Effect of COD on methanotrophic growth and the anaerobic digestibility of its sludge as a further step for integration in WWTPS.

Within wastewater treatment plants (WWTPs), the anaerobically produced biogas is often underutilized. Fortunately, methanotrophic based biotechnologies can be the remedy for on-site exploitation and recovery of unused biogas. In this regard, efforts have been placed on evaluating the suitably of methanotrophs to be deployed in WWTPs. Even so, the effect of chemical oxygen demand (COD) on methanotrophic activity and methanotrophic sludge digestibility have not been studied, which is the focus of the present study. A methanotrophic culture enriched from activated sludge was exposed to four different COD concentrations (0-540 mg/L) to evaluate the effect of COD on the culture activity in batch mode. It was attained that the presence of COD concentrations up to 540 mg/L has limited influence on methanotrophic activity. This finding was supported by the similar average methane uptake rate (between 2.48 and 2.53 mgCH4/hr) and consumption (61.4 ± 1.5%) observed under the different COD concentrations. On the other hand, methanotrophic sludge was digested in comparison to waste activated sludge (WAS) collected from a WWTP for more than 40 days to evaluate its digestibility. It was obtained that the methanotrophic sludge had a methane specific yield of approximately 1.72 times greater than WAS and had a higher solids destruction rate. This research is another step demonstrating the feasibility of methanotrophs integration in WWTP.

Production of poly-hydroxy-butyrate using nitrogen removing methanotrophic mixed culture bioreactor.

Methanotrophic biotechnologies for methane mitigation and nitrogen removal are becoming more apparent. However, the sludge produced during these processes is often underutilized and instead can be applied for resources recovery. Fortunately, methanotrophic bacteria can utilize methane while also producing poly-hydroxy-butyrate (PHB), bioplastics, under nutrients deficient conditions. Bioplastics are increasing in popularity and can be produced from unexploited resources, such as methane and carbon dioxide, within wastewater facilities. This research demonstrates that methanotrophic sludge generated during a methanotrophic-based nitrogen removal process, which has been recently suggested, can be directly utilized for PHB production. It was found that the PHB storage response of the methanotrophic driven mixed culture was greatest when methane and oxygen were supplied in equal volume to volume ratios. In addition, the PHB response due to imposing feast-like conditions along with nitrogen or phosphorus deprivation were assessed. The highest PHB storage achieved was 21 ± 1.31% after one cycle under methane sufficient and nitrogen limited conditions. Whereas, only applying feast-like conditions demonstrated a PHB storage of 15 ± 0.67% while simultaneously removing nitrate. Finally, further optimization and continued feast- and famine-like cycles can lead to a greater PHB storage response by the culture.