Determination of the energy value of corn distillers dried grains with solubles containing different oil levels when fed to growing pigs.

This experiment used indirect calorimetry to determine the net energy (NE) content of five corn distillers dried grains with solubles (corn DDGS) containing different oil levels and to compare the NE obtained using indirect calorimetry with that calculated using previously published prediction equations. There were two samples of high-oil DDGS, one sample of medium-oil DDGS and two samples of low-oil DDGS. Twelve barrows (initial BW of 32.8 ± 2.0 kg) were used in a repeated 3 × 6 Youden square design with three periods and six diets. The diets were comprised of a corn-soybean meal basal diet and five diets containing 29.25% of one of the corn DDGS added at the expense of corn and soybean meal. During each period, the pigs were individually housed in metabolism crates for 16 days which included 7 days for adaption to feed and environmental conditions. On day 8, the pigs were transferred to respiration chambers and fed one of the six diets at 2300 kJ ME/kg BW0.6 /day. Faeces and urine were collected from day 9 to 13 and heat production (HP) was also measured. From day 14 to 15, the pigs were fed 893 kJ ME/kg BW0.6 /day to allow them to adapt from the fed to the fasted state. On the last day of each period (day 16), the pigs were fasted and fasting HP was measured. The digestible energy value was 16.0, 17.1 and 15.3 MJ/kg DM, the metabolizable energy value was 14.6, 15.5 and 13.7 MJ/kg DM and the NE value was 10.7, 11.0 and 9.4 MJ/kg DM, for the high-oil, medium-oil and low-oil corn DDGS, respectively. The NE obtained with indirect calorimetry in the present study did not differ from values calculated using previously published prediction equations.

Effect of L- or DL-methionine Supplementation on Nitrogen Retention, Serum Amino Acid Concentrations and Blood Metabolites Profile in Starter Pigs.

The objective of the current study was to evaluate the effect of supplementation of either L-methionine (L-Met) or DL-methionine (DL-Met) to diets of starter pigs on nitrogen (N) balance, metabolism, and serum amino acid profile. Eighteen crossbred (Duroc×Landrace×Yorkshire) barrows weighing 15.45±0.88 kg were randomly allotted to 1 of 3 diets with 6 pigs per treatment. The diets included a basal diet (Met-deficient diet) containing 0.24% standardized ileal digestibility Met with all other essential nutrients meeting the pig's requirements. The other two diets were produced by supplementing the basal diet with 0.12% DL-Met or L-Met. The experiment lasted for 18 days, consisting of a 13-day adaptation period to the diets followed by a 5-day experimental period. Pigs were fed ad libitum and free access to water throughout the experiment. Results showed that the supplementation of either L-Met or DL-Met improved N retention, and serum methionine concentration, and decreased N excretion compared with basal diet (p<0.01). The N retention of pigs fed diets supplemented with the same inclusion levels of DL-Met or L-Met were not different (p>0.05). In conclusion, on equimolar basis DL-Met and L-Met are equally bioavailable as Met sources for starter pigs.

Effects of Coated Compound Proteases on Apparent Total Tract Digestibility of Nutrients and Apparent Ileal Digestibility of Amino Acids for Pigs.

Two experiments were conducted to evaluate effects of coated compound proteases (CC protease) on apparent total tract digestibility (ATTD) of nitrogen (N) and energy, and apparent ileal digestibility (AID) of amino acids (AA) and nutrients in diets for pigs. In Exp. 1, 12 crossbred barrows (initial body weight: 20.14±1.71 kg) were housed in individual metabolism crates and allotted into 2 treatments with 6 piglets per treatment according to weight in a randomized complete block design. The 2 diets were corn-soybean meal basal diets with (0.2 g/kg) or without CC protease supplementation. The CC protease supplementation increased (p<0.05) the digestible and metabolizable N and energy values and the digestibility and retention rate of N in the diet. The ATTD of energy and nutrients had been improved (p<0.05) in the diet supplemented with CC protease. In Exp. 2, 12 crossbred barrows (initial body weight: 20.79±1.94 kg), fitted with T-cannulas at the distal ileum, were blocked by body weight into 2 groups with 6 pigs each. The diets were the same as those in Exp. 1. The CC protease increased (p<0.05) the AID of crude protein and some essential AA including arginine, isoleucine and leucine. The AID and ATTD of energy and nutrients had been improved (p<0.05) by supplemental CC protease, but the hindgut digestibility of nutrients was unaffected. Overall, the CC protease improved the ATTD of N and energy and AID of some indispensible AA and nutrients in the corn-soybean meal diet for pigs. Therefore, the CC protease supplement could improve the utilization of protein in the corn-soybean meal diet and thus contribute to lower N excretion to the environment.

Effect of γ-Aminobutyric Acid-producing Lactobacillus Strain on Laying Performance, Egg Quality and Serum Enzyme Activity in Hy-Line Brown Hens under Heat Stress.

Heat-stress remains a costly issue for animal production, especially for poultry as they lack sweat glands, and alleviating heat-stress is necessary for ensuring animal production in hot environment. A high γ-aminobutyric acid (GABA)-producer Lactobacillus strain was used to investigate the effect of dietary GABA-producer on laying performance and egg quality in heat-stressed Hy-line brown hens. Hy-Line brown hens (n = 1,164) at 280 days of age were randomly divided into 4 groups based on the amount of freeze-dried GABA-producer added to the basal diet as follows: i) 0 mg/kg, ii) 25 mg/kg, iii) 50 mg/kg, and iv) 100 mg/kg. All hens were subjected to heat-stress treatment through maintaining the temperature and the relative humidity at 28.83±3.85°C and 37% to 53.9%, respectively. During the experiment, laying rate, egg weight and feed intake of hens were recorded daily. At the 30th and 60th day after the start of the experiment, biochemical parameters, enzyme activity and immune activity in serum were measured. Egg production, average egg weight, average daily feed intake, feed conversion ratio and percentage of speckled egg, soft shell egg and misshaped egg were significantly improved (p<0.05) by the increasing supplementation of the dietary GABA-producer. Shape index, eggshell thickness, strength and weight were increased linearly with increasing GABA-producer supplementation. The level of calcium, phosphorus, glucose, total protein and albumin in serum of the hens fed GABA-producing strain supplemented diet was significantly higher (p<0.05) than that of the hens fed the basal diet, whereas cholesterol level was decreased. Compared with the basal diet, GABA-producer strain supplementation increased serum level of glutathione peroxidase (p = 0.009) and superoxide dismutase. In conclusion, GABA-producer played an important role in alleviating heat-stress, the isolated GABA-producer strain might be a potential natural and safe probiotic to use to improve laying performance and egg quality in heat-stressed hens.

Determination and prediction of the amino Acid digestibility of sunflower seed meals in growing pigs.

This experiment was conducted to evaluate the chemical composition and amino acid (AA) digestibility of sunflower seed meal (SFSM) and to use this data to develop prediction equations for estimating AA digestibility for growing pigs. Ten SFSM were collected from five provinces in China. Twelve barrows (38.8±4.6 kg), fitted with ileal T-cannula were allotted into two 6×6 Latin square designs. Each of six experimental periods comprised a 5-d adaption period followed by a 2-d collection of ileal digesta. The ten test diets contained 50% SFSM as the sole source of AA. Another nitrogen-free diet was used to measure the basal endogenous losses of crude protein (CP) and AA. Chromic oxide (0.3%) was used as an inert marker in each diet. There was considerable variation (CV>10%) among the ten SFSM in chemical composition (dry matter [DM]). The concentration of CP and ether extract (EE) ranged from 29.33% to 39.09% and 0.88% to 11.33%, respectively. Crude fibre (CF), neutral detergent fibre and acid detergent fibre ranged from 21.46% to 36.42%, 38.15% to 55.40%, and 24.59% to 37.34%, respectively. There was variation among the ten SFSM in apparent ileal digestibility (AID) and standardized ileal digestibility (SID) for lysine and threonine, which ranged from 63.16 to 79.21 and 55.19% to 72.04% for AID and 67.03% to 82.07% and 61.97% to 77.01% for SID, respectively. The variation in CP and methionine ranged from 60.13% to 74.72% and 74.79% to 88.60% for AID and 66.70% to 79.31% and 77.16% to 90.27% for SID, respectively. Methionine was a good indicator to predict AA digestibility. These results indicate that conventional chemical composition of SFSM was variable (CV>10%) among the ten SFSM (DM). The results of AID, SID and prediction equations could be used to evaluate the digestibility of SFSM in growing pigs.

Effect of different inclusion level of condensed distillers solubles ratios and oil content on amino Acid digestibility of corn distillers dried grains with solubles in growing pigs.

The purpose of this experiment was to determine and compare the digestibility of crude protein (CP) and amino acids (AA) in full-oil (no oil extracted) and de-oiled (oil extracted) corn distillers dried grains with solubles (DDGS) with different condensed distillers solubles (CDS) ratios. Six barrows (29.6±2.3 kg) fitted with ileal T-cannula were allotted into a 6×6 Latin square design. Each period was comprised of a 5-d adaption period followed by a 2-d collection of ileal digesta. The five test diets contained 62% DDGS as the sole source of AA. A nitrogen-free diet was used to measure the basal endogenous losses of CP and AA. Chromic oxide (0.3%) was used as an index in each diet. The results showed that CP and AA were very similar in 5 DDGS, but the standardized ileal digestibility (SID) of lysine (from 56.16% to 71.15%) and tryptophan (from 54.90% to 68.38%) had the lowest values and largest variation within the essential AA, which suggests reduced availability of AA and different levels of Maillard reactions in the five DDGS. The apparent ileal digestibility and SID of CP and most of AA in full-oil DDGS (sources 1 and 2) were greater (p<0.05) than de-oiled DDGS (sources 3, 4, and 5). Comparing the AA SID in the 5 DDGS, full-oil with low CDS ratio DDGS (source 1) had non-significantly higher values (p >0.05) than full-oil with high CDS ratio DDGS (source 2); however, the SID of most AA of de-oiled with low CDS ratios DDGS (source 3) were non-significantly lower (p>0.05) than de-oiled with high CDS ratio DDGS (source 4); and the de-oiled DDGS with middle CDS ratio (source 5) but with different drying processing had the lowest SID AA values. In conclusion, de-oiled DDGS had lower SID of CP and AA than full-oil DDGS; a higher CDS ratio tended to decrease the SID of AA in full-oil DDGS but not in de-oiled DDGS; and compared with CDS ratio, processing, especially drying, may have more of an effect on AA digestibility of DDGS.

Forsythia suspensa extract attenuates corticosterone-induced growth inhibition, oxidative injury, and immune depression in broilers.

Forsythia suspensa extract (FSE) has been demonstrated to attenuate physiological stress induced by high temperature or high stocking density. This experiment was conducted with 144 male Arbor Acre broilers (1-d-old, weighing 42.7 ± 1.7 g) to determine the effects of FSE on performance, nutrient digestibility, antioxidant activities, serum metabolites, and immune parameters for birds treated with corticosterone (CS). The birds were randomly allotted to 1 of 4 treatments in a 2 × 2 factorial arrangement that included FSE supplementation (0 or 100 mg/kg) and CS administration (0 or 20 mg/kg of diet for 7 consecutive days starting on d 14). The feeding program consisted of a starter diet from d 1 to 21 and a finisher diet from d 22 to 42. Corticosterone administration decreased (P < 0.01) ADG and impaired (P < 0.01) feed conversion ratio in both phases and overall, which were alleviated (P < 0.01) by dietary FSE supplementation in the finisher phase and overall. At d 21, CS administration caused decreases (P < 0.05) in the apparent digestibility of energy, relative weight of bursa and thymus, total antioxidant capacity, superoxide dismutase (SOD) activity, and antibody titers to Newcastle disease virus (NDV); however, serum malondialdehyde and uric acid were increased. All of these changes were attenuated (P < 0.05) by dietary FSE supplementation. At d 42, FSE supplementation improved (P < 0.05) the apparent digestibility of DM and CP, relative weights of bursa, SOD activity, and antibody titers to NDV, which were impaired by CS administration. Interactions (P < 0.05) were noted between CS and FSE for ADG and feed conversion ratio in the finisher phase and overall, as well as total antioxidant capacity, SOD activity, uric acid, and antibody titers to NDV at d 21, as well as relative weights of thymus at d 42. In conclusion, dietary FSE supplementation enhanced nutrient digestibility and performance of broiler possibly by reducing oxidative stress and immune depression challenged by CS.

Determination and prediction of digestible and metabolizable energy from the chemical composition of chinese corn gluten feed fed to finishing pigs.

Two experiments were conducted to determine the digestible energy (DE) and metabolizable energy (ME) contents of corn gluten feed (CGF) for finishing pigs and to develop equations predicting the DE and ME content from the chemical composition of the CGF samples, as well as validate the accuracy of the prediction equations. In Exp. 1, ten CGF samples from seven provinces of China were collected and fed to 66 finishing barrows (Duroc×Landrace×Yorkshire) with an initial body weight (BW) of 51.9±5.5 kg. The pigs were assigned to 11 diets comprising one basal diet and 10 CGF test diets with six pigs fed each diet. The basal diet contained corn (76%), dehulled soybean meal (21%) and premix (3%). The ten test diets were formulated by substituting 25% of the corn and dehulled soybean meal with CGF and contained corn (57%), dehulled soybean meal (15.75%), CGF (24.25%) and premix (3%). In Exp. 2, two additional CGF sources were collected as validation samples to test the accuracy of the prediction equations. In this experiment, 18 barrows (Duroc×Landrace×Yorkshire) with an initial BW of 61.1±4.0 kg were randomly allotted to be fed either the basal diet or two CGF containing diets which had a similar composition as used in Exp. 1. The DE and ME of CGF ranged from 10.37 to 12.85 MJ/kg of dry matter (DM) and 9.53 to 12.49 MJ/kg of DM, respectively. Through stepwise regression analysis, several prediction equations of DE and ME were generated. The best fit equations were: DE, MJ/kg of DM = 18.30-0.13 neutral detergent fiber-0.22 ether extract, with R(2) = 0.95, residual standard deviation (RSD) = 0.21 and p<0.01; and ME, MJ/kg of DM = 12.82+0.11 Starch-0.26 acid detergent fiber, with R(2) = 0.94, RSD = 0.20 and p<0.01. These results indicate that the DE and ME content of CGF varied substantially but the DE and ME for finishing pigs can be accurately predicted from equations based on nutritional analysis.

Effects of Adding Super Dose Phytase to the Phosphorus-deficient Diets of Young Pigs on Growth Performance, Bone Quality, Minerals and Amino Acids Digestibilities.

Two experiments were conducted to evaluate the efficacy of feeding an Escherichia coli (E. coli) derived phytase to pigs fed P deficient, corn-soybean meal diets. In Exp. 1, one hundred and twenty crossbred piglets (9.53±0.84 kg) were allocated to one of five treatments which consisted of four low P diets (0.61% Ca, 0.46% total P and 0.24% non-phytate P) supplemented with 0, 500, 1,000, or 20,000 FTU/kg E. coli phytase as well as a positive control formulated to be adequate in all nutrients (0.77% Ca, 0.62% total P and 0.42% non-phytate P). The treatments were applied to six pens with four pigs per pen for 28 days. In Exp. 2, ten crossbred pigs (19.66±1.16 kg) fitted with ileal T-cannula were used in a nutrient balance study. The pigs were assigned to treatments similar to those used in Exp. 1 in a doubly replicated 5×4 incomplete Latin square design (5 diets with 4 periods). Each period consisted of a 5-d adjustment period followed by a 3-d total collection of feces and urine and then a 2-d collection of ileal digesta. Supplementation with phytase linearly increased (p<0.05) weight gain, feed intake, feed efficiency, bone breaking strength and fat-free dry and ash bone weight. There were linear increases (p<0.01) in the apparent ileal digestibility (AID) of DM, GE, CP, Ca, total P, inositol hexaphosphate (IP6) and some AA with increasing dose of E. coli phytase. Pigs fed 20,000 FTU/kg had a greater (p<0.05) AID of IP6 (80% vs 59% or 64%, respectively) than pigs fed diets with 500 or 1,000 FTU/kg phytase. There were linear increases (p<0.05) in the total tract digestibility of Ca, total P, Na, K, Mg, and Zn as well as in the retention of Mg and Zn with increased phytase dose. The retention and utilization of Cu, and the total tract digestibility of CP and Cu quadratic increased (p<0.05) with increased phytase dose. In conclusion, supplementation of 500 FTU of phytase/kg and above effectively hydrolyzed phytate in low-P corn-soybean diets for pigs. In addition, a super dose of phytase (20,000 FTU/kg) hydrolyzed most of the IP6 and consequently further improved mineral use, protein utilization and performance.

Energy and ileal digestible amino Acid concentrations for growing pigs and performance of weanling pigs fed fermented or conventional soybean meal.

A new strategy of co-inoculating Bacillus subtilis MA139 with Streptococcus thermophilus and Saccharomyces cerevisiae was used to produce fermented soybean meal (FSBM). Three experiments were conducted to determine the concentration of digestible energy (DE) and metabolizable energy (ME) (Exp. 1), apparent ileal digestibility (AID) and standardized ileal digestibility (SID) of amino acids (AA) (Exp. 2), and feeding value (Exp. 3) of FSBM produced by this new strategy (NFSB) compared with soybean meal (SBM) and conventionally available FSBM (Suprotein). In Exp. 1, twenty-four barrows (initial body weight [BW] of 32.2 ±1.7 kg) were randomly allotted to 1 of 4 diets with 6 replicates per diet. A corn basal diet and 3 diets based on a mixture of corn and 1 of 3 soybean products listed above were formulated and the DE and ME contents were determined by the difference method. The results showed that there were no differences in DE and ME between SBM and either FSBM product (p>0.05). In Exp. 2, eight barrows (initial BW of 26.8±1.5 kg) were fitted with ileal T-cannulaes and used in a replicated 4×4 Latin square design. Three corn-starch-based diets were formulated using each of the 3 soybean products as the sole source of AA. A nitrogen-free diet was also formulated to measure endogenous losses of AA. The results showed that the SID of all AA except arginine and histidine was similar for NFSB and SBM (p>0.05), but Suprotein had greater (p<0.05) SID of most AA except lysine, aspartate, glycine and proline than NFSB. In Exp. 3, a total of 144 piglets (initial BW of 8.8±1.2 kg) were blocked by weight and fed 1 of 4 diets including a control diet with 24% SBM as well as diets containing 6% and 12% NFSB or 12% Suprotein added at the expense of SBM. During d 15 to 28, replacing SBM with 6% NFSB significantly improved average daily gain (ADG) and average daily feed intake (ADFI) (p<0.05) for nursery piglets. During the overall experiment, ADG of piglets fed diets containing 6% NFSB was significantly greater (p<0.05) than that of piglets fed SBM. In conclusion, fermentation with the new strategy did not affect the energy content or the AID and the SID of AA in SBM. However, inclusion of 6% NFSB in diets fed to nursery piglets improved performance after weaning likely as a result of better nutritional status and reduced immunological challenge.

The effects of Forsythia suspensa extract and berberine on growth performance, immunity, antioxidant activities, and intestinal microbiota in broilers under high stocking density.

A 42-d experiment was conducted with 276 Arbor Acres broilers (1 d of age, weighing 41.1 ± 1.5 g) to determine the effects of Forsythia suspensa extract (FSE) and berberine (BE) on growth performance, immunity, antioxidant activities, and intestinal microbiota stocked at high stocking density (28 kg of BW/m(2) as the normal density, 46 kg of BW/m(2) as the high density). The feeding program consisted of a starter diet from d 1 to 21 of age and a finisher diet from d 22 to 42. Dietary treatments included (1) negative control group (NC), stocked at high density; (2) positive control group (PC), stocked at normal density; (3) FSE, NC + 100 mg/kg of FSE; (4) BE, NC + 100 mg/kg of BE; and (5) FSE + BE, NC + 100 mg/kg of FSE + 100 mg/kg of BE. Birds had free access to diets and water. Body weight and feed intake were measured at d 21 and 42. Blood, spleen and bursa, and intestinal contents were collected at d 42 for analysis. The results showed that growth performance did not differ among treatments in the starter period; however, in the finisher and overall periods, birds in FSE + BE, FSE, BE, and PC had greater final BW, ADG, and ADFI than the birds in NC (P < 0.05). The birds in FSE + BE, FSE, BE, and PC had greater bursa weight, bursa weight/BW ratio, serum total antioxidant capacity, and superoxide dismutase activity than birds in NC (P < 0.05). The FSE + BE, FSE, and BE birds had lower serum malondialdehyde level than NC birds (P < 0.05). The FSE + BE, FSE, BE, and PC birds had lower counts of Escherichia coli but greater Lactobacillus in the cecum than that of NC birds (P < 0.05). Dietary supplementation with FSE, BE, or both can improve the growth performance possibly by enhancing immunity, reducing oxidative stress, and promoting intestinal colonization by healthy microbiota of broilers under high stocking density.

Effects of Supplementation of ß-Mannanase in Corn-soybean Meal Diets on Performance and Nutrient Digestibility in Growing Pigs.

A total of 288 crossbred (Duroc×Landrace×Yorkshire) growing pigs were used in two experiments to investigate the effects of adding ß-mannanase to corn-soybean meal-based diets on pig performance and apparent total tract digestibility (ATTD). Both experiments lasted 28 d and were split into two phases namely 1 to 14 days (phase 1) and 15 to 28 days (phase 2). In Exp. 1,144 pigs weighing 23.60±1.59 kg BW were assigned to one of four corn-soybean meal-based diets containing 0, 200, 400 or 600 U/kg ß-mannanase. Increasing the level of ß-mannanase increased weight gain (quadratic effect; p<0.01) and feed efficiency (linear and quadratic effect; p<0.01) during the second phase and the overall experiment. However, performance was unaffected (p>0.05) by treatment during phase 1. Increasing the amount of ß-mannanase in the diet improved (linear and quadratic effect; p<0.05) the ATTD of CP, NDF, ADF, calcium, and phosphorus during both phases. Based on the results of Exp. 1, the optimal supplementation level was determined to be 400 U/kg and this was the level that was applied in Exp. 2. In Exp. 2, 144 pigs weighing 23.50±1.86 kg BW were fed diets containing 0 or 400 U/kg of ß-mannanase and 3,250 or 3,400 kcal/kg digestible energy (DE) in a 2×2 factorial design. ß-Mannanase supplementation increased (p<0.01) weight gain and feed efficiency while the higher energy content increased (p<0.01) feed intake and feed efficiency during both phases and overall. Increased energy content and ß-mannanase supplementation both increased (p<0.05) the ATTD of DM, CP, NDF, ADF, phosphorus, and GE during both phases. There were no significant interactions between energy level and ß-mannanase for any performance or digestibility parameter. In conclusion, the ß-mannanase used in the present experiment improved the performance of growing pigs fed diets based on corn and soybean. The mechanism through which the improvements were obtained appears to be related to improvements in ATTD.

The Metabolizable Energy Value, Standardized Ileal Digestibility of Amino Acids in Soybean Meal, Soy Protein Concentrate and Fermented Soybean Meal, and the Application of These Products in Early-weaned Piglets.

Three experiments were conducted to evaluate the metabolizable energy (ME) value, standardized ileal digestibility (SID) of amino acids (AA) of soybean meal (SBM), soy protein concentrate (SPC) and fermented soybean meal (FSBM), and the application of these products in early-weaned piglets. In Exp. 1, four barrows with initial body weight (BW) of 14.2±1.4 kg were used in a 4×4 Latin square design. The diet 1 contained corn as the only energy source. The other three diets replaced 25% of corn in diet 1 with one of the three soybean products, and the digestable energy (DE) and ME contents were determined by difference. In Exp. 2, four barrows (initial BW of 18.2±1.5 kg) were fitted with ileal T-cannulas and allotted to a 4×4 Latin square design. Three cornstarch-based diets were formulated using each of the soybean products as the sole source of AA. A nitrogen-free diet was also formulated to measure endogenous losses of AA. In Exp. 3, ninety six piglets (initial BW of 5.6±0.9 kg) weaned at 21±2 d were blocked by weight and assigned to one of three treatments for a 21-d growth performance study. The control diet was based on corn and SBM, the two treatments' diets contained either 10% SPC or FSBM and were formulated to same SID lysine to ME ratio of 3.6 g/Mcal. The results showed that the ME content of SPC was greater than SBM (p<0.05). The SID of most AA in SPC was greater than the SID of AA in SBM (p<0.05). For the essential AA, the SID of histidine, isoleucine, leucine, lysine and threonine in FSBM were greater than in SBM (p<0.05). Even though they were fed same SID lysine to ME ratio of 3.6 g/Mcal diets, pigs fed SPC and FSBM diets had greater weight gain, G:F (p<0.05) and better fecal score (p<0.05) than pigs fed SBM diet. In conclusion, SPC showed a higher ME content and SID of AA than the SBM. SID of some essential AA in FSBM was higher than SBM and was similar with SPC. But the lower antigenic proteins and anti-nutritional factors content in SPC and FSBM may be the main factors affecting the performance of early-weaned piglets rather than the increased ME content and SID of AA.

Effects of single cell protein replacing fish meal in diet on growth performance, nutrient digestibility and intestinal morphology in weaned pigs.

Three experiments were conducted to evaluate the ME value, standardized ileal digestibility (SID) of amino acids (AA) of fish meal, and the effects of single cell protein (Prosin and Protide) replacing fish meal in diet on growth performance, nutrient digestibility and intestinal morphology in weaned piglets. In Exp. 1, twenty-four barrows with initial BW of 30.8±2.6 kg were allotted to one of four dietary treatments. Diet 1 contained corn as the only energy source. The other three diets replaced 20% of the corn in diet 1 with one of the three protein feeds (fish meal, Prosin and Protide), and the DE and ME contents were determined by difference. In Exp. 2, eight barrows (initial BW of 25.6±3.2 kg) were fitted with ileal T-cannulas and allotted to a replicated 4×4 Latin square design. Three cornstarch-based diets were formulated using each of the protein feeds as the sole source of AA. A nitrogen-free diet was also formulated to measure endogenous losses of AA. In Exp. 3, one hundred and eighty piglets (initial BW of 7.95±1.59 kg) weaned at 28±2 d were blocked by weight and assigned to one of five treatments for a 28-d growth performance study, each treatment was fed to six pens with six pigs (three barrows and three gilts) per pen. The five treatments consisted of the control group (CON), which was a corn-soybean meal diet containing 5% fish meal, and the other four treatments, which replaced a set amount of fish meal with either Prosin (2.5% or 5%) or Protide (2.5% or 5%). The diets were formulated to provide same nutrient levels. The results showed that on a DM basis, both of the DE and ME contents were lower in Prosin and Protide than that of fish meal (p<0.05). The SID of CP and all essential AA were greater in fish meal than in Prosin and Protide (p<0.05). The pigs fed CON diet had greater weight gain and lower feed conversion rate (FCR) than pigs fed 5% Prosin and 5% Protide diets (p<0.05). The digestibility of CP was greater in pigs fed CON, 2.5% Prosin and 2.5% Protide diets than the pigs fed 5% Prosin and 5% Protide diets (p<0.05). Villus height in jejunum and ileum, and villus height to crypt depth ratio in the jejunum were higher (p<0.05) in pigs fed CON, 2.5% Prosin and 2.5% Protide diets compared with the 5% Prosin and 5% Protide diets. Pigs fed CON diet had greater villus height to crypt depth ratio in the ileum than the pigs fed 5% Prosin and 5% Protide diets (p<0.05). In conclusion, although Prosin and Protide contained lower ME content and SID of AA than fish meal, Prosin and Protide replacing 50% of fish meal in diet with identical nutrient levels could obtain similar performance, nutrient digestibility and intestinal morphology in weaned pigs.

The effects of enzyme complex on performance, intestinal health and nutrient digestibility of weaned pigs.

Two experiments were conducted to evaluate the effect of supplementing a corn-soybean meal-based diet with an enzyme complex containing amylase, protease and xylanase on the performance, intestinal health, apparent ileal digestibility of amino acids and nutrient digestibility of weaned pigs. In Exp. 1, 108 piglets weaned at 28 d of age were fed one of three diets containing 0 (control), 100, or 150 ppm enzyme complex for 4 wks, based on a two-phase feeding program namely 1 to 7 d (phase 1) and 8 to 28 d (phase 2). At the end of the experiment, six pigs from the control group and the group supplemented with 150 ppm enzyme complex were chosen to collect digesta samples from intestine to measure viscosity and pH in the stomach, ileum, and cecum, as well as volatile fatty acid concentrations and composition of the microflora in the cecum and colon. There were linear increases (p<0.01) in weight gain, gain: feed ratio and digestibility of gross energy with the increasing dose rate of enzyme supplementation during the whole experiment. Supplementation with enzyme complex increased the digesta viscosity in the stomach (p<0.05) and significantly increased (p<0.01) the concentrations of acetic, propionic and butyric acid in the cecum and colon. Enzyme supplementation also significantly increased the population of Lactobacilli (p<0.01) in the cecum and decreased the population of E. coli (p<0.05) in the colon. In Exp. 2, six crossbred barrows (initial body weight: 18.26±1.21 kg), fitted with a simple T-cannula at the distal ileum, were assigned to three dietary treatments according to a replicated 3×3 Latin Square design. The experimental diets were the same as the diets used in phase 2 in Exp. 1. Apparent ileal digestibility of isoleucine (p<0.01), valine (p<0.05) and aspartic acid (p<0.05) linearly increased with the increasing dose rate of enzyme supplementation. In conclusion, supplementation of the diet with an enzyme complex containing amylase, protease and xylanase improved piglet performance. This is likely a result of improvement in nutrient digestibility, volatile fatty acid concentrations and bacteria ratio in the large intestine.

Predicting the Digestible Energy of Rapeseed Meal from Its Chemical Composition in Growing-finishing Pigs.

Two experiments were conducted to establish a digestible energy (DE) content prediction model of rapeseed meal for growing-finishing pig based on rapeseed meal's chemical composition. In experiment 1, observed linear relationships between the determined DE content of 22 rapeseed meal calibration samples and proximate nutrients, gross energy (GE) and neutral detergent fiber (NDF) were used to develop the DE prediction model. In experiment 2, 4 samples of rapeseed meal selected at random from the primary rapeseed growing regions of China were used for testing the accuracy of DE prediction models. The results indicated that the DE was negatively correlated with NDF (r = -0.86) and acid detergent fiber (ADF) (r = -0.73) contents, and moderately correlated with gross energy (GE; r = 0.56) content in rapeseed meal calibration samples. In contrast, no significant correlations were found for crude protein, ether extract, crude fiber and ash contents. According to the regression analysis, NDF or both NDF and GE were found to be useful for the DE prediction models. Two prediction models: DE = 16.775-0.147×NDF (R(2) = 0.73) and DE = 11.848-0.131×NDF+0.231×GE (R(2) = 0.76) were obtained. The maximum absolute difference between the in vivo DE determinations and the predicted DE values was 0.62 MJ/kg and the relative difference was 5.21%. Therefore, it was concluded that, for growing-finishing pigs, these two prediction models could be used to predict the DE content of rapeseed meal with acceptable accuracy.

Prediction of digestible and metabolizable energy content and standardized ileal amino Acid digestibility in wheat shorts and red dog for growing pigs.

Two experiments were conducted to evaluate the effects of chemical composition of wheat shorts and red dog on energy and amino acid digestibility in growing pigs and to establish prediction models to estimate their digestible (DE) and metabolizable (ME) energy content and as well as their standardized ileal digestible (SID) amino acid content. For Exp. 1, sixteen diets were fed to thirty-two growing pigs according to a completely randomized design during three successive periods. The basal diet was based on corn and soybean meal while the other fifteen diets contained 28.8% wheat shorts (N = 7) or red dog (N = 8), added at the expense of corn and soybean meal. Over the three periods, each diet was fed to six pigs with each diet being fed to two pigs during each period. The apparent total tract digestibility (ATTD) of energy in wheat shorts and red dog averaged 75.1 and 87.9%. The DE values of wheat shorts and red dog averaged 13.8 MJ/kg (range 13.1 to 15.0 MJ/kg) and 15.1 MJ/kg (range 13.3 to 16.6 MJ/kg) of dry matter, respectively. For Exp. 2, twelve growing pigs were allotted to two 6×6 Latin Square Designs with six periods. Ten of the diets were formulated based on 60% wheat shorts or red dog and the remaining two diets were nitrogen-free diets based on cornstarch and sucrose. Chromic oxide (0.3%) was used as an indigestible marker in all diets. There were no differences (p>0.05) in SID values for the amino acids in wheat shorts and red dog except for lysine and methionine. Apparent ileal digestibility (AID) and SID values for lysine in different sources of wheat shorts or red dog, which averaged 78.1 and 87.8%, showed more variation than either methionine or tryptophan. A stepwise regression was performed to establish DE, ME and amino acid digestibility prediction models. Data indicated that fiber content and amino acid concentrations were good indicators to predict energy values and amino acid digestibility, respectively. The present study confirms the large variation in the energy content and amino acid digestibility in wheat shorts and red dog, and describes the factors that influence this variation and presents equations based on chemical composition that could probably be used to predict the DE and ME values as well as the amino acid digestibility of wheat shorts and red dog.

Forsythia suspensa Extract Has the Potential to Substitute Antibiotic in Broiler Chicken.

Two experiments were conducted to investigate the potential for Forsythia suspensa extract (FSE) to substitute for antibiotic in broiler chicken. First, a well-diffusion assay procedure and a 2-fold dilution method were used to determine the bacteriostatic activity of FSE on Escherichia coli K88, staphylococcus aureus, and salmonella was assayed. An inhibitory effect of FSE was observed on the growth of these bacteria. This effect seems to be dose depended, which disappeared after 25.00, 12.50, 1.56 mg/ml. Second, a 42-d trial with 252 broiler chickens (d 1, 38.7±1.1 g BW) was conducted to evaluate the effect of dietary supplementation of FSE in broiler chicken. The feeding program consisted of a starter diet from d 1 to 21 and a finisher diet from d 22 to 42. Dietary treatments included were: i) NC: negative control fed a corn-soybean meal based diet; ii) PC: positive control group fed based diet with chlortetracycline; and iii) FC: a test group fed with 100 mg FSE/kg diet. In this study growth performance did not differ among treatments during the starter period. However, dietary supplemental chlortetracycline and FSE increased (p<0.05) average daily gain (ADG), average daily feed intake (ADFI) compared with NC during the finisher and overall phase. Apparent digestibility of calcium on d 21, digestibility of energy and calcium on d 42 of FC was greater (p<0.05) than NC. Moreover, cecal Escherichia coli counts for birds from FC were lower (p<0.05) than NC. Dietary FSE supplementation also improved (p<0.05) villus height and villus height to crypt depth ratios in both duodenum and ileum and decreased (p<0.05) crypt depth in the duodenum. Duodenum villus height and villus height to crypt depth ratio in both duodenum and ileum from the FC group were also greater (p<0.05). Serum growth hormone and IGF-1 were not influenced by different treatments. Apparently, FSE has the potential to substitute for antibiotic in broiler chicken.

Effects of natural capsicum extract on growth performance, nutrient utilization, antioxidant status, immune function, and meat quality in broilers.

This research was conducted to determine the effects of natural capsaicin extract (NCE) as an alternative to the antibiotic (chlortetracycline, CTC) on growth performance, antioxidant capacity, immune function, and meat quality of broiler chickens. A total of 168 one-day-old Arbor Acre male broiler chickens with an average weight of 46.4 ± 0.6 g were randomly allotted to 3 dietary treatments, with 7 replicates per treatment and 8 broilers per pen. These 3 dietary treatments included a corn-soybean meal basal diet (CON), a basal diet + 75 mg/kg CTC (CTC), and a basal diet + 80 mg/kg NCE (NCE). Broilers from the NCE group showed higher average daily gain compared to broilers from the CON group at all stages (P < 0.05). On d 42, NCE supplementation improved dietary nitrogen-corrected apparent metabolizable energy compared to nonsupplemented or CTC-supplemented diets (P < 0.05). The digestibility of organic matter and crude protein were higher in the NCE diet than in the CON or CTC diets (P < 0.05). Higher relative weight of bursa of Fabricius was observed in broilers fed NCE diets compared with CON (P < 0.05). Pancreatic trypsin and lipase activities were significantly increased in the NCE group compared with those in the CON group (P < 0.05). The value of lightness (L*) of breast muscles from broilers fed NCE diets was significantly lower compared to those fed CON diets (P < 0.05). Broilers fed NCE diets also had higher levels of serum total antioxidant capacity, glutathione peroxidase, superoxide dismutase, and lower levels of interleukin-1ß, and tumor necrosis factor-α compared with broilers fed CON diets (P < 0.05). The liver catalase activity of broilers was also significantly increased in the NCE group than the CON group (P < 0.05). In addition, broilers from NCE group had lower concentrations of serum urea-N, low-density lipoprotein cholesterol, and total cholesterol, and higher concentration of growth hormone compared with those from the CON group (P < 0.05). Therefore, we concluded that supplementation of 80 mg/kg of NCE in diets could improve growth performance, nutrient digestibility, antioxidant status, immune function, and meat quality in broilers.

The effects of berberine on the magnitude of the acute inflammatory response induced by Escherichia coli lipopolysaccharide in broiler chickens.

One hundred twenty-six 19-d-old male broiler chickens were used to determine the effects of berberine on the magnitude of the acute inflammatory response induced by Escherichia coli lipopolysaccharide (LPS). The birds were weighed and randomly allotted to 1 of 3 treatments at d 19 (3 treatments x 7 replicates x 6 birds). The treatments comprised a control group in which saline was injected at d 21, an LPS-treated group in which LPS (3 mg/kg of BW) was injected at d 21, and finally a berberine and LPS-treated group in which berberine (15 mg/kg of BW) was orally administered from d 19 to d 24 with LPS injection (3 mg/kg of BW) at d 21. Injection of LPS alone decreased (P < 0.01) weight gain, feed intake, and feed conversion compared with the control and the berberine-administered group. Relative liver weight was increased (P < 0.05) in the LPS-treated group 72 h postinjection compared with the control and the berberine-treated group. Total counts of white blood cells and lymphocytes were also increased (P < 0.05) in the LPS-treated group 72 h postinjection. The heterophil concentration of the LPS-treated group was greater (P < 0.05) than that of both the control and the berberine-administered group 24 h postinjection. Broilers in the LPS-treated group had greater (P < 0.05) total serum protein compared with birds in the control and the berberine-administered group both 24 and 72 h postinjection. In addition, the plasma interleukin-6 level of the LPS-treated group was significantly elevated (P < 0.01) at 24 h compared with that of the control and the berberine-administered group. Our results indicate that LPS injection initiated a series of physiological changes typical of an acute phase response in broiler chickens. These effects were largely mitigated by oral administration of berberine.