RESUMO
Proximate composition, cooking quality and sensory characteristics of traditional Turkish egg pasta, eriste, fortified with edible insect and legume flours were evaluated. Egg pasta samples were produced using different blends of wheat flour: legume (lentil and white kidney bean) flour and wheat flour: edible insect (mealworm and grasshopper) flour. Optimum cooking time significantly (p < 0.05) increased with the fortification of egg pasta. The fortification of egg pasta with edible insect flours resulted in a reduced volume expansion from 236.7% (control) to 215.6% and 196.9% for grasshopper flour (W:G) and mealworm flour (W:M) samples, respectively. On the other hand, W:M and W:G samples exhibited significantly (p < 0.05) higher nutritional profile in terms of protein, ash and crude fiber content. Results showed that the smoothness of pasta was also influenced; strengthened by addition of white kidney bean flour and weakened by the addition of grasshopper flour. The received scores from sensory evaluation showed that flours including lentil flour (W:L) and white kidney bean flour (W:B) samples had higher flavor and overall acceptability values with compared to the mealworm flour (W:M), grasshopper flour (W:G) and control sample (C).
RESUMO
The effect of Lactobacillus plantarum fermentation on the functional and physicochemical properties of pea protein-enriched flour (PPF) was investigated. Over the course of the fermentation the extent of hydrolysis increased continuously until reaching a maximum degree of hydrolysis of 13.5% after 11 h. The resulting fermented flour was then adjusted to either pH=4 or 7 prior to measuring the surface and functional attributes as a function of fermentation time. At pH=4 surface charge, as measured by zeta potential, initially increased from +14 to +27 mV after 1 h of fermentation, and then decreased to +10 mV after 11 h; whereas at pH=7 the charge gradually increased from -37 to -27 mV over the entire fermentation time. Surface hydrophobicity significantly increased at pH=4 as a function of fermentation time, whereas at pH=7 fermentation induced only a slight decrease in PPF surface hydrophobicity. Foam capacity was highest at pH=4 using PPF fermented for 5 h whereas foam stability was low at both pH values for all samples. Emulsifying activity sharply decreased after 5 h of fermentation at pH=4. Emulsion stability improved at pH=7 after 5 h of fermentation as compared to the control. Oil-holding capacity improved from 1.8 g/g at time 0 to 3.5 g/g by the end of 11 h of fermentation, whereas water hydration capacity decreased after 5 h, then increased after 9 h of fermentation. These results indicate that the fermentation of PPF can modify its properties, which can lead towards its utilization as a functional food ingredient.
RESUMO
In order to determine the impact of fermentation on protein quality, pea protein concentrate (PPC) was fermented with Lactobacillus plantarum for 11 h and total phenol and tannin contents, protease inhibitor activity, amino acid composition and in vitro protein digestibility were analyzed. Phenol levels, expressed as catechin equivalents (CE), increased on dry mass basis from 2.5 at 0 h to 4.9 mg CE per 1 g of PPC at 11 h. Tannin content rose from 0.14 at 0 h to a maximum of 0.96 mg CE per 1 g of PPC after 5 h, and thereafter declined to 0.79 mg/g after 11 h. After 9 h of fermentation trypsin inhibitor activity decreased, however, at all other fermentation times similar levels to the PPC at time 0 h were produced. Chymotrypsin inhibitor activity decreased from 3.7 to 1.1 chymotrypsin inhibitory units (CIU) per mg following 11 h of fermentation. Protein digestibility reached a maximum (87.4%) after 5 h of fermentation, however, the sulfur amino acid score was reduced from 0.84 at 0 h to 0.66 at 11 h. This reduction in sulfur content altered the in vitro protein digestibility-corrected amino acid score from 67.0% at 0 h to 54.6% at 11 h. These data suggest that while fermentation is a viable method of reducing certain non-nutritive compounds in pea protein concentrate, selection of an alternative bacterium which metabolises sulfur amino acids to a lesser extent than L. plantarum should be considered.
RESUMO
In this research, pullulan was incorporated in protein-based encapsulation matrix in order to assess its cryoprotective effect on the viability of freeze-dried (FD) probiotic Lactobacillus acidophilus NRRL-B 4495. This study demonstrated that pullulan in encapsulation matrix resulted in a 90.4% survival rate as compared to 88.1% for whey protein (WPI) encapsulated cells. The protective effects of pullulan on the survival of FD-encapsulated cells in gastrointestinal conditions were compared. FD WPI-pullulan capsules retained higher survived cell numbers (7.10 log CFU/g) than those of FD WPI capsules (6.03 log CFU/g) after simulated gastric juice exposure. Additionally, use of pullulan resulted in an increased viability after bile exposure. FD-free bacteria exhibited 2.18 log CFU/g reduction, while FD WPI and FD WPI-pullulan encapsulated bacteria showed 0.95 and 0.49 log CFU/g reduction after 24 h exposure to bile solution, respectively. Morphology of the FD microcapsules was visualized by scanning electron microscopy.
Assuntos
Crioprotetores/química , Liofilização/métodos , Glucanos/química , Lactobacillus acidophilus/citologia , Proteínas do Soro do Leite/química , Cápsulas/química , Cápsulas/farmacologia , Células Imobilizadas/citologia , Crioprotetores/farmacologia , Glucanos/farmacologia , Lactobacillus acidophilus/efeitos dos fármacos , Proteínas do Soro do Leite/farmacologiaRESUMO
In this research, whey protein/pullulan (WP/pullulan) microcapsules were developed in order to assess its protective effect on the viability of Lactobacillus acidophilus NRRL-B 4495 under in vitro gastrointestinal conditions. Results demonstrated that WP/pullulan microencapsulated cells exhibited significantly (p ≤ 0.05) higher resistance to simulated gastric acid and bile salt. Pullulan incorporation into protein wall matrix resulted in improved survival as compared to free cells after 3 h incubation in simulated gastric solution. Moreover WP/pullulan microcapsules were found to release over 70% of encapsulated L. acidophilus NRRL-B 4495 cells within 1 h. The effect of encapsulation during refrigerated storage was also studied. Free bacteria exhibited 3.96 log reduction while, WP/pullulan encapsulated bacteria showed 1.64 log reduction after 4 weeks of storage.