Use of dairy industry side-stream lactose for tablet manufacturing - proof of concept study.

During recent years there have been shortages of certain drugs due to problems in raw material supply. These are often related to active ingredients but could also affect excipients. Lactose is one of the most used excipients in tableting and comes in two anomeric and several solid-state forms. The aim of this study was to utilize lactose from a dairy side-stream and compare it against a commercial reference in direct compression. This would be a sustainable option and would secure domestic availability during crises. Two types of lactose, spray-dried and freeze-dried, were evaluated. Lactose was mixed with microcrystalline cellulose in different ratios together with lubricant and glidant, and flowability and tabletability of the formulations was characterized. The fully amorphous and small particle-sized spray-dried lactose flowed inadequately but exhibited good tabletability. The larger particle-sized, freeze-dried lactose exhibited sufficient flow and better tabletability than the commercial reference. However, disintegration and drug release were slower when using the investigational lactose formulations. This was most likely due to remaining milk proteins, especially caseins, in the lactose. Overall, the investigational lactose provides promise for the use of such a side-stream product during crisis situations but enhancing their properties and/or purity would be needed.

Influence of long term nitrogen limitation on lipid, protein and pigment production of Euglena gracilis in photoheterotrophic cultures.

Nitrogen limitation is considered a good strategy for enhancement of algal lipid production while conversely N repletion has been shown to result in biomass rich in proteins. In this study, the influence of long-term N limitation on Euglena gracilis fatty acid (FA), protein, chlorophyll a, and carotenoid concentrations was studied in N limited cultures. Biomass composition was analyzed from three-time points from N starved late stationary phase cultures, exposed to three different initial N concentrations in the growth medium. Total lipid content increased under N limitation in ageing cultures, but the low N content and prolonged cultivation time resulted in the formation of a high proportion of saturated FAs. Furthermore, growth as well as the production of proteins, chlorophyll a and carotenoids were enhanced in higher N concentrations and metabolism of these cellular components stayed stable during the stationary growth phase. Our findings showed that a higher N availability and a shorter cultivation time is a good strategy for efficient E. gracilis biomass production, regardless of whether the produced biomass is intended for maximal recovery of polyunsaturated FAs, proteins, or photosynthetic pigments. Additionally, we showed an increase of neoxanthin, ß-carotene, and diadinoxanthin as a response to higher N availability.

Culturing of Selenastrum on diluted composting fluids; conversion of waste to valuable algal biomass in presence of bacteria.

Growth and fatty acid production of microalga Selenastrum sp. with associated bacteria was studied in lab-scale experiments in three composting leachate liquids. Nutrient reduction in cultures was measured at different initial substrate strengths. A small, pilot-scale photobioreactor (PBR) was used to verify lab-scale results. Similar growth conditions supported growth of both Selenastrum and bacteria. CO2 feed enhanced the production of biomass and lipids in PBR (2.4gL-1 and 17% DW) compared to lab-scale (0.1-1.6gL-1 and 4.0-6.5% DW) experiments. Also prolonged cultivation time increased lipid content in PBR. At both scales, NH4-N with an initial concentration of ca. 40mgL-1 was completely removed from the biowaste leachate. In lab-scale, maximal COD reduction was over 2000mgL-1, indicating mixotrophic growth of Selenastrum. Co-cultures are efficient in composting leachate liquid treatment, and conversion of waste to biomass is a promising approach to improve the bioeconomy of composting plants.