Influence of calcium concentration on the re-assembly of sodium caseinate into casein micelles and on their renneting behavior.

Inducing the spontaneous aggregation from casein molecules (i.e. αs1, αs2, ß, and κ-casein) into re-assembled casein micelles (RCMs) through the addition of salts as an alternative to native casein micelles, has garnered increasing attention in recent years. In this investigation, re-assembled casein micelles were generated by adding varying amounts of calcium, phosphate, and citrate ions to a sodium caseinate dispersion. The formed micelles were further characterized in terms of particle size, optical density, and partitioning of calcium ions and caseins. Besides, their small-angle X-ray scattering (SAXS) profiles and renneting properties were evaluated. The observations revealed that the particle size and optical density of RCMs increased with the continuous addition of salts, while the micellar yield improved and could exceed 85 %. Moreover, the quantity of individual casein molecules that contributed to the creation of micelles was in concordance with their level of phosphorylation (i.e. αs2-casein > αs1-casein > ß-casein > κ-casein). Mineral analysis results and SAXS scattering profiles confirmed that the added calcium ions acted as cross-linkers and participated in the construction of calcium phosphate nanoclusters. The renneting ability of RCMs was primarily dependent upon the colloidal calcium content per gram of micellar casein.

Rheo-NMR to investigate fat crystallization under shear.

It is well known that shear has an effect on fat crystallization. Whereas rheo-NMR has been used to study the impact of shear on the crystallization kinetics in the past, these methods mostly used a simple Teflon mixing shaft inside a sophisticated NMR instrument to apply shear to the sample. However, this method did not enable the determination of rheological parameters. In this work, a custom made low-field rheo-NMR device was evaluated, consisting of a commercial rheometer combined with a low-field permanent magnet to enable simultaneous rheological and NMR measurements. Two fats, i.e. partially hardened sunflower oil (PHSO) and soft palm mid fraction (sPMF), were submitted to several rheo-NMR experiments. The results of these experiments clearly indicated that these fats crystallized differently. First, PHSO crystallized faster than sPMF. Moreover, the latter seemed to crystallize in two steps. Initially a weak structure was formed when a low amount of solids was present, but this structure was replaced by a stronger network once more crystals were present. Both fats were studied under stagnant conditions, but also when submitted to low shear rates (1 s-1 and 5 s-1). It was shown that the amount of solids necessary to obtain a viscosity of 10 â€‹Pa â€‹s was higher when the shear rate was higher. The strength of the formed crystal network at a given percentage of solids was also weaker as the shear rate during crystallization increased. Whereas these experiments were done non-isothermally, it was shown that rheo-NMR can also perfectly be used for isothermal measurements.