Production of versatile peroxidase from Pleurotus eryngii by solid-state fermentation using agricultural residues and evaluation of its catalytic properties.

Interest in production of ligninolytic enzymes has been growing over recent years for their use in various applications such as recalcitrant pollutants bioremediation; specifically, versatile peroxidase (VP) presents a great potential due to its catalytic versatility. The proper selection of the fermentation mode and the culture medium should be an imperative to ensure a successful production by an economic and available medium that favors the process viability. VP was produced by solid-state fermentation (SSF) of Pleurotus eryngii, using the agricultural residue banana peel as growth medium; an enzymatic activity of 10,800 U L(-1) (36 U g(-1) of substrate) was detected after 18 days, whereas only 1800 U L(-1) was reached by conventional submerged fermentation (SF) with glucose-based medium. The kinetic parameters were determined by evaluating the H2O2 and Mn(2+) concentration effects on the Mn(3+)-tartrate complex formation. The results indicated that although the H2O2 inhibitory effect was observed for the enzyme produced by both media, the reaction rates for VP obtained by SSF were less impacted. This outcome suggests the presence of substances released from banana peel during the fermentation, which might exhibit a protective effect resulting in an improved kinetic behavior of the enzyme.

Fostering the action of versatile peroxidase as a highly efficient biocatalyst for the removal of endocrine disrupting compounds.

Response surface methodology (RSM) was used to optimize the removal of five endocrine disrupting compounds (EDCs) by the enzyme versatile peroxidase (VP): bisphenol A (BPA), triclosan (TCS), estrone (E1), 17ß-estradiol (E2) and 17α-ethinylestradiol (EE2). The optimal variables of enzyme activity (90-100 U L(-1)), sodium malonate (29-43 mM) and MnSO4 (0.8-1 mM) led to very high removal rates of the five pollutants (2.5-5.0 mg L(-1) min(-1)). The structural elucidation of transformation products arising from the enzymatic catalysis of the EDCs was investigated by Gas Chromatography coupled to Mass Spectrometry (GC-MS) and Liquid Chromatography Electrospray Time-of-Flight Mass Spectrometry (LC-ESI-TOF-MS). The presence of dimers and trimers, indicative of oxidative coupling, was demonstrated.

Continuous operation of a fluidized bed reactor for the removal of estrogens by immobilized laccase on Eupergit supports.

The feasibility of the operation of a fluidized bed reactor for the removal of estrogens by immobilized laccase was investigated in order to improve the degradation yields and enzyme stability previously obtained with packed bed reactors. High removal levels (between 76 and 90%) and significantly prolonged stability of the biocatalyst over 16 days were attained. In parallel, a decrease up to 90% in the estrogenic activity of the effluent was measured. Thus, the technology presented seems a promising tool to increase the applicability of laccases in bioremediation processes.

Degradation of estrogens by laccase from Myceliophthora thermophila in fed-batch and enzymatic membrane reactors.

Several studies reported that natural and synthetic estrogens are the major contributors to the estrogenic activity associated with the effluents of wastewater treatment plants. The ability of the enzyme laccase to degrade these compounds in batch experiments has been demonstrated in previous studies. Nevertheless, information is scarce regarding in vitro degradation of estrogens in continuous enzymatic bioreactors. The present work constitutes an important step forward for the implementation of an enzymatic reactor for the continuous removal of estrone (E1) and estradiol (E2) by free laccase from Myceliophthora thermophila. In a first step, the effect of the main process parameters (pH, enzyme level, gas composition (air or oxygen) and estrogen feeding rate) were evaluated in fed-batch bioreactors. E1 and E2 were oxidized by 94.1 and 95.5%, respectively, under the best conditions evaluated. Thereafter, an enzymatic membrane reactor (EMR) was developed to perform the continuous degradation of the estrogens. The configuration consisted of a stirred tank reactor coupled with an ultrafiltration membrane, which allowed the recovery of enzyme while both estrogens and degradation products could pass through it. The highest removal rates at steady state conditions were up to 95% for E1 and nearly complete degradation for E2. Furthermore, the residual estrogenic activity of the effluent was largely reduced up to 97%.

Immobilisation of laccase on Eupergit supports and its application for the removal of endocrine disrupting chemicals in a packed-bed reactor.

Laccase from Myceliophthora thermophila was covalently immobilised on Eupergit C and Eupergit C 250L yielding specific activities of up to 17 and 80 U/g, respectively. Due to its superior activity, Eupergit C 250L was chosen for further research. The somewhat lower catalytic efficiency (based on the ratio between the turnover number and the Michaelis constant, k(cat)/K(M)) of the immobilised enzyme in comparison with that of the free enzyme was balanced by its increased stability and broader operational window related to temperature and pH. The feasibility of the immobilised laccase was tested by using a packed bed reactor (PBR) operating in consecutive cycles for the removal of Acid Green 27 dye as model substrate. High degrees of elimination were achieved (88, 79, 69 and 57% in 4 consecutive cycles), while the levels of adsorption on the support varied from 18 to 6%, proving that dye removal took place mainly due to the action of the enzyme. Finally, a continuous PBR with the solid biocatalyst was applied for the treatment of a solution containing the following endocrine disrupting chemicals: estrone (E1), 17ß-estradiol (E2) and 17α-ethinylestradiol (EE2). At steady-state operation, E1 was degraded by 65% and E2 and EE2 were removed up to 80% and only limited adsorption of these compounds on the support, between 12 and 22%, was detected. In addition, a 79% decrease in estrogenic activity was detected in the effluent of the enzymatic reactor while only 14% was attained by inactivated laccase.

Immobilization of laccase by encapsulation in a sol-gel matrix and its characterization and use for the removal of estrogens.

Laccase from Myceliophthora thermophila was immobilized by encapsulation in a sol-gel matrix based on methyltrimethoxysilane and tetramethoxysilane. The amount of laccase used for the preparation of the hydrogel was in the range 2.2-22 mg of protein/mL sol and the corresponding enzymatic activities were in the range 5.5-17.0 U/g biocatalyst. The kinetic parameters of the encapsulated laccase showed that the immobilized enzyme presented lower affinity for the substrate 2,2'-azinobis-(3-ethylbenzothiazoline-6-sulfonate) (ABTS). However, the stability of laccase was significantly enhanced after immobilization; thus, both pH and thermal stability improved about 10-30% and tolerance to different inactivating agents (NaN(3) , ZnCl(2) , CoCl(2) , CaCl(2) , methanol, and acetone) was 20-40% higher. The reusability of the immobilized laccase was demonstrated in the oxidation of ABTS for several consecutive cycles, preserving 80% of the initial laccase activity after 10 cycles. The feasibility of the immobilized biocatalyst was tested for the continuous elimination of Acid Green 27 dye as a model compound in a packed-bed reactor (PBR). Removals of 70, 58, 57, and 55% were achieved after four consecutive cycles with limited adsorption on the support: only 10-15%. Finally, both batch stirred tank reactor (BSTR) operated in several cycles and PBR, containing the solid biocatalyst were applied for the treatment of a solution containing the endocrine disrupting chemicals (EDCs): estrone (E1), 17ß-estradiol (E2), and 17α-ethinylestradiol (EE2). Eliminations of EDCs in the BSTR were higher than 85% and the reusability of the biocatalyst for the degradation of those estrogens was demonstrated. In the continuous operation of the PBR, E1 was degraded by 55% and E2 and EE2 were removed up to 75 and 60%, at steady-state conditions. In addition, a 63% decrease in estrogenic activity was detected.

Genetic analysis of the transcriptional arrangement of Azotobacter vinelandii alginate biosynthetic genes: identification of two independent promoters.

The study of alginate biosynthesis, the exopolysaccharide produced by Azotobacter vinelandii and Pseudomonas aeruginosa, might lead to different biotechnological applications. Here we report the cloning of A. vinelandii algA, the gene coding for the bifunctional enzyme phosphomannose isomerase-guanosine diphospho-o-mannose pyrophosphorylase (PMI-GMP). This gene was selected by the complementation for xanthan gum production of Xanthomonas campestris pv. campestris xanB-mutants, which lack this enzymatic activity. The complementing cosmid clones selected, besides containing algA, presented a gene coding for an alginate lyase activity (algL), and some of them also contained algD which codes for GDP-mannose dehydrogenase. We present here the characterization of the A. vinelandii chromosomal region comprising algD and its promoter region, algA and algL, showing that, as previously reported for P. aeruginosa, A. vinelandii has a cluster of the biosynthetic alginate genes. We provide evidence for the presence of an algD-independent promoter in this region which transcribes at least algL and algA, and which is regulated in a manner that differs from that of the algD promoter.

Characterization of the gene coding for GDP-mannose dehydrogenase (algD) from Azotobacter vinelandii.

Azotobacter vinelandii presents a differentiation process leading to the formation of desiccation-resistant cysts. Alginate, the exopolysaccharide produced by this bacterium, has been postulated to have a role in cyst formation. Here, we report the cloning and characterization of the A. vinelandii gene coding for the enzyme GDP-mannose dehydrogenase (algD), which is the key enzyme for alginate synthesis in Pseudomonas aeruginosa. This gene has a high degree of similarity with the algD gene from P. aeruginosa, and similar proteins seem to be involved in algD regulation in both bacteria. We show the existence of two mRNA start sites; one of these sites corresponds to a promoter transcribed by RNA polymerase containing a sigma E subunit. An A. vinelandii algD mutant which is completely impaired in alginate production and which is unable to form desiccation-resistant cells was constructed. The effects of NH4, NO3, and NaCl concentrations on algD transcription for three A. vinelandii strains producing different alginate levels were evaluated. We found a strict correlation between alginate production and algD transcription for the three strains studied; however, the effects on algD transcription under the conditions studied were different for each strain. The nitrogen source regulates algD expression in the wild-type strain.