RESUMO
A United States Government (USG) interagency group, the Filovirus Animal Non-Clinical Group (FANG), has been established to support the development of biodefense medical countermeasures (MCMs). As both vaccines and therapeutics are licensed using "non-traditional pathways", such as the U.S. Food and Drug Administration's (FDA) Animal Rule (AR), non-human primate (NHP) models and associated assays have been developed and standardized across BSL4 testing sites to evaluate candidate products. Vaccine candidates are evaluated using these NHP models, and through this public-private partnership, a meta-analysis of NHP control data has been conducted and submitted to the FDA as a master file. This is an example of how existing NHP control data can be leveraged in lieu of conducting separate natural history studies at multiple testing facilities to demonstrate the consistency of a standardized animal model for vaccine development. As a result, animal use can be minimized and the duplication of effort avoided, thus reducing the amount of time needed to conduct additional studies, as well as the cost of vaccine candidate development. This successful strategy may be applied to other pathogens of high consequence for vaccine development, and shows how strategic preparedness for biodefense can be leveraged in response to outbreaks and public health emergencies.
RESUMO
Recombinant structural proteins (VP1 and VP2) of the human parvovirus B19 have been expressed simultaneously using the baculovirus expression system to form virus-like particles (VLPs) that have potential use as vaccines. In this study, we report optimization of extraction conditions to recover these VLPs from cell paste. Under hypotonic conditions with neutral pH these VLPs were poorly extracted (up to 3% extraction). Addition of reducing agents, detergents, salts, and sonication did not improve the extractability. While screening for conditions to improve the extractability of the VLPs, we discovered that a combination of higher pH and elevated processing temperature significantly increased the extraction. Whereas increasing pH alone increased extractability from 3% to 6% (pH increased from 8.0 to 9.5), the effect of elevated temperature was much more substantial. At 50 degrees C, we observed the extraction to be more than fivefold higher than that at room temperature (up to 25% extracted at pH 9.0). The kinetics of extraction at elevated temperatures showed a rapid initial rate of extraction (on the order of minutes) followed by a plateau. In addition, we compared the extraction of VP1 expressed alone. VP1 expressed alone is incapable of forming VLPs. We observed that non-VLP VP1 was easily extractable (up to 60% extracted) under conditions in which the VP1 + VP2 VLPs were not extractable. From these studies we conclude that parvovirus B19 structural proteins expressed to form VLPs have a hindered extractability as compared with non-VLP protein. This hindrance to extraction can be significantly reduced by processing at elevated temperatures and an increased pH, possibly due to the enhanced rates of solubilization and diffusion.