Plasmin and coagulant activities in a minicurd model system: Study of technological parameters.

The effect of scalding temperature of the curd, the inclusion of a washing step, and the pH at whey drainage on plasmin and coagulant activities were assessed in a minicurd model of young hard cooked cheese. The variables were tested as follows: draining pH was assayed at 3 levels (4.6, 5.6, and 6.4), curd scalding temperature was tested at 50 and 56°C, and washing of the curd was examined at 2 levels (no washing step, and the replacement of the whey by water). Increase in pH at whey drainage and washing of the curd had a positive effect on plasmin activity, which was also evidenced by compatible changes in soluble peptide profiles. No effect of increased cooking temperature was found on plasmin activity. Plasminogen activation was not verified in any treatment. As for coagulant, lower pH values at whey drainage and a decrease in curd cooking temperature increased its activity; washing of the curd showed no influence on coagulant residual activity. These results were consistent with proteolysis described by peptide profiles, electrophoresis, and soluble nitrogen fractions.

Growth, survival, and peptidolytic activity of Lactobacillus plantarum I91 in a hard-cheese model.

In this work, we studied the growth, survival, and peptidolytic activity of Lactobacillus plantarum I91 in a hard-cheese model consisting of a sterile extract of Reggianito cheese. To assess the influence of the primary starter and initial proteolysis level on these parameters, we prepared the extracts with cheeses that were produced using 2 different starter strains of Lactobacillus helveticus 138 or 209 (Lh138 or Lh209) at 3 ripening times: 3, 90, and 180 d. The experimental extracts were inoculated with Lb. plantarum I91; the control extracts were not inoculated and the blank extracts were heat-treated to inactivate enzymes and were not inoculated. All extracts were incubated at 34°C for 21 d, and then the pH, microbiological counts, and proteolysis profiles were determined. The basal proteolysis profiles in the extracts of young cheeses made with either strain tested were similar, but many differences between the proteolysis profiles of the extracts of the Lh138 and Lh209 cheeses were found when riper cheeses were used. The pH values in the blank and control extracts did not change, and no microbial growth was detected. In contrast, the pH value in experimental extracts decreased, and this decrease was more pronounced in extracts obtained from either of the young cheeses and from the Lh209 cheese at any stage of ripening. Lactobacillus plantarum I91 grew up to 8 log during the first days of incubation in all of the extracts, but then the number of viable cells decreased, the extent of which depended on the starter strain and the age of the cheese used for the extract. The decrease in the counts of Lb. plantarum I91 was observed mainly in the extracts in which the pH had diminished the most. In addition, the extracts that best supported the viability of Lb. plantarum I91 during incubation had the highest free amino acids content. The effect of Lb. plantarum I91 on the proteolysis profile of the extracts was marginal. Significant changes in the content of free amino acids suggested that the catabolism of free amino acids by Lb. plantarum I91 prevailed in a weakly proteolyzed medium, whereas the release of amino acids due to peptidolysis overcame their catabolism in a medium with high levels of free amino acids. Lactobacillus plantarum I91 was able to use energy sources other than lactose to support its growth because equivalent numbers of cells were observed in extracts containing residual amounts of lactose and in lactose-depleted extracts. The contribution of Lb. plantarum I91 to hard-cooked cheese peptidolysis was negligible compared with that of the starter strain; however, its ability to transform amino acids is a promising feature of this strain.

Two strains of nonstarter lactobacilli increased the production of flavor compounds in soft cheeses.

The contribution to flavor generation and secondary proteolysis of 2 strains of mesophilic lactobacilli isolated from cheese was studied. Miniature soft cheeses (200 g) were produced with or without the inclusion of a culture of Lactobacillus plantarum I91 or Lactobacillus casei I90 in the starter composed of Streptococcus thermophilus. During ripening, cheeses containing the added lactobacilli showed an increased content of total free amino acids, but this increase was only significant in cheeses with Lb. plantarum I91. In addition, free amino acid profiles were modified by selective increases of some amino acids, such as Asp, Ser, Arg, Leu, and Phe. Cheeses inoculated with Lb. plantarum I91 or Lb. casei I90 were also characterized by a significantly higher concentration of diacetyl, a key flavor compound, and an increased content of acetoin. Results suggest an increase in the catabolism of either citrate or aspartate, with the production of the derived aroma compounds. Overall, aspartate content increased in both lactobacilli-added cheeses, whereas citrate was more or less constant, suggesting that aspartate could be the source of increased diacetyl and acetoin. A triangle aroma test showed that the addition of the lactobacilli strains significantly changed the sensory attributes of cheeses. At least 11 of 12 panelists commented that the aroma of cheeses with adjuncts was more buttery than that of control cheeses, which is desirable in most soft cheeses. Both Lb. plantarum I91 and Lb. casei I90 performed well as adjunct cultures by influencing cheese aroma development and cheese proteolysis.

Multivariate analysis of proteolysis patterns differentiated the impact of six strains of probiotic bacteria on a semi-hard cheese.

The individual contribution of 6 strains of probiotic bacteria (3 of Lactobacillus acidophilus and 3 of the Lactobacillus casei group) to proteolysis patterns in a semi-hard cheese was assessed. Control cheeses (without probiotics) and 2 types of experimental cheeses (with the addition of probiotics either directly to milk or by a 2-step fermentation method) were manufactured. Cheeses containing Lb. acidophilus showed the most extensive peptidolysis, which was evidenced by changes in the peptide profiles and a noticeable increase of free amino acids compared with control cheeses. The strains of the Lb. casei group showed a lower contribution to cheese peptidolysis, which consisted mainly of free amino acid increase. Two-step fermentation improved peptidolytic activity for only one of the cultures of Lb. acidophilus tested. The addition of Lb. acidophilus strains into cheese may be suitable not only for their beneficial health effect but also for their influence on secondary proteolysis, consistent with acceleration of ripening and improved flavor formation.

Proteolysis on Reggianito Argentino cheeses manufactured with natural whey cultures and selected strains of Lactobacillus helveticus.

Reggianito Argentino cheese is traditionally manufactured with whey starter cultures that provide typical and intense flavor but can cause poor quality standardization. In this study, the influence of natural and selected starters on Reggianito Argentino cheese proteolysis was investigated. Cheeses were manufactured with three strains of Lactobacillus helveticus (SF133, SF138 and SF209) cultured individually in sterile whey and used as single or mixed starters. Control cheeses were made with natural whey starter culture. Cheeses were analyzed to determine gross composition, as well as total thermophilic lactic flora. Proteolysis was assessed by N fractions, electrophoresis and liquid chromatography. Gross composition of the cheeses did not significantly differ, while viable starter cell counts were lower for cheeses made with strain SF209 alone or combined with other strains. Soluble N at pH 4.6 was the same for cheeses made with natural or selected starters, but soluble N in 12% trichloroacetic acid and 2.5% phosphotungstic acid was significantly higher in cheeses made with starters containing strain SF209. Nitrogen fractions results indicated that natural whey starter cultures could be replaced by several starters composed of the selected strains without significant changes to proteolysis patterns. Starter cultures prepared only with SF209 or with the three selected L. helveticus strains produced cheese products with significantly more proteolysis than control cheeses. Chromatographic profiles analyzed by principal components showed that three main peaks on chromatograms, presumptively identified as Tyr, Phe, and Trp, explained most of variability. Principal component scores indicated that cheese samples were grouped by ripening time, which was confirmed by linear discriminant analysis. On the contrary, samples did not cluster by Lactobacillus strain or type of starter.