving of buckwheat flours to produce protein and phenolic (especially rutin) enriched fractions. Because of that, dehulled whole buckwheat flour (GSTQ) was sieved obtaining fractions with a particle size of 215 µm, 160 µm, 85 µm, and 45 µm (GS215, GS160, GS85, and GS45). For that purpose, the determination of protein, ash, and total starch content and free and bound phenolic compounds was carried out. The highest content of total phenolic compounds was obtained in GS215 (3118.84 mg Kg-1 d.w.), followed by GS160 (2499.11 mg Kg-1 d.w.), GS85 (989.46 mg Kg-1 d.w.), GSTQ (983.15 mg Kg-1 d.w.), and GS45 (481.31 mg Kg-1 d.w.). Therefore, the phenolic content decreased with the particle size decrease from 215 µm to 45 µm. Besides, there were no significant differences between the total phenolic content in GS85 and GSTQ. The fraction with 215 µm reported the highest protein and mineral salt content and presented rutin amounts four times higher than GSTQ.
The potential of heterogeneous systems like oil-in-water (O/W) nanoemulsions is exploited as an oral delivery system for curcumin, a natural lipophilic compound with numerous health benefits. Two types of O/W nanoemulsions, one stabilized by sodium caseinate (Cas-O/W), a surface-active and emulsifying protein, and the other stabilized by a blend of caseinate and Tween 20 (Mix-O/W), were loaded with the bioactive compound and tested through a simulated gastrointestinal digestion process to evaluate their effects on delivering of curcumin. It was first demonstrated that the amount of curcumin solubilized through Mix-O/W nanoemulsion was higher than that in Cas-O/W nanoemulsion. Cas-O/W nanoemulsions, indeed, at their best, solubilized about 55 µg/mL of curcumin while Mix-O/W nanoemulsions reached a curcumin concentration around 180 µg/mL. Furthermore, for both the systems an increase of curcumin loading capacity was recorded with the rise of incubation temperature. Finally, after the in vitro simulated digestion process, the potential curcumin bioavailability was evaluated and the data suggested that Mix-O/W nanoemulsions provided more than twice the amount of curcumin compared to Cas-O/W nanoemulsions. On balance, the outcomes of this investigation demonstrated that the mixed emulsifier system offered a higher amount of lipophilic compound with a low fat intake compared to nanoemulsions stabilized by sodium caseinate. PRACTICAL APPLICATION: The outcomes of this study allow the recognition of the protein/surfactant-stabilized nanoemulsions as a suitable solution to deliver curcumin. The nanoemulsions proposed here provide a high intake of curcumin, a lipophilic compound, with low fat content. The use of such delivery systems helps to overcome limits in oral bioavailability related with the scarce solubility of some compounds in food preparations and beverages.
Caseins/chemistry , Curcumin , Emulsions/chemistry , Nanoparticles/chemistry , Surface-Active Agents/chemistry , Biological Availability , Curcumin/chemistry , Curcumin/pharmacokinetics , Digestion/physiology , Models, Biological , Polysorbates/chemistry
Deoxynivalenol (DON) is an important mycotoxin produced by several species of Fusarium. It occurs often in wheat grain and is frequently associated with significant levels of its modified form DON-3-glucoside (DON-3-Glc). Ozone (O3) is a powerful disinfectant and oxidant, classified as GRAS (Generally Recognised As Safe), that reacts easily with specific compounds including the mycotoxins aflatoxins, ochratoxin A, trichothecenes and zearalenone. It degrades DON in aqueous solution and can be effective for decontamination of grain. This study reports the efficacy of gaseous ozone treatments in reducing DON, DON-3-Glc, bacteria, fungi and yeasts in naturally contaminated durum wheat. A prototype was used to dispense ozone continuously and homogeneously at different concentrations and exposure time, in 2 kg aliquots of durum wheat. The optimal conditions, which do not affect chemical and rheological parameters of durum wheat, semolina and pasta, were identified (55 g O3 h-1 for 6 h). The measured mean reductions of DON and DON-3-Glc in ozonated wheat were 29% and 44%, respectively. Ozonation also produced a significant (p < 0.05) reduction of total count (CFU/g) of bacteria, fungi and yeasts in wheat grains.
Flour/microbiology , Food Analysis , Food Contamination/analysis , Food Microbiology , Ozone/chemistry , Trichothecenes/analysis , Triticum/chemistry , Triticum/microbiology , Flour/analysis
In this work, an effective and simple approach for vinegar production from olive oil press-mill wastewaters (OMW) is presented. Effects of sterilization and yeast presence on the acetic acid production were investigated. Sugar addition and inoculum of selected yeast starter have been crucial for a satisfactory acidification. In the obtained olive vinegar, the pH and total acidity were 2.92 and 5.6%, respectively. A considerable high level of ash (2%) and total phenols (3600mg/L as GAE) characterized olive vinegar, in comparison with samples of apple, wine and balsamic commercial vinegars. Moreover, a high presence of hydroxytyrosol (1019mg/L) was obtained. This abundant presence of antioxidants makes olive vinegar a promising nutraceutical and environmentally-friendly product, based upon a waste material such as OMW.
Acetic Acid/analysis , Olea , Industrial Waste , Olive Oil , Phenols , Wastewater
Phenolic acids, total phenolics content and DPPH radical scavenging capacity in raw ingredients, fresh and dried spaghetti, and in uncooked and cooked spaghetti were evaluated and compared with semolina spaghetti as a reference. Ferulic acid was the major phenolic acid found in the free and bound phenolic extracts in all the investigated pasta samples. The addition of barley flour into pasta at incorporation levels of 30, 50 and 100% increased phenolic acids and total phenolics content. Pasta processing did not significantly affect the total phenolics content and free radical scavenging capacity, but a significant reduction in total phenolic acids measured by HPLC was found. Drying process differently affected individual phenolic compounds in the free and bound fractions, and thus, the total phenolic acids content. Free vanillic, caffeic and p-coumaric acids did not significantly change, while p-hydroxybenzoic and ferulic acids of the free extracts showed higher values compared to the corresponding fresh pasta. Cooking did not greatly affect total phenolic acids, more leading to conserving free and bound phenolic compounds.
Food Handling/methods , Free Radical Scavengers/analysis , Functional Food/analysis , Hordeum/chemistry , Hydroxybenzoates/analysis , Biphenyl Compounds/chemistry , Cooking , Free Radical Scavengers/pharmacology , Hot Temperature , Hydroxybenzoates/pharmacology , Picrates/chemistry
OBJECTIVE: Cochlear implants (CIs) have become the gold standard treatment for deafness. These neuroprosthetic devices feature a linear electrode array, surgically inserted into the cochlea, and function by directly stimulating the auditory neurons located within the spiral ganglion, bypassing lost or not-functioning hair cells. Despite their success, some limitations still remain, including poor frequency resolution and high-energy consumption. In both cases, the anatomical gap between the electrode array and the spiral ganglion neurons (SGNs) is believed to be an important limiting factor. The final goal of the study is to characterize response profiles of SGNs growing in intimate contact with an electrode array, in view of designing novel CI devices and stimulation protocols, featuring a gapless interface with auditory neurons. APPROACH: We have characterized SGN responses to extracellular stimulation using multi-electrode arrays (MEAs). This setup allows, in our view, to optimize in vitro many of the limiting interface aspects between CIs and SGNs. MAIN RESULTS: Early postnatal mouse SGN explants were analyzed after 6-18 days in culture. Different stimulation protocols were compared with the aim to lower the stimulation threshold and the energy needed to elicit a response. In the best case, a four-fold reduction of the energy was obtained by lengthening the biphasic stimulus from 40 µs to 160 µs. Similarly, quasi monophasic pulses were more effective than biphasic pulses and the insertion of an interphase gap moderately improved efficiency. Finally, the stimulation with an external electrode mounted on a micromanipulator showed that the energy needed to elicit a response could be reduced by a factor of five with decreasing its distance from 40 µm to 0 µm from the auditory neurons. SIGNIFICANCE: This study is the first to show electrical activity of SGNs on MEAs. Our findings may help to improve stimulation by and to reduce energy consumption of CIs and thereby contribute to the development of fully implantable devices with better auditory resolution in the future.
Action Potentials/physiology , Cochlear Implants , Microarray Analysis/instrumentation , Microelectrodes , Spiral Ganglion/cytology , Spiral Ganglion/physiology , Animals , Electric Stimulation Therapy/instrumentation , Equipment Design , Equipment Failure Analysis , Mice , Mice, Inbred C57BL , Reproducibility of Results , Sensitivity and Specificity
Proanthocyanidins are a class of polyphenols present in many foodstuffs (i.e., tea, cocoa, berries, etc.) that may reduce the risk of several chronic diseases. Barley, with sorghum, rice, and wheat, are the only cereals that contain these compounds. Because of that, two barley genotypes, named waxy and non-waxy, were analyzed by normal-phase high-performance liquid chromatography-fluorescence detection-mass spectrometry (NP-HPLC-FLD-MS). Total proanthocyanidin content ranged between 293.2 and 652.6 µg/g of flour. Waxy samples reported the highest content (p < 0.05) of proanthocyanidins. Dimer compounds were the principal proanthocyanidin constituents of barley samples. Moreover, the possibility to use near-infrared (NIR) spectroscopy as a rapid method to discriminate between waxy and non-waxy samples and to predict quantitatively proanthocyanidins in barley samples was evaluated. Partial least squares (PLS) models were built to predict the proanthocyanidin constituent, obtaining determination coefficients (R(2)) ranging from 0.92 to 0.97, in test set validation. Because of that, this study highlights that NIR spectroscopy technology with multivariate calibration analysis could be successfully applied as a rapid method to determine proanthocyanidin content in barley.
Chromatography, High Pressure Liquid/methods , Hordeum/chemistry , Mass Spectrometry/methods , Plant Extracts/chemistry , Proanthocyanidins/chemistry , Spectroscopy, Near-Infrared/methods , Genotype , Hordeum/classification , Hordeum/genetics
