RESUMO
Repurposed used cooking oil is a sustainable alternative to other feedstocks for biodiesel production offering enviro-economic benefits. Residual crude glycerol (RCG) from such biodiesel production plants is difficult to utilize due to presence of numerous toxic impurities with various inhibitory effects on biological fermentative reforming process. However, it is a new industrial feedstock for bio-based production of 1,3-propanediol. In this work, a new Clostridium butyricum strain L4 was isolated from biogas reactor leachate after rigorous adaption and 35 subcultures under increasing stress conditions and studied for green production of 1,3-propanediol (PDO) from RCG and further process development. Evaluation of fermentative reforming kinetics was performed and the optimal reaction conditions are pH 7.0, temperature 30 °C, 2 g yeast extract/L and 15 g ammonium sulphate/L. Glycerol-glucose co-fermentation (10:1) enhanced cell growth and thus, PDO output by 11.6 g/L. In comparison to batch fermentation (24.8 g PDO/L; 0.58 mol PDO/mol glycerol) there was 2.8-fold improvement with fed-batch process resulting in accumulation of 70.1 g PDO/L (Yield = 0.65 mol PDO/mol glycerol) using the studied biocatalyst in 150 h. In order to predict yields under different operational conditions a multiple linear regression model was developed (r2 = 0.783) with six independent variables (p < 0.05), where biomass (g/L) and temperature (oC) were forecasted as top contributors to PDO yield. Finally, this biocatalyst appears as a potential candidate for industrial use due to its non-pathogenic nature, ability to grow in wide pH and temperature conditions, tolerance to high substrate and product concentration, insignificant generation of by-products and Coenzyme B12 independent biotransformation. The study can add value to bio-utilization of RCG to produce green 1,3-propanediol.
Assuntos
Clostridium butyricum , Fermentação , Glicerol , PropilenoglicóisRESUMO
The present study provides an integrated method for utilizing the wastewaters from second generation (2G) ethanol pretreatment plant for microalgal biomass and lipid production. The study was conducted using a mixture of wastewaters (referred as MW; pH 4.3) generated after washing of acidic and alkaline-soaked lignocellulosic biomass prior to pretreatment process. The growth studies indicated that the thermotolerant strain of Chlorella pyrenoidosa (C. pyrenoidosa) M18 exhibited higher cell proliferation in wastewater as compared to freshwater. About 20-25% enhancement in biomass (509 mg L-1 d-1 ± 3.09) and lipid productivity (146 mg L-1 d-1 ± 1.34) was observed in MW. The total chlorophyll content and variable fluorescence by maximum fluorescence (Fv/Fm) ratio of strain cultivated in MW were 10.32 µg mL-1 and 0.75, respectively. The use of MW also enhanced the content of saturated and monounsaturated fatty acids in total lipid. The exhausted wastewater medium obtained after harvesting the auto-flocculated biomass was also reused up to three successive growth cycles. The recycled medium without any nutrient addition could be used for two subsequent rounds with enhanced biomass (520 mg L-1 d-1 ± 4.07) and lipid (157.71 mg L-1 d-1 ± 1.09) productivities. This synergistic approach of cultivating thermotolerant microalgae with wastewater from 2G pretreatment plant provides an economical setup for development of commercial algal biofuel technology.