Addition of chickpea markedly increases the indigestible carbohydrate content in semolina pasta as eaten.

BACKGROUND: There is a growing interest in increasing dietary fiber (DF) consumption because of the health benefits associated with this nutrient. Pulses are considered a good source of non-digestible carbohydrates. The aim of this study was to investigate the possibility of substituting semolina with chickpea flour to increase indigestible carbohydrate content without altering the texture of the pasta. RESULTS: Pasta was prepared by extruding semolina-chickpea blends. The protein and DF content in the cooked pasta increased with the chickpea level, with an important contribution of resistant starch (RS) to the DF values. The optimum cooking time decreased as the chickpea content increased, which was related to the degree of starch gelatinization of the raw pasta. The in vitro digestible starch content decreased with the chickpea substitution level, concomitant with the increase in RS content. In general, the texture of the chickpea-containing pasta was similar to that of semolina pasta. CONCLUSIONS: Pending acceptability studies on these pastas may grant their promotion as good fiber sources, probably helpful in the fight against obesity and diet-related non-communicable diseases. © 2020 Society of Chemical Industry.

Starch digestibility: past, present, and future.

In the last century, starch present in foods was considered to be completely digested. However, during the 1980s, studies on starch digestion started to show that besides digestible starch, which could be rapidly or slowly hydrolysed, there was a variable fraction that resisted hydrolysis by digestive enzymes. That fraction was named resistant starch (RS) and it encompasses those forms of starch that are not accessible to human digestive enzymes but can be fermented by the colonic microbiota, producing short-chain fatty acids. RS has been classified into five types, depending on the mechanism governing its resistance to enzymatic hydrolysis. Early research on RS was focused on the methods to determine its content in foods and its physiological effects, including fermentability in the large intestine. Later on, due to the interest of the food industry, methods to increase the RS content of isolated starches were developed. Nowadays, the influence of RS on the gut microbiota is a relevant research topic owing to its potential health-related benefits. This review summarizes over 30 years of investigation on starch digestibility, its relationship with human health, the methods to produce RS and its impact on the microbiome. © 2018 Society of Chemical Industry.

ADP-Glucose Pyrophosphorylase Is Located in the Plastid and Cytosol in the Pulp of Tropical Banana Fruit (Musa acuminata).

ADP-glucose pyrophosphorylase (AGPase) is a key enzyme of starch synthesis in seeds, tubers and fruits. UDP-glucose pyrophosphorylase (UGPase) is an important enzyme of sucrose metabolism in the cytosol while alkaline phosphatase (ALP) is a marker enzyme of the amyloplast that keeps the production of ADPG by removing PPi. Unripe banana accumulates starch in the pulp during development, while ripe fruits are characterized by the accumulation of soluble sugars. The aim of the study was to compare starch granule structure, carbohydrate levels, subcellular location and activities of three enzymes: AGPase, UGPase and ALP. Protein extracts from the cytosolic and amyloplastidial fractions were obtained from the pulp of banana fruit at three developmental stages (11, 16 and 21 weeks after flowering) and analyzed by electrophoresis and immunodetection. Protein profiles were similar during ripening, showing a main electrophoretic band at 50-55 kDa. Higher protein content was found in the cytosolic than in the amyloplastidial fraction. Starch granules and ALP activity were enriched in the amyloplast, whereas AGPase showed a subcellular distribution similar to UGPase. Immunoblot analysis also confirmed the presence of AGPase in both cytosol and amyloplast. AGPase activity was higher in the cytosol than in the amyloplast. Both AGPase activity and western blot band intensity were highest at 16 weeks. UGPase activity was highest at 21 weeks. We conclude that cytosolic production of ADP-glucose is not an exclusive feature of cereal endosperms due to plant breeding, but it also occurs in fruits of non-domesticated plants such as tropical banana (Musa acuminata). This work increases our understanding about pyrophosphorylase activities in the pulp of banana fruit.

Preparation and partial characterization of films made with dual-modified (acetylation and crosslinking) potato starch.

BACKGROUND: Starch is an alternative material for the production of biodegradable plastics; however, native starches have drawbacks due to their hydrophilic nature. Chemical modifications such as acetylation and crosslinking are used to broaden the potential end-uses of starch. Dual modification of starches increases their functionality compared to that of starches with similar single modifications. In this study, a dual-modified potato starch (acetylated and crosslinked) was used to produce films by casting. RESULTS: Changes in the arrangement of the amylopectin double helices of dual-modified starch were evident from X-ray diffraction patterns, pasting profiles and thermal properties. The degree of substitution for acetyl groups was low (0.058 ± 0.006) because crosslinking dominated acetylation. Modified starch film had higher elongation percentage (82.81%) than its native counterpart (57.4%), but lower tensile strength (3.51 MPa for native and 2.17 MPa for dual-modified) and lower crystallinity in fresh and stored films. The sorption isotherms indicated that the dual modification decreased the number of reactive sites for binding water, resulting in a reduction in the monolayer value and a decrease in the solubility and water vapor permeability. CONCLUSIONS: Dual modification of starch may be a feasible option for improving the properties of biodegradable starch films. © 2018 Society of Chemical Industry.

Whole unripe plantain (Musa paradisiaca L.) as raw material for bioethanol production.

BACKGROUND: The use of byproducts such as rejected plantain with final disposition problems and conversion processes with 'green' technologies are important research topics. Bioethanol production from crops with a high content of fermentable sugars is an alternative to that from traditional crops (corn and sugar cane). The aim of this work was to study the use of whole (peel and pulp) unripe plantain (WP) for bioethanol production. RESULTS: Lab-scale liquefaction and saccharification of both materials released mainly three carbohydrates, glucose (9.02 mg g-1 ), maltose (0.45 mg g-1 ) and xylose (0.25 mg g-1 ). The WP saccharification required the use of pectinase and cellulase because of the high amounts of pectin and cellulose associated with the peel. Fermentation for 11 h produced similar ethanol concentration for both samples, but at the end of fermentation (32 h), the ethanol production was higher in the WP (58.6 mL L-1 ) compared with the plantain pulp (PP) (45.5 mL L-1 ). The theoretical ethanol yield was lower with WP (67%) than with PP (90%). CONCLUSION: WP can be an alternative raw material for bioethanol production. © 2019 Society of Chemical Industry.

Influence of blue maize flour on gluten-free pasta quality and antioxidant retention characteristics.

Due to its bioactive compounds, blue maize flour is a valuable ingredient for developing gluten-free products. The incorporation of alternative flours into gluten-free pasta is a challenge as it usually results in products that, despite their enhanced nutraceutical features, show reduced quality characteristics. Composite pasta was prepared with variable (25, 50 and 75%) contents of flours from white and blue maize, chickpea and unripe plantain, following a laboratory-scale process. The composite pasta exhibited acceptable cooking loss (9-11%); pasta with blue maize showed lower hardness and chewiness, but higher adhesiveness than its white maize-based counterpart. Blue maize-based pasta presented dark color. The addition of blue maize flour at 75% conveyed the highest total phenolic content retention after extrusion (80%) and cooking (70%). Pasting profile of blue maize pasta (50 and 75%) showed a defined second viscosity peak due to re-arrangement of starch components upon cooling. The observed retention of phenolic compounds with antioxidant capacity after cooking will be useful for further development (selection of ingredients, formulations and conditions of operation) of gluten-free products with potential health benefits.

Multivariable Analysis of Gluten-Free Pasta Elaborated with Non-Conventional Flours Based on the Phenolic Profile, Antioxidant Capacity and Color.

The phenolic compounds, color and antioxidant capacity of gluten-free pasta prepared with non-conventional flours such as chickpea (CHF), unripe plantain (UPF), white maize (WMF) and blue maize (BMF) were analyzed. Fifteen phenolic compounds (five anthocyanins, five hydroxybenzoic acids, three hydroxycinnamic acids, one hydroxyphenylacetic acid and one flavonol) were identified in pasta prepared with blue maize, and 10 compounds were identified for samples prepared with white maize. The principal component analysis (PCA) led to results describing 98% of the total variance establishing a clear separation for each pasta. Both the proportion (25, 50 and 75%) and type of maize flour (white and blue) affected the color parameters (L*, C ab *, h ab and ΔE* ab ) and antioxidant properties (DPPH, ABTS and FRAP methods) of samples, thus producing gluten-free products with potential health benefits intended for general consumers (including the population with celiac disease).

Functional properties and dietary fiber characterization of mango processing by-products (Mangifera indica L., cv Ataulfo and Tommy Atkins).

Several reports have focused on utilization of post-harvest residues of crops, while neglecting those residues produced by mango processing. These residues represent a waste of nutrients and a source of environmental contaminants. Such by-products could be valuable sources of dietary fiber (DF), antioxidant compounds, and single carbohydrates. The aim of this study was to evaluate some functional properties (FP), and the content of DF and polyphenols (PP) of the peel and coarse material obtained from residues during the industrial processing of Ataulfo and Tommy Atkins mangoes. The total dietary fiber (TDF) content was about 225 mg/g and 387 mg/g (dry weight) for the coarse material and the peel, respectively, from which soluble dietary fiber represented 23 and 42%, respectively. The main neutral sugar identified was rhamnose, especially in peels; the klason lignin (KL) content was 92 mg/g, which highlights the Ataulfo peel (Ataulfo-P) and the Tommy Atkins peel (Tommy Atkins-P). The extractable PP content in Ataulfo-P was higher than in Tommy-Atkins-P, and interesting data for non-extractable PP were obtained in the residues. FP as swelling, water holding, oil holding, and glucose absorption in the residues was studied, obtaining better functional properties when compared to cellulose fiber. The results show that mango industrial by-products, mainly from the Ataulfo-P variety, could be used as ingredients in food products because of their functional properties as well as their DF and PP content.

Interaction between starch and dietary compounds: New findings and perspectives to produce functional foods.

Due to the increased prevalence of overweight, obesity, diabetes, colon cancer, cardiovascular diseases, and metabolic syndrome, dietary approaches to reduce starch digestion and regulate glucose homeostasis have gained attention. Starch is a polysaccharide in most daily food consumed as bakery products, snacks, breakfast cereals, and pasta, which are often vilified. However, it is also present in beans, lentils, and oatmeal, which are considered healthy food products. The difference relays on the food matrix and the thermal process that can produce interactions between starch and dietary compounds (protein, lipid, non-starch polysaccharide, and bioactive compounds) or among starch chains (retrogradation). Such interactions produce structural changes so the digestive enzymes cannot hydrolyze them; additionally, the physical barrier of some macromolecules (proteins, hydrocolloids) restricts starch gelatinization and accessibility of the digestive enzymes to hydrolyze the starch. The interactions mentioned above and the use of some macromolecules as physical barriers could be explored as a pathway to develop functional foods. This review analyzes the interactions between starch and dietary compounds influenced by the processing of some food matrices to better understand their potential for developing functional foods.

Avocado seed starch: Effect of the variety on molecular, physicochemical, and digestibility characteristics.

Agro-industrial residues can increase environmental pollution owing to poor knowledge of the use of some components, such as dietary fiber, protein, starch, minerals, and bioactive compounds, which can be used in the food industry. This study compared the molecular, physicochemical, and digestibility characteristics of three avocado seed starches (Criolla, Fuerte, and Hass). Starch was extracted through successive washing and sedimentation. The morphology, size distribution, thermal properties, pasting properties, infrared spectra with Fourier transform, size distribution of amylopectin chains, and digestibility of the three avocado seed strains were analyzed. The starch grains were oval and spherical in shape. The average size of Criolla avocado starch (24.55 µm) was the largest, followed by Hass and Fuerte starches (21.37 µm). Higher gelatinization enthalpy (8.55 J/g), gelatinization temperature (75.28 °C), and pasting temperature (75.57 °C) were observed for Fuerte avocado starch, followed by Hass and Criolla starches. Hass avocado starch exhibited higher maximum (836.27 mPa.s), final (1407.37 mPa.s), setback (588.78 mPa.s), and breakdown (17.68 mPa.s) viscosities than Criolla and Fuerte avocado starches. In addition, the probed avocado starches exhibited high content of resistant starch (60.06-68.90%). Therefore, it was demonstrated that differences in the chemical composition and structure of avocado starch can affect the digestibility of native starch.

Optimal conditions for anthocyanin extract microencapsulation in taro starch: Physicochemical characterization and bioaccessibility in gastrointestinal conditions.

This research aims to find the optimal conditions for the encapsulation of anthocyanin extract using taro starch to increase the retention of active compounds (RAC), drying yield (DY), antioxidant activity, stability, and bioaccessibility. The microencapsulation is carried out in a spray dryer, and the process is optimized using response surface method (RSM), applying starch concentration and inlet air temperature as independent parameters. Optimized microcapsules (OM) are obtained with solids concentration of 20.9 % and inlet temperature of 125 °C as optimal conditions. Drying yield (70.1 %), moisture content (5.2 %), water activity (0.211), phenolic compound content (797.8 mg GAE/g), anthocyanins (469.4 mg CE3G/g), ABTS (116.2 mg AAE/g) and DPPH (104.4 mg AAE/g) are analyzed through RSM. Retention percentage in OM show values of 60 % in bioactive compounds up to four weeks of storage under accelerated storage conditions. Bioaccessibility of OM is 10 % higher than that observed in the extract without encapsulation during gastrointestinal digestion. The results in this study show that OM made with taro starch and obtained with RSM effectively protect through digestion and ensure bioactive compound stability during storage.

Chemical composition, starch digestibility and antioxidant capacity of tortilla made with a blend of quality protein maize and black bean.

Tortilla and beans are the basic components in the diet of people in the urban and rural areas of Mexico. Quality protein maize is suggested for tortilla preparation because it presents an increase in lysine and tryptophan levels. Beans contain important amounts of dietary fiber. The objective of this study was to prepare tortilla with bean and assesses the chemical composition, starch digestibility and antioxidant capacity using a quality protein maize variety. Tortilla with bean had higher protein, ash, dietary fiber and resistant starch content, and lower digestible starch than control tortilla. The hydrolysis rate (60 to 50%) and the predicted glycemic index (88 to 80) of tortilla decreased with the addition of bean in the blend. Extractable polyphenols and proanthocyanidins were higher in the tortilla with bean than control tortilla. This pattern produced higher antioxidant capacity of tortilla with bean (17.6 µmol Trolox eq/g) than control tortilla (7.8 µmol Trolox eq/g). The addition of bean to tortilla modified the starch digestibility and antioxidant characteristics of tortilla, obtaining a product with nutraceutical characteristics.

Effect of gelatinization degree on emulsification capacity of corn starch esterified with octenyl succinic acid.

Normal corn starch (∼26% amylose content) was subjected to different degrees of extrusion-based pregelatinization (55, 75, and 95%) to improve the efficiency of octenyl succinic anhydride (OSA) esterification. The partial disruption of the native semi-crystalline structure was verified with X-ray diffraction and Fourier transform infrared analysis. It was found that partial gelatinization (pregelatinization) reduced the relative crystallinity, which is an effect that was magnified by OSA esterification. Polarized and scanning electron microscopies revealed gradual destruction of the starch granules, yielding a fraction of insoluble remnants for high gelatinization degrees. The emulsification index showed a marked increase of about 18% by single extrusion treatment. However, fully stable emulsions (emulsification index = 1.0) were obtained by dual extrusion-esterification treatment. The hardness of hydrogels was reduced by pregelatinization. Principal component analysis revealed that most starch characteristics were mutually interdependent and that the impact of gelatinization degree was independent of the impact of OSA esterification.

Fiber concentrate from orange (Citrus sinensis L.) bagase: characterization and application as bakery product ingredient.

Orange is a tropical fruit used in the juice industry, yielding important quantities of by products. The objective of this work was to obtain a dietary fiber-rich orange bagasse product (DFROBP), evaluate its chemical composition and its use in the preparation of a bakery product (muffin). Muffins containing two different levels of DFROBP were studied regarding chemical composition, in vitro starch digestibility, predicted glyceamic index and acceptability in a sensory test. DFROBP showed low fat and high dietary fiber contents. The soluble and insoluble dietary fiber fractions were balanced, which is of importance for the health beneficial effects of fiber sources. DFROBP-containing muffins showed the same rapidly digestible starch content as the reference muffin, whilst the slowly digestible starch level increased with the addition of DFROBP. However, the resistant starch content decreased when DFROBP increased in the muffin. The addition of DFROBP to muffin decreased the predicted glyceamic index, but no difference was found between the muffins prepared with the two DFROBP levels. The sensory score did not show difference between control muffin and that added with 10% of DFROBP. The addition of DFROBP to bakery products can be an alternative for people requiring low glyceamic response.

Influence of gelatinization degree and octenyl succinic anhydride esterification on the water sorption characteristics of corn starch.

The effects of gelatinization degree (GD) and octenyl succinic anhydride (OSA) esterification in the sorption-desorption characteristics of normal corn starch (NCS) were studied. NCS was subjected to different GD (53, 70, and 96%) with an extruder and lyophilized. FTIR analysis revealed that GD increased the hydrated (995/1022 ratio) and decreased the short-range ordered (1022/1047 ratio). The equilibrium sorption-desorption curve of starches was obtained for water activities up to 0.95 and fitted with the Guggenheim-Anderson-de Boer (GAB) model. Gelatinization of corn starch decreased its water sorption capacity, increased its sorption hysteresis and decreased its monolayer moisture content. OSA treatment of NCS reduced the water sorption capacity, hysteresis, and monolayer moisture content as reflected by slight variations of these parameters with the GD. A principal component analysis showed that GD and OSA esterification are mutually independent treatments, which can provide different effects on the water sorption characteristics of NCS.

Effects of mixing, sheeting, and cooking on the starch, protein, and water structures of durum wheat semolina and chickpea flour pasta.

The influence of the pasta preparation stages on starch, proteins, and water structures of semolina and chickpea pasta was studied. The hydrated starch structures (995/1022 FTIR ratio) increased in semolina and reduced in chickpea pasta. The processing stages in semolina pasta led to a significant increase of ß-sheet structures (~50% to ~68%). The ß-sheet structures content in chickpea pasta was lower (~52%), and was most affected by sheeting and cooking. The water structure was assessed by the analysis of the OH fingerprint FTIR region (3700-2800 cm-1) and showing that water molecules (~90%) are strongly and moderately bound. The chickpea pasta displayed the highest content of strongly bonded water (about 55%) in contrast to the semolina pasta (~48%). A principal component analysis showed that the molecular organization of semolina pasta was mostly affected by dough formation and cooking; the molecular organization of chickpea pasta was determined by the cooking stage.

Relationships among molecular, physicochemical and digestibility characteristics of Andean tuber starches.

This study aimed to determine and correlate the physicochemical, thermal, pasting, digestibility and molecular characteristics of native starches, such as mashua (Tropaeolum tuberosum R. and P.), oca (Oxalis tuberosa Mol.), and olluco (Ullucus tuberosus C.), which were extracted via successive washing and sedimentation. The morphology of native starches was determined by scanning electron microscopy, granule size distribution, thermal properties, pasting properties, X-ray diffraction (XRD), amylopectin chain-length distribution and amylose and amylopectin molecular weights. Mashua starch was smaller in size than oca and olluco starches. Moreover, the granules of mashua starch were round in shape, whereas those of oca and olluco starches were ellipsoidal in shape. The B XRD spectra showed similar profiles for the three Andean tuber starches. Mashua and olluco starches exhibited the lowest gelatinization temperatures and enthalpy values, and olluco amylopectin exhibited a longer chain length than mashua and oca starches. The resistant starch of gelatinized and ungelatinized samples exhibited a positive and strong correlation with the molecular properties of amylose and amylopectin, gelatinization enthalpy and molecular order.

In vitro starch digestibility and expected glycemic index of pound cakes baked in two-cycle microwave-toaster and conventional oven.

Bread baking technology has an important effect on starch digestibility measured as its predicted glycemic index tested in vitro. The aim of this work was to evaluate the changes in predicted glycemic index of pound cake baked in a two-cycle microwave toaster and a conventional oven. The glycemic index was calculated from hydrolysis index values by the Granfeldt method. Non-significant differences (P > 0.05) were found in hydrolysis index (60.67 ± 3.96 for the product baked in microwave oven and 65.94 ± 4.09 for the product baked in conventional oven) and predicted glycemic index content (60.5 for product baked in microwave oven and 65 for the product baked in conventional oven) in freshly-baked samples. Results clearly demonstrate that the baking pound cake conventional process could be replicated using a two-cycle multifunction microwave oven, reducing the traditional baking time. Further research is required in order to achieve pound cake crumb uniformity.

In vitro fermentability and antioxidant capacity of the indigestible fraction of cooked black beans (Phaseolus vulgaris L.), lentils (Lens culinaris L.) and chickpeas (Cicer arietinum L.).

BACKGROUND: Pulses represent an important source of protein, as well as digestible and indigestible carbohydrates. Little information is available on the indigestible carbohydrates and antioxidant capacity of legume seeds. The cooked seeds of three pulses (black bean, chickpea and lentil) were evaluated for their indigestible fraction (IF), polyphenols content, antioxidant capacity and in vitro fermentability, including short-chain fatty acid production. RESULTS: The insoluble indigestible fraction (IIF) was higher than the soluble counterpart (soluble indigestible fraction, SIF). The SIF value was highest in black beans, while no difference was observed between chickpeas and lentils. Black beans and lentils had higher polyphenols content than chickpeas. The IF of black beans exhibited the lowest and chickpeas the highest associated polyphenols content. Condensed tannins were retained to some extent in the IF that exhibited significant antioxidant capacity. The total IF of the three pulses produced short chain fatty acids (SCFA) after 24 h of in vitro fermentation by human colonic microflora. IF from black bean and lentil were best substrates for the fermentative production of butyric acid. CONCLUSIONS: It is concluded that the IF of pulses might be an important source of bioactive compounds.

Physicochemical, rheological and structural characteristics of starch in maize tortillas.

Fresh and stored maize (white and blue) tortillas were evaluated for physicochemical, rheological and structural characteristics assessed by calorimetry, x-ray diffraction, Fourier transform infrared (FTIR) spectroscopy, dynamic viscoelastic tests, and high-performance size-exclusion chromatography. Two endotherms were found in studies of fresh and stored tortillas. The low temperature endotherm (50-56 degrees C) was due to reorganized (retrograded) amylopectin, while the high temperature endotherm (105-123 degrees C) was attributed to retrograded amylose. The enthalpy value for the lower temperature transition was minor than that of the high temperature transition. Fresh tortillas showed an amorphous starch arrangement by x-ray diffraction study. Stored samples showed the presence of peaks at 2theta = 17 masculine and 23 masculine, indicating re-crystallization of starch components. FTIR results confirmed the development of higher levels of starch crystals during storage. Differences in the viscoelastic parameters were also observed between fresh and stored samples. At the longest storage times, white tortillas were more rigid than blue tortillas. Molar mass values for starch increased for both white and blue tortillas as storage time progressed, though relatively higher values were obtained for white tortillas. More starch reorganization occurred in white tortillas, in accordance to calorimetric, x-ray diffraction, FTIR and rheological results. These results corroborate that changes occurring in tortillas during storage are related to reorganization of starch components, and the maize variety more than the color plays an important role.